| 1997 FORD AEROMAX |
|---|
| Bulletin Number: 02169 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT |
| Bulletin Number: 11755 |
| SOME VEHICLES WITH THE CATERPILLAR 3306 ENGINE MAY EXHIBIT THE LOWER RADIATOR HOSE BEING DISCONNECTED FROM THE ENGINE WATER PUMP OUTLET. *TT |
| Bulletin Number: 8164 |
| INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT |
| Bulletin Number: 962216 |
| STEP PLATE - FUEL TANK STEP PLATE VIBRATES - VEHICLES BUILT THROUGH 10/1/96 EQUIPPED WITH 70 AND/OR 120 GALLON REAR-MOUNTED CYLINDRICAL FUEL TANKS WITH TANK-MOUNTED STEP PLATE. *TW |
| Bulletin Number: 962419 |
| HOOD GRILLE OPENING PANEL - CRACK AT TOP LEFT AND RIGHT CORNERS - VEHICLES BUILT FROM 11/1/95 THROUGH 4/1/96. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 97010510638 |
| THE VERTICAL EXHAUST HEAT SHIELD MAY EXHIBIT CRACKING AROUND ITS MOUNTING BOLT HOLE. *YC |
| Bulletin Number: 97050110609 |
| VEHICLES EQUIPPED WITH THE FD 1460 ENGINE MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTACHING BOLTS LOSSENING. *TW |
| Bulletin Number: 97050110626 |
| THE CENTER SUPPORT BAR TO THE OPTIONAL BUG/DIRT SCREEN MAY CRACK AT EITHER END. *TW |
| Bulletin Number: 970902971813 |
| UNDER CERTAIN CONDITIONS, ROAD SPLASH AND SPRAY MAY BUILD UP ON THE CAB SIDE WINDOWS. *YC |
| Bulletin Number: 970902971815 |
| SOME VEHICLES FAN CLUTCH MAY CYCLE ON WHEN ELECTRICAL ACCESSORIES, SUCH AS TURN SIGNALS, HEADLAMPS, ETC. ARE ACTIVATED. *YC |
| Bulletin Number: 970902971816 |
| THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY WEAR AND/OR COME OFF ON SOME VEHICLES EQUIPPED WITH A DETROIT DIESEL ENGINE AND AIR CONDITIONING. *YC |
| Bulletin Number: 970902971817 |
| SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC |
| Bulletin Number: 97119 |
| NOISE- AIR LEAK FROM BEHIND INSTRUMENT- PANEL- VEHICLES BUILT THROUGH 10/21/96. *JD |
| Bulletin Number: 97217 |
| DOORS - BATTERY ACCESS DOORS MAY COME LOOSE - NEW PART AVAILABILITY - VEHICLES BUILT THROUGH 9-96. *TW |
| Bulletin Number: 97412 |
| COOLING SYSTEM- ENGINE COOLING FAN CRACKS AT CENTER HUB. *JD |
| Bulletin Number: 97517 |
| ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD |
| Bulletin Number: 97518 |
| FRONT END ACCESSORY DRIVE BELT (FEAD)- FEAD BELT MAY WEAR AND/OR COME OFF- VEHICLES EQUIPPED WITH FD1460 ENGINE BUILT THROUGH 12/96. *JD |
| Bulletin Number: 97630 |
| HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD |
| Bulletin Number: 97715 |
| SUN VISOR- OPTIONAL ROOF-MOUNTED SUN VISOR VIBRATES AT HIGHWAY SPEEDS. *JD |
| Bulletin Number: 97717 |
| WIRING- WIRE HARNESS GROUND- INTERMITTENT OR OPEN. *JD |
| Bulletin Number: 9811333 |
| ENGINEERING IS INVESTIGATING CONDITIONS ON THE HOOD SPRING CONTACTING THE HOOD CAUSING DAMAGE TO THE HOOD AND / OR INSULATION. *TT |
| Bulletin Number: 9811468 |
| SOME MODELS WITH CAT C10/C12 ENGINES MAY EXHIBIT CRACKS IN THE ENGINE FRONT COVER, NEAR THE FAN HUB PULLEY SUPPORT MOUNTING CONTAC STUDS. *TT |
| Bulletin Number: 98157 |
| FRONT ENGINE COVER CRACKS. YD |
| Bulletin Number: 98162 |
| HARD TO MOVE THE HOOD UP AND DOWN.*AK |
| Bulletin Number: 98201 |
| INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 98202 |
| THE POWER DISTRIBUTION BOX COVER IS NOW AVAILABLE. *YC |
| Bulletin Number: 982022 |
| DELCO-REMY HAS MADE AVAILABLE A REVISED GENERATOR FOR SERVICE. *YC |
| Bulletin Number: 982023 |
| HINGES AND HINGE SPRINGS ARE NOW AVAILABLE FOR SERVICE FOR THE OPTIONAL READY LINE ACCESS DOOR, BUTTERFLY DOORS OR TRANSVERSE ACCESS DOORS. *YC |
| Bulletin Number: 982115 |
| A NEW SERVICE PARTS RELEASED. *YC |
| Bulletin Number: 982116 |
| THE LOWER RADITTOR HOSE IS BEING PULLED OFF AT THE ENGINE WATER PUMP ON SOME VEHICLES. *YC |
| Bulletin Number: 982118 |
| A NOISE HEARD DURING DRIVELINE TORQUE. |
| Bulletin Number: 98237 |
| SOME VEHICLES EXPERIENCE HEATER SUPPLY TUBES THAT MAY CRACK AND/ OR LEAK COOLANT. *YC |
| Bulletin Number: 98243 |
| CONCERNS REGARDING THE INSTRUMENT PANEL PLATE CRACKS AT PARKING BRAKE VALVE. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982520 |
| SOME VEHICLES EQUIPPED WITH FRAME-MOUNTED VERTICAL MUFFLER SUPPORTS MAY EXHIBIT A CRACK ALONG THE PIPE BEND. *YC |
| Bulletin Number: 98257 |
| CONCERNS WITH THE FRONT END ACCESSORY DRIVE BELT ( FEAD )-FEAD BELT MAY WEAR AND/OR COME OFF. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 98424 |
| CONDITION WITH TIRES BEING LOWER THAN EXPECTED TIRE LIFE. *YC |
| Bulletin Number: 98425 |
| DIAGNOSTIC INFORMATIN AND WIRING SCHEMATICS FOR BOTH THE HORTON AND KYSOR ENGINE COOLING FAN CLUTCHES. *YC |
| Bulletin Number: 98518 |
| THE OIL LEVEL INDICATOR MAY BE DIFFICULT TO INSTALL AND/OR WHEN INSTALLED MAY CONTACT THE CRAKSHAFT ON SOME VEHICLES. *YC |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 98711 |
| INFORMATION ON AVAILABILITY OF REVISED COOLANT LEVEL SENSOR. *YC |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99205 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT |
| Bulletin Number: 9944 |
| PROCEDURES ON REPAIRING BROKEN RADIATOR COOLANT SUPPLY TANK VENT HOSE NIPPLES. *TT |
| Bulletin Number: BC0193970201 |
| REVISED FAN ASSEMBLIES FOR PREMIUM DIESEL ENGINES ARE NOW AVAILABLE. *JD |
| Bulletin Number: BC0200970201 |
| DASH MOUNTED AIR VALVE ASSEMBLIES, BASE PART #4484, MAY LEAK AIR. NEW VALVE PART. *JD |
| Bulletin Number: BC0205970201 |
| VEHICLES EQUIPPED WITH THE CUMMINS ELECTRONIC ENGINE THE TACHOMETER MAY BE INOPERATIVE OR ERRATIC. *JD |
| Bulletin Number: BC0323961101 |
| TACHOMETER INOPERATIVE. *TW |
| Bulletin Number: BC0323970201 |
| TACHOMETER INOPERATIVE. *JD |
| Bulletin Number: BC0323972301 |
| TACHOMETER INOPERATIVE. *JD |
| Bulletin Number: BC0480961113 |
| REPLACEMENT LEVELING VALVE EXTENTION ROD FOR HENDRICKSON AIR-RIDE SUSPENSION. *TW |
| Bulletin Number: BC0756961017 |
| INFORMATION WHEN TROUBLESHOOTING THE SPEEDOMETER & TACHOMETER. *TT |
| Bulletin Number: BC0831961009 |
| BATTERY ACCESS PANEL MAY BECOME LOOSE. *TT |
| Bulletin Number: BC0840961008 |
| COOLANT TEMP GAUGE MAY READ ON THE HIGH OR HOT SIDE OF NORMAL, CAUSED BY LOCATION OF COOLANT TEMP SENSOR. *TT |
| Bulletin Number: BC1009097020 |
| VEHICLES EQUIPPED WITH THE CUMMINS ELECTRONIC ENGINE THE TACHOMETER MAY BE INOPEATIVE OR ERRATIC. *JD |
| Bulletin Number: BC1018797230 |
| DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| Bulletin Number: BC1022997230 |
| IF ONE OF THE FOLLOWING SYMPTOMS IS REPROTED ON A VEHICLE EQUIPPED WITH AN ELECTRONIC ENGINE PLEASE CONTACT FORD HEAVY TRUCKS: INTERMITTENT SPEEDOMETER OR SPEED CONTROL FUNCTIONS. *JD |
| Bulletin Number: BC1026897020 |
| THE DIPSTICK RUBBING AGAINST THE ENGINE CRANKSHAFT. *JD |
| Bulletin Number: BC1031997020 |
| VEHICLES EQUIPPED WITH THE HENDRICKSON AIR SUSPENSION, IT MAY BE DIFFICULT TO MAINTAIN THE CORRECT VEHICLE RIDE HEIGHT DUE TO THE CURRENT MOUNTING OF THE AIR LEVELING VALVE. *JD |
| Bulletin Number: BC2234970501 |
| VEHICLES MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTATCHING BOLTS LOOSENING. *TW |
| Bulletin Number: BC2444970501 |
| VEHICLES EQUIPPED WITH CUMMINS M-11 AND N-14 SELECT PLUS ENGINES MAY EXHIBIT THE AIR OPERATED COOLING FAN RUNNING CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW |
| Bulletin Number: BC3093970225 |
| A/C COMPRESSOR DRIVE BELT OR ALTERNATOR DRIVE BELT ROLLING OFF DRIVE PULLEYS. *TW |
| Bulletin Number: BC3157970219 |
| FEAD BELT MAY OR ROLL OFF - VEHICLES EQUIPPED WITH FD 1460 ENGINE. *TW |
| Bulletin Number: BC3163970218 |
| VEHICLES EQUIPPED WITH HENDRICKSON HAS SUSPENSION - MAY BE DIFFICULT TO MAINTAIN CORRECT VEHICLE RIDE HEIGHT. *TW |
| Bulletin Number: BC3202970214 |
| VEHICLES EQUIPPED WITH POWER STEERING AND A BUG/DIRT SCREEN - THE SCREEN MAY CONTACT THE POWER STEERING COOLER ON THE PASSENGER SIDE CAUSING A NOISE CONCERN AND OVER TIME, MAY WEAR A HOLE IN THE POWER STEERING COOLER, RESULTING IN A FLUID L |
| Bulletin Number: BC3222970212 |
| CONCERN WITH LOWER ROOF AIR DEFLECTOR SUPPORT BRACKETS. *TW |
| Bulletin Number: BC3223970212 |
| VEHICLES EQUIPPED WITH DETROIT DIESEL ENGINES MAY EXPERIENCE A CONCERN WITH ENGINE WARNING LAMPS COMING ON INTERMITTENTLY. *TW |
| Bulletin Number: BC3235970211 |
| FD 1060 ENGINES - DIPSTICK RUBBING AGAINST CRANKSHAFT. *TW |
| Bulletin Number: BC3275970207 |
| INOPERATIVE HORN OR HORN OPERATES EVEN THOUGH NOT PUSHED. *TW |
| Bulletin Number: BC3278970207 |
| AIR CONDITIONING COMPRESSOR BELT MAY COME OFF DRIVE PULLY. *TW |
| Bulletin Number: BC3350972301 |
| ENGINE DERATE (REDUCTION IN ENGINE-POWER) POSSIBLY INTERMITTENT- INTERMITTEN SPEEDOMETER OR SPEED CONTROL FUNCTION. *JD |
| Bulletin Number: BC3505972301 |
| THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| Bulletin Number: BC5189961001 |
| INFORMATION ON TROUBLESHOOTING THE SPEEDOMETER & TACHOMETER. *TT |
| Bulletin Number: BC5193961001 |
| PROCEDURE FOR AIR SUSPENSION LIGHT ON. *TT |
| 1997 FORD AEROSTAR |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 01124 |
| ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01197 |
| SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 02138 |
| LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02221 |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ |
| Bulletin Number: 0282 |
| SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 13118 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT |
| Bulletin Number: 13180 |
| INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS |
| Bulletin Number: 15887 |
| SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT |
| Bulletin Number: 5518 |
| INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT |
| Bulletin Number: 6896 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT |
| Bulletin Number: 6997 |
| SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT |
| Bulletin Number: 8164 |
| INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR |
| Bulletin Number: 870197 |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 962215 |
| FLUID - NEW MERCON V REQUIRED - TRANSMISSION - 4R44E - DESCRIPTION OF FEATURES AND MAJOR COMPONENTS. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96226 |
| AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW |
| Bulletin Number: 962410 |
| TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962617 |
| BRAKES - BRAKE SERVICE - SERVICE TIPS. *TW |
| Bulletin Number: 97050110607 |
| ENGINEERING IS INVESTIGATING CONCERNS OF THE REAR ABS LIGHT COMING ON WHEN THE IGNITION IS IN THE ON POSITION. |
| Bulletin Number: 97090297189 |
| EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC |
| Bulletin Number: 97111097234 |
| VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9747 |
| FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 97610 |
| BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD |
| Bulletin Number: 97623 |
| BATTERY- DISCHARGED- VEHICLES BUILT THROUGH 2/14/97. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 97716 |
| FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD |
| Bulletin Number: 98112 |
| SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982312 |
| ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98233 |
| CONCERNS WITH FRONT DRIVE AXLE FLUID MAY LEAK OUT OF THE VENT UNDER SOME DRIVING MODES ON SOME VEHICLES. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 983080 |
| INFORMATION REGARDING TRANSFER CASE REAR HOUSING AND DRIVESHAFT REPLACEMENT. *TT |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 9832 |
| FRONT AND REAR BUMPERS MADE OF XENOY PLASTIC HAVE HAD THE CONDUCTIVE PRIMER REMOVED FROM SERVICE PARTS. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 9844 |
| SOME DIFFICULTY IN MATCHING THE TEXTURE OF THE OEM ANTI-CHIP STONE ABRASION MATERIAL TO RPAIR MATERIALS WHEN SERVICING. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98514 |
| CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 985A52 |
| THIS BULLETIN CONTAINS SERVICE TIPS WHEN SERVICING ANY BRAKE RELATED ROUGHNESS / PULL CONCERNS. *TT |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9868 |
| A ROUGH IDLE, STALLING AT AN IDLE AND/OR DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, AND/OR P1151 MAY BE STORED IN MEMORY ON SOME VEHICLES WITH A 4.OL ENGINE. *YC |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99183 |
| SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99235 |
| DURING EXTREME COLD AMBIENT TEMPERATURES AND UNDER CERTAIN DRIVING CONDITIONS, MOISTURE IN THE CRANKCASE MAY ENTER THE PCV SYSTEM, FREEZE AND CAUSE PRESURE IN THE ENGINE CRANKCASE. THE PCV FITTING IN THE UPPER INTAKE MANIFOLD MAY FREEZE OR |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: BC0191970201 |
| VEHICLE ELECTRICAL SYSTEM, SEVERAL MEGAFUSES ARE USED. NOW HAS A NEW PLASTIC COVER. *JD |
| Bulletin Number: BC0324961101 |
| COLD ENGINE KNOCK/TICK NOISE. *TW |
| Bulletin Number: BC0324970201 |
| COLD ENGINE KNOCK/TICK NOISE. *JD |
| Bulletin Number: BC0344961127 |
| 1996-1997 AEROSTAR INTERIOR TRIM PANELS ARE OCCASIONALLY BEING REPORTED WITH ISSUES OF DAMAGE/DELAMINATION/HOLES. *TW |
| Bulletin Number: BC0344972301 |
| INTERIOR TRIM PANELS ARE OCCASIONALLY BEING REPORTED WITH ISSUES OF DAMAGE/DELAMINATION/HOLES. *JD |
| Bulletin Number: BC0407961115 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW |
| Bulletin Number: BC0490961112 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW |
| Bulletin Number: BC1018997230 |
| BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD |
| Bulletin Number: BC1019797230 |
| THE VEHICLES WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSITION. *JD |
| Bulletin Number: BC1019997230 |
| 4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD |
| Bulletin Number: BC1028597020 |
| DISCHARGED BATTERIES ON 97 AEROSTARS MAY BE CAUSED BY AN INTERMITTENT ELECTRICAL DRAW THAT MAY BE DIFFICULT T DUPLICATE. *JD |
| Bulletin Number: BC105979705 |
| UPDATE INFORMATION FOR 1997 4R44E AND 5R55E TRANSMISSIONS - THERE ARE TWO (2) DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW |
| Bulletin Number: BC2226970501 |
| SERVICING TIP - TRANSMISSION - THERE ARE TWO DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW |
| Bulletin Number: BC2232970501 |
| ENGINEERING IS INVESTIGATING CONDITIONS THAT CAUSE THE ABS LIGHT (RABS) TO ILLUMINATE. *TW |
| Bulletin Number: BC2394970501 |
| THE AIR OPERATED COOLING FAN MAYU RUN CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW |
| Bulletin Number: BC2431970501 |
| AEROSTAR E4WD MODELS MAY EXPERIENCE FRONT AXLE LUBRICANT LEAKAGE FROM THE VENT TUBE UNDER SOME DRIVING CONDITIONS. *TW |
| Bulletin Number: BC2433970501 |
| ENGINES MAY EXHIBIT A DRIVEABILITY CONCERN DESCRIBED AS A SURGE/BUCK/JERK OR HESITATION. *TW |
| Bulletin Number: BC3234970211 |
| WINDSHIELD CRACKS. *TW |
| Bulletin Number: BC3244970210 |
| FD 1460 ENGINES - NON-FUNCTIONING AIR INTAKE HEATERS - ENSURE THAT THE DIAGNOSTIC SWITCH IS IN OFF POSITION. *TW |
| Bulletin Number: BC3301970204 |
| DISCHARGED BATTERIES MAY BE CAUSED BY INTERMITTENT ELECTRICAL DRAW DIFFICULT TO DUPLICATE. *TW |
| Bulletin Number: BC3441972301 |
| AS OF 1/7/97 THE AUTOMATIC SHIFT LOCK FEATURE TAG THAT WAS AFFIXED AROUND THE GEAR SELECTOR, HAS BEEN DISCONTINUED FOR PRODUTION. *JD |
| Bulletin Number: BC3483972301 |
| THE VEHICLE WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSTION. *JD |
| Bulletin Number: BC3485972301 |
| 4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD |
| Bulletin Number: BC3491972301 |
| SOME 4.0L ENGINES WITH BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9666961001 |
| 2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC9714961101 |
| DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW |
| 1997 FORD ASPIRE |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 12196 |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0300 STORED IN MEMORY. ENGINEERING IS INVESTIGATING. *TT |
| Bulletin Number: 12526 |
| SOME VEHICLES MAY EXHIBIT REPEAT MISFIRE DIAGNOSTIC TROUBLE CODES P0300 - P0304 AFTER SSM 11543 (REPLACEMENT DISTRIBUTION VANE COVER) HAS BEEN PERFORMED. *TT |
| Bulletin Number: 12575 |
| INFORMATION ON HEAD GASKET OIL & COOLANT PASSAGES. *TT |
| Bulletin Number: 5241 |
| INFORMATION ON VEHICLES EXHIBITING A MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE P0300 STORED IN MEMORY. *TT |
| Bulletin Number: 5850 |
| SUBJECT REGARDING REPEATED MISFIRE CODES - DTCS P0300 - P0304. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96227 |
| NOISE - CLICK, CLUNK, RATTLE - MTX TRANSAXLE REVERSE GEAR. *TW |
| Bulletin Number: 96245 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODE (DTC) P1794 STORED IN CONTINUOUS MEMORY - PROBE WITH 2.5L, ESCORT WITH 1.8L AND ASPIRE. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96262 |
| GLASS - DOOR GLASS WILL NOT ROLL DOWN. *TW |
| Bulletin Number: 97050110631 |
| CUSTOMER CONCERNS OF MIL (MALFAUNCTION INDICATOR LAMP) AND DTC'S OF P0505 AND/ OR PO140. *YC |
| Bulletin Number: 9711 |
| THE DOOR GLASS WINDOW MAY NOT ROLL DOWN ON SOME VEHICLES- THIS MAY BE DUE TO THE FOAM PAD BRACKET PULLING AWAY FROM THE DOOR SKIN. *JD |
| Bulletin Number: 97111097236 |
| SOME VEHICLES AFTER A TRANSAXLE OVERHAUL MAY BE EXPERIENCE NO THIRD GEAR AND/OR REVERSE. *YC |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 983304 |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON AND CODES P0140 OR P0141 PRESENT WITH NO DRIVEABILITY CONCERNS. *TT |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9874 |
| A NEW SILICONE GASKET AND SEALANT. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 996124 |
| INFORMATION REGARDING DOOR LOCK FREEZING REPAIR. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: BC0304972301 |
| MIL LIGHT ON WITH DTC P0505. *JD |
| Bulletin Number: BC0304A97020 |
| CONCERNS OF DTC P0505 THAT ARE NOT RESOLVED BY FOLLOWING PP TESTS. *TW |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9666961001 |
| 2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT |
| 1997 FORD B700 |
|---|
| Bulletin Number: 11817 |
| SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT |
| Bulletin Number: 4709 |
| SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT |
| Bulletin Number: 991311 |
| CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT |
| 1997 FORD B800 |
|---|
| Bulletin Number: 11817 |
| SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT |
| Bulletin Number: 4709 |
| SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT |
| Bulletin Number: 991311 |
| CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT |
| 1997 FORD BRONCO |
|---|
| Bulletin Number: 12905 |
| SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT |
| Bulletin Number: 983074 |
| CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT |
| Bulletin Number: BC0053970201 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0053972301 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC1015397020 |
| VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC2301970501 |
| NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| 1997 FORD B SERIES |
|---|
| Bulletin Number: 02169 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04217 |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 12564 |
| SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT |
| Bulletin Number: 17467 |
| ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT |
| Bulletin Number: 5899 |
| CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT |
| Bulletin Number: 6473 |
| SOME MEDIUM TRUCKS PRODUCED AT KENTUCKY ASSEMBLY PLANT MAY EXHIBIT OIL LEAKING OUT OF THE TRANSMISSION SHIFT LEVER. *TT |
| Bulletin Number: 962218 |
| STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 962529 |
| FEAD BELT - HIGH WEAR AND/OR COMES OFF THE DRIVE PULLEY - VEHICLES BUILT FROM 4/1/92 THROUGH 9/1/96 WITH FD1060 ENGINE. *TW |
| Bulletin Number: 97115 |
| SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD |
| Bulletin Number: 97117 |
| HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97118 |
| ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD |
| Bulletin Number: 97218 |
| SUSPENSION - NOISE FROM FRONT SPRING REAR HANGER - REVISED REAR SPRING HANGER INSULATOR PAD - VEHICLES EQUIPPED WITH 6000, 7000 OR 9000 LB AXLES BUILT THROUGH 10/1/97. *TW |
| Bulletin Number: 97315 |
| NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97411 |
| FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97517 |
| ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD |
| Bulletin Number: 97630 |
| HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD |
| Bulletin Number: 97716 |
| FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD |
| Bulletin Number: 981511 |
| HARD TO START VEHICLE AT COLD TEMPERATURE.*AK |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 98614 |
| THE COOLANT TEMPERATURE GAUGE READING MAY BE INACCURATE. *YC |
| Bulletin Number: 99133 |
| SUBJECT REGARDING INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED. *TT |
| Bulletin Number: 991413 |
| VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99205 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9983 |
| EXPERIENCING VARIOUS INTERMITTENT CONCERNS, SUCH AS LOW COOLANT LEVEL SENSOR LEAKING COOLANT INTO WIRING HARNESS. *TT |
| Bulletin Number: BC0601961101 |
| MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW |
| Bulletin Number: BC0604961101 |
| NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW |
| Bulletin Number: BC1018797230 |
| DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| Bulletin Number: BC1029697020 |
| FD 1060 ENGINES THE LOWER COOLANT PIPE, BASE PART NUMBER -8291- WAS CHANGED. *JD |
| Bulletin Number: BC2312970501 |
| NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW |
| Bulletin Number: BC3236970211 |
| FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW |
| Bulletin Number: BC3505972301 |
| THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| 1997 FORD B SERIES (MEDIUM) |
|---|
| Bulletin Number: 13736 |
| SOME VEHICLES MAY EXPERIENCE OIL LEAKING FROM THE SHIFT LEVER. *MJS |
| 1997 FORD CARGO |
|---|
| Bulletin Number: 02169 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT |
| Bulletin Number: 962218 |
| STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 962529 |
| FEAD BELT - HIGH WEAR AND/OR COMES OFF THE DRIVE PULLEY - VEHICLES BUILT FROM 4/1/92 THROUGH 9/1/96 WITH FD1060 ENGINE. *TW |
| Bulletin Number: 962622 |
| ASSIST HANDLE- INSTRUMENT PANEL-MOUNTED ASSIS HANDLE MAY COME LOOSE- VEHICLES BUILT FROM 8/1/90 THROUGH 6/1/96. *JD |
| Bulletin Number: 97115 |
| SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD |
| Bulletin Number: 97117 |
| HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97118 |
| ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD |
| Bulletin Number: 97315 |
| NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97411 |
| FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97517 |
| ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD |
| Bulletin Number: 97630 |
| HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD |
| Bulletin Number: 98201 |
| INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 98711 |
| INFORMATION ON AVAILABILITY OF REVISED COOLANT LEVEL SENSOR. *YC |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99205 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT |
| 1997 FORD CF SERIES |
|---|
| Bulletin Number: BC0601961101 |
| MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW |
| Bulletin Number: BC0604961101 |
| NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW |
| Bulletin Number: BC1018797230 |
| DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| Bulletin Number: BC1026797230 |
| FD 1060 ENGINE HARD START OR NO START IN EXTREMELY COLD AMBIENTS. *JD |
| Bulletin Number: BC3236970211 |
| FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW |
| Bulletin Number: BC3505972301 |
| THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| 1997 FORD CONTOUR |
|---|
| Bulletin Number: 00141 |
| SOME VEHICLES MAY EXPERIENCE A NO START CONDITION AND / OR THE 10 AMP GFI INJECTOR FUSE MAY OPEN. *JB |
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 00152 |
| ADDRESSING CONCERNS OF VIBRATION NOISE FROM THE REAR OF VEHICLE AFTER INSTALLATION OF THE COMPRESSED NATURAL GAS (CNG) TANK ON BI-FUEL VEHICLES ONLY. *JB |
| Bulletin Number: 00182 |
| SOME VEHICLES MAY EXHIBIT NO FORWARD GEAR RANGES DUE TO THE MISALIGNMENT OF THE FORWARD / COAST CLUTCH CYLINDER SNAP RING WITH RESPECT TO THE LEGS OF THE FORWARD CLUTCH PISTON. *JB |
| Bulletin Number: 0019 |
| INFORMATION REGARDING SEVERAL INTERNAL CHANGES THAT HAVE BEEN IMPLEMENTED ON THE MRX-75 TRANSAXLE TO IMPROVE SHIFT EFFORTS. *MJS |
| Bulletin Number: 00239 |
| A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT |
| Bulletin Number: 00611 |
| SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS |
| Bulletin Number: 0085 |
| DUE TO AN INTERNAL DESIGN CHANGE TO THE SOLENOID TANK VALVE, THE PRESSURE RELEASE DEVICE (PRD) CAN NO LONGER BE REMOVED FROM THE TANK VALVE WITHOUT FIRST VENTING THE FUEL TANK. **MR |
| Bulletin Number: 00S03 |
| SAFETY RECALL PERTAINING TO BRAKE PRESSURE CONTROL REDUCING VALVE REPLACEMENT. *JB |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01214 |
| INFORMATION TO AID IN DIAGNOSIS FOR CLARIFICATION OF LOCK-OFF SOLENOID AND SOLENOID TANK VALVE COIL RSISTANCES FOR BI-FUEL VEHICLES. *TT |
| Bulletin Number: 01231 |
| SOME COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT ROUGH IDLE OR NO START WHEN COLD. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 01M07 |
| SOME VEHICLES MAY EXPERIENCE A LOSS OF FUNCTION WITH THE HEATER BLOWER MOTOR SWITCH IN ONE OR MORE SWITCH POSITIONS. *SLC |
| Bulletin Number: 020503 |
| GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 022001 |
| REPLACEMENT SPEAKER INSTALLATION TIPS. *TT |
| Bulletin Number: 02208 |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH |
| Bulletin Number: 0224 |
| SOME VEHICLES EQUIPPED WITH THE CD4E TRANSAXLE MAY EXHIBIT HARSH AND DELAYED 1-2/2-3 UPSHIFTS AFTER TRANSAXLE OR TURBINE SHAFT SPEED SENSOR REPLACEMENT, POSSIBLE DIAGNOSTIC TROUBLE CODES 628, 642, 645, 646, 647, 648, P0731, P0732, P0734, P0 |
| Bulletin Number: 0253 |
| SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT |
| Bulletin Number: 03102 |
| COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT |
| Bulletin Number: 03103 |
| VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 041516 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE(S) P0420 AND/OR P0430. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 11499 |
| EXHIBITING A NOISE IN THE FRONT OF THE VEHICLE AND POSSIBLY CAUSED BY A FRONT STABILIZER BAR OR LINK NOISE. *TT |
| Bulletin Number: 11725 |
| SOME VEHICLES MAY EXHIBIT A KNOCKING OR CLUNKING SOUND DURING RAPID ACCELERATION / DECELERATION AS WHEN LETTING OFF AND PUTTING YOUR FOOT DOWN ON THE ACCELERATOR QUICKLY. *TT |
| Bulletin Number: 11791 |
| SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT |
| Bulletin Number: 12075 |
| VEHICLES BUILT PRIOR TO 6/16/98 MAY HAVE A BROKEN/DETACHED IP CLUSTR BEZEL GAPHIDER. THE HIDER IS A HINGED FLAP BETWEEN THE STEERING COLUMN SHROUD AND THE IP BEZEL. *MJS |
| Bulletin Number: 12140 |
| SOME VEHICLES EQUIPPED ITH 2.0L MAY REQUIRE REPLACEMENT OF THE LEFT AIR BAG MODULE OR STEERING WHEEL DURING NORMAL REPAIR SITUATIONS. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12508 |
| SOME VEHICLES MAY REQUIRE STEERING WHEEL AND AIRBAG REPLACEMENT. *TT |
| Bulletin Number: 12520 |
| SUBJECT REGARDING 60 AMP FUSE BLOWN. *TT |
| Bulletin Number: 12525 |
| CONCERNS WITH THE LEFT AIR CONDITIONING PANEL REGISTER DISCHARGE TEMPERATURE THAT IS WARMER THAN THE CENTER AND / OR RIGHT VENTS. *TT |
| Bulletin Number: 12556 |
| SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT |
| Bulletin Number: 12707 |
| SOME VEHICLES MAY EXHIBIT A FRONT BRAKE GROAN. *TT |
| Bulletin Number: 12726 |
| INFORMATION REGARDING DECKLID RELEASE ISSUES. *TT |
| Bulletin Number: 13178 |
| INFORMATION REGARDING CLUNK/RATTLE ON TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *MJS |
| Bulletin Number: 13316 |
| EXHIBITING A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT |
| Bulletin Number: 13364 |
| CUSTOMER MAY COMMENT ON VIBRATION AT 60 - 70 MPH AT CRUISE. *TT |
| Bulletin Number: 13379 |
| SOME VEHICLES EQUIPPED WITH 2.5L ENGINE AND CD4E TRANSMISSION MAY EXHIBIT A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT |
| Bulletin Number: 13387 |
| VEHICLES WITH REAR DISC BRAKES MAY EXHIBIT A SQUEAK IN THE REAR SUSPENSION AREA. *TT |
| Bulletin Number: 13454 |
| SUBJECT REGARDING THE SPEED CONTROL SWITCH VOLTAGE READINGS - SERVICE TIP. *TT |
| Bulletin Number: 13761 |
| SOME VEHICLES EQUIPPED WITH 2.0L ENGINES MAY EXHIBIT SYMPTOMS OF CLUTCH SLIPPAGE OR NO CLUTCH ENGAGEMENT AFTER PERFORMINB REPAIRS TO THE CLUTCH SYSTEM. *MJS |
| Bulletin Number: 14375 |
| SOME VEHICLES EQUIPPED WITH A 2.5L DURATEC ENGINE MAY EXHIBIT AN ENGINE OVERHEAT CONDITION DUE TO LACK OF CIRCULATION OF COOLANT. *JB |
| Bulletin Number: 14490 |
| SOME VEHICLES EQUIPPED WITH 2.5L DURATEC (24V) ENGINE MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P0420 AND / OR P0430. *TT |
| Bulletin Number: 14775 |
| SOME VEHICLES EQUIPPED WITH DAYTIME RUNNING LAMPS (DRL) MAY EXHIBIT THE HIGH BEAM INDICATOR IN THE INSTRUMENT CLUSTER FLASHING WHEN THE DAYTIME RUNNING LAMPS ARE ON. *TT |
| Bulletin Number: 14877 |
| SOME VEHICLES MAY ILLUMINATE THE MALFUNCTION INDICATOR LAMP OR RUN ROUGH AFTER THE CATALYST IS REMOVED AND / OR REPLACED. THIS MAY BE DUE TO VACUUM LEAKS AS A RESULT OF TOLERANCE STACKUP WITHIN THE EXHAUST / EGR / INTAKE SYSTEM. |
| Bulletin Number: 15065 |
| SOME VEHICLES MAY EXHIBIT A/C DISCHARGE AIR TEMPERATURES DIFFERENCES OF GREATER THAN 10 DEGREES F FROM REGISTERS ON LEFT SIDE OF DASH THAN ON RIGHT. *TT |
| Bulletin Number: 15241 |
| SOME VEHICLES MAY EXHIBIT A NOISE THAT APPEARS TO COME FROM THE FRONT WHEEL BEARINGS. *TT |
| Bulletin Number: 15241 |
| SOME VEHICLES MAY EXHIBIT A NOISE THAT APPEARS TO COME FROM THE FRONT WHEEL BEARINGS. *TT |
| Bulletin Number: 15390 |
| SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT AND/OR EGR DIAGNOSTIC TROUBLE CODES 332, P0401, P1407 (LACKOF EGR FLOW). *TT |
| Bulletin Number: 15636 |
| CONCERN WITH HEADLAMPS AND/OR INSTRUMENT PANEL LAMPS DIMMING SLIGHTLY AT IDLE. *TT |
| Bulletin Number: 15894 |
| SUBJECT REGARDING AUTOMATIC SHIFTER ASSEMBLY OR THE INDICATOR HOUSING REPLACEMENT. *TT |
| Bulletin Number: 16880 |
| INOPERATIVE SHIFT INTERLOCK SOLENOID OR REPEAT INSTRUMENT INTERFACE MODULE FAILURE. *TT |
| Bulletin Number: 4674 |
| SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 5306 |
| SOME VEHICLES MAYE XHIBIT EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0171 AND P0172 STORED IN MEMORY. *TT |
| Bulletin Number: 5810 |
| SUBJECT ON STEERING WHEEL & AIRBAG REPLACEMENT. *TT |
| Bulletin Number: 5844 |
| SOME VEHICLES BUILT BETWEEN AUGUST 1997 AND FEBRUARY 1998 MAY EXHIBIT AN ANTI-LOCK BRAKE SYSTEM (ABS) LIGHT ON AND THE BLOWER INOPERATIVE. *TT |
| Bulletin Number: 5849 |
| SOME VEHICLES MAY EXHIBIT A LEFT AIR CONDITIONING PANEL REGISTER DISCHARGE TEMPERATURE THAT IS WARMER THAN THE CENTER AND / OR RIGHT VENTS. *TT |
| Bulletin Number: 5892 |
| SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT |
| Bulletin Number: 6091738 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION AT 60 - 70 MPH (100 - 115 KPH). *TT |
| Bulletin Number: 6201 |
| EXPERIENCING A FRONT BRAKE GROAN DURING CITY DRIVING. *TT |
| Bulletin Number: 6243 |
| ONLINE SERVICE INFORMATION PERTAINING TO VARIOUS DECKLID RELEASE ISSUES. *TT |
| Bulletin Number: 6320 |
| CONCERNS WITH VIBRATION AT 60 - 70 MPH. *TT |
| Bulletin Number: 6567 |
| SUBJECT REGARDING FORD QUALITY RENEWAL (FQR) ASSEMBLIES. *TT |
| Bulletin Number: 6906 |
| EXHIBITING A STARTER GRINDING NOISE AND / OR LACK OF STARTER DRIVE ENGAGEMENT. *TT |
| Bulletin Number: 6994 |
| CONCERNS WITH VEHICLES EXHIBITING A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT |
| Bulletin Number: 7344 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION AT 60-70 MPH. *TT |
| Bulletin Number: 7349 |
| SOME VEHICLES EQUIPPED WITH 2.5L ENGINE AND CD4E TRANSMISSION MAY EXHIBIT A DRIVELINE RATTLE OR CLUNKING TYPE NOISE DURING TIP-IN OR TRANSMISSION GEAR ENGAGEMENT. *TT |
| Bulletin Number: 7430 |
| INFORMATION REGARDING SPEED CONTROL SWITCH VOLTAGE READINGS - SERVICE TIP. *TT |
| Bulletin Number: 7864 |
| WORLD WIDE DIAGNOSTICS SERVICE TIP. |
| Bulletin Number: 7923 |
| CLUTCH WILL NOT ENGAGE AFTER SERVICE. |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 962411 |
| TRANSAXLE - CD4E - NEW DESIGN PARKING PAWL RATCHET SPRING AND PARKING CAM ACTUATING LEVER ASSEMBLY. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96256 |
| PARKING BRAKE - PARKING BRAKE STICKS AND BINDS - DOES NOT RELEASE - VEHICLES EQUIPPED WITH REAR DISC BRAKES. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962614 |
| TRANSAXLE - CD4E - HARSH SHIFT AND/OR ENGAGEMENT - DIAGNOSTIC TROUBLE CODE 628 OR P0741. *TW |
| Bulletin Number: 96712 |
| SUBJEC REGARDING THE MTX-75 TRANSAXLES WILL BE INSTALLED CERTAIN MODE YEAR VEHICLES. *TT |
| Bulletin Number: 97050110616 |
| CONCERNS OF SULPHUR ODOR FROM EXHAUST SYSTEM. *TW |
| Bulletin Number: 97111097234 |
| VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC |
| Bulletin Number: 9721 |
| DOOR GLASS - WINDOW BELT LINE MOULDING LOOSE OR FALLS OFF - VEHICLES BUILT THROUGH 10/31/96. *TW |
| Bulletin Number: 9731 |
| CARPET- POOR FIT AND/OR PULLS FROM UNDERNEATH COWL SIDE TRIM PANEL- VEHICLES BUILT THROUGH 10/18/96. *JD |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9746 |
| TRANSAXLE- CD4E- HARSH SHIFT AND/OR ENGAGEMENT- DIAGNOSTIC TROUBLE CODE (DTC) 628 OR P0741- SERVICE TIP. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 9752 |
| PARKING BRAKE- PARKING BRAKE STICKS AND BINDS- DOES NOT RELEASE- VEHICLES EQUIPPED WITH REAR DISC BRAKES. *JD |
| Bulletin Number: 9759 |
| LEAK- AUTOMATIC TRANSMISSION FLUID- CD4E TRANSAXLE IN FLUID COLLECTION ON MAIN CONTROL ASSEMBLY. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 980309 |
| STALL ON COLD START WHEN COLD. *AK |
| Bulletin Number: 9810799 |
| SUBJECT REGARDING SEAT BELT LOCATOR BUTTON REPLACEMENT. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 981512 |
| A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK |
| Bulletin Number: 98164 |
| A TRANSEAL COATING IS ON THE FRONT AND REAR BUMPERS. THIS COATING MUST BE REMOVED BEFORE DELIVERY TO THE CUSTOMER. YD |
| Bulletin Number: 98166 |
| THE TEMPERATURE GAUGE READS HIGH IN THE NORMAL RANGE WHEN ENGINE IS AT NORMAL OPERATING TEMPERATURE. |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 98207 |
| SOME VEHICLES MAY EXPERIENCE A STALL OR ROUGH IDLE AFTER STARTING IN AMBIENT TEMPERATURES. *YC |
| Bulletin Number: 98213 |
| CONCERNS WITH TEMPERATURE READS HIGH WITHIN NORMAL RANGE WHEN ENGINE IS AT NORMAL OPERATING TEMPERATURE. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982311 |
| MINIMAL CLEARANCE OF THE CD4E TRANSAXLE TO SUBFRAME MAKES TRANSAXLE INSTALLATION AND REMOVAL MORE DIFFICULT. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982462 |
| SOME VEHICLES MAY EXHIBIT A NOISE IN THE FRONT OF THE VEHICLE. *YC |
| Bulletin Number: 982514 |
| CONCERNS WITH THE TIMING ARROWS/FLAGS ON THE BACK OF THE CAMSHAFT SPROCKET (S) ARE MIS-MARKED BY AS MUCH AS 30 DEGREES ROTATION. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 982672 |
| SOME VEHICLES MAY EXHIBIT A CUSTOMERS CONCERN OF A RATTLING SOUND FROM ENGINE TIMING BELT AREA DURING WARM-UP. *YC |
| Bulletin Number: 983081 |
| CONCERNS WITH INCORRECT BRAKE SHOE / LINING ASSEMBLY. *TT |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 9832 |
| FRONT AND REAR BUMPERS MADE OF XENOY PLASTIC HAVE HAD THE CONDUCTIVE PRIMER REMOVED FROM SERVICE PARTS. *YC |
| Bulletin Number: 983216 |
| SOME VEHICLES MAY EXHIBIT MULTIPLE WHEEL SPEED SENSOR CODES. *TT |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 983311 |
| EXHIBITING A MALFUNCTION INDICATOR LIGHT (MIL) ON WITH VARIOUS CODES AND POSSIBLE DRIVEABILITY CONCERNS. *TT |
| Bulletin Number: 983583 |
| SOME VEHICLES MAY EXPERIENCE A VIBRATION AT HIGHWAY SPEEDS. *TT |
| Bulletin Number: 9841 |
| DURING REMOVAL THE LICENSE PLATE ATTACHING FASTENERS MAY BREAK. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 985089 |
| SOME VEHICLES BUILT PRIOR TO 6/16/98 MAY HAVE A BROKEN / DETACHED INSTRUMENT PANEL CLUSTER BEZEL GAPHIDER. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A17 |
| SOME VEHICLES PARKING BRAKE EQUIPPED WITH REAR DISC BRAKES MAY STICK AND/OR BIND WHEN ATTEMPTING TO RELEASE. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9874 |
| A NEW SILICONE GASKET AND SEALANT. *YC |
| Bulletin Number: 9881 |
| ISSUE WITH DOOR SPEAKER GRILLES MAY CRACK DURING NORMAL USAGE ON SOME VEHICLES. *YC |
| Bulletin Number: 9886 |
| AN ENGINE COOLANT LOSS MAY OCCUR FROM THE ENGINE BLOCK HEATER AREA. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 98B21 |
| SUBJECT ON ENGINE BLOCK HEATERS. *TT |
| Bulletin Number: 98S26S1 |
| SAFETY RECALL INVOLVING CERTAIN VEHICLES WITH AUTOMATIC TRANSAXLE SHIFT INDICATOR (PRNDL) BEZEL. *TT |
| Bulletin Number: 98S26S2 |
| SAFETY RECALL INVOLVING CERTAIN VEHICLES WITH AUTOMATIC TRANSAXLE SHIFT INDICATOR (PRNDL) BEZEL - PART AVAILABILITY). *TT |
| Bulletin Number: 9903 |
| UNDER HOOD WIRE HARNESS. ADDITIONAL 10 YEARS OR 100,000 MILES. FORD. *KB |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 9912781 |
| EXPERIENCING VIBRATION AT 60 - 70 MPH (110 - 12- KPH). *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 9913137 |
| CONCERNS WITH 2.5L ENGINE EQUIPPED VEHICLES AND CD4E TRANSAXLE EXHIBITING A STARTER GRINDING NOISE AND / OR LACK OF STARTER DRIVE ENGAGEMENT. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99195 |
| SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99201 |
| CONCERNS WITH A HARSH SHIFT FELT AT LARGE THROTTLE OPENINGS (OR AT HEAVY ACCELERATION RATE) ON SOME VEHICLES. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99249 |
| THIS BULLETIN ADDRESSES AN ISSUE WITH THE AUTOMATIC TRANSMISSION FLUID SEEPING FROM THE VENT, RESULTING IN FLUID COLLECTING ON THE MAIN CONTROL ASSEMBLY. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 996041 |
| VEHICLES MAY EXHIBIT A HARD TO SHIFT CONDITION IN COLD WEATHER. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 9989 |
| SOME VEHICLES MAY EXHIBIT A GROANING NOISE FROM THE FRONT BRAKES DURING CITY DRIVING. *TT |
| Bulletin Number: 99M01 |
| OWNER NOTIFICATION PROGRAM PROVIDING ADDITIONAL COVERAGE FOR REPLACEMENT OF THE BLOWER SWITCH, RESISTOR AND ATTACHED WIRE CONNECTORS. THIS ADDITIONAL COVERAGE IS PROVIDED IN CASE THE VEHICLE OWNER EXPERIENCES DURABILITY CONCERNS WITH THES |
| Bulletin Number: 99M07 |
| OWNER NOTIFICATION PROGRAM FOR ADDITONAL COVERAGE ON HEATER BLOWER SWITCH, RESISTOR AND ATTACHED WIRE CONNECTORS REPLACEMENT. THIS ADDITIONAL COVERAGE IS PROVIDED IN CASE THE VEHICLE OWNER EXPERIENCES DURABILITY CONCERNS WITH THESE COMPO |
| Bulletin Number: BC0043970201 |
| ENGINEERING IS INVESTIGATING INCIDENTS OF LOW COOLANT LIGHT ILLUMINATION ON 2.5L CONTOUR/MYSTIQUES. *JD |
| Bulletin Number: BC0043972301 |
| LOW COOLANT LIGHT ILLUMINATION ON 2.5L VEHICLES. *JD |
| Bulletin Number: BC0044970201 |
| INTERMITTENT SURGING, BUCKING OR SHUDDER CONCERN, INTERMEDIATE ERRATIC SPEDDOMETER AND/OR POSSIBLY DTC452. *JD |
| Bulletin Number: BC0044972301 |
| INTERMITTENT SURGING, BUCKING OR SHUDDER CONCERN, INTERMEDIATE ERRATIC SPEEDOMETER AND/OR POSSIBLY DTC 452- INSPECT THE VSS AND SPEEDO GEAR. *JD |
| Bulletin Number: BC0045970201 |
| BEGINNING DECEMBER 2, 1996 ALL CD4E TRANSAXLES ARE BUILT WITH A REDESIGNED PUMP BODY SEPARATOR PLATE AND PUMP BODY SEPARATOR PLATE GASKET. *JD |
| Bulletin Number: BC0045972301 |
| BEGINNING DECEMBER 2, 1996 (BEGINNING TRAN SERIAL NUMBER (6337-0001)) ALL CD4E TRANSAXLES ARE BUILT WITH A REDESIGNED PUMP BODY SEPARATOR PLATE AND PUMP BODY SEPARATOR PLATE GASKET. *JD |
| Bulletin Number: BC0142970201 |
| CONCERNS OF LOCKING DOORS, A REVISED DOOR LOCK BEZEL IS COMING. *JD |
| Bulletin Number: BC0195970201 |
| BUZZ/RATTLE ON TIP IN DURING CRUISE THAT APPEARS TO COME FROM CENTER OF RIGHT SIDE OF THE INSTRUMENT PANEL. *JD |
| Bulletin Number: BC0301970201 |
| BUZZ/RATTLE ON TIP IN - INSTRUMENT PANEL AREA. *TW |
| Bulletin Number: BC0301972301 |
| BUZZ/RATTLE ON TIP IN - INSTRUMENT PANEL AREA. *JD |
| Bulletin Number: BC0302970201 |
| EGR ISSUES - IF NORMAL PC/ED DIAGNOSIS FAILS, FAILURE MAY BE DUE TO CARBON DEPOSITS. *TW |
| Bulletin Number: BC0302972301 |
| DTC'S 332 OR P1401 - LACK OF EGR FLOW. *JD |
| Bulletin Number: BC0303972301 |
| VIBRATION AT IDLE. *JD |
| Bulletin Number: BC0501961111 |
| SQUEAKS FROM THE REAR SUSPENSION. *TW |
| Bulletin Number: BC0502961111 |
| CONCERNS OF MOULDING AT BOTTOM OF DOOR WINDOW GLASS COMING LOOSE. *TW |
| Bulletin Number: BC0783961014 |
| NEW PCM CALIBRATION TO CORRECT LOW SPEED MANEUVER, HIGH AMBIENT TEMP, & START/RUN/STALL CONCERNS. *TT |
| Bulletin Number: BC0785961014 |
| DIAGNOSING CHARGING OR STARTING SYSTEM CONCERNS OF POTENTIAL CHAFE BETWEEN CIRCUIT 30 & THE SUBFRAME IN THE AREA BETWEEN THE ALTERNATOR & THE MEGA-FUSE. *TT |
| Bulletin Number: BC0824961010 |
| COMPLAINTS OF STALLING ON 1996 & 1997 VEHICLES W/ 2.0L CD4E. *TT |
| Bulletin Number: BC1012197020 |
| CONCERNS OF LOCKING DOORS, A REVISED DOOR LOCK BEZEL IS COMING- CUSTOMERS MAY LOCK THEMSELVES OUT OF THE VEHICLE. *JD |
| Bulletin Number: BC1018897230 |
| THE THIRD/FOURTH SYNCHRONIZER ASSEMBLY SHOULD BE INSTALLED WITH THE LARGE COLLAR FACING OUTWARD (TOWARD REVERSE GEAR). *JD |
| Bulletin Number: BC1026697230 |
| VEHICLES EXHIBITING HARSH SHIFTS AND/OR HARSH ENGAGEMENT ACCOMPANIED BY DTCS 628 OR P0741. *JD |
| Bulletin Number: BC1032697020 |
| VEHICLES HAVE A CABIN AIR FILTER THAT MUST BE CHANGED EVERY 15000 MILES. *JD |
| Bulletin Number: BC105899705 |
| VEHICELS BUILT IN JANUARY 1997 MAY EXHIBIT MIL ILLUMINATION WITH A CODE P0171. *TW |
| Bulletin Number: BC106019705 |
| CLIMATE CONTROL SYSTEM VACUUM MOTOR LINKS FALLING OFF MAY BE REPAIRED BY ADDING THE APPROPRIATE SIZE INTERNAL STAR WASHER RETAINER TO THE END OF THE SHAFT AFTER INSTALLING THE LINK. *TW |
| Bulletin Number: BC2243970501 |
| CLIMATE CONTROL SYSTEM - VACUUM MOTOR LINKS FALLING OFF - REPAIR WITH LOCALLY PROCURED STAR WASHER. *TW |
| Bulletin Number: BC2294970501 |
| VEHICLES MAY EXHIBIT MIL ILLUMINATION WITH A CODE OF P0171 - THIS MAY BE CAUSED BY A DISCONNECTED FUEL PRESSURE REGULATOR VCUUM HOSE. *TW |
| Bulletin Number: BC2395970501 |
| CUSTOMER COMPLAINTS OF DOORS THAT LOCK INADVERTENTLY. *TW |
| Bulletin Number: BC2432970501 |
| ENGINE OIL PRESSURE SPECIFICATION. *TW |
| Bulletin Number: BC2446970501 |
| SOME 96 & 97 VEHICLES MISBUILT WITH 1998 MODEL YEAR FUEL GAUGE. *TW |
| Bulletin Number: BC3100970224 |
| MICRON FILTER - REMINDER THAT THE FILTER MUST BE CHANGED EVERY 15000 MILES - SYMPTOMS THAT MIGHT INDICATE NEED FOR CHANGE INCLUDE POOR A/C-HEATER PERFORMANCE AND/OR WINDOW FOGGING. *TW |
| Bulletin Number: BC3162970218 |
| CLICKING NOISE CAUSED BY DIFFERENTIAL LUBE TUBE CONTACTING DIFFERENTIAL CASE. *TW |
| Bulletin Number: BC3204970214 |
| HARSH SHIFTS AND/OR HARSH ENGAGEMENT ACCOMPANIED BY DTC'S 628 OR P0741. *TW |
| Bulletin Number: BC3232970211 |
| BATTERY ILLUMINATION AND DECREASED POWER STEERING ASSIST WHEN DRIVING THROUGH DEEP PUDDLES. *TW |
| Bulletin Number: BC3245970210 |
| REAR APPLIQUES - SERVICE KIT BEING DEVELOPED TO REPAIR DAMAGED APPLIQUES FROM LICENSE PLATE CHANGES. *TW |
| Bulletin Number: BC3274970207 |
| REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A |
| Bulletin Number: BC3490972301 |
| THE THIRD/FOURTH SYNCHRONIZER ASSEMBLY SHOULD BE INSTALLED WITH THE LARGE COLLAR FACING OUTWARD- THE SERVICE MANUAL INCORRECTLY ADVISES TO INSTALL THE THIRD/FOURTH GEAR ASSEMBLY WITH THE SMALL COLLAR FACING OUT. *JD |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9640961001 |
| CONCERN OF ONE OR MORE INJECTORS STAYING ON AT TIMES. |
| Bulletin Number: BC9641961001 |
| COMPLAINTS OF STALLING ON VEHICLES WITH 2.0L CD4E ENGINES. *TT |
| Bulletin Number: BC9666961001 |
| 2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC9667961001 |
| INVESTIGATING MIL ON ACCOMPANIED BY CODE 1405. *TT |
| 1997 FORD CROWN VICTORIA |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 00213 |
| SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 00E11 |
| SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT |
| Bulletin Number: 00E11 |
| SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01194 |
| THIS ARITLCE IS TO PROVIDE INFORMATION ON REPLACEMENT OF OLD STYLE HOOD LAMP SWITCH TO THE RVISED MECHANICAL HOOD LAMP SWITCH. *TT |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 012114 |
| PARTS AND PROCEDURE TO REDUCE THE POTENTIAL OF FUEL TANK PUNCTURES DURING RARE AND EXTREMELY HIGH-SPEED REAR IMPACTS. *TT |
| Bulletin Number: 01221 |
| SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 01M02 |
| OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE ON CERTAIN 4.6L SOHC INTAKE MANIFOLDS. SOME OF THE COMPOSITE INTAKE MANIFOLDS MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. *TT |
| Bulletin Number: 01M02 |
| SOME OF THE COMPOSITE INTAKE MANIFOLDS USED ON 4.6L SOHC ENGINES MAY DEVELOP FATIGUE CRACKS AT THE COOLANT CROSSOVER DUCT. THIS CONDITION COULD RESULT IN ENGINE COOLANT LEAKAGE WHICH, IF NOT SERVICED, MAY CAUSE ENGINE OVERHEATING. COMPL |
| Bulletin Number: 020503 |
| GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT |
| Bulletin Number: 02107 |
| TRANSFER SERVICE TIPS FOR THE FRONT WIPER MOTOR MOUNT BRACKET AND DEPRESSED PARK OUTPUT ARM. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02208 |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH |
| Bulletin Number: 0222 |
| SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT |
| Bulletin Number: 0253 |
| SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT |
| Bulletin Number: 02B02 |
| INSTALLATION OF OPTIONAL POLICE INTERCEPTOR PACKAGE UPGRADE KIT. *TT UPDATE PART 2. EXPIRATION DATE REMOVED. *TT |
| Bulletin Number: 030409 |
| POSSIBLE FUEL LEAK AT FILL VALVE - FILL VALVE SERVICE PART REVISIONS - CNG VEHICLES ONLY. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03183 |
| DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT |
| Bulletin Number: 03206 |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, |
| Bulletin Number: 03245 |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0420 AND/OR P0430. *TT |
| Bulletin Number: 03261 |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT |
| Bulletin Number: 0349 |
| A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE ON SOME CNG (COMPRESSED NATURAL GAS) VEHICLES. *TT *JB |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04B26 |
| ABRASION OF THE REAR BRAKE TUBE NEAR THE FLOOR PAN STIFFENING RIB AND THE #3 TRANSMISSION CROSS MEMBER. ADVANCE NOTICE-CUSTOMER SATISFACTION PROGRAM 04B26. *TT |
| Bulletin Number: 05N04 |
| EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF |
| Bulletin Number: 07212 |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE |
| Bulletin Number: 090308 |
| MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455 |
| Bulletin Number: 12154 |
| SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12178 |
| INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS |
| Bulletin Number: 12219 |
| FOR ALL VEHICLES WITH LIGHTING CONTROL MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12223 |
| FOR ALL VEHICLES WITH DRIVERS DOOR MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING. *TT |
| Bulletin Number: 12226 |
| FOR ALL VEHICLES WITH REMOTE KEYLESS ENTRY CONCERNS THAT REQUIRE A MODULE AND / OR TRANSMITTER (KEYFOB) REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE OR KEYFOB. *TT |
| Bulletin Number: 12230 |
| ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12298 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT |
| Bulletin Number: 12725 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT |
| Bulletin Number: 12890 |
| BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT |
| Bulletin Number: 13025 |
| SOME VEHICLES MAY EXHIBIT A BANG POPPING NOISE HEARD FROM THE EXHAUST SYSTEM DURING COOL-DOWN. *TT |
| Bulletin Number: 13240 |
| INFORMATION REGARDING VIBRATION/EXTENSION HOUSING BUSHING. *MJS |
| Bulletin Number: 13925 |
| SOME POLICE VEHICLES MAY EXHIBIT SHIFT CONCERNS DUE TO ENGINE DRIVEABILITY ISSUES. *TT |
| Bulletin Number: 13933 |
| SOME VEHICLES MAY EXHIBIT YELLOWING OF THE HEADLAMPS. *TT |
| Bulletin Number: 14081 |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE KEYLESS ENTRY PAD. **MR |
| Bulletin Number: 14370 |
| INFORMATION ON PROGRAMMING REMOTES AFTER DRIVER DOOR MODULE REPLACEMENT. *JB |
| Bulletin Number: 14862 |
| INFORMATION ON REPLACING FUEL TANK STRAP BOLTS. *TT |
| Bulletin Number: 15061 |
| SOME VEHICLES BUILT 04/15/2000 OR EARLIER EQUIPPED WITH A KEYLESS ENTRY SYSTEM MAY EXHIBIT AN INOPERATIVE DOOR-MOUNTED KEYPAD, INTERIOR AND EXTERIOR LAMPS THAT SELF-ACTIVATE AND A WEAK OR DISCHARGED VEHICLE BATTERY. *TT |
| Bulletin Number: 15113 |
| SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD |
| Bulletin Number: 15158 |
| SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH |
| Bulletin Number: 15171 |
| INFORMATION REGARDING POLICE OPTION-REAR WINDOW DISABLE-TAMPER RESISTANCE. *YD |
| Bulletin Number: 15271 |
| DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG |
| Bulletin Number: 15761 |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS OF HARD START / NO START / ROUGH RUNNING. *TT |
| Bulletin Number: 16996 |
| POLICE INTERCEPTOR MAY EXHIBIT LOW CHARGING SYSTEM VOLTAGE AT IDLE. *TT |
| Bulletin Number: 17310 |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0420 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOLD - BANK 1) AND/OR P0430 (CATALYST SYSTEM EFFICIENCY BELOW THRESHOLD - BANK 2). *TT |
| Bulletin Number: 18351 |
| CHARGING SYSTEM LIMITATIONS. *EH |
| Bulletin Number: 4619 |
| SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 6242 |
| EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT |
| Bulletin Number: 6505 |
| BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT |
| Bulletin Number: 8060 |
| SOME VEHICLES MAY EXHIBIT A SLIGHT STEERING DRIFT / WANDER CONDITION, USUALLY NOTED DURING HIGHWAY DRIVING. *TT |
| Bulletin Number: 8243 |
| SOME POLICE VEHICLES MAY EXHIBIT SHIFT CONCERNS DUE TO ENGINE DRIVABILITY ISSUES. **MR |
| Bulletin Number: 8243 |
| SOME POLICE VEHICLES MAY EXHIBIT SHIFTING CONCERNS DUE TO ENGINE DRIVEABILITY ISSUES. *TT |
| Bulletin Number: 8257 |
| BRIEF INFORMATION REGARDING VEHICLES THAT EXHIBIT YELLOWING OF THE HEADLAMPS. *TT |
| Bulletin Number: 8300 |
| SOME VEHICLES MAY EXHIBIT A BANG / POPPING NOISE HEARD FROM THE EXHAUST SYSTEM DURING COOL-DOWN. **MR |
| Bulletin Number: 8425 |
| SUBJECT REGARDING KEYFOB PROGRAMMING INFORMATION - SERVICE REPLACEMENT DRIVERS DOOR MODULE. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 97090297182 |
| SOME VEHICLES MAY EXPERIENCE A LEAN RIGHT CONDITION. *YC |
| Bulletin Number: 97090297183 |
| EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC |
| Bulletin Number: 97090297185 |
| A VIBRATION/"BUZZING" NOISE MAY BE HEARD OR FELT IN THE STEERING WHEEL ON RIGHT TURNS. *YC |
| Bulletin Number: 9722 |
| SEAT - FRONT - DRIVER'S SIDE SEAT CUSHION PAD SUPPORT SPRING MAY SAG AND/OR SEAT MAY BECOME UNCOMFORTABLE - FLEET USAGE. *TW |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 9755 |
| MALFUNCTION INDICATOR LAMP (MIL)- MIL ILLUMINATION- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN MEMORY. *JD |
| Bulletin Number: 976011 |
| EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9773 |
| VIBRATION- SHUDDER OR VIBRATION UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35 MPH) WHILE IN 3RD OR 4TH GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. *JD |
| Bulletin Number: 97B13 |
| VARIOUS INFORMATION REGARDING INTAKE MANIFOLD INSPECTION / REPLACEMENT. *TT |
| Bulletin Number: 97M91 |
| INFORMATION REGARDING ADDITIONAL COVERAGE FOR INTAKE MANIFOLD MALFUNCTIONS. *TT |
| Bulletin Number: 98111 |
| VEHICLES MAY EXHIBIT HARSH RIDE QUALITY OR EXCESSIVE ROAD FEEL THROUGH THE STEERING WHEEL WHILE GOING OVER SHARP BUMPS. *TT |
| Bulletin Number: 9811483 |
| SOME POLICE AND EXPORT CARS EQUIPPED WITH PHONELIC PISTON CALIPERS MAY EXHIBIT BRAKE SQUEAL FROM THE REAR WHEN BRAKING. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982320 |
| SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98245 |
| CONCERNS REGARDING THE FRONT SEAT FEELING LOOSE ON SOME VEHICLE. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982525 |
| SOME VEHICLES MAY EXHIBIT BRAKE SQUEAL FROM THE REAR WHEN BRAKING. *YC |
| Bulletin Number: 98258 |
| A VIBRATION / NOISE FELT IN STEERING WHEEL ON RIGHT TURNS. |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983107 |
| BRIEF INFORMATION REGARDING ENGINES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT |
| Bulletin Number: 9836 |
| INFORMATION CONCERNING VIBRATION-SHUDDER UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35MPH) IN 3RD OR 4RD GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. |
| Bulletin Number: 98410 |
| VEHICLES MAY EXPERIENCE TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 9847 |
| SUBJECT REGARDING REVISED REMOTE KEYLESS ENTRY (RKE) SYSTEM. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A3 |
| THE ANTI-LOCK BRAKE SYSTEM ( ABS ) MAY ACTIVATE UNDER FALSE ABS CONDITIONS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9863 |
| SOME VEHICLES MAY EXHIBIT NO TEMPERATURE CONTROL AND/OR A CLICKING NOISE HEARD COMING FROM BEHIND THE INSTRUMENT PANEL NEAR THE GLOVE COMPARTMENT. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9874 |
| A NEW SILICONE GASKET AND SEALANT. *YC |
| Bulletin Number: 9887 |
| EXPERIENCING A TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 98B19S1 |
| OWNER NOTIFICATION PROGRAM 98B19-S1 - BRAKE LINE WEAR ON CERTAIN VEHICLES. CORRECTION TO ORIGINAL TECHNICAL INSTRUCTIONS REGARDING DIAMETER OF REPLACEMENT BRAKE LINES. YD |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 9913125 |
| SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99185 |
| VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99195 |
| SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99234 |
| INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 9947 |
| ENGINE EXPERIENCING ROUGHNESS AT IDLE DUE TO EXHAUST SYSTEM RESONANCE. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 99910 |
| ADDRESSING CONCERNS WITH THE BRAKE LAMP INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK ON POLICE VEHICLES. *TT |
| Bulletin Number: 9996 |
| EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT |
| Bulletin Number: 99E03 |
| EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT |
| Bulletin Number: BC0020961101 |
| FRONT WHEEL RATTLE MAY BE CAUSED BY THE DUST SHIELD RATTLING. *TW |
| Bulletin Number: BC0072961101 |
| WIRE WHEEL COVER CENTER ORNAMENT SEPARATES FROM THE BACKING PLATE. *TW |
| Bulletin Number: BC0263970201 |
| LOCKING WIRE WHEEL COVER CENTER ORNAMENT WHERE THE EMBLEM HAS SEPARATED FROM THE BACKING PLATE. NEW REPLACEMENT PART. *JD |
| Bulletin Number: BC031A497020 |
| INADVERTENT ABS ACTIVATION ON SMOOTH DRY PAVEMENT. *TW |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0706961022 |
| LIGHT TO MODERATE AXLE NOISE (AXLE WHINE) AT 50 TO 65 MPH (80 TO 105 KPH) DURING ACCELS, DECELS OR CRUISE. *TT |
| Bulletin Number: BC0773961015 |
| HIGH PITCH WHINING NOISE FROM THE ALTERNATOR MAY BE CAUSED BY A LOOSE ENG GROUND STRAP. *TT |
| Bulletin Number: BC0774961015 |
| CONCERN FOR INTERMITTENT NO START/OR INTERMITTENT STALL & W/ NO DTC'S. *TT |
| Bulletin Number: BC0810961011 |
| VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT |
| Bulletin Number: BC1017097230 |
| WHITE STRESS MARK IN THE DOOR SCUFF PLATE, REPLACE WITH NEW LEVEL PART. *JD |
| Bulletin Number: BC1017797230 |
| WIND NOISE FROM THE FRONT DOOR AREA ON AFFECTED VEHICLES. *JD |
| Bulletin Number: BC1017897230 |
| WIND NOISE FROM THE FRONT DOOR AREA AT VARYING SPEEDS AND CONDITIONS ON AFFECTED VEHICLES. *JD |
| Bulletin Number: BC1020197230 |
| THE POWER POINT ELECTRICAL OUTLET WAS DELETED- DISREGARD THE NOTE IN THE 1997 OWNERS GUIDE ADVISING NOT TO PLUG OPTIONAL ELECTRICAL ACCESSORIES INTO THE CIGARETTE LIGHTER. *JD |
| Bulletin Number: BC105999705 |
| VEHICLES BUILT BETWEEN 1/4/97 AND 4/14/97 MAY EXHIBIT A CONCERN OF LACK OF POWER. *TW |
| Bulletin Number: BC2241970501 |
| VEHICLE MAY EXHIBIT A LACK OF POWER. *TW |
| Bulletin Number: BC2296970501 |
| DIAGNOSTIC INSTRUCTIONS FOR A/C MODE FAILURE. *TW |
| Bulletin Number: BC3430972301 |
| THE POWER POINT ELECTRICAL OUTLET WAS DELETED. *JD |
| Bulletin Number: BC3511972301 |
| WIND NOISE FROM THE FRONT DOOR AREA ON AFFECTED VEHICLES. *JD |
| Bulletin Number: BC3512972301 |
| WIND NOISE FROM THE FRONT DOOR AREA AT VARYING SPEEDS AND CONDITIONS ON AFFECTED VEHICLES. *JD |
| Bulletin Number: BC3552972301 |
| A WHITE STRESS MARK IN THE DOOR SCUFF PLATE. *JD |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9679961001 |
| COMPLAINT OF A BUZZ/VIBRATION FELT IN THE STEERING WHEEL WHILE TURNING (USUALLY MORE NOTICEABLE TURNING RIGHT). *TT |
| Bulletin Number: CSP 08B04 |
| FORD/LINCOLN MERCURY: CERTAIN 1992-2001 MODEL YEAR CROWN VICTORIA, GRAND MARQUIS, AND TOWN CAR VEHICLES REGISTERED IN THE STATES OF WISCONSIN AND CONNECTICUT UPGRADE MODIFICATIONS FOR HIGH SPEED REAR IMPACTS. *PE |
| 1997 FORD C SERIES |
|---|
| Bulletin Number: 97716 |
| FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD |
| 1997 FORD E-150 |
|---|
| Bulletin Number: 05248 |
| VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT |
| Bulletin Number: 071110 |
| BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ |
| Bulletin Number: 090308 |
| MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455 |
| Bulletin Number: 11496 |
| SOME VEHICLES EQUIPPED WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870 - 900 RPMS. *TT |
| Bulletin Number: 13186 |
| INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS |
| Bulletin Number: 14992 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT |
| Bulletin Number: 15038 |
| SOME VEHICLES MAY EXHIBIT RAPID WEAR OF THE FRONT BRAKE PADS (UNDER 10,000 MILES). *TT |
| Bulletin Number: 15354 |
| SOME VEHICLES MAY EXHIBIT ACCELERATED FRONT DISC BRAKE PAD WEAR UNDER EXTREME LOADING CONDITIONS. *TT |
| Bulletin Number: 15517 |
| SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD |
| Bulletin Number: 15799 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT |
| Bulletin Number: 17381 |
| FRONT BRAKE PAD WEAR. *TT |
| Bulletin Number: 4619 |
| SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT |
| Bulletin Number: 4628 |
| SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT |
| Bulletin Number: 4638 |
| MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT |
| Bulletin Number: 6996 |
| INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT |
| Bulletin Number: 97090297183 |
| EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC |
| Bulletin Number: 976011 |
| EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT |
| Bulletin Number: 980317 |
| SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC |
| Bulletin Number: 982474 |
| SOME VEHICLES WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870-900 RPMS. *YC |
| Bulletin Number: 99131 |
| CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 99146 |
| CONCERNS WITH THE OIL DIPSTICK AND / OR PCV VALVE DISLODGING FROM THE ENGINE AND / OR ENGINE OIL LEAKING FROM DIPSTICK TUBE. *TT |
| Bulletin Number: 99207 |
| SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 99234 |
| INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT |
| Bulletin Number: BC0325961129 |
| SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT. *TW |
| Bulletin Number: BC0325972301 |
| SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0853961007 |
| AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC5219961001 |
| INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT |
| 1997 FORD E-250 |
|---|
| Bulletin Number: 05248 |
| VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT |
| Bulletin Number: 071110 |
| BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ |
| Bulletin Number: 11496 |
| SOME VEHICLES EQUIPPED WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870 - 900 RPMS. *TT |
| Bulletin Number: 11779 |
| SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT |
| Bulletin Number: 12835 |
| SUBJECT REGARDING TIRE BALANCE HINT. *TT |
| Bulletin Number: 13186 |
| INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS |
| Bulletin Number: 14992 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT |
| Bulletin Number: 15113 |
| SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD |
| Bulletin Number: 15634 |
| CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT |
| Bulletin Number: 15799 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT |
| Bulletin Number: 17211 |
| A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT |
| Bulletin Number: 4614 |
| INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT |
| Bulletin Number: 4616 |
| BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT |
| Bulletin Number: 4617 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT |
| Bulletin Number: 4625 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT |
| Bulletin Number: 4629 |
| BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT |
| Bulletin Number: 4638 |
| MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT |
| Bulletin Number: 4662 |
| SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT |
| Bulletin Number: 5046 |
| REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT |
| Bulletin Number: 5047 |
| REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT |
| Bulletin Number: 5050 |
| REPEAT MESSAGE REGARDING A STALL ON DECEL CONDITION. *TT |
| Bulletin Number: 5250 |
| INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT |
| Bulletin Number: 5251 |
| SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES. *TT |
| Bulletin Number: 5254 |
| INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT |
| Bulletin Number: 5262 |
| SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT |
| Bulletin Number: 6417 |
| ADDRESSING TIRE BALANCE HINTS. *TT |
| Bulletin Number: 6996 |
| INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT |
| Bulletin Number: 976011 |
| SUBJECT ON RELATIVE INJECTOR FLOW TEST SUCCESS STORY. *TT |
| Bulletin Number: 980298 |
| INFORMATION REGARDING THE HOTLINE SURVEY. *YC |
| Bulletin Number: 9803000 |
| HOTLINE CONTACT ID NUMBER ON OASIS. A NINE DIGIT CONTACT NUMBER IS ATTACHED TO THE OASIS INFORMATION WHEN A VIN AND SYMPTOM CODE IS ENTERED INTO OASIS. *YC |
| Bulletin Number: 980307 |
| VEHICLE STALLS/QUITS WHILE DRIVING. *AK |
| Bulletin Number: 980312 |
| EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT |
| Bulletin Number: 980317 |
| SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC |
| Bulletin Number: 980323 |
| CONCERNS WITH EXTERNAL OIL LEAKS. *YC |
| Bulletin Number: 980325 |
| COLD ENGINE UPPER KNOCK/TICK. *YC |
| Bulletin Number: 98120 |
| SOME VEHICLES MAY EXPERIENCE BOOM / VIBRATION NOISE OFF IDLE DURING ACCELERATION AND DECELERATION. *TT |
| Bulletin Number: 982474 |
| SOME VEHICLES WITH THE 4.2L ENGINE MAY EXHIBIT A VIBRATION OR BOOM, OFF IDLE BETWEEN 870-900 RPMS. *YC |
| Bulletin Number: 98-4722 |
| REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK |
| Bulletin Number: 98-4726 |
| REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK |
| Bulletin Number: 98-4734 |
| LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST |
| Bulletin Number: 98-4742 |
| VEHICLE STALLS UPON ACCELERATION. *AK |
| Bulletin Number: 985042 |
| REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT |
| Bulletin Number: 985058 |
| SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT |
| Bulletin Number: 98L20 |
| SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT |
| Bulletin Number: 99131 |
| CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 99146 |
| CONCERNS WITH THE OIL DIPSTICK AND / OR PCV VALVE DISLODGING FROM THE ENGINE AND / OR ENGINE OIL LEAKING FROM DIPSTICK TUBE. *TT |
| Bulletin Number: 99207 |
| SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: BC0256970201 |
| A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0853961007 |
| AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC2297970501 |
| WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS. *TW |
| Bulletin Number: BC3212970213 |
| CAMSHAFT POSITION SENSOR INFORMATION . *TW |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC5219961001 |
| INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT |
| Bulletin Number: DOR-X8B9R-11 |
| This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma |
| 1997 FORD E-350 |
|---|
| Bulletin Number: 032120 |
| 7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TT |
| Bulletin Number: 032121 |
| A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT |
| Bulletin Number: 032123 |
| LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT |
| Bulletin Number: 05248 |
| VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT |
| Bulletin Number: 071110 |
| BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ |
| Bulletin Number: 11779 |
| SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT |
| Bulletin Number: 12261 |
| SUBJECT REGARDING ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT. *TT |
| Bulletin Number: 12835 |
| SUBJECT REGARDING TIRE BALANCE HINT. *TT |
| Bulletin Number: 14963 |
| SOME CUT-AWAY VEHICLES MAY EXHIBIT ANTI-SKID BRAKE SYSTEM DIAGNOSTIC TROUBLE CODE C1229, C1230 AND C1237. *TT |
| Bulletin Number: 14992 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A DRIVELINE VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50 - 55 MPH. *TT |
| Bulletin Number: 15113 |
| SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD |
| Bulletin Number: 15634 |
| CONCERNS WITH BUMP STEER STEERING FEELING NOTED WHEN FRONT WHEELS / TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT |
| Bulletin Number: 15799 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSION (DRIVESHAFT >70 INCH) MAY EXHIBIT A VIBRATION / ROUGHNESS ON ACCELERATION OR UNDER LOAD AT ABOUT 50-55 MPH. *TT |
| Bulletin Number: 17211 |
| A BUMP STEER STEERING FEELING, NOTED WHEN THE VEHICLE'S FRONT WHEELS/TIRES CONTACT ROAD SURFACE IRREGULARITIES. *TT |
| Bulletin Number: 4614 |
| INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT |
| Bulletin Number: 4616 |
| BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT |
| Bulletin Number: 4617 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT |
| Bulletin Number: 4625 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT |
| Bulletin Number: 4629 |
| BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT |
| Bulletin Number: 4662 |
| SOME VEHICLES MAY EXHIBIT BRAKE ROTOR CHECKING OR SIGNS OF EXCESSIVE HEAT BUILD-UP. *TT |
| Bulletin Number: 5046 |
| REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT |
| Bulletin Number: 5047 |
| REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT |
| Bulletin Number: 5050 |
| REPEAT MESSAGE REGARDING A STALL ON DECEL CONDITION. *TT |
| Bulletin Number: 5250 |
| INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT |
| Bulletin Number: 5254 |
| INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT |
| Bulletin Number: 5262 |
| SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT |
| Bulletin Number: 5343 |
| THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE, REQUIRES THAT THE REPLACED COMPONENT BE RETURNED WITH THE APPROPRIATE YEAR DIESEL ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIM |
| Bulletin Number: 6417 |
| ADDRESSING TIRE BALANCE HINTS. *TT |
| Bulletin Number: 97214 |
| ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TW |
| Bulletin Number: 97215 |
| DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW |
| Bulletin Number: 97216 |
| LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW |
| Bulletin Number: 9726 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED - GASEOUS FUEL PREP (GFP) VEHICLES - POWERTRAIN CONTROL MODULE (PCM) REPROGRAMMING REQUIRED - VEHICLES WITH 2.0L OR 4.9L ENGINE. *TW |
| Bulletin Number: 97618 |
| LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD |
| Bulletin Number: 980307 |
| VEHICLE STALLS/QUITS WHILE DRIVING. *AK |
| Bulletin Number: 980312 |
| EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT |
| Bulletin Number: 980323 |
| CONCERNS WITH EXTERNAL OIL LEAKS. *YC |
| Bulletin Number: 980323 |
| DTC'S P1211/1212 ICP PRESSURE HIGHER/LOWER THAN EXPECTED. |
| Bulletin Number: 980325 |
| COLD ENGINE UPPER KNOCK/TICK. *YC |
| Bulletin Number: 98-4722 |
| REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK |
| Bulletin Number: 98-4726 |
| REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK |
| Bulletin Number: 98-4734 |
| LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST |
| Bulletin Number: 98-4742 |
| VEHICLE STALLS UPON ACCELERATION. *AK |
| Bulletin Number: 985042 |
| REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT |
| Bulletin Number: 985058 |
| SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT |
| Bulletin Number: 985A26 |
| EXPERIENCING VIBRATION DURING LIGHT BRAKE APPLICATIONS AT HIGHWAY SPEEDS. *YC |
| Bulletin Number: 98L20 |
| SPECIAL FIELD ACTION REGARDING REVISED WARANTY INFORMATION. *TT |
| Bulletin Number: 99E01 |
| SUBJECT REGARDING ON-BOARD DIAGNOSTIC (OBD) SYSTEM UPGRADES. *TT |
| Bulletin Number: BC0256970201 |
| A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0853961007 |
| AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC2297970501 |
| WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS. *TW |
| Bulletin Number: BC2390970501 |
| IF AN E350 REQUIRES ROTOR AND HUB REPLACEMENT, A REVISED THICKER PLATE ROTOR IS NOW AVAILABLE. *TW |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC5219961001 |
| INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT |
| Bulletin Number: DOR-X8B9R-11 |
| This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma |
| 1997 FORD E-450 |
|---|
| Bulletin Number: 05248 |
| VIBRATION/HARSHNESS ABOVE 45 MPH (72 KM/H) AFTER TIRE BALANCE. *TT |
| Bulletin Number: 12186 |
| SOME E-450 VEHICLES WITH THE DANA 80 MODEL AXLE MAY EXHIBIT A CUSTOMER CONCERN WITH THE LEVEL OF SOUND (WHINE) THAT IS PRODUCED ABOVE 35 MPH. *MJS |
| Bulletin Number: 12514 |
| SUBJECT REGARDING DANA 80 AXLE WHINE / DAMPENED DRIVESHAFT. *TT |
| Bulletin Number: 13822 |
| SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY, MAY EXHIBIT A WHINE ABOVE 35 MPH. *MJS |
| Bulletin Number: 13822 |
| SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT |
| Bulletin Number: 14963 |
| SOME CUT-AWAY VEHICLES MAY EXHIBIT ANTI-SKID BRAKE SYSTEM DIAGNOSTIC TROUBLE CODE C1229, C1230 AND C1237. *TT |
| Bulletin Number: 18382 |
| FLUID LEAKING FROM THE VENT ON THE TRANSMISSION MOUNTED PARKING BRAKE ASSEMBLY. *TT |
| Bulletin Number: 5224 |
| SOME VEHICLES WITH THE DANA 80 MODEL AXLE MAY EXHIBIT A CUSTOMER CONCERN WITH THE LEVEL OF SOUND (WHINE) THAT IS PRODUCED ABOVE 35 MPH. ENGINEERING IS INVESTIGATING. *TT |
| Bulletin Number: 5816 |
| FOR VEHICLES WITH MODEL 80 REAR AXLES, EXHIBITING A WHINE NOISE CONCERN, A SERVICE KIT WITH A DAMPENED DRIVESHAFT IS AVAILBLE. *TT |
| Bulletin Number: 6599 |
| SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH. |
| Bulletin Number: 8048 |
| SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT |
| Bulletin Number: 8048 |
| SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY, MAY EXHIBIT A WHINE ABOVE 35 MPH. *TT |
| 1997 FORD ECONOLINE |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 00154 |
| INFORMATION ON REAR AXLE WHINE-VEHICLES EQUIPPED WITH DANA 80 AXLES-5.4L/6.8L AND 7.3L. *JB |
| Bulletin Number: 00154 |
| SOME VEHICLES WITH DANA 80 REAR AXLES MAY EXHIBIT AN EXCESSIVE AMOUNT OF AXLE WHINE NOISE. *JB |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 00239 |
| A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT |
| Bulletin Number: 00261 |
| SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT |
| Bulletin Number: 0038 |
| VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS |
| Bulletin Number: 00510 |
| CUSTOMERS MAY BE CONCERNED THAT VEHICLE LOOKS LIKE IT DOGTRACKS, DUE TO A UNIQUE FEATURE OF THE VEHICLE THAT COMBINE TO CREATE AN OPTICAL ILLUSION OF DOGTRACKING, A CONDITION WHICH THE REAR AXLE IS NOT SQUARE TO THE CHASSIS. *MJS |
| Bulletin Number: 00610 |
| INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *MJS |
| Bulletin Number: 00611 |
| SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS |
| Bulletin Number: 00L05 |
| THIS SERVICE ACTION REQUIRES THE REPLACEMENT OF TWO EMISSION CONTROL LABELS. *TT |
| Bulletin Number: 01119 |
| SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING OVER UNEVEN SURFACES ON VEHICLES PRODUCE BEFORE 2/6/2001. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03213 |
| A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT |
| Bulletin Number: 032131 |
| ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT |
| Bulletin Number: 032132 |
| SOME VEHICLES EQUIPPED WITH AFTERMARKET MODIFICATIONS MAY EXHIBIT A CRANK BUT NO START OR A HARD START/LONG CRANK CONDITION. *TT |
| Bulletin Number: 032137 |
| FOR 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PURCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *TT |
| Bulletin Number: 04E10 |
| EMISSION RECALL 04E10: COMPRESSED NATURAL GAS (CNG) VEHICLES - FITTING CONNECTOR REPLACEMENT. *MJ |
| Bulletin Number: 11781 |
| INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT |
| Bulletin Number: 12070 |
| VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *MJS |
| Bulletin Number: 12123 |
| VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS. *MJS |
| Bulletin Number: 12139 |
| SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS |
| Bulletin Number: 12162 |
| SOME VEHICLES EQUIPPED WITH 6.8L ENGINES, MAY EXHIBIT A CUSTOMER CONCERN OR ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS |
| Bulletin Number: 12230 |
| ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12287 |
| SOME VEHICLES MAY EXHIBIT A CONCERN WITH POOR RANGE OF THE REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT |
| Bulletin Number: 12593 |
| CONCERNS WITH CRACKS ON THE RIGHT REAR SIDE OF THE #1 FRAME CROSSMEMBER. *TT |
| Bulletin Number: 12741 |
| SOME VEHICLES UNDER SEVERE DUTY CYCLES MAY EXHIBIT CRACKS ON THE LOWER RADIATOR SUPPORT. *TT |
| Bulletin Number: 12767 |
| EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT |
| Bulletin Number: 12835 |
| SUBJECT REGARDING TIRE BALANCE HINT. *TT |
| Bulletin Number: 12870 |
| SOME CUSTOMERS MAY COMMENT ON A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT |
| Bulletin Number: 12890 |
| BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT |
| Bulletin Number: 12915 |
| CUSTOMER MAY COMPLAIN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT |
| Bulletin Number: 13117 |
| SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS. *TT |
| Bulletin Number: 13180 |
| INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS |
| Bulletin Number: 13367 |
| SOME VEHICLES WITH REAR BRAKE DRUMS MAY EXHIBIT BRAKE SQUEAL NOISE. *TT |
| Bulletin Number: 13488 |
| SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT |
| Bulletin Number: 13934 |
| SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT |
| Bulletin Number: 14365 |
| THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB |
| Bulletin Number: 15271 |
| DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG |
| Bulletin Number: 15871 |
| SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO. *TT |
| Bulletin Number: 16480 |
| DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT |
| Bulletin Number: 16683 |
| FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB |
| Bulletin Number: 16697 |
| EXHAUST AIR RUSH NOISE AND LOWER POWER. *TT *JB |
| Bulletin Number: 16916 |
| REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT |
| Bulletin Number: 16945 |
| AN OIL LEAK AT THE TURBOCHARGER PEDESTAL AROUND THE EXHAUST BACKPRESSURE ACTUATOR. *TT |
| Bulletin Number: 16999 |
| HIGH PRESSURE OIL PUMP LEAK. *TT |
| Bulletin Number: 17385 |
| AIR BAG LAMP ILLUMINATED. *TT |
| Bulletin Number: 17467 |
| ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT |
| Bulletin Number: 4664 |
| THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. * |
| Bulletin Number: 4981 |
| SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT |
| Bulletin Number: 5257 |
| INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT |
| Bulletin Number: 5371 |
| SOME VEHICLES MAY EXHIBIT A CONCERN WITH POOR RANGE OF THE REMOTE KEYLESS ENTRY (RKE) TRANSMITTER. *TT |
| Bulletin Number: 5892 |
| SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT |
| Bulletin Number: 6290 |
| INFORMATION REGARDING THE IMPROVED RADIATOR SUPPORT. *TT |
| Bulletin Number: 6417 |
| ADDRESSING TIRE BALANCE HINTS. *TT |
| Bulletin Number: 6461 |
| CONCERNS OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *T |
| Bulletin Number: 6505 |
| BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT |
| Bulletin Number: 6538 |
| SOME VEHICLES BUILT BEFORE APRIL 1, 1999 MAY HAVE A CUSTOMER CONCERN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT |
| Bulletin Number: 6585 |
| SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINES MAY DEVELOP A CRACKED FLEXPLATE. *TT |
| Bulletin Number: 6997 |
| SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT |
| Bulletin Number: 7263 |
| SOME VEHICLES WITH REAR BRAKE DRUMS MAY EXHIBIT BRAKE SQUEAL NOISE. *TT |
| Bulletin Number: 7475 |
| SOME VEHICLES EQUIPPED WITH 73L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT |
| Bulletin Number: 8260 |
| SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 962410 |
| TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW |
| Bulletin Number: 962418 |
| TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962523 |
| RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY - VEHICLES BUILT THROUGH 10/14/96 WITH 4.6L ENGINE. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 97090297187 |
| SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC |
| Bulletin Number: 971110972313 |
| A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC |
| Bulletin Number: 971110972314 |
| EXHIBITING A HARSH 1-2 UPSHIFT DURING LIGHT THROTTLE. *YC |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 97410 |
| TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD |
| Bulletin Number: 9747 |
| FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 97512 |
| IDLE- ROLLING IDLE- SURGE- VEHICLES BUILT 8/96 THROUGH 12/96 WITH 7.3L ENGINE. *JD |
| Bulletin Number: 9755 |
| MALFUNCTION INDICATOR LAMP (MIL)- MIL ILLUMINATION- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN MEMORY. *JD |
| Bulletin Number: 976011 |
| SUBJECT ON RELATIVE INJECTOR FLOW TEST SUCCESS STORY. *TT |
| Bulletin Number: 97625 |
| AIR CONDITIONING- NO TEMPERATURE CONTROL- VEHICLES BUILT THROUGH 11/21/96. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 97710 |
| POWER WINDOWS- INOPERATIVE- FUSE OPENS- VEHICLES BUILT 9/1/96 THROUGH 1/13/97. *JD |
| Bulletin Number: 98021698310 |
| SOME VEHICLES SEAT BELTS MAY BE SLOW TO RETRACT. *YC |
| Bulletin Number: 98113 |
| SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT |
| Bulletin Number: 9811339 |
| INFORMATION ON THE REVISED FUEL INJECTOR O-RING KIT. *TT |
| Bulletin Number: 9811341 |
| INFORMATION ON SERVICING AN ILLUMINATED AIR BAG LAMP. *TT |
| Bulletin Number: 98114 |
| INFORMATION PROVIDED TO AID THE TECHINICIAN IN DIAGNOSING AND REPAIRING VARIOUS DOOR LOCK AND LATCH CONCERNS. *TT |
| Bulletin Number: 98123 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT |
| Bulletin Number: 98129 |
| SOME VEHICLES MAY EXHIBIT A 1ST GEAR "TICKING" NOISE. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 98151 |
| MALFUNCTION INDICATOR LAMP FAILED. YD |
| Bulletin Number: 981512 |
| A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98168 |
| TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982019 |
| CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC |
| Bulletin Number: 98205 |
| EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982312 |
| ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 982313 |
| SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION. |
| Bulletin Number: 982314 |
| PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982512 |
| SOME VEHICLES WITH HIGHER ODOMETER READINGS MAY EXPERIENCE A HESITATION ON ACCELERATION JUST OFF IDLE AND MISFIRE COMPLAINTS WITH MALFUNCTION INDICATOR LALMP ( MIL ) ON. *YC |
| Bulletin Number: 982544 |
| SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983106 |
| INFORMATION REGARDING ENGINE ASSEMBLIES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) PROGRAM. *TT |
| Bulletin Number: 983215 |
| SOME VEHICLES WITH MAY EXHIBIT HIGHER THAN NORMAL ENGINE IDLE SPEEDS. *TT |
| Bulletin Number: 983281 |
| SOME CUSTOMERS MAY EXPERIENCE A NOISE WHILE TURNING. *TT |
| Bulletin Number: 983283 |
| ADDRESSING A CONCERN WITH AN AMBER ABS WARNING INDICATOR ILLUMINATED WITH CODE 1095 OR 1096 STORED IN MEMORY OF THE 4WABS MODULE. *TT |
| Bulletin Number: 983312 |
| SOME VEHCILES MAY EXHIBIT A SLOW RETRACTING SEAT BELT. *TT |
| Bulletin Number: 983570 |
| SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT |
| Bulletin Number: 98418 |
| ABSENCE OF TEMPERATURE CONTROL ON SOME VEHICLES. *YC |
| Bulletin Number: 98419 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC |
| Bulletin Number: 98423 |
| SOME VEHICLES MAY EXPERIENCE A HARSH 1/2 SHIFT WHILE DRIVING UNDER LIGHT THROTTLE CONDITIONS. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 985097 |
| SOME VEHICLES WITH 4WABS MAY HAVE AN AMBER ABS WARNING INDICATOR ILLUMINATED WITH CODE C1095 OR C1096 STORED IN MEMORY OF THE 4WABS MODULE. *TT |
| Bulletin Number: 98510 |
| CONCERNS WITH NO TEMPERATURE CONTROL. *YC |
| Bulletin Number: 985102 |
| SOME VEHICLES THAT ARE LOADED TO THE UPPER END OF GVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *TT |
| Bulletin Number: 985153 |
| SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 9859 |
| A HARD TO TURN IGNITION KEY, AND/OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 98710 |
| A HARSH 1-2 SHIFT WHILE DRIVING UNDER LIGHT THROTTLE CONDITIONS. *YC |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 98E02 |
| REPROGRAMMINGPOWERTRAIN CONTROL MODULE CALIBRATION CODES ON SOME 1997 VEHICLES. *YC |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99141 |
| COMPLAINTS OF TIRE WEAR AND LOOSE FEELINGS IN THE STEERING SYSTEM. *TT |
| Bulletin Number: 99141 |
| SUBJECT REGARDING A HIGH NUMBER OF BALL JOINTS BEING REPLACED AS THE RESULT OF ROUTINE INSPECTIONS OR OF COMPLAINTS OF TIRE WEAR AND LOOSE FEELINGS IN THE STEERING SYSTEM. *TT |
| Bulletin Number: 991411 |
| SOME VEHICLES MAY EXHIBIT A CRACK ON THE RIGHT REAR SIDE OF THE #1 CROSSMEMBER RESULTING IN A CREAKING NOISE WHILE TURNING THE WHEEL OR DRIVING OVER UNEVEN SURFACES. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99164 |
| CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT |
| Bulletin Number: 991811 |
| SUBJECT REGARDING FRONT PASSENGER SIDE STEPWELL COVER NOT FLUSH. *TT |
| Bulletin Number: 99185 |
| VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 992311 |
| EXPERIENCING INTERMITTENT OR LOW RANGE OF THE REMOTE KEYLESS ENTRY (RKE) SYSTEM. *TT |
| Bulletin Number: 99236 |
| SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 996034 |
| EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT |
| Bulletin Number: 996890 |
| SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 9996 |
| EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT |
| Bulletin Number: 9997 |
| SOME VEHICLES MAY EXHIBIT A "SQUEAKING" OR "MOANING" NOISE FROM THE STEERING COLUMN WHILE TURNING. *TT |
| Bulletin Number: 99E03 |
| EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT |
| Bulletin Number: BC0042961101 |
| DIAGNOSTIC INSTRUCTIONS FOR ECONOLINES EQUIPPED WITH A PASSENGER SIDE AIRBAG AND AN ERROR CODE OF 29. *TW |
| Bulletin Number: BC0052970201 |
| 1997 ECONOLINE EQUIPPED WITH 7.3L ENGINES MAY EXPERIENCE AN INOPERATIVE CHARGING SYSTEM. THE TERMINAL B+ CONNECTION AT THE ALTERNATOR MAY BE BROKEN DUE TO HIGH TENSION ON THE TERMINAL FROM THE WIREING HARNESS. *JD |
| Bulletin Number: BC0052972301 |
| VEHICLES EQUIPPED WITH 7.3L ENGINES MAY EXPERIENCE AN INOPERATIVE CHARGING SYSTEM- THE TERMINAL B+ CONNECTION AT THE ALTERNATOR MAY BE BROKEN DUE TO HIGH TENSION ON THE TERMINAL FROM THE WIRING HARNESS. JD |
| Bulletin Number: BC0053970201 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0053972301 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0054961101 |
| VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY. *TW |
| Bulletin Number: BC0056972301 |
| SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD |
| Bulletin Number: BC007191101 |
| ECONOLINES WITH POWER WINDOWS MAY EXPERIENCE AN OPEN 30 AMP FUSE. *TW |
| Bulletin Number: BC0211970201 |
| POWER WINDOWS MAY EXPERIENCE AN OPEN 30 AMP FUSE. NEW WINDOW REGULATOR MOTOR. *JD |
| Bulletin Number: BC0315961101 |
| FEAD BELT SQUEAL, COLD ONLY. *TW |
| Bulletin Number: BC0315970201 |
| FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD |
| Bulletin Number: BC0320961101 |
| ROLLING IDLE/STALL. *TW |
| Bulletin Number: BC0320970201 |
| ROLLING IDLE/STALL. *JD |
| Bulletin Number: BC0320972301 |
| ROLLING IDLE/STALL- CYLINDER CONTRIBUTION TEST, AND INJECTOR BUZZ TEST. *JD |
| Bulletin Number: BC0322961101 |
| HARD STARTING WITH DTC'S P0341, P0344. *TW |
| Bulletin Number: BC0325972301 |
| SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD |
| Bulletin Number: BC0340961127 |
| CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW |
| Bulletin Number: BC0362961125 |
| IF ON A 1977 ECONOLINE THE KEY CHIMES SOUND 5 TIMES DURING THE START OR DURING VEHICLE OPERATION, THIS INDICATES THAT THE AIRBAG LAMP HAS A FAULT AND THERE IS A FAULT IN THE AIR BAG SYSTEM. *TW |
| Bulletin Number: BC0363961125 |
| 1997 ECONOLINES EQUIPPED WITH PASSENGER SIDE AIR BAG EXHIBITING CODE 29 OR OTHER INTERMITTENT AIR BAG CODES. *TW |
| Bulletin Number: BC0477961114 |
| ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS. *TW |
| Bulletin Number: BC0603961101 |
| CORRECTION TO 1997 ECONOLINE EVTM PAGE 60-5 - PIN CALL-OUTS ON ILLUSTRATIONS FOR C224 AND C225 ARE IN REVERSE ORDER. *TW |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0695961023 |
| 'OFF-IDLE' VIBRATION/BOOM/DRONE EMITTING FROM THE EXHAUST SYSTEM ON 4.2L ENGINES. *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0754961017 |
| VEHICLES MAY EXPERIENCE FLICKERING INTERIOR COURTESY LIGHTS WHILE TURNING OR GOING OVER BUMPS. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0853961007 |
| AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC1015297020 |
| VEHICLES MAY EXPERIENCE AN INOPERATIVE CHARGING SYSTEM. *JD |
| Bulletin Number: BC1015397020 |
| VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC1016997230 |
| REAR RADIO CONTROLS MAY EXPERIENCE INOPERATIVE REAR SPEAKERS. *JD |
| Bulletin Number: BC1020597230 |
| VEHICLES BUILT BETWEEN AUGUST 1996-SEPTEMBER 1996 WITH SPEED CONTROL AND AIRBAGS MAY EXPERIENCE A NOISE IN THE STEERING WHEEL WHILE TURNING. *JD |
| Bulletin Number: BC1022397230 |
| VEHICLES WITH 7.3L ENGINE WHICH AS A ROLLING IDLE CONDITION AND HAS A CALIBARATION OF 7-90C-R10, 7-90K-R10, 7-90N-R10. OR 7-90Q-R10, YOU CAN SERVICE THE IDLE CONDITION BY REPROGRAMMING THE PCM WITH THE FEBRUARY SBDS UPDATE DISK. *JD |
| Bulletin Number: BC1028197020 |
| FLASHING AIRBAG LIGHT AFTER REPLACING THE ECS MODULE. *JD |
| Bulletin Number: BC2393970501 |
| THE PROPER ADAPTER FOR CONNECTING THE 1997 ECONOLINE 4 WHEEL ANTI-LOCK BRAKE SYSTEM TO THE BREAKOUT BOX IS THE ROTUNDA 007-00108 ABS ADAPTER. *TW |
| Bulletin Number: BC3213970213 |
| CONTINUOUSLY FLASHING AIRBAG AFTER REPLACING THE ECS MODULE AND NO CODES PRESENT. *TW |
| Bulletin Number: BC3274970207 |
| REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A |
| Bulletin Number: BC3341973101 |
| EFFECTIVE IMMEDIATELY THE 5.8L ENGINE ASSEMBLY FOR THE VEHICLE IS AVAILABLE AS A FORD QUALITY RENEWAL ASSEMBLY. *JD |
| Bulletin Number: BC3373972301 |
| 7.3L ENGINE WHICH HAS A ROLLING IDLE CONDITION AND HAS A CALIBARATION OF 7-90CK-R10 OR 7-90N-R10, CAN SERVICE THE IDLE CONDITION BY REPROGRAMMING THE PCM WITH THE JANUARY SBDS UPDATE DISK. |
| Bulletin Number: BC3420972301 |
| VEHICLES BUILT BETWEEN AUGUST 1996 - SEPTEMBER 1996 WITH SPEED CONTROL AND AIR BAGS MAY EXPERIENCE A NOISE IN THE STEERING WHEEL WHILE TURNING. *JD |
| Bulletin Number: BC3551972301 |
| VEHICLES WITHOUT REAR RADIO CONTROLS MAY EXPERIENCE INOPERATIVE REAR SPEAKERS. *JD |
| Bulletin Number: BC5187961001 |
| EXPERIENCE VEHICLE W/ FLICKERING INTERIOR COURTESY LIGHTS WHILE TURNING OR GOING OVER BUMPS. *TT |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC5203961001 |
| 'OFF-IDLE' VIBRATION/BOOM/DRONE EMITTING FROM THE EXHAUST SYSTEM ON VEHICLES EQUIPPED W/ 4.2L ENGINES. *TT |
| Bulletin Number: BC5219961001 |
| INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT |
| Bulletin Number: DOR-X8B9R-11 |
| This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly ma |
| 1997 FORD ESCORT |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 0059 |
| SUBJECT CONCERNING THE IDLE-VIBRATION- 2.0L AND ZETEC ENGINES- SERVICE TIP. *MJS |
| Bulletin Number: 0069 |
| SOME VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE BRAKING, BRAKE DRAG AND/OR UNEVEN FRONT BRAKE PAD WEAR MAY OCCUR. *MJS |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 020901 |
| ROUGH IDLE, LOW POWER AND / OR STALL AT IDLE, A MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0300 THROUGH P0304 STORED IN MEMORY. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02208 |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH |
| Bulletin Number: 0291 |
| SOME VEHICLES EQUIPPED WITH THE 2.0L SPI ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND DIAGNOSTIC TROUBLE CODES (DTC) P0300 THROUGH P0304 STORED. *TT |
| Bulletin Number: 031515 |
| IDLE VIBRATION ON VEHICLES EQUIPPED WITH 2.0L SPI OR ZETEC ENGINE ONLY. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04V09 |
| TRW VEHICLE SAFETY SYSTEMS, INC. IS RECALLING CERTAIN SERVICE REPLACEMENT SEATBELT RETRACTORS (DRIVER'S SIDE FRONT RETRACTOR IN GRAY) MANUFACTURED IN DECEMBER 2002 AND SOLD AS A SERVICE REPLACEMENT PART BETWEEN DECEMBER 2002 AND JULY 2004. |
| Bulletin Number: 11518 |
| SOME VEHICLES MAY EXHIBIT CONCERNS CREATED BY WATER INGESTION INTO THE INTEGRATED RELAY CONTROL MODULE (IRCM). *TT |
| Bulletin Number: 11525 |
| INFORMATION ON THE DIFFERENT TYPES OF REMOTE KEYLESS ENTRY SYSTEMS. *TT |
| Bulletin Number: 11526 |
| THE WORKSHOP MANUAL REFERENCE TO TRANSMISSION FLUID TEMPERATURE SENSOR RESISTANCE IS INCORRECT. THIS BULLETIN LIST THE CORRECT RESISTANCE. *TT |
| Bulletin Number: 11769 |
| SOME VEHICLES MAY EXHIBIT BRIEF SPARK KNOCK ON ACCELERATION DURING HOT WEATHER ONCE THE ENGINE HAS THOROUGHLY WARMED UP. *TT |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12216 |
| THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12294 |
| SUBJECT REGARDING THE NGS FUEL ECONOMY TEST. *TT |
| Bulletin Number: 12295 |
| SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON, STALL AT TIP-IN FROM IDLE, ENGINE HESITATION, AND / OR SURGE CAUSED BY THE MASS AIR FLOW (MAF) SENSOR. *TT |
| Bulletin Number: 12594 |
| SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR (TR). *TT |
| Bulletin Number: 12834 |
| BRIEF INFORMATION REGARDING TRANSMISSION FLUID. *TT |
| Bulletin Number: 13107 |
| CONCERNS WITH LACK OF HEAT / THERMOSTAT CONTAMINATION. *TT |
| Bulletin Number: 13160 |
| VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGER SENSOR (TRS). *TT |
| Bulletin Number: 13162 |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT |
| Bulletin Number: 13214 |
| INFORMATION REGARDING BRAKE CALIPER PIN CORROSION. *MJS |
| Bulletin Number: 13421 |
| SOME VEHICLES MAY EXHIBIT GRINDING NOISES, OR GREATER THAN NORMAL BRAKE ROUGHNESS WHEN APPLYING THE BRAKES IMMEDIATELY AFTER INSTALLING MOTORCRAFT BR-18 FRONT BRAKE PAD. *TT |
| Bulletin Number: 13494 |
| SOME VEHICLES WITH THE 2.0L SPI ENGINE MAY EXHIBIT A LACK OF HEAT AND TEMPERATURE GAUGE READING COLD. *TT |
| Bulletin Number: 14846 |
| SOME VEHICLES WITH 2.0L SPI ENGINE ONLY, MAY EXHIBITA BURNING OIL SMELL NOTED FROM OUTSIDE OR FROM WITHIN THE PASSENGER COMPARTMENT. *TT |
| Bulletin Number: 14993 |
| SOME VEHICLES PRODUCED THROUGH JULY 1999 MAY EXHIBIT REAR SUSPENSION SPRING FAILURE WITH NO RESULTING OPERATIONAL CONCERN. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 5264 |
| INFORMATION CONCERNING CLICK NOISE FROM FRONT CALIPERS DURING BRAKE APPLICATION. *TT |
| Bulletin Number: 5381 |
| BRIEF INFORMATION STATING THAT THE NGS FUEL ECONOMY TEST ON SOME VEHICLES MAY NOT FUNCTION PROPERLY. *TT |
| Bulletin Number: 6416 |
| BRIEF INFORMATION REGARDING TRANSMISSION FLUID APPEARANCE. *TT |
| Bulletin Number: 6932 |
| SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MIL ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR. *TT |
| Bulletin Number: 6934 |
| CONCERNS WITH A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT |
| Bulletin Number: 7076 |
| INFORMATION REGARDING BRAKE CALIPER PIN CORROSION. *MJS |
| Bulletin Number: 7292 |
| NNERS OF THE EDSR-OF-THE-MONTH QUALITY AWARD ANNOUNCEMENT FOR SEPTEMBER. *TT |
| Bulletin Number: 7369 |
| SOME VEHICLES MAY EXHIBIT GRINDING NOISE, OR GREATER THAN NORMAL BRAKE ROUGHNESS, WHEN APPLYING THE BRAKES IMMEDIATELY AFTER INSTALLING MOTORCRAFT FRONT BRAKE PAD PART NUMBER BR-18 (XU2Z-2V001-RA). *T |
| Bulletin Number: 8316 |
| SOME VEHICLES EQUIPPED WITH COMPACT DISC CHANGER MAY EXHIBIT A 6 DISC CD CHANGER THAT IS NOT EJECTING THE MAGAZINE OR IS NOT RESPONDING TO COMMAND FROM THE RADIO. |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 9623A1 |
| 1997 ESCORT/TRACER - FIX IT RIGHT TIPS - COMMON LOCATIONS OF INTERMITTENT VISUAL CONCERNS. *TW |
| Bulletin Number: 9623A2 |
| 1997 ESCORT/TRACER ELECTRICAL INTERMITTENT - INSPECTION AREAS. *TW |
| Bulletin Number: 9623A3 |
| 1997 ESCORT/TRACER - FIX IT RIGHT TIPS - WATER LEAKS. *TW |
| Bulletin Number: 9623A4 |
| 1997 ESCORT/TRACER - FIX IT RIGHT TIPS - COMMON LOCATIONS OF INTERMITTENT VIBRATION, PULL AND SHUDDER CONCERNS. *TW |
| Bulletin Number: 9623A5 |
| 1997 ESCORT/TRACER - FIX IT RIGHT TIPS - COMMON LOCATIONS OF INTERMITTENT NOISE/SQUEAK AND RATTLE CONCERNS. *TW |
| Bulletin Number: 9623A6 |
| 1997 ESCORT/TRACER - FIX IT RIGHT TIPS - COMMON LOCATIONS OF INTERMITTENT ODOR CONCERNS. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962510 |
| MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 AND/OR P0308 STORED IN MEMORY. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96265 |
| MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMORY. *TW |
| Bulletin Number: 97050110606 |
| THE POWER STEERING TRANSDUCER IS NOW AVAILABLE AS A SERVICEABLE COMPONENT. *TW |
| Bulletin Number: 97050110628 |
| FUEL DIAGNOSTICS WERE COMPUTER EXHIBITS DTC 300. *YC |
| Bulletin Number: 9705013906 |
| HOTLINE INFORMATION REGARDING AUDIO REPAIR. *YC |
| Bulletin Number: 97111097234 |
| VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC |
| Bulletin Number: 9734 |
| MALFUNCTION INDICATOR LAMP- MIL ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE 0401 STORED IN MEMORY- VEHICLES EQUIPPED WITH 2.0L ENGINE. *JD |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9744 |
| EXHAUST- EXHAUST NOISE FROM BEHIND INSTRUMENT PANEL OR REAR OF ENGINE- 2.0L VEHICLES BUILT THROUGH 9/1/96. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 97610 |
| BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD |
| Bulletin Number: 97612 |
| NOISE- "BUZZING" NOISE HEARD FROM INSTRUMENT PANEL AREA FOR 3 SECONDS AFTER IGNITION SWITCH IS TURNED OFF AND/OR AT ENGINE IDLE SPEED ON DECELERATION WHILE DRIVING- VEHICLES WITH 2.0L ENGINE. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 980316 |
| CONDITION REGARDING THE ENGINE MISFIRE CODE ( DTC P0304 ). *YC |
| Bulletin Number: 9811340 |
| INFORMATION ON REPLACING THE WIRING HARNESS ON SOME VEHICLES. *TT |
| Bulletin Number: 9811345 |
| ENGINEERING IS INVESTGATING VEHICLES EXHIBITING A CONDITION IN WHICH THE IGNITION KEY IS DIFFICULT TO TURN AND / OR DIFFICULT TO REMOVE THE FROM THE SWITCH. *TT |
| Bulletin Number: 9811473 |
| SOME VEHICLES MAY EXHIBIT A CUSTOME CONCERN OF STEADY OR INTERMITTENT MISS WITH DIAGNOSTIC TROUBLE CODES P0300 AND P0304. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 981512 |
| A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK |
| Bulletin Number: 981520 |
| INTEGRATED AIR BAG MONITOR REPLACEMENT SERVICE KIT. YD |
| Bulletin Number: 9819 |
| SOME VEHICLES MAY EXHIBIT INTERMITTENT OPERATION OR INOPERATIVE INTERIOR DOME LAMP. *TT |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982017 |
| EXPERIENCING " SQUEAKING " AND / OR " RATTLING " NOISES MAY OCCUR DURING DIFFERENT DRIVING CHARACTERISTICS AND FROM VARYING POINTS ON THE VEHICLE. *YC |
| Bulletin Number: 982037 |
| INITIAL PRINTING OF 1997 SERVICE MANUAL CONTAINED INCORRECT ALIGNMENT SPECIFICATIONS.GN |
| Bulletin Number: 98204 |
| A PORTION OF FOAM TAPE AT THE WINDSHIELD AND INSTRUMENT PANEL (I/P) MAY BE STICKING OUT ON SOME VEHICLES. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982534 |
| SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF STEADY OR INTERMITTENT MISS WITH DTCS P0300 AND P0304. THIS MAY BE CAUSED BY A SPREAD ELECTRICAL TERMINAL IN CONNECTORS AT INJECTOR. REPAIR TERMINAL/CONNECTOR CONCERN BY USING A SMALL SCRE |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983103 |
| CONDITIONS WITH CARPET PULLING OUT FROM UNDERNEATH THE LEFT / RIGHT COWL SIDE TRIM PANEL. *TT |
| Bulletin Number: 983162 |
| CONCERNS WITH PAINT STAINS ON THE HOOD WHICH MAY BE CAUSED BY WINDSHIELD WASHER SOLVENT LEAKING FROM THE WINDSHIELD WASHER JETS WHILE DRIVING. *TT |
| Bulletin Number: 983218 |
| ENGINEERING IS INVESTIGATING IF ANY HEADLAMP CONCERNS EXIST FOR SOME VEHICLES. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A12 |
| RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9861 |
| DIFFICULTIES REMOVING KEY FROM IGNITION ON SOME VEHICLES. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9874 |
| A NEW SILICONE GASKET AND SEALANT. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99195 |
| SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 996877 |
| SOME VEHICLES EQUIPPED WITH 2.0L SPI ENGINE MAY EXHBIT A LACK OF HEAT AND TEMPERATURE GAUGE READING COLD. *TT |
| Bulletin Number: 99810 |
| EXHIBITING A CLICKING NOISE HEARD WHILE APPLYING THE BRAKES AFTER CHANGING VEHICLE DIRECTION ON SOME VEHICLES. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: BC0014970201 |
| VEHICLES BUILT THRU 6/96 MAY EXHIBIT A "BUZZING" NOISE FROM THE DASH PANEL AREA FOR APPROXIMATELY 3 SECONDS AFTER THE IGNITION IS SWITCHED OFF. *JD |
| Bulletin Number: BC0014972301 |
| VEHICLES BUILT THRU 6/96 MAY EXHIBIT A "BUZZING" NOISE FROM THE DASH PANEL AREA FOR APPROXIMATELY 3 SECONDS AFTER THE IGNITION IS SWITCHED OFF. *JD |
| Bulletin Number: BC0131970201 |
| VEHICLES HAVING A WATER LEAK CONCERN UNDER THE DRIVE AND/OR PASSENGER FRONT SEATS. *JD |
| Bulletin Number: BC0181970201 |
| INITIAL PRINTING OF THE 1997 SERVICE MANUAL CONTAINED INCORRECT ALIGNMENT SPECIFICATIONS. *JD |
| Bulletin Number: BC0265970201 |
| EXHIBITING AN AIR BAG WARNING LIGHT. DTC 13 OR 51. *JD |
| Bulletin Number: BC0267970201 |
| THE CARGO/TRUNK LAMP LENS/COVER HAS BEEN DELETED AS OF 10/1/96. *JD |
| Bulletin Number: BC0300970201 |
| MIL LIGHT ON WITH DTC'S P0443 AND P1443. *JD |
| Bulletin Number: BC0407961115 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW |
| Bulletin Number: BC0490961112 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW |
| Bulletin Number: BC0540961107 |
| VEHICLES MAY EXHIBIT A "CLICK" NOISE FROM THE AREA OF THE FRONT CV JOINTS WHILE SHIFTING BETWEEN DRIVE AND REVERSE. *TW |
| Bulletin Number: BC0717961021 |
| INFORMATION FOR WHEN REPLACING AN INTERIOR TRIM COMPONENT UNDER WARRANTY. *TT |
| Bulletin Number: BC0760961016 |
| WAVE SPRING LOCATED UNDER THE FORWARD ONE-WAY CLUTCH IN NO LONGER ONE PIECE. IT HAS BEEN 'SPLIT'. *TT |
| Bulletin Number: BC0770961015 |
| DIAGNOSING VEHICLES WHICH EXHIBIT THE SYMPTOM OF BRAKE DRAG. *TT |
| Bulletin Number: BC1016697020 |
| VEHICLES BUILT THRU 6/96 MAY EXHIBIT A "BUZZING" NOISE FORM THE DASH PANEL AREA FOR APPROXIMATELY 3 SECONDS AFTER THE IGNITON IS SWITCHED OFF. *JD |
| Bulletin Number: BC1018097230 |
| THE ROOF RACK CROSS BAR WAS REVISED TO ELIMINATE THE ADHESIVE STRIP ON THE BOTTOM SURFACE. *JD |
| Bulletin Number: BC1020297230 |
| ENGINE BLOCK HEATER KIT (#F7CZ-6D008-AA) INSTRUCTION SHEET #7000 HAS A MISPRINT ON INSTALLATION INSTRUCTION #8. *JD |
| Bulletin Number: BC1020397230 |
| VEHICLES WHICH EXHIBIT AUTOMATIC TRANSMISSION SHIFTER ISSUES RESULTING IN EITHER THE INABILITY TO REMOVE THE IGNITION KEY FROM THE IGNITION LOCK CYLINDER, OR INABILITY TO MOVE THE SHIFTER OUT OF "PARK". *JD |
| Bulletin Number: BC1023197230 |
| ABS WARNING LIGHT AND NO DIAGNOSTIC CODES SHOULD BE INSPECTED FOR A POOR ELECTRICAL GROUND AT G-302. *JD |
| Bulletin Number: BC1030797020 |
| HEADLAMP CONCERN. *JD |
| Bulletin Number: BC105139705 |
| SOME VEHICLES MAY EXHIBIT A MIL (MALFUNCTION INDICATOR LAMP) AND DTC (DIAGNOSTIC TROUBLE CODE) P1443 STORED IN MEMORY WITH NO DRIVEABILITY CONCERNS. *TW |
| Bulletin Number: BC2231970501 |
| THE POWER STEERING TRANSDUCER IS NOW RELEASED AS A SERVICEABLE COMPONENT. *TW |
| Bulletin Number: BC2430970501 |
| SOME VEHICLES MAY EXHIBIT A SLIGHT DELAY FROM PARK-TO-REVERSE AND PARK-TO-DRIVE AFTER BEING PARKED FOR A LENGTHY PERIOD OF TIME. *TW |
| Bulletin Number: BC3080970226 |
| INTERMITTENT MIL LIGHTS MAY BE DUE TO CHAFING OF THE INJECTOR WIRE HARNESS. *TW |
| Bulletin Number: BC3218970213 |
| HEADLAMP CONCERNS FOR ESCORT/TRACER. *TW |
| Bulletin Number: BC3218970501 |
| ENGINEERING IS INVESTIGATING IF ANY HEADLAMP CONCERNS EXIST FOR 97 ESCORT/TRACER. *TW |
| Bulletin Number: BC3340972301 |
| RADIO WIRE HARNESS SHORTED TO GROUND AT THE RADIO CHASSIS. *JD |
| Bulletin Number: BC3340973101 |
| THE RADIO WIRE HARNESS SHORTED TO GROUND AT THE RADIO CHASSIS. *JD |
| Bulletin Number: BC3352972301 |
| VEHICLES WHICH EXHIBIT AN ABS WARNING LIGHT AND NO DIAGNOSTIC CODES SHOULD BE INSPECTED FOR A POOR ELECTRICAL GROUND AT G-302. *JD |
| Bulletin Number: BC3431972301 |
| THE ENGINE BLOCK HEATER KIT INSTRUCTION SHEET #7000 HAS A MISPRINT ON INSTALLATION INSTRUCTION #8. *JD |
| Bulletin Number: BC3432972301 |
| VEHICLES EXHIBIT AUTOMATIC TRANSMISSION SHIFTER ISSUES RESULTING IN EITHER THE INABILITY TO REMOVE THE IGNITION KEY FORM THE IGNITION LOCK CYLINDER, OR INABILITY TO MOVE THE SHIFTER OUT OF "PARK." *JD |
| Bulletin Number: BC3514972301 |
| ROOF RACK CROSS BAR WAS REVISED TO ELIMINATE THE ADHESIVE STRIP ON THE BOTTOM SURFACE. *JD |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9666961001 |
| 2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC9714961101 |
| DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW |
| 1997 FORD E SERIES |
|---|
| Bulletin Number: 01119 |
| SOME VEHICLES WITH HIGH ODOMETER READING OR SEVERE SERVICE MAY EXHIBIT A CREAKING NOISE WHEN TURNING WHEEL OR DRIVING OVER UNEVEN SURFACES ON VEHICLES PRODUCE BEFORE 2/6/2001. *TT |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01221 |
| SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT |
| Bulletin Number: 01233 |
| SOME DEDICATED AND BI-FUEL CNG VEHICLES MAY EXHIBIT A CONDITION OF FUEL LEAK OR FUEL ODOR AT THE CNG FUEL FILL VALVE AREA. *TT |
| Bulletin Number: 01234 |
| SOME VEHICLES EQUIPPED WITH AFTERMARKET HIGH-CURRENT DEVICES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR MODULE. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 020503 |
| GUIDANCE FOR CNG TANK INSPECTION FOR VEHICLES PRODUCED AFTER DECEMBER 2, 1996. *TT UPDATE. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02168 |
| REPORTS THAT CERTAIN VEHICLES APPEAR TO BE DOGTRACKING. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02221 |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ |
| Bulletin Number: 0253 |
| SUBJECT REGARDING ALTERNATIVE FUEL VEHICLE COMPRESSED NATURAL GAS TANK INSPECTION. *TT |
| Bulletin Number: 030402 |
| ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT |
| Bulletin Number: 031404 |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. |
| Bulletin Number: 03144 |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03183 |
| DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT |
| Bulletin Number: 03206 |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, |
| Bulletin Number: 032122 |
| ROLLING IDLE, SURGE ON VEHICLES BUILT 8/96 THROUGH 12/96 WITH 7.3L ENGINE. *TT |
| Bulletin Number: 032145 |
| EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT |
| Bulletin Number: 032306 |
| DIAGNOSTIC TROUBLE CODE B1876, B1880, B1915 AND/OR B1920 IN THE ECS MODULE - VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT |
| Bulletin Number: 03236 |
| DIAGNOSTIC TROUBLE CODES (DTC) B1876, B1880, B1915 AND/OR B1920 AIRBAG ELECTRONIC CRASH SENSOR (ECS) MODULE ON VEHICLES EQUIPPED WITH AFTERMARKET HIGH CURRENT DEVICES. *TT |
| Bulletin Number: 03261 |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT |
| Bulletin Number: 0342 |
| POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 041601 |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04266 |
| A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT |
| Bulletin Number: 05417 |
| INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT |
| Bulletin Number: 07212 |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE |
| Bulletin Number: 11776 |
| SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT |
| Bulletin Number: 11796 |
| SOME VEHICLES MAY EXHIBIT POWER DOOR LOCKS THAT SELF ACTIVATE, ARE INOPERATIVE, OR REMOTE KEYLESS ENTRY INOPERATIVE DURING OR AFTER WET CONDITIONS. *TT |
| Bulletin Number: 12070 |
| VEHICLES THAT ARE LOADED TO THE UPPER END OF FVW, WITH THE MAJORITY OF THE LOAD BETWEEN THE AXLES, MAY EXHIBIT INNER EDGE TIRE WEAR DUE TO INCORRECT ALIGNMENT. *MJS |
| Bulletin Number: 12123 |
| VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT, DUE TO INCORRECT FRONT END ALIGNMENT SETTINGS. *MJS |
| Bulletin Number: 12162 |
| SOME VEHICLES EQUIPPED WITH 6.8L ENGINES, MAY EXHIBIT A CUSTOMER CONCERN OR ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12298 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT |
| Bulletin Number: 12556 |
| SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT |
| Bulletin Number: 12593 |
| CONCERNS WITH CRACKS ON THE RIGHT REAR SIDE OF THE #1 FRAME CROSSMEMBER. *TT |
| Bulletin Number: 12741 |
| SOME VEHICLES UNDER SEVERE DUTY CYCLES MAY EXHIBIT CRACKS ON THE LOWER RADIATOR SUPPORT. *TT |
| Bulletin Number: 12743 |
| EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT |
| Bulletin Number: 12744 |
| SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT |
| Bulletin Number: 12798 |
| SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 12870 |
| SOME CUSTOMERS MAY COMMENT ON A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT |
| Bulletin Number: 12915 |
| CUSTOMER MAY COMPLAIN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT |
| Bulletin Number: 13117 |
| SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS. *TT |
| Bulletin Number: 13285 |
| EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 13322 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 13331 |
| SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 13832 |
| SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT |
| Bulletin Number: 13870 |
| CONCERNS WITH A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT |
| Bulletin Number: 13934 |
| SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT |
| Bulletin Number: 14240 |
| SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS EXPERIENCED BEST IN A SLIGHT TURN, AT SPEEDS NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. ENGINEERING IS ADDRESSING T |
| Bulletin Number: 14374 |
| SUBJECT REGARDING FRONT SUSPENSION INSPECTION PROCEDURES. *JB |
| Bulletin Number: 14455 |
| OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT |
| Bulletin Number: 14514 |
| EXPERIENCING A CLUNKING TYPE NOISE THAT CAN BE FELT OR HEAR THROUGH THE STEERING WHEEL. CONDITION BEST EXPERIENCED IN A SLIGHT TURN, NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. *TT |
| Bulletin Number: 14514 |
| SOME VEHICLES MAY EXHIBIT A CLUNK THAT CAN BE FELT OR HEARD THROUGH THE STEERING WHEEL. THE CONDITION IS BEST EXPERIENCED IN A SLIGHT TURN, NEAR 20 MPH, ON ROAD SURFACES WITH SLIGHT IRREGULARITIES. *TT |
| Bulletin Number: 14735 |
| SOME VANS / WAGONS WITH 138 INCH WHEELBASE AND 4R70W TRANSMISSION (DRIVE SHAFT >70 INCH) MAY EXHIBIT A VIBRATION BOOM UNDER HEAVY ACCELERATION (WOT) OR A LOADED DRIVE MODE. *TT |
| Bulletin Number: 14943 |
| SOME VEHICLES MANUFACTURED AS INCOMPLETE VEHICLES (1FD IN THE FIRST THREE POSITIONS OF VIN) EQUIPPED WITH A POWER SEAT PEDESTAL (OPTION 21Z), BUT MANUFACTURED WITHOUT A SEAT, MAY HAVE A CONDITION OF REPEAT POWE SEAT TRACK FAILURE. |
| Bulletin Number: 15099 |
| SOME VEHICLES MAY EXHIBIT DRIVELINE CLUNK / THUMP NOISE CONDITION ON INITIAL ACCELERATION FROM A STOP. |
| Bulletin Number: 15150 |
| SOME E-SERIES EQUIPPED WITH AN RV MODIFIED POWER SEAT MAY EXHIBIT FAILURE OF THE POWER PEDESTAL MOTOR. *ET |
| Bulletin Number: 15161 |
| SOME VEHICLES MAY EXHIBIT A FUEL LEAK AT CNG FILL VALVE. *YH |
| Bulletin Number: 15218 |
| INFORMATION ON A REINFORCEMENT KIT FOR VEHICLES EXHIBITING FAILURE OF THE POWER SEAT PEDESTAL MOTOR. *TT |
| Bulletin Number: 15355 |
| SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT |
| Bulletin Number: 15373 |
| SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT |
| Bulletin Number: 15397 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT |
| Bulletin Number: 15901 |
| THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT |
| Bulletin Number: 16040 |
| EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT |
| Bulletin Number: 16515 |
| OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT |
| Bulletin Number: 16916 |
| REPEATED BLOWN FUSES FOR REAR IN VEHICLE CIRCUITS WITH INOPERATIVE REAR BRAKE OR TAIL LAMPS. *TT |
| Bulletin Number: 17254 |
| CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT |
| Bulletin Number: 17320 |
| BROKEN EXHAUST MANIFOLD STUDS. *TT |
| Bulletin Number: 17385 |
| AIR BAG LAMP ILLUMINATED. *TT |
| Bulletin Number: 17777 |
| REAR LEAF SPRING NOISE. *TT |
| Bulletin Number: 4658 |
| SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT |
| Bulletin Number: 4684 |
| SOME VEHICLES MAY EXHIBIT POWER DOOR LOCKS THAT SELF ACTIVATE, ARE INOPERATIVE, OR REMOTE KEYLESS ENTRY INOPERATIVE DURING OR AFTER WET CONDITIONS. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 6290 |
| INFORMATION REGARDING THE IMPROVED RADIATOR SUPPORT. *TT |
| Bulletin Number: 6350 |
| SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 6417 |
| ADDRESSING TIRE BALANCE HINTS. *TT |
| Bulletin Number: 6461 |
| CONCERNS OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *T |
| Bulletin Number: 6538 |
| SOME VEHICLES BUILT BEFORE APRIL 1, 1999 MAY HAVE A CUSTOMER CONCERN OF A CLUNK FELT / HEARD IN THE STEERING WHEEL. *TT |
| Bulletin Number: 6599 |
| SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH. |
| Bulletin Number: 8058 |
| SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR |
| Bulletin Number: 8058 |
| SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT |
| Bulletin Number: 8138 |
| SOME VEHICLES MAY EXHIBIT A NO START CONDITION AFTER INSTALLATION OF A NEW 6.8L ENGINE ASSEMBLY. *TT |
| Bulletin Number: 8260 |
| SOME VEHICLES MAY EXHIBIT A-PILLAR SHEET METAL CRACKS AROUND FRONT DOOR HINGES; FRONT DOOR SKIN SEPARATES AND DOOR INNER SHEET METAL CRACKED AROUND FRONT HINGES; OR FRONT DOORS OPEN TOO FAR AND EXTEND INTO THE FRONT FENDERS. *TT |
| Bulletin Number: 870197 |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT |
| Bulletin Number: 976007 |
| BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT |
| Bulletin Number: 980301 |
| CONDITION WITH ROUGH IDLE. *YC |
| Bulletin Number: 980301 |
| EXPERIENCING ROUGH IDLE/MISS. *AK |
| Bulletin Number: 980302 |
| SOME VEHICLES EXPERIENCING HARD START/ NO START. *YC |
| Bulletin Number: 980303 |
| SYMPTOMS WITH LACK OF POWER. VERIFY ACTUAL ENGINE TURBO-BOOST AS OUTLINED ON THE DIAGNOSTIC SHEET. *AK |
| Bulletin Number: 980304 |
| COMPLAINTS REGARDING THE FUEL ECONOMY. *YC |
| Bulletin Number: 980307 |
| CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC |
| Bulletin Number: 980317 |
| PARK BRAKE CABLE DRAG, CAUSING REAR BRAKE VIBRATION. *AK |
| Bulletin Number: 980323 |
| CONCERNS WITH EXTERNAL OIL LEAKS. *YC |
| Bulletin Number: 982733 |
| VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC |
| Bulletin Number: 985072 |
| SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT |
| Bulletin Number: 985153 |
| SOME VEHICLES MAY EXHIBIT A STEERING PULL TO THE RIGHT OR LEFT. *TT |
| Bulletin Number: 985199 |
| SOME VEHICLES EQUIPPED WITH 6.8L ENGINE, MAY EXHIBIT A CUSTOMER CONCERN OF ENGINE ROAR OR ENGINE NOISE FOR THE FIRST FEW MINUTES OF OPERATION AFTER A COLD START. *MJS |
| Bulletin Number: 991411 |
| SOME VEHICLES MAY EXHIBIT A CRACK ON THE RIGHT REAR SIDE OF THE #1 CROSSMEMBER RESULTING IN A CREAKING NOISE WHILE TURNING THE WHEEL OR DRIVING OVER UNEVEN SURFACES. *TT |
| Bulletin Number: 996130 |
| INFORMATION ON THE IMPROVED LOWER INTAKE MANIFOLD SIDE GASKETS. *TT |
| Bulletin Number: 996890 |
| SOME VEHICLES WITH AN ILLUMINATED AIR BAG LAMP MAY HAVE MODIFIED SEAT CONFIGURATIONS WHICH MAY HAVE BEEN CHANGED BY MODIFIERS OR THE CUSTOMER. *TT |
| Bulletin Number: BC0053970201 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0255970201 |
| 4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD |
| Bulletin Number: BC0256970201 |
| A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0695961023 |
| 'OFF-IDLE' VIBRATION/BOOM/DRONE EMITTING FROM THE EXHAUST SYSTEM ON 4.2L ENGINES. *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0853961007 |
| AIRBAG LIGHT ON & CODE 21, MAY BE CAUSED BY AN ELECTROMAGNETIC INTERFERENCE GENERATED WITHIN THE ELECTRICAL SYSTEM. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC5219961001 |
| INCORRECT INFORMATION IN 1997 EVTM MANUAL. PIN CALL-OUTS ILLUSTRATIONS FOR C224 & C225 ARE IN REVERSE ORDER. *TT |
| Bulletin Number: TSB-11-11-21 |
| FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE |
| 1997 FORD E-SERIES |
|---|
| Bulletin Number: 07212 |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE |
| Bulletin Number: TSB-11-11-21 |
| FORD: THE BLOWER MOTOR ON SOME VEHICLES ARE OPERATING EITHER INCORRECTLY OR NOT OPERATING OR JUST FUNCTIONING ON ONE SPEED. *PE |
| 1997 FORD E-SUPER DUTY |
|---|
| Bulletin Number: 6599 |
| SOME VEHICLES WITH MODEL 80 REAR AXLES ONLY MAY EXHIBIT A CONCERN WITH THE AMOUNT OF SOUND, WHINE PRODUCED ABOVE 35 MPH. |
| 1997 FORD EXCURSION |
|---|
| Bulletin Number: 17467 |
| ENGINE OR FUEL SYSTEM CONCERNS WHEN USING FUEL WITH GREATER THAN 5% BIODIESEL CONCENTRATION. *TT |
| Bulletin Number: 17571 |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT |
| 1997 FORD EXPEDITION |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 0017 |
| SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS |
| Bulletin Number: 0018 |
| VEHICLES EQUIPPED WITH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) , MAY EXERIENCE THE BLOWER MOTOR STAYING ON HIGH AFTER DESIRED TEMPERATURE IS REACHED AND/ OR THE SYSTEM DOES NOT MAINTAIN SET TEMPERATURE. *MJS |
| Bulletin Number: 00201 |
| SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 00261 |
| SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT |
| Bulletin Number: 01128 |
| SOME VEHICLES MAY EXHIBIT A CHECK SUSPENSION LAMP ON WITH DIAGNOSTIC TROUBLE CODES B2140 OR C2140 EVEN AFTER THE AIR SUSPENSION SWITCH IN THE UPPER RH KICK PANEL HAS BEEN TURNED ON. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01166 |
| SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01215 |
| A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 0162 |
| VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02193 |
| DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ |
| Bulletin Number: 02208 |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH |
| Bulletin Number: 030709 |
| REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT |
| Bulletin Number: 031404 |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. |
| Bulletin Number: 03144 |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 031513 |
| TIE ROD END INSPECTION PROCEDURE. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03610 |
| TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB |
| Bulletin Number: 0392 |
| REPEAT AIR SUSPENSION COMPRESSOR DRIER FAILURES. *TT |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 0399 |
| TIE ROD END INSPECTION PROCEDURE. *TT |
| Bulletin Number: 041601 |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 0454 |
| AIR SUSPENSION COMPRESSOR NOISE. *TT |
| Bulletin Number: 0457 |
| POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT |
| Bulletin Number: 04L19 |
| CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT |
| Bulletin Number: 050618 |
| REAR AXLE NOISE REPAIR. *SC |
| Bulletin Number: 0554 |
| USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT |
| Bulletin Number: 05618 |
| REAR AXLE NOISE REPAIR. *TT |
| Bulletin Number: 07212 |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE |
| Bulletin Number: 090308 |
| MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455 |
| Bulletin Number: 11530 |
| WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A |
| Bulletin Number: 11781 |
| INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT |
| Bulletin Number: 11806 |
| SUBJECT REGARDING A MISSING RUBBER STOP BUMPER FROM THE PARKING BRAKE COTNROL. *TT |
| Bulletin Number: 12139 |
| SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS |
| Bulletin Number: 12154 |
| SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS |
| Bulletin Number: 12170 |
| INFORMATION CONCERNING THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION/SPARK KNOCK. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12216 |
| THIS BULLETIN MENTIONS THAT FOR ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12227 |
| FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12282 |
| SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT |
| Bulletin Number: 12529 |
| SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT |
| Bulletin Number: 12572 |
| VEHICLES MAY EXHIBIT A HIGH SPEED DRIVELINE VIBRATION. *TT |
| Bulletin Number: 12720 |
| SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT |
| Bulletin Number: 12738 |
| SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION. |
| Bulletin Number: 12743 |
| EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT |
| Bulletin Number: 12767 |
| EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT |
| Bulletin Number: 12796 |
| ON SOME VEHICLES, THE DOOR TRIM PANELS MAY HAVE LOOSE OR BROKEN PULL HANDLES. *TT |
| Bulletin Number: 12797 |
| ADDRESSING CONCERNS OF A LOW SPEED (UNDER 35 MPH) CLICKING NOISE CAUSED BY A CAGE NUT ROCKING ON THE COTTER PIN FOR THE FRONT AXLE HALF SHAFT SPINDLE. *TT |
| Bulletin Number: 12798 |
| SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 12905 |
| SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT |
| Bulletin Number: 12994 |
| SUBJECT REGARDING A/C VACUUM RESERVOIR / CHECK VALVE LOCATION FOR THE AIR CONDITIONING SYSTEM. *TT |
| Bulletin Number: 13054 |
| EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT |
| Bulletin Number: 13106 |
| ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT |
| Bulletin Number: 13285 |
| EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 13322 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 13331 |
| SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 13342 |
| VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT |
| Bulletin Number: 13505 |
| ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT |
| Bulletin Number: 13711 |
| SUBJECT REGARDING THE SERVICING OF TRAILER HITCHES ON VEHICLES. *MJS |
| Bulletin Number: 13712 |
| INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT. *MJS |
| Bulletin Number: 13744 |
| SOME VEHICLES MAY EXHIBIT A BODY BOOM WHILE DRIVING HIGHWAY SPEEDS. *MJS |
| Bulletin Number: 13745 |
| SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS |
| Bulletin Number: 13773 |
| INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT. *MJS |
| Bulletin Number: 13832 |
| SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT |
| Bulletin Number: 13838 |
| CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT |
| Bulletin Number: 14197 |
| SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION. *TT |
| Bulletin Number: 14359 |
| SUBJECT PERTAINING TO AIR SUSPENSION LEAKS. *JB |
| Bulletin Number: 14365 |
| THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB |
| Bulletin Number: 14372 |
| INFORMATION ON IDLE VIBRATION OR ENGINE DROAN ON ACCELERATION. *JB |
| Bulletin Number: 14609 |
| SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB |
| Bulletin Number: 14905 |
| SOME VEHICLES MAY EXHIBIT AMBER ANTI-LOCK BRAKE SYSTEM (ABS) LAMP ON WITH UNDEFINED DIAGNOSTIC TROUBLE CODES (DTCS) STORED. *TT |
| Bulletin Number: 15122 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC |
| Bulletin Number: 15123 |
| SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC |
| Bulletin Number: 15152 |
| SOME VEHICLES MAY EXHIBIT COURTESY RAIL LAMPS ABOVE THE 2ND ROW SEATS THAT DO NOT OPERATE PROPERLY OR CAUSE A BATTERY DRAW. *ET |
| Bulletin Number: 15362 |
| SOME VEHICLES MAY EXHIBIT AIR SUSPENSION MALFUNCTION. *TT |
| Bulletin Number: 15480 |
| SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING RE-FUELED. *TT |
| Bulletin Number: 15504 |
| SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT |
| Bulletin Number: 15517 |
| SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD |
| Bulletin Number: 15526 |
| SUBJECT REGARDING INOPERATIVE RUNNING BOARD LIGHTS.*YD |
| Bulletin Number: 15528 |
| SUBJECT REGARDING AIR SUSPENSION COMPRESSOR QUALITY. *YD |
| Bulletin Number: 15549 |
| INFORMATION REGARDING POP/THUMP NOISE FROM POWER WINDOW. *YH |
| Bulletin Number: 15605 |
| SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT |
| Bulletin Number: 15648 |
| SOME VEHICLES MAY EXHIBIT A SLOW FUEL FILL CONDITION AND/OR PREMATURE SHUTOFF OF THE GAS PUMP WHEN THE VEHICLE IS BEING REFUELED. *TT |
| Bulletin Number: 15651 |
| SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN AIR LEAK AND/OR OVERNIGHT BLEED DOWN OF THE AIR SUSPENSION. *TT |
| Bulletin Number: 15692 |
| SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT |
| Bulletin Number: 15708 |
| SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT |
| Bulletin Number: 15727 |
| SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT |
| Bulletin Number: 15749 |
| SOME VEHICLES EQUIPPED WITH 4 WHEEL DRIVE MAY EXHIBIT A NOTCHY OR STICKING FEELING IN SLOW SPEED TURNS WITH NO EFFECT ON STEERING EFFORTS OR ASSIST WHILE IN THE AUTOMATIC 4X4 POSITION. *TT |
| Bulletin Number: 15794 |
| SOME 4X2 VEHICLES EQUIPPED WITH P275/60/R17 CONTINENTAL-GENERAL TIRES MAY EXHIBIT A HIGHWAY SPEED TIRE VIBRATION. *TT |
| Bulletin Number: 15897 |
| SUBJECT REGARDING DRIVELINE ANGLE-RELATED VIBRATION AT VARIOUS SPEEDS AND LOAD CONDITIONS. *TT |
| Bulletin Number: 15901 |
| THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT |
| Bulletin Number: 15939 |
| CONCERNS WITH SPEED BODY BOOM. *TT |
| Bulletin Number: 16015 |
| SOME VEHICLES WITH AIR SUSPENSION MAY EXHIBIT AN INITIAL OR REPEAT COMPRESSOR DRYER FAILURE. *TT |
| Bulletin Number: 16683 |
| FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB |
| Bulletin Number: 17320 |
| BROKEN EXHAUST MANIFOLD STUDS. *TT |
| Bulletin Number: 17459 |
| COURTESY RAIL LAMPS DO NOT OPERATE CORRECTLY OR CAUSE A BATTERY DRAW. *TT |
| Bulletin Number: 4619 |
| SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT |
| Bulletin Number: 4626 |
| INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728. *TT |
| Bulletin Number: 4628 |
| SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT |
| Bulletin Number: 4631 |
| BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT |
| Bulletin Number: 4638 |
| MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT |
| Bulletin Number: 4664 |
| THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. * |
| Bulletin Number: 4698 |
| ON SOME VEHICLES, THE RUBBER STOP BUMPER MAY BE MISSING FROM THE PARKING BRAKE CONTROL, A REPLACEMENT SERVICE PART IS NOW AVAILABLE. *TT |
| Bulletin Number: 4802 |
| REAR WIPER ARM INSTALLATION. *TT |
| Bulletin Number: 4981 |
| SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT |
| Bulletin Number: 5128 |
| SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 5206 |
| FOR CERTAIN VEHICLES THE OCTANE SHORTING BAR LOCATED ON THE PASSENGER SIDE OF ENGINE COMPARTMENT NEAR THE BULKHEAD IS NOT INTENDED TO BE FUNCTIONAL IN REDUCING DETONATION / SPARK KNOCK. *TT |
| Bulletin Number: 5257 |
| INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT |
| Bulletin Number: 5258 |
| INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT |
| Bulletin Number: 5370 |
| SOME VEHICLES MAY EXHIBIT A REAR WIPER THAT DOES NOT FUNCTION PROPERLY (JAMMED). *TT |
| Bulletin Number: 5852 |
| VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT |
| Bulletin Number: 6232 |
| SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT |
| Bulletin Number: 6287 |
| SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT |
| Bulletin Number: 6332 |
| CONDITIONS WITH DOOR TRIM PANEL HAVING LOOSE OR BROKEN PULL HANDLES. *TT |
| Bulletin Number: 6350 |
| SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 6640 |
| EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT |
| Bulletin Number: 6686 |
| SUBJECT REGARDING AIR CONDITIONER VACUUM RESERVOIR / CHECK VALVE LOCATION. *TT |
| Bulletin Number: 7100 |
| INFORMATION REGARDING TRANSMISSION TROUBLE CODES. *MJS |
| Bulletin Number: 7155 |
| VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 7353 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT |
| Bulletin Number: 7896 |
| SERVICING TRAILER HITCH. |
| Bulletin Number: 7897 |
| DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLES, NO DISC OR CD WILL NOT EJECT. THIS INDICATES NO COMMUNICATION BETWEEN RADIO AND DISC PLAYER. |
| Bulletin Number: 7929 |
| DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS. |
| Bulletin Number: 8058 |
| SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR |
| Bulletin Number: 8058 |
| SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96228 |
| WINDNOISE - FRONT WINDOW RUN LIP HANGING OUT - VEHICLES BUILT THROUGH 8/14/96. *TW |
| Bulletin Number: 962410 |
| TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW |
| Bulletin Number: 962418 |
| TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962518 |
| DOOR - POWER POINT ACCESS DOOR BREAKS - VEHICLES BUILT THROUGH 8/31/96. *TW |
| Bulletin Number: 962523 |
| RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY - VEHICLES BUILT THROUGH 10/14/96 WITH 4.6L ENGINE. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96S60 |
| REVISED TECHNICAL INSTRUCTIONS CONCERNING RECALL 96S60. *TW |
| Bulletin Number: 97050110612 |
| RATTLE OR BUZZ IN TAILGATE TRIM PANEL AFTER REMOVAL IF THE RETAINING CLIPS ARE NOT REPLACED AFTER REPAIR. *TW |
| Bulletin Number: 97050110618 |
| STRESS CRACKS ON WINDSHIELDS. *TW |
| Bulletin Number: 97050110622 |
| REQUEST FOR INFORMATION ON CONCERNS OF LEATHER SEAT COVERS WRINKLING, FOLDING,LEATHER WEAR OR CRACKING. *TW |
| Bulletin Number: 97050110632 |
| NEWLY DESIGNED VOLUME KNOB, INCORPORATING A MOMENTARY ON/OFF SWITCH. *TW |
| Bulletin Number: 970902971811 |
| CONCERNS WITH "SQUEAKING" AND/OR "RATTLING" NOISES MAY OCCUR DURING DIFFERENT DRIVING CHARACTERISTICS AND FROM VARYING POINTS ON THE VEHICLE. *YC |
| Bulletin Number: 97090297183 |
| EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC |
| Bulletin Number: 97090297187 |
| SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC |
| Bulletin Number: 971110972313 |
| A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC |
| Bulletin Number: 97111097234 |
| VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 97410 |
| TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 976007 |
| BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT |
| Bulletin Number: 976011 |
| EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT |
| Bulletin Number: 97614 |
| STEERING COLUMN- HIGH SPEED VIBRATION- 4X2 VEHICLES EQUIPPED WITH 5.4L ENGINE. *JD |
| Bulletin Number: 97620 |
| MALFUNCTION INDICATOR LAMP (MIL) - ILLUMINATED- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN CONTINUOUS MEMORY- VEHICLES BUILT THROUGH 1/17/97. *JD |
| Bulletin Number: 97626 |
| ENGINE- CHECKING ENGINE OIL LEVEL IN OWNER'S GUIDE INCORRECT. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 97713 |
| NOISE- "BUZZING"- UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION. *JD |
| Bulletin Number: 98021698312 |
| SOME COMPONENTS OF THE FRAME MAY REQUIRE SERVICING DUE TO COLLISION DAMAGE. *YC |
| Bulletin Number: 980310 |
| EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC |
| Bulletin Number: 980317 |
| SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC |
| Bulletin Number: 9810569 |
| CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC |
| Bulletin Number: 98110 |
| SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT |
| Bulletin Number: 98113 |
| SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT |
| Bulletin Number: 9811342 |
| INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT |
| Bulletin Number: 9811344 |
| SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT |
| Bulletin Number: 98123 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 981512 |
| A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK |
| Bulletin Number: 981515 |
| A CLUNKING NOISE HEARD FROM FRONT ENDCAUSED BY FRONT STABILIZER BAR CONTACTING THE FRAME. *AK |
| Bulletin Number: 981612 |
| FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD |
| Bulletin Number: 981613 |
| TRANSMISSION FLUID LEAKS AT RADIATOR. YD |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98168 |
| TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD |
| Bulletin Number: 98169 |
| STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982019 |
| CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC |
| Bulletin Number: 982110 |
| DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC |
| Bulletin Number: 982117 |
| A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 982325 |
| THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 98239 |
| EXPERIENCING NO OR INTERMITTENT AUXILLARY A/C MODE / BLOWER CONTROL ON SOME VEHICLES. *YC8 |
| Bulletin Number: 98241 |
| DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982521 |
| CONCERNS OF BREAKAGE OF THE EXHAUST SYSTEM BETWEEN THE MUFFLER AND TAILPIPE MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 98254 |
| SOME VEHICLES EQUIPPED WITH AIR SUSPENSION MAY EXHIBIT AN INTERMITTENT CHECK SUSPENSION LAMP ON AND DIAGNOSTIC TROUBLE CODE (DTC) C1770 AND/OR C1845 ILLUMINATED. *YC |
| Bulletin Number: 982544 |
| SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC |
| Bulletin Number: 982545 |
| IMPORTANT SERVICE INSTRUCTIONS FOR ONP 97-B-17, EXPEDITION ONLY. *YC |
| Bulletin Number: 982548 |
| BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 982673 |
| IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC |
| Bulletin Number: 982691 |
| CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC |
| Bulletin Number: 982733 |
| VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC |
| Bulletin Number: 982741 |
| SOME VEHICLES MAY EXHIBIT A LOW SPEED ( UNDER 35MPH ) CLICKING NOISE. THIS MAY BE CAUSED BY A CAGE NUT ROCKING ON THE COTTOR PIN FOR FRONT AXLE HALF SHAFT SPINDLE. *AK |
| Bulletin Number: 983074 |
| CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983170 |
| CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT |
| Bulletin Number: 983284 |
| SOME VEHICLES MAY EXPERIENCE AN AUDIBLE 50 HZ BODY BOOM. *TT |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 983302 |
| THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT |
| Bulletin Number: 983566 |
| INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT |
| Bulletin Number: 983566 |
| INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT |
| Bulletin Number: 983570 |
| SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT |
| Bulletin Number: 983582 |
| ERRATIC AND / OR INACCURATE FUEL GAUGE READINGS. *TT |
| Bulletin Number: 983582 |
| SUBJECT REGARDING VEHICLES EXHIBITING ERRATIC AND / OR INACCURATE FUEL GAUGE READINGS. *TT |
| Bulletin Number: 983592 |
| SUBJECT PERTAINING TO RADIO INOPERATIVE CONDITIONS. *TT |
| Bulletin Number: 98417 |
| COLD AIR MAY BE FELT ON THE FLOOR WHILE IN HEAT MODE ON SOME VEHICLES. *YC |
| Bulletin Number: 98419 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98-4725 |
| VIBRATION AT CRUISE OVER 50 MPH. *AK |
| Bulletin Number: 98-4738 |
| COLD ENGINE KNOCK 5.4L ACTION. *AK |
| Bulletin Number: 98-4802 |
| INFORMATION ON PROCEDURES TO FOLLOW WHEN INSTALLING A REAR WIPER ARM. *TT |
| Bulletin Number: 984802 |
| WHEN INSTALLING A REAR WIPER ARM ON SOME VEHICLES, BE SURE TO FOLLOW THE PROCEDURE IN THE 1999 WORKSHOP MANUAL SECTION 501-16-92. *YC |
| Bulletin Number: 98-4817 |
| SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH |
| Bulletin Number: 985059 |
| EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT |
| Bulletin Number: 985062 |
| SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT |
| Bulletin Number: 985063 |
| SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT |
| Bulletin Number: 985128 |
| SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT |
| Bulletin Number: 985185 |
| COLD START ENGINE NOISE |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 9858 |
| THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 98613 |
| SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE. *YC |
| Bulletin Number: 9869 |
| CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9874 |
| A NEW SILICONE GASKET AND SEALANT. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 98B33 |
| OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS. *TT |
| Bulletin Number: 98S14 |
| SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 9912778 |
| INFORMATION REGARDING NEW SERVICE STEERING GEAR. *TT |
| Bulletin Number: 9912792 |
| CONDITIONS ON BROKENT DOOR PULL HANDLES. *TT |
| Bulletin Number: 99128 |
| SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 991313 |
| SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99143 |
| SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99157 |
| SOME VEHICLES MAY EXHIBIT VIBRATION, SHIMMY AND BODY BOOM AT SPEEDS ABOVE 72 KM/H (45 MPH). *TT |
| Bulletin Number: 99164 |
| CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT |
| Bulletin Number: 99185 |
| VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99195 |
| SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99234 |
| INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 99411 |
| VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT |
| Bulletin Number: 996034 |
| EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT |
| Bulletin Number: 996042 |
| INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT |
| Bulletin Number: 996113 |
| EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT |
| Bulletin Number: 996139 |
| CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT |
| Bulletin Number: 996780 |
| THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT |
| Bulletin Number: 996876 |
| INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 9996 |
| EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT |
| Bulletin Number: 99B02 |
| INFORMATION ON REPLACING MULTIFUNCTION SWITCH. *TT |
| Bulletin Number: 99E03 |
| EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT |
| Bulletin Number: BC0009961101 |
| SOFT PARKING BRAKE PEDAL OR LONG PARKING BRAKE PEDAL FEEL. *TW |
| Bulletin Number: BC0053970201 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0053972301 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0054961101 |
| VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY. *TW |
| Bulletin Number: BC0056970201 |
| SOME EXPEDITIONS MAY EXPERIENCE SOME BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD |
| Bulletin Number: BC0056972301 |
| SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD |
| Bulletin Number: BC0065961101 |
| 4X4 FRONT AXLE LEAKING THROUGH VENT TUBE. *TW |
| Bulletin Number: BC0121970201 |
| DRIVELINE RATTLE OVER BUMPS. *JD |
| Bulletin Number: BC0197970201 |
| ENGINE OVERHEATING- WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. *JD |
| Bulletin Number: BC0254970201 |
| 4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD |
| Bulletin Number: BC0315961101 |
| FEAD BELT SQUEAL, COLD ONLY. *TW |
| Bulletin Number: BC0315970201 |
| FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD |
| Bulletin Number: BC0318970201 |
| FRONT DRIVE AXLE FLUID LEAK. *JD |
| Bulletin Number: BC0318972301 |
| FRONT DRIVE AXLE FLUID LEAK. *JD |
| Bulletin Number: BC0318A97020 |
| FRONT DRIVE AXLE FLUID LEAK. *TW |
| Bulletin Number: BC0325961129 |
| SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT. *TW |
| Bulletin Number: BC0325972301 |
| SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD |
| Bulletin Number: BC0340961127 |
| CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW |
| Bulletin Number: BC0474961114 |
| LONG TRAVEL OF PARKING BRAKE PEDAL. *TW |
| Bulletin Number: BC0477961114 |
| ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS. *TW |
| Bulletin Number: BC0600961101 |
| ACCELERATOR CABLE CONTACTING THE POWER STEERING RESERVOIR MAY CAUSING ACCELERATOR PEDAL VIBRATION. *TW |
| Bulletin Number: BC0675961025 |
| VEHICLES MAY EXPERIENCE FLUID LEAKS OUT OF THE FRONT AXLE VENT TUBE. *TT |
| Bulletin Number: BC0676961025 |
| INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS. *TT |
| Bulletin Number: BC0683961024 |
| HIGH OR IRREGULAR GAUGE MOVEMENT OR IRREGULAR LOW FUEL LIGHT BELOW 1/4 FULL. *TT |
| Bulletin Number: BC0694961023 |
| INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0743961018 |
| PROCEDURE WHEN AIR SUSPENSION LIGHT IS ON. *TT |
| Bulletin Number: BC0745961018 |
| CONCERN OF STARTER STAYING ENGAGED, LOOK AT CHAFED WIRE AT THE REAR BRACKET FOR THE RIGHT FRONT UPPER CONTROL ARM. *TT |
| Bulletin Number: BC0753961017 |
| 4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0843961008 |
| INFORMATION ON REPLACING THE COMPASS ASSY FOR ERRATIC/NON-OPERATION. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0854961007 |
| REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC1006597230 |
| IF 4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE, ORDER THE NEW FRONT AXLE TUBE ASSEMBLY FROM THE NATIONAL PARTS DEPOT. *JD |
| Bulletin Number: BC1011097020 |
| OVERHEATING ON 4.6/5.4L VEHICLES MAY BE CAUSED BY POSSIBLE WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. |
| Bulletin Number: BC1012997020 |
| DRIVELINE RATTLE OVER BUMPS. *JD |
| Bulletin Number: BC1014697020 |
| BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD |
| Bulletin Number: BC1014797020 |
| BELT CHIRP AT COLD START UP IN AMBIENT TEMPERATURES OF 30-50 DEGREES F. *JD |
| Bulletin Number: BC1015397020 |
| VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC1017397230 |
| PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS BROUGHT INTO THE DEALERSHIP WITH CUSTOMER COMPLAINTS CONCERNING PARKING BRAKE. *JD |
| Bulletin Number: BC1017697230 |
| CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON VEHICLE APPLICATIONS. *JD |
| Bulletin Number: BC1017997230 |
| ALL AIR SUSPNESION EXPEDTIONS ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD |
| Bulletin Number: BC1018197230 |
| ENGINEERING IS LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES. *JD |
| Bulletin Number: BC1022497230 |
| INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD |
| Bulletin Number: BC1022797230 |
| THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC1025097230 |
| PASSIVE ANTI-THEFT SYSTEM. *JD |
| Bulletin Number: BC1025597230 |
| VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH GARAGE/CARPORTS. *JD |
| Bulletin Number: BC1033797020 |
| CONDENSATE FORMING ON THE OUTSIDE OF THE EVAPORATOR. *JD |
| Bulletin Number: BC1034197020 |
| RESETTING OF THE TRIPCOMPUTER ON EXPEDITION & NAVIGATOR WHERE THE INFORMATION IS NOT CONTAINED IN THE OWNERS GUIDE. *JD |
| Bulletin Number: BC1034397020 |
| ILLUMINATION OF THE CHECK ENGINE LIGHT. *JD |
| Bulletin Number: BC1035197020 |
| THE FUEL GAGE MAY SWING ERRATICALLY ON STEEP SLOPES. *JD |
| Bulletin Number: BC1035297020 |
| FUEL PUMP SENDER, IN AREAS WITH STEEP SLOPES, THE LOW FUEL WARNING LIGHT MAY PREMATURELY ACTIVATE. *JD |
| Bulletin Number: BC105819705 |
| SOME EXPEDITIONS MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION. *TW |
| Bulletin Number: BC105849705 |
| VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW |
| Bulletin Number: BC105969705 |
| VEHICLES BUILT BEFORE 4/11/97 MAY EXPERIENCE A RATTLE OR CLUNK. *TW |
| Bulletin Number: BC106039705 |
| INSTRUCTIONS ON HOW TO ENABLE AND DISABLE THE AUTO LOCK FEATURE. *TW |
| Bulletin Number: BC2225970501 |
| RATTLE OR CLUNK NOISE IN REAR OF VEHICLE CAUSED BY THE BUSHING FALLING OUT OF THE SWAY BAR LINK. *TW |
| Bulletin Number: BC2226970501 |
| SERVICING TIP - TRANSMISSION - THERE ARE TWO DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW |
| Bulletin Number: BC2245970501 |
| INSTRUCTIONS FOR ENABLING/DISABLING THE AUTOMATIC LOCK FEATURE. *TW |
| Bulletin Number: BC2305970501 |
| VEHICLES MAY EXPERIENCE AN INTERMITTENT VISOR VANITY MIRROR LIGHT OPERATION. *TW |
| Bulletin Number: BC2307970501 |
| LOSS OF SOME ACCESSORIES SUCH AS DRIVER'S POWER WINDOW FUNCTION WHEN THE TRANSMISSION IS SHIFTED OUT OF PARK OR NEUTRAL. *TW |
| Bulletin Number: BC2363970501 |
| THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME. *TW |
| Bulletin Number: BC2375970501 |
| VEHICLES BUILT BEFORE 3/24/97 MAY EXPERIENCE WIND NOISE AT THE A-PILLAR. *TW |
| Bulletin Number: BC2382970501 |
| VEHICLES MAY EXPERIENCE A STAINING OF THE ANODIZED ALUMINUM TRIM WITH THE USE OF SOME CAR WASHES WHICH CONTAIN ULTRA VIOLET PROTECTANTS. *TW |
| Bulletin Number: BC3007970501 |
| REVISION TO THE TECHNICAL INSTRUCTIONS WHEN PERFORMING RECALL 96S60. *TW |
| Bulletin Number: BC3060970228 |
| INSTRUCTIONS FOR RESETTING THE TRIP COMPUTER. *TW |
| Bulletin Number: BC3062970228 |
| ILLUMINATION OF CHECK ENGINE LIGHT WITH DTC P0446 MAY BE DUE TO CONTAMINATED CANNISTER, EVAP LINES OR VENT SOLENOID. *TW |
| Bulletin Number: BC3070970227 |
| CONCERNS OF CONDENSATE FORMING ON OUTSIDE OF EVAPORATOR CASE. *TW |
| Bulletin Number: BC3090970225 |
| VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE - CHECK FOR DAMAGE TO CAMSHAFT. *TW |
| Bulletin Number: BC3140970220 |
| INOPERATIVE CD CHANGER MAY BE DUE TO LOOSE 66 PIN CONNECTOR. *TW |
| Bulletin Number: BC3141970220 |
| VEHICLES BUILT WITH RUNNING BOARDS AFTER 1/30/97 WILL NOT HAVE SEALS ON THE LOWER EDGE OF THE FRONT AND REAR DOORS. *TW |
| Bulletin Number: BC3153970219 |
| INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS. *TW |
| Bulletin Number: BC3270970207 |
| CHECK ENGINE LIGHT - DTC P0446 - CHECK FOR MOLD FLASHING IN THE 90 DEGREE ELBOW EVAP LINE CONMING OUT OF THE CANNISTER. *TW |
| Bulletin Number: BC3272970207 |
| VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY. *TW |
| Bulletin Number: BC3277970207 |
| VEHICLES EQUIPPED WITH 4-WHEEL DRIVE, ROOF RACK AND BASE SUSPENSION MAY EXPERIENCE CLEARANCE DIFFICULTIES WITH CERTAIN GARAGES/CARPORTS. *TW |
| Bulletin Number: BC3282970206 |
| GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW |
| Bulletin Number: BC3360972301 |
| INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD |
| Bulletin Number: BC3363972301 |
| THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC3500972301 |
| LOOKING FOR MORE DEFINITION OF VIBRATION CONCERNS ON 4X2 VEHICLES. *JD |
| Bulletin Number: BC3510972301 |
| CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS. *JD |
| Bulletin Number: BC3513972301 |
| AIR SUSPENSION VEHICLES ARE SHIPPED WITH THE AIR SUSPENSION SWITCH IN THE OFF POSITION. *JD |
| Bulletin Number: BC3522972301 |
| PARKING BRAKE PEDAL TRAVEL AND EFFORT ON EXPEDITIONS. *JD |
| Bulletin Number: BC5168961001 |
| PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT |
| Bulletin Number: BC5177961001 |
| INFORMATION FOR CONCERNS OS SPEEDOMETER, SPEED CONTROL INOP & VSS (VEHICLE SPEED SENSOR) DTC'S. *TT |
| Bulletin Number: BC5194961001 |
| REVISED SWITCH BEZEL IS AVAILABLE THAT WILL MINIMIZE CARGO CONTACT W/ THE SWITCH. *TT |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5196961001 |
| CONCERN OF STARTER STAYING ENGAGED. RED WIRE THAT RUNS FROM THE STARTER RELAY TO THE STARTER MAY CHAFE & CAUSE STARTER TO STAY ENGAGED AFTER CRANK. *TT |
| Bulletin Number: BC5211961001 |
| INFORMATION FOR HIGH OR IRREGULAR FUEL GAUGE MOVEMENT OR IRREGULAR LOW FUEL FUEL LIGHT BELOW 1/4 FULL. *TT |
| Bulletin Number: BC9668961001 |
| CONCERN FOR VEHICLES EXHIBITING LEAN CODES P0171 & P0174 (VACUUM LEAK). *TT |
| Bulletin Number: BC9671961001 |
| PUSH CONNECTION BETWEEN THE FLEXIBLE FUEL VAPOR LINE AT THE CARBON CANISTER & THE METAL FUEL VAPOR LINE MAY NOT SEAT FULLY ON THE FUEL VAPOR LINE. *TT |
| Bulletin Number: BC9672961001 |
| PROCEDURE FOR BRAKE WARNING INDICATOR STAYS ON RED IN CLUSTER. *TT |
| Bulletin Number: BC9673961001 |
| PROCEDURE FOR BRAKE EXTERIOR LIGHTS STAY ON (TAIL & HIGH MOUNT STOP LIGHT). *TT |
| Bulletin Number: BC9674961001 |
| LIGHT TO MODERATE AXLE NOISE (AXLE WHINE) AT 50 TO 65 MPH (80 TO 105 KPH) DURING ACCELS, DECELS OR CRUISE MAY BE DUE TO AXLE NOISE BEING TRANSMITTED FROM THE AXLE INTO THE VEHICLE. *TT |
| Bulletin Number: BC9676961001 |
| IMPROPER RTV APPLICATION AT THE FRONT/REAR LOWER INTAKE MANIFOLD END SEALS & SIDE GASKETS MAY CAUSE AN OIL/COOLANT LEAK. *TT |
| Bulletin Number: BC9680961001 |
| CONCERN WHERE THE DOOR GLASS DROPS WHEN CYCLED DOWN ON VEHICLES WITH THE POWER DOOR OPTION. *TT |
| Bulletin Number: BC9682961001 |
| CONCERNS FOR THE LABOR TIME STANDARD IN TBS 96-19-02 (STEERING - GRUNT NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN) IS INCORRECT. *TT |
| Bulletin Number: BC9688961001 |
| INFORMATION FOR WHEN DIAGNOSING CONCERNS W/ FACTORY INSTALLED CELLULAR PHONES. *TT |
| Bulletin Number: BC9694961001 |
| INFORMATION ON VEHICLES THAT MAY EXHIBIT A SLIGHT DELAY IN THE FIRST DRIVE AWAY AFTER THE VEHICLE HAS BEEN PARKED OVERNIGHT, OR FOR A LONGER PERIOD OF TIME. *TT |
| Bulletin Number: BC9695961001 |
| ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) INVALID DIAGNOSTIC CODES U1235 & 155 MAY BE STORED IF THE IGNITION SWITCH IS CYCLED FROM 'OFF' TO 'RUN' EXTREMELY SLOWLY. *TT |
| 1997 FORD EXPLORER |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 00201 |
| SOME VEHICLES MAY EXHIBIT HESITATION ON ACCELERATION OR WHILE TURNING. *JB |
| Bulletin Number: 00213 |
| SUBJECT REGARDING CLIMATE CONTROL - EATC - BLOWER MOTOR CONTROL SERVICE TIPS. *JB |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 00243 |
| ON SOME VEHICLES, THE ACCELERATOR PEDAL BRACKET MAY BECOME LOOSE OR SEPARATED FROM THE DASH PANEL. THIS MAY BE CAUSED BY REPEATED EXCESSIVE FORCE ON THE ACCELERATOR PEDAL, RESULTING IN CRACKING OF THE DASH PANEL SHEET METAL AT THE ACCELER |
| Bulletin Number: 0083 |
| SOME VEHICLES EQUIPPED WITH A 5.0L ENGINE MAY EXHIBIT A RUBBING NOISE DURING RIGHT HAND TURNS FROM THE REAR OF THE VEHICLE. **MR |
| Bulletin Number: 00E11 |
| SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT |
| Bulletin Number: 00E11 |
| SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT |
| Bulletin Number: 00L09 |
| SUBJECT PERTAINING TO SUPPLEMENTAL TIRE INFLATION LABEL. *JB |
| Bulletin Number: 00M11 |
| INFORMATION REGARDING FRONT SWAY BAR LINK . *YH |
| Bulletin Number: 00M11 |
| SUBJECT REGARDING ADDITIONAL COVERAGE PROGRAM FOR SWAY BAR LINKS. *JB |
| Bulletin Number: 00M12 |
| FORD MOTOR COMPANY IS PROVIDING ADDITIONAL COVERAGE FOR THE 4.0L SOHC CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET. *TT |
| Bulletin Number: 00M12 |
| SUBJECT REGARDING OWNER NOTIFICATION SUPPLLEMENTAL PROGRAM FOR VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES - CAMSHAFT CHAIN TENSIONER AND LOWER INTAKE MANIFOLD GASKET ADDITIONAL COVERAGE. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01197 |
| SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0186 |
| ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT |
| Bulletin Number: 01B77 |
| OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT |
| Bulletin Number: 01M01 |
| OWNER NOTIFICATION PROGRAM REGARDING ADDITIONAL COVERAGE PROGRAM FOR FRONT CAM CHAIN GUIDE ASSEMBLY WHICH MAY WEAR OR BREAK AND CAUSE EXCESSIVE CAM CHAIN NOISE THAT DOES NOT GO AWAY AFTER FIVE MINUTES OF ENGINE OPERATION. *TT |
| Bulletin Number: 01M01 |
| SUBJECT REGARDING ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY FOR RENTAL VEHICLES WITH 4.0L SINGLE OVERHEAD CAM (SOHC) ENGINES. *TT |
| Bulletin Number: 01M01 |
| SUBJECT REGARDING ADVANCE NOTICE ON UPCOMING OWNER NOTIFICATION PROGRAM WHICH WILL PROVIDE ADDITIONAL COVERAGE ON THE FRONT CAM CHAIN GUIDE ASSEMBLY ON CERTAIN VEHICLES. *TT |
| Bulletin Number: 01M01 |
| SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 REGARDING ADDITIONAL COVERAGE FOR FRONT CAM CHAIN GUIDE ASSEMBLY. *TT |
| Bulletin Number: 02138 |
| LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02221 |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ |
| Bulletin Number: 0232 |
| SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT |
| Bulletin Number: 0242 |
| CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT |
| Bulletin Number: 0282 |
| SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT |
| Bulletin Number: 030508 |
| FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03261 |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT |
| Bulletin Number: 0358 |
| FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 060199 |
| CUSTOMER MAY COMPLAIN OF AN INTERMITTENT STUMBLE / BUCK / JERK AT 38 MPH WHILE IN HIGH GEAR AND AT VERY LIGHT THROTTLE APPLICATION. *TT |
| Bulletin Number: 070101 |
| SUBJECT REGARDING OWNER NOTIFICATION PROGRAM 01M01 SUPPLEMENT #2: REVISED TECHNICAL INSTRUCTIONS AND NEW LABOR OPERATION. NLM |
| Bulletin Number: 090308 |
| MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455 |
| Bulletin Number: 11512 |
| ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT |
| Bulletin Number: 11759 |
| SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT |
| Bulletin Number: 11811 |
| SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT |
| Bulletin Number: 12115 |
| INFORMATION REGARDING THE TIRE INFLATION PRESSURE FOR ALL MODELS DURING PREDELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *MJS |
| Bulletin Number: 12150 |
| INFORMATION CONCERNING THE REPLACEMENT OF THE ENGINES ON VEHICLES EQUIPPED WITH A 4.0L SOHC THAT REQUIRE SERVICE. *MJS |
| Bulletin Number: 12154 |
| SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12227 |
| FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12230 |
| ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12298 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT |
| Bulletin Number: 12512 |
| BRIEF INFORMATION ON CHECKING TRANSMISSION FLUID LEVEL. *T |
| Bulletin Number: 12518 |
| CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT |
| Bulletin Number: 12529 |
| SOME VEHICLES MAY EXHIBIT AN AIR BAG LIGHT ON INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODE B1924. *TT |
| Bulletin Number: 12571 |
| EXPERIENCING A WHINNING NOISE FROM THE TRANSFER CASE. *TT |
| Bulletin Number: 12624 |
| SOME VEHICLES MAY EXHIBIT A HESITATION / LACK OF POWER ON RE-ACCELERATION AFTER DECELERATING FROM 45 - 65 MPH TO A SLOW ROLL CONDITION. *TT |
| Bulletin Number: 12710 |
| SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOISE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT |
| Bulletin Number: 12852 |
| USE KLEENEX BRAND JUNIORS OR LI'L TRAVELERS TO REFILL TISSUES FOR CERTAIN VEHICLES WITH THE HIGH SERIES CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT |
| Bulletin Number: 12905 |
| SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT |
| Bulletin Number: 13049 |
| EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT |
| Bulletin Number: 13118 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT |
| Bulletin Number: 13154 |
| SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT |
| Bulletin Number: 13154 |
| SUBJECT REGARDING ENGINE HOTLINE PHONE NUMBERS. *TT |
| Bulletin Number: 13170 |
| INFORMATION REGARDING 4.0 L SOHC CAMSHAFT BOLT TORQUE. *MJS |
| Bulletin Number: 13171 |
| INFORMATION REGARDING 4.0L SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS |
| Bulletin Number: 13172 |
| INFORMATION REGARDING SOHC ENGINE NOISE (CAM CHAIN NOISE). *MJS |
| Bulletin Number: 13177 |
| INFORMATION REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *MJS |
| Bulletin Number: 13180 |
| INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS |
| Bulletin Number: 13218 |
| INFORMATION REGARDING SEAT THAT WILLL NOT MOVE FORWARD. *MJS |
| Bulletin Number: 13222 |
| INFORMATION REGARDING NEUTRAL TOW KIT AVAILABLE. *MJS |
| Bulletin Number: 13260 |
| SERVICE TIPS INFORMATION PROVIDED TO ASSIST WHEN SERVICING VEHICLES WITH SHORT BLOCK ASSEMBLY. *TT |
| Bulletin Number: 13261 |
| SERVICE TIPS WHEN SERVICING A 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT |
| Bulletin Number: 13300 |
| SOME VEHICLES WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT |
| Bulletin Number: 13388 |
| VEHICLES EQUIPPED THE NEUTRAL TOW FEATURE, BE AWARE THAT WHEN THE NEUTRAL TOW FEATURE IS ENABLED AND THE CUSTOMER PLACES THE VEHICLE INTO THE NEUTRAL MODE, THE NEUTRAL TOW INDICATOR WILL GO OUT WHEN THE GEM GOES TO SLEEP. *TT |
| Bulletin Number: 13404 |
| SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT |
| Bulletin Number: 13412 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT |
| Bulletin Number: 13415 |
| EXHIBITING A SQUEAK TYPE NOISE FROM THE REAR STABILIZER BAR WHILE DRIVING, ESPECIALLY WHEN GOING OVER BUMPS. *TT |
| Bulletin Number: 13424 |
| SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI LOCK BRAKES MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH. *TT |
| Bulletin Number: 13426 |
| EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT |
| Bulletin Number: 13440 |
| EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT |
| Bulletin Number: 13482 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE-OFF DUE TO THE REAR TRANSMISSION MOUNT BEING TWISTED AND ALLOWING A GROUND OUT CONDITION TO OCCUR. *TT |
| Bulletin Number: 13484 |
| VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT |
| Bulletin Number: 13504 |
| CONCERNS WITH VEHICLES EXHIBITING AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. ENGINEERING IS CURRENTLY ADDRESSING THIS ISSUE THROUGH THE HIGH MILAGE / TIME-IN-SERVICE CONCERN RESOLUTION PROCESS. *TT |
| Bulletin Number: 13505 |
| ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT |
| Bulletin Number: 13527 |
| SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT AN OVERHEAT CONDITION THAT MAY BE ATTRIBUTED TO THE THERMOSTAT. ENGINEERING IS CURRENTLY INVESTIGATING THIS ISSUE AND IS LOOKING FOR THERMOSTATS AND COOLANTS SAMPLES FROM THESE |
| Bulletin Number: 13723 |
| SOME ALL WHEEL DRIVE VEHICLES MAY EXPERIENCE A LOW SPEED WHINING NOISE FROM THE TRANSFER CASE. *MJS |
| Bulletin Number: 13745 |
| SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS |
| Bulletin Number: 13752 |
| SOME 4X4 VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT |
| Bulletin Number: 13752 |
| SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *MJS |
| Bulletin Number: 13857 |
| SOME VEHICLES EQUIPPED WITH 5.0L ENGINES AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT |
| Bulletin Number: 13879 |
| INFORMATION ON REPLACING A GEM MODULE ON 4X4 VEHICLES EQUIPPED WITH 4.0L SOHC, OHV AND THE NEUTRAL TOW KIT. *TT |
| Bulletin Number: 14048 |
| SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR |
| Bulletin Number: 14056 |
| SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR |
| Bulletin Number: 14061 |
| SOME VEHICLES MAY COME IN FOR A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE P0171 AND/OR P0174 IN SELF TEST. **MR |
| Bulletin Number: 14265 |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HESITATION ON ACCELERATION OR WHILE TURNING. *TT |
| Bulletin Number: 14371 |
| SUBJECT REGARDING POP / CREAK NOISE FROM THE REAR UNDERBODY WHILE DRIVING. *JB |
| Bulletin Number: 14560 |
| VEHICLES MAY EXPERIENCE START UP TIMING CHAIN NOISE. *JB |
| Bulletin Number: 14583 |
| CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB |
| Bulletin Number: 14617 |
| SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB |
| Bulletin Number: 14819 |
| SOME 4X4 VEHICLES MAY EXHIBIT A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT |
| Bulletin Number: 14847 |
| CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT |
| Bulletin Number: 14868 |
| SOME VEHICLES EQUIPPED WITH THE 4.0 SOHC ENGINE MAY EXHIBIT A PRIMARY CHAIN RATTLE NOISE (SOMETIMES DESCRIBED AS A SPARK KNOCK-TYPE NOISE). *TT |
| Bulletin Number: 15006 |
| SOME VEHICLES WITH 4.0L SOHC ENGINES MAY MAKE A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT |
| Bulletin Number: 15040 |
| SOME EXPLORER / SPORT / SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE CONDITION FROM THE LEFT FRONT OF THE ENGINE. *TT |
| Bulletin Number: 15040 |
| SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT |
| Bulletin Number: 15168 |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT HIGH FREQUENCY BRAKE SQUEAL NOISE. *YH |
| Bulletin Number: 15249 |
| CONCERNS WITH HIGH BRAKE PEDAL FORCE TO STOP AFTER ROTOR MACHINING. *TT |
| Bulletin Number: 15532 |
| INFORMATION ON VEHICLES EXHIBITNG FUEL LINE DAMAGE DUE TO PINCHING/SQUEEZING OF THE FUEL RETURN LINE. *TT |
| Bulletin Number: 15563 |
| INFORMATION REGARDING MALFUNCTION INDICATOR LIGHT ILLUMINATING WITH DIAGNOSTIC TROUBLE CODE P0300/P0301.*YH |
| Bulletin Number: 15692 |
| SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT |
| Bulletin Number: 15887 |
| SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT |
| Bulletin Number: 15910 |
| CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT |
| Bulletin Number: 16040 |
| EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT |
| Bulletin Number: 16385 |
| AIR RIDE CONTROL LAMP ON AFTER SHOCK ABSORBER REPLACEMENT / CONTACT REQUEST. *TT |
| Bulletin Number: 16735 |
| VARIOUS NOISE ISSUES FROM THE REAR LEAF SPRINGS WHILE DRIVING. *TT |
| Bulletin Number: 16935 |
| AN UNCOMMANDED SHIFT TO 4X4 LOW. *TT |
| Bulletin Number: 4619 |
| SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT |
| Bulletin Number: 4623 |
| BRIEF INFORMATION FOR VEHICLES EXHIBITING ENGINE STALL. *TT |
| Bulletin Number: 4634 |
| STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT |
| Bulletin Number: 4642 |
| SOME VEHICLES MAY COME IN FOR A BENT FRONT SEAT BACK RECLINER LEVER. *TT |
| Bulletin Number: 4703 |
| SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT |
| Bulletin Number: 5049 |
| BRIEF INFORMATION REGARDING UPPER ENGINE NOISE. *TT |
| Bulletin Number: 5128 |
| SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 5249 |
| INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT |
| Bulletin Number: 5256 |
| INFORMATION ON VEHICLES EXHIBITING UPPER ENGINE NOISE. *TT |
| Bulletin Number: 5272 |
| BRIEF INFORMATION REGARDING ENGINE STALL CONDITION. *TT |
| Bulletin Number: 5652 |
| COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT |
| Bulletin Number: 5814 |
| SERVICE TIPS FOR CHECKING TRANSMISSION FLUID LEVEL. *TT |
| Bulletin Number: 5852 |
| VEHICLES EXHIBITING INTERMITTENT ILLUMINATION OF AIR BAG LIGHT WITH DIAGNOSTIC TROUBLE CODE B1924. *TT |
| Bulletin Number: 6203 |
| SOME VEHICLES MAY EXHIBIT A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT |
| Bulletin Number: 6429 |
| INFORMATION ON REFILLING TISSUES FOR THE CENTER CONSOLE FACIAL TISSUE COMPARTMENT. *TT |
| Bulletin Number: 6574 |
| SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT |
| Bulletin Number: 6603 |
| SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT |
| Bulletin Number: 6640 |
| EXHIBITING AN AIR BAG LAMP ON INTERMITTENTLY WITH LAMP FAULT CODE (LFC) 24, OR DIAGNOSTIC TROUBLE CODE B1924 AND / OR B1342 STORED IN MEMORY. *TT |
| Bulletin Number: 6896 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT |
| Bulletin Number: 6926 |
| SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT |
| Bulletin Number: 6980 |
| SOME VEHICLES MAY EXHIBIT THE CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODE PO420. *TT |
| Bulletin Number: 6986 |
| INFORMATION REGARDING 4.0L SOHC CAMSHAFT BOLT TORQUE. *TT |
| Bulletin Number: 6987 |
| SOME VEHICLES MAY EXHIBIT ENGINE NOISE(CAM CHAIN NOISE). *TT |
| Bulletin Number: 6993 |
| SUBJECT REGARDING 4.0L SOHC ENGINE REPAIR PROCEDURE UPDATE. *TT |
| Bulletin Number: 6997 |
| SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT |
| Bulletin Number: 7079 |
| INFORMATION REGARDING SEAT THAT WILL NOT MOVE FORWARD. *MJS |
| Bulletin Number: 7083 |
| INFORMATION REGARDING NEUTRAL TOW KIT AVAILABILITY. *MJS |
| Bulletin Number: 7138 |
| SERVICE TIP INFORMATION WHEN SERVICING THE 4.0L SOHC SHORT BLOCK ASSEMBLY. *TT |
| Bulletin Number: 7270 |
| SOME VEHICLES EQUIPPED WITH 4.0L SOHC ENGINES MAY EXHIBIT A VIBRATION / MOAN / BOOM AT IDLE. *TT |
| Bulletin Number: 7316 |
| SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *TT |
| Bulletin Number: 7353 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT |
| Bulletin Number: 7360 |
| SOME VEHICLES MAY EXHIBIT A SQUEAK NOISE FROM THE REAR WHILE DRIVING, ESPECIALLY WHEN GOING BUMPS. *TT |
| Bulletin Number: 7366 |
| SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). *TT |
| Bulletin Number: 7367 |
| SOME VEHICLES EQUIPPED WITH FOUR WHEEL ANTI-LOCK BRAKES (4WABS) MAY EXHIBIT WHEEL SPEED PARAMETER IDENTIFICATIONS (PIDS) WHICH READ N/A IMMEDIATELY OR ABOVE 7 MPH WHEN VIEWED USING THE NEW GENERATION STAR (NGS) TESTER. *TT |
| Bulletin Number: 7468 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION / GROAN ON ACCELERATION OR TAKE OFF. |
| Bulletin Number: 7471 |
| SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT |
| Bulletin Number: 7494 |
| ALL VEHICLES WITH ELECTRONIC SHIFT ON THE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF WHAT THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT |
| Bulletin Number: 7918 |
| FRONT AXLE PINION LIL SEAL LEAKS. |
| Bulletin Number: 8119 |
| SOME VEHICLES EQUIPPED WITH 5.0L ENGINE AND ALL WHEEL DRIVE (AWD) TRANSFER CASE MAY EXHIBIT A CONDITION OF 4X4 INDICATORS FLASHING AND MULTIPLE GEM DIAGNOSTIC TROUBLE CODES. *TT |
| Bulletin Number: 8149 |
| SUBJECT REGARDING NEUTRAL TOW INOPERATIVE AFTER GEM REPLACEMENT. *TT |
| Bulletin Number: 8164 |
| INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT |
| Bulletin Number: 8164 |
| INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR |
| Bulletin Number: 8493 |
| SOME VEHICLES MAY EXPERIENCE AN OIL LEAK AT THE REAR CRANKSHAFT AREA AFTER SERVICE. **MR |
| Bulletin Number: 8512 |
| SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR |
| Bulletin Number: 870197 |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96226 |
| AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW |
| Bulletin Number: 962410 |
| TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96E57 |
| EMISSIONS RECALL 96E57 - CERTAIN 1996 EXPLORERS EQUIPPED WITH THE 4.0L ENGINES AND BUILT AT THE LOUISVILLE ASSEMBLY PLANT ON 11/18/95 AND CERTAIN 1997 EXPLORERS EQUIPPED WITH THE 4.0L ENGINES AND BUILT AT THE LOUISVILLE ASSEMBLY PLANT FROM |
| Bulletin Number: 97050110611 |
| VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK. *TW |
| Bulletin Number: 97050110613 |
| WHEN PERFORMING TSB 97-4-9, DO NOT USE A BAFFLE TO CORRECT HTE ISSUE, USE THE REVISED AXLE COVER PLATE. *TW |
| Bulletin Number: 97050110634 |
| ENGINEERING IS INVESTIGATING CONCERNS OF BROKEN LIFTGATE GLASS. *YC |
| Bulletin Number: 97090297183 |
| EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC |
| Bulletin Number: 97090297189 |
| EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC |
| Bulletin Number: 971110972312 |
| CONCERNS WITH "PINGING" OR "CREAKING" BEING HEARD FROM THE DRIVELINE WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE, OR WHEN ENGAGING THE CLUTCH. *YC |
| Bulletin Number: 97116 |
| TRANSFER CASE- WATER INGESTION THROUGH VENT TUBE. *JD |
| Bulletin Number: 97312 |
| CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD |
| Bulletin Number: 97314 |
| TRANSFER CASE- BINDING OR SHUDDER- DIAGNOSTICS- VEHICLES WITH 4.0L ENGINE- SERVICE TIP. *JD |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9738 |
| REMOTE KEYLESS ENTRY- RKE INOPERATIVE- VEHICLES BUILT THROUGH 10/30/96. *JD |
| Bulletin Number: 9747 |
| FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 97513 |
| IDLE- "BOOMING" NOISE HEARD AT IDLE- 4.0L ENGINE- VEHICLES BUILT FROM 7/29/96 THROUGH 11/11/96. *JD |
| Bulletin Number: 97514 |
| CD PLAYER- "SKIPS"- HIGH SERIES CONSOLE- NORMAL DRIVING CONDITIONS. *JD |
| Bulletin Number: 9755 |
| MALFUNCTION INDICATOR LAMP (MIL)- MIL ILLUMINATION- DIAGNOSTIC TROUBLE CODE (DTC) P0446 STORED IN MEMORY. *JD |
| Bulletin Number: 976011 |
| EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9776 |
| IDLE- "BOOMING" NOISE HEARD AT IDLE- 4.0L SOHC ENGINE- VEHICLES BUILT FROM 7/29/96 THROUGH 11/11/96. *JD |
| Bulletin Number: 98021698311 |
| SOME VEHICLES MAY EXHIBIT A DRIFT/PULL, SHOW SIGNS OF TIRE WEAR, OR EXHIBIT POOR RIDE QUALITY. *YC |
| Bulletin Number: 980313 |
| EXPERIENCING IDLE VIBRATION / EXHAUST BOOM. *YC |
| Bulletin Number: 980318 |
| CONDITIONS WITH AXLE WIND-UP ON TIGHT TURNS WITH CONTROL TRAC TRANSFER CASE. *YC |
| Bulletin Number: 980319 |
| CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC |
| Bulletin Number: 980324 |
| COLD ENGINE UPPER KNOCK/TICK. *AK |
| Bulletin Number: 980324 |
| CONCERNS OF COLD ENGINE UPPER KNOCK / TICK. *YC |
| Bulletin Number: 98112 |
| SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT |
| Bulletin Number: 98113 |
| SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT |
| Bulletin Number: 98117 |
| SOME VEHICLE MAY EXHIBIT MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) PO171, PO174, P1131 AND / OR P1151 STORED IN MEMORY. *TT |
| Bulletin Number: 98118 |
| EXPERIENCING AN AUDIBLE NOISE IN ENGINE. |
| Bulletin Number: 98124 |
| SUBJECT REGARDING AN OVERHEATING CONDITION OCCURRING TO THE LAMP OUTAGE MODULE (LOM-2) WITH THE INSTALLATION OF CERTAIN AFTERMARKET TRAILER KITS THAT IMPROPERLY CONNECT TO THE TAIL AND BRAKE LAMPS CIRCUITS. *TT |
| Bulletin Number: 98126 |
| SUBJECT REGARDING LAMP OUTAGE MODULE HOUSING AND SURROUNDING PLASTIC COMPONENTS MELTED - EDDIE BAUER AND LIMITED EDITION MODELS EQUIPPED WITH MESSAGE CENTERS AND IMPROPERLY CONNECTED TOW WIRING KITS (VEHICLES BEING TOWED). *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 981512 |
| A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK |
| Bulletin Number: 981514 |
| A VEHICLE VIBRATES DURING A HOT OR COLD IDLE CONDITION. |
| Bulletin Number: 981613 |
| TRANSMISSION FLUID LEAKS AT RADIATOR. YD |
| Bulletin Number: 981617 |
| FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98165 |
| EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982019 |
| CONCERNS WITH THE POWER SEAT CONTROL BUTTON ( KNOB ) MAY DETACH FROM THE SWITCH ACTUATOR. *YC |
| Bulletin Number: 98211 |
| EXPERIENCING A NOISE AND VIBRATION DURING IDLE. |
| Bulletin Number: 982122 |
| SOME CUSTOMERS HAVE REPORTED THE THROTTLE STUCK AT IDLE ON SOME VEHICLES. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982312 |
| ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 982320 |
| SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98234 |
| AIR INTAKE TUBE CONTACTING HOOD INSULATOR CAUSING INSULATOR WEAR. *YC |
| Bulletin Number: 98238 |
| CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982511 |
| SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC |
| Bulletin Number: 982515 |
| CONDITIONS WITH THE FRONT SEAT BACK LEVER BENT. *YC |
| Bulletin Number: 982540 |
| CONCERNS WITH BUILT-IN REAR CHILD SAFETY SEAT MAY NOT EASILY ACCOMMODATE SOME CHILDREN. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 983074 |
| CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT |
| Bulletin Number: 983092 |
| REAR CRANKSHAFT SEAL OIL LEAK. *AK |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983109 |
| INFORMATION REGARDING ENGINES ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98-4732 |
| STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS.. |
| Bulletin Number: 98-4817 |
| SOME 1997-1998 EXPLORER/MOUNTAINEER/EXPEDITION OR NAVIGATOR VEHICLES WITH 4-WD 4X4 SYSTEM MAY EXHIBIT BOTH |
| Bulletin Number: 985045 |
| REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT |
| Bulletin Number: 985064 |
| REPEAT MESSAGE REGARDING ENGINE STALLING *TT |
| Bulletin Number: 985128 |
| SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT |
| Bulletin Number: 98514 |
| CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT |
| Bulletin Number: 985144 |
| ALL VEHICLES EQUIPPED WITH 4.0L SOHC THAT REQUIRE ENGINE SERVICE PLEASE NOTE THAT THE XL2Z-6M289-AA (DRIVE ASSEMBLY-CAMSHAFT-LH) MUST BE USED ON 4.0L SOHC ENGINES IF REPLACEMENT IS REQUIRED. *TT |
| Bulletin Number: 985157 |
| INFORMATION ON SETTING THE TIRE INFLATION PRESSURE FOR 1991 THROUGH 1999 MODEL YEAR VEHICLES IN THE PRE-DELIVERY PROCESS AND DURING MAINTENANCE INTERVALS. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 9889 |
| SOME CUSTOMERS NOTICE A GRINDING, WHINING, PULSING, OR FLUTTERING AT THE BRAKE PEDAL AT SPEEDS BELOW 19 KM/H (12 MPH). *YC |
| Bulletin Number: 98R03 |
| SAFETY RECALL LETTER INFORMING OWNERS OF MODIFICATION TO THE POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM. *TT |
| Bulletin Number: 98R03 |
| SUBJECT REGARDING POSITIVE CRANKCASE VENTILATION (PCV) TUBE MODIFICATION. *TT |
| Bulletin Number: 99104 |
| THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, P1131, AND / OR P1151 MAY BE PRESENT WITH OR WITHOUT MISFIRE, ROLLING IDLE, ROUGH IDLE, ETC. *TT |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 9913035 |
| VEHICLES MAY EXPERIENCE A NO START CONDITION WHEN PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99142 |
| VEHICLES WITH A4WD TRANSMISSION AND 4.0L ENGINE MAY HAVE THE 4X4 INDICATOR LAMPS FLASHING. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99156 |
| SOME VEHICLES MAY EXHIBIT A BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE OCCURING WHEN THE BLOWER MOTOR IS RUNNING IF LEAVES OR FOREIGN MATERIAL ENTERS THE BLOWER CASE. *TT |
| Bulletin Number: 99185 |
| VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99203 |
| INFORMATION ON REPLACING THE FRONT BUMPER BRACKET. *TT |
| Bulletin Number: 99206 |
| CONCERNS WITH BURNING ODOR OR SMOKE, AND / OR RUSTLING NOISE WHILE BLOWER MOTOR IS ON. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99223 |
| A NO START CONDITION WHEN VEHICLE IS PARKED ON AN INCLINE WITH THE VEHICLE IN A NOSE DOWN POSITION AND LESS THAN 1/4 TANK OF FUEL MAY OCCUR. *TT |
| Bulletin Number: 99234 |
| INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT |
| Bulletin Number: 99238 |
| A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT |
| Bulletin Number: 995157 |
| INFORMATION ON MAINTAINING TIRE PRESSURE. *TT |
| Bulletin Number: 996777 |
| EXHIBITING A POWER STEERING FLUID LEAK FROM THE STEERING GEAR BOOT(S). *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 9987 |
| SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING, HESITATION AFTER ACCELERATION FROM STOP AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP ON VEHICLES WITH 4.0L OR 5.0L ENGINES. *TT |
| Bulletin Number: 9987 |
| SOME VEHICLES MAY EXHIBIT HARSH DOWNSHIFT FROM 3RD TO 1ST GEAR WHILE STOPPING; HESITATION AFTER ACCELERATION FROM STOP; AND / OR LACK OF POWER AFTER ACCELERATION FROM STOP. *TT |
| Bulletin Number: 9988 |
| CONCERNS OR ERRATIC OR INSUFFICIENT TEMPERATURE CONTROL. *TT |
| Bulletin Number: 9996 |
| EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT |
| Bulletin Number: 99S09 |
| RECALL INFORMATION REGARDING SPEED CONTROL CABLE REPLACEMENT. *TT |
| Bulletin Number: BC0012970201 |
| CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD |
| Bulletin Number: BC0012972301 |
| CUSTOMERS REPORT INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. *JD |
| Bulletin Number: BC0050970201 |
| WHEN SERVICING THE LAMP OUTAGE MODULE (LOM) ON THE ABOVE VEHICLES PLEASE VERIFY IF THE VEHICLE HAS 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD |
| Bulletin Number: BC0050972301 |
| WHEN SERVICING THE LAMP OUTAGE MODULE (LOM) ON A VEHICLE PLEASE VERIFY IF THE VEHICLE HAS 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD |
| Bulletin Number: BC0069961101 |
| CONCERN OF BINDING/AXLE WIND-UP AT LOW SPEED. *TW |
| Bulletin Number: BC0133970201 |
| REVISED VENT TUBE FOR 1995-97 EXPLORERS & MOUNTAINEERS WITH WATER INGESTION INTO TRANSFER CASE. *JD |
| Bulletin Number: BC0184970201 |
| PROCEDURE TO PURGE POTENTIAL WATER CONTAMINATION FROM TRANSFER CASE. *JD |
| Bulletin Number: BC0190970201 |
| VEHICLES BUILT PRIOR TO 10/1/96 MAY HAVE BEEN BUILT WITH WRONG TEMP GAUGE SYSTEM PARTS. *JD |
| Bulletin Number: BC0206970201 |
| TRANSFER CASE BIND OR SHUDDER. *JD |
| Bulletin Number: BC0225970201 |
| BINDING/AXLE WIND-UP AT LOW SPEED. *JD |
| Bulletin Number: BC0257970201 |
| POWER LOCKS CYCLE BY THEMSELVES REMOVE EACH POWER LOCK SWITCH AND MEASURE THE OPEN RESISTANCE. *JD |
| Bulletin Number: BC0317970201 |
| DRIVELINE WIND-UP IN "4-AUTO" MODE. *JD |
| Bulletin Number: BC0317972301 |
| DRIVELINE WIND-UP IN "4-AUTO" MODE. *JD |
| Bulletin Number: BC0317A97020 |
| DRIVELINE WIND-UP IN 4-AUTO MODE. *TW |
| Bulletin Number: BC0324961101 |
| COLD ENGINE KNOCK/TICK NOISE. *TW |
| Bulletin Number: BC0324970201 |
| COLD ENGINE KNOCK/TICK NOISE. *JD |
| Bulletin Number: BC0342961127 |
| WHEN A REAR HEGO (CMS) CONCERN IS NOTED, PLEASE CHECK THE REAR CMS HEGO FOR WIRE CHAFING/DAMAGE AND LOOSE HEGO WIRE. *TW |
| Bulletin Number: BC0481961113 |
| VEHICLES MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW |
| Bulletin Number: BC0533961108 |
| INSTRUCTIONS FOR DIAGNOSING FAULTY ABS SENSORS. *TW |
| Bulletin Number: BC0534961108 |
| DRIVESHAFT DESIGN MAY CAUSE FLOORPAN VIBRATION WHILE AT HIGHWAY SPEEDS OR WITH THROTTLE WIDE OPEN. *TW |
| Bulletin Number: BC0744961018 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC0755961017 |
| TENSIONER RATTLE . INSTALL A 1 INCH SHORTER MOTORCRAFT BELT (P/N F19Z-8620-C). *TT |
| Bulletin Number: BC0881961004 |
| THUMP/CLUNK NOISE IN TURNS OR OVER BUMPS MAY BE CAUSED BY THE KEVLAR PATCH WEARING THROUGH ON THE TORSION BAR ADJUSTERS. *TT |
| Bulletin Number: BC0882961004 |
| INFORMATION FOR ALL BASE ENGINE CONCERNS OF 4.0L SOHC ENGINES. *TT |
| Bulletin Number: BC1011297020 |
| 4.0L OHV/SOHC 4X4 EXPLORERS WITH TRANSFER CASE BIND OR SHUDDER. *JD |
| Bulletin Number: BC1012797020 |
| REVISED VENT TUBE FOR VEHICLES WITH WATER INGESTION INTO TRANSFER CASE. *JD |
| Bulletin Number: BC1015097020 |
| LAMP OUTAGE MODULE (LOM) ON THE VEHICLES- PLEASE VERIFY IF THE VEHICLE HAS: 1) AN AFTERMARKET KIT FOR TRAILER TOWING OR 2) AFTERMARKET KIT ALLOWING THE VEHICLE TO BE TOWED. *JD |
| Bulletin Number: BC1016497020 |
| INOPERABLE REMOTE ENTRY OR KEYLESS ENTRY FEATURE. THE CAUSE HAS BEEN IDENTIFIED AS A STATIC BUILD-UP ON THE SEAT THAT DAMAGES THE RAP MODULE. *JD |
| Bulletin Number: BC1018997230 |
| BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD |
| Bulletin Number: BC1019197230 |
| EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD |
| Bulletin Number: BC1019297230 |
| VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM. *JD |
| Bulletin Number: BC1019497230 |
| VEHICLES MAY EXHIBIT REVERSE OPERATING CHARACTERISTICS WHEN SWITCHING THE AIR SUSPENSION SWITCH FROM NORMAL TO OFF ROAD. *JD |
| Bulletin Number: BC1019597230 |
| EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT A TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD |
| Bulletin Number: BC1019797230 |
| THE VEHICLES WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSITION. *JD |
| Bulletin Number: BC1019897230 |
| PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE. |
| Bulletin Number: BC1019997230 |
| 4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD |
| Bulletin Number: BC1022797230 |
| THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC1024097230 |
| INCREASED THROTTLE EFFORTS MAY BE NOTED ON SOME 4.0L SOHC EQUIPPED VEHICLES DUE TO THROTTLE PLATE ALIGNMENT. *JD |
| Bulletin Number: BC1025297230 |
| FRONT AXLE VENT LEAKS ON 1997 EXSPLORERS BUILT BEFORE 11/1/06. *JD |
| Bulletin Number: BC1028397020 |
| THE 1997 EXPLORER 4.0L SOHC IS THE ONLY VEHICLE EQUIPPED WITH A NEW STYLE (BLACK PLASTIC) DPFE SENSOR. *JD |
| Bulletin Number: BC1030297020 |
| ENGINE MAY EXHIBIT A HISS/WHISTLE AT TIP-IN FROM THE THROTTLE BODY/IAC AREA OF THE ENGINE. *JD |
| Bulletin Number: BC1031297020 |
| SOME VEHICLE ENGINE COMPARTMENT DECALS MAY INCORRECTLY LIST 10W30 FOR OIL VISCOSITY. *JD |
| Bulletin Number: BC1033197020 |
| VEHICLES WITH REAR CRANKSHAFT SEAL OIL LEAKS. *JD |
| Bulletin Number: BC1035497020 |
| 4.0L SOHC ENGINE COMES FROM THE FACTORY WITH SINGLE PLATINUM PLUGS. *JD |
| Bulletin Number: BC1035597020 |
| RADIATORS MAY EXHIBIT A COOLANT LEAK AT THE END TANK SEALS IN COLD TEMPERATURES. *JD |
| Bulletin Number: BC105609705 |
| VEHICLES MAY EXHIBIT SHUDDER/BIND IN TURNS WHILE IN 4X4 AUTO MODE. *TW |
| Bulletin Number: BC105789705 |
| VEHICLES WITH DTC P0402 IN MEMORY ARE UNDER INVESTIGATION BY ENGINEERING DEPARTMENT. *TW |
| Bulletin Number: BC105829705 |
| SOME RUNNING BOARD PADS MAY BE WARPED. *TW |
| Bulletin Number: BC105979705 |
| UPDATE INFORMATION FOR 1997 4R44E AND 5R55E TRANSMISSIONS - THERE ARE TWO (2) DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW |
| Bulletin Number: BC106049705 |
| VEHICLES BUILT AFTER 4/14/97 NO LONGER HAVE A REAR WASHER BOTTLE - REDESIGNED FRONT WASHER BOTTLE WILL SERVICE THE FRONT AND REAR WASHERS. *TW |
| Bulletin Number: BC2236970501 |
| VEHICLES MAY EXHIBIT A CENTER CONSOLE SQUEAK OR RATTLE. *TW |
| Bulletin Number: BC2237970501 |
| RECALL 97S67 - MODIFICATION OF THE PCV VALVE REQUIRES A SPECIAL TOOL WHICL WILL SENT TO LISTED PARTS MANAGERS. *TW |
| Bulletin Number: BC2246970501 |
| VEHICLES BUILT ON OR AFTER 4/14/97 WILL NO LONGER HAVE A REAR WASHER BOTTLE - A REDESIGNED FRONT WASHER BOTTLE WILL SUPPLY THE FLUID TO BOTH WASHERS. *TW |
| Bulletin Number: BC2301970501 |
| NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW |
| Bulletin Number: BC2302970501 |
| DTC P0402 IN MEMORY UNDER INVESTIGATION BY ENGINEERING. *TW |
| Bulletin Number: BC2306970501 |
| SOME RUNNING BOARD PADS MAY WARPED. *TW |
| Bulletin Number: BC2313970501 |
| MAY 1997 GEM SOFTWARE HAS ERRORS - JUNE SOFTWARE IS CORRECT. *TW |
| Bulletin Number: BC2383970501 |
| SERVICE FIX FOR VEHICLES WHICH EXHIBIT SHUDDER/BIND IN TURNS WHILE IN 4X4 MODE. |
| Bulletin Number: BC2384970501 |
| LIFTGATE LOCK CONCERNS ON VEHICLES BUILT THROUGH 12/96. *TW |
| Bulletin Number: BC2440970501 |
| 1997 4.0L SOHC 4X4 EXPLORERS AND 1997 5.0L AWD EXPLORERS/MOUNTAINEERS SHOULD NOT BE EQUIPPED WITH A VIBRATION DAMPER ON THE TRANSFER CASE. *TW |
| Bulletin Number: BC2442970501 |
| LIFTGATE LOCKS WILL NOT LOCK/UNLOCK WHEN ACTUATED BY THE POWER SWITCHES. *TW |
| Bulletin Number: BC3092970225 |
| REAR CRANKSHAFT SEAL OIL LEAKS. *TW |
| Bulletin Number: BC3092970501 |
| ENGINEERING IS INVESTIGATING REAR CRANKSHAFT OIL LEAKS. *TW |
| Bulletin Number: BC3132970221 |
| INCORRECT OIL VISCOSITY LABEL IN ENGINE COMPARTMENT. *TW |
| Bulletin Number: BC3134970221 |
| OEM SPARK PLUGS MAY EXHIBIT A CONCERN OF AN OPEN CIRCUIT CAUSED BY AN INTERNAL CRACK. *TW |
| Bulletin Number: BC3155970219 |
| 4.0L SHOC ENGINE QUITS WHILE DRIVING AND WILL NOT RESTART. *TW |
| Bulletin Number: BC3156970219 |
| EXPLORERS EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A HISS/WHISTLE AT TIP IN. *TW |
| Bulletin Number: BC3274970207 |
| REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A |
| Bulletin Number: BC3282970206 |
| GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW |
| Bulletin Number: BC3283970206 |
| DOOR LATCH SWITCH IS CAUSING THE DOOR AJAR LIGHT/CHIME NOT TO WORK PROPERLY. *TW |
| Bulletin Number: BC3363972301 |
| THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC3441972301 |
| AS OF 1/7/97 THE AUTOMATIC SHIFT LOCK FEATURE TAG THAT WAS AFFIXED AROUND THE GEAR SELECTOR, HAS BEEN DISCONTINUED FOR PRODUTION. *JD |
| Bulletin Number: BC3481972301 |
| EXHAUST NOISE HEARD IN THE PASSENGER COMPARTMENT MOST PRESENT AT TIP-IN A ND CRUISE AFTER SSM 5238 HAS BEEN PERFORMED. *JD |
| Bulletin Number: BC3483972301 |
| THE VEHICLE WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSTION. *JD |
| Bulletin Number: BC3484972301 |
| WHEN PERFORMING TSB 96-24-16, THE EXISTING TRANSFER CASE VIBRATION DAMPER SHOULD NOT BE ADAPTED AND REINSTALLED TO THE SERVICE REPLACEMENT TRANSFER CASE. *JD |
| Bulletin Number: BC3485972301 |
| 4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD |
| Bulletin Number: BC3491972301 |
| SOME 4.0L ENGINES WITH BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD |
| Bulletin Number: BC3493972301 |
| VEHICLES EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD |
| Bulletin Number: BC3494972301 |
| VARIOUS VEHICLES MAY EXPERIENCE A HIGH PITCHED WHISTLE DURING HEAVY ACCELERATION AT 3800-5000 RPM WHEN ENGINE IS WARM- TO FIX, REMOVE EXISTING MUFFLER AND REPLACE WITH SAME PART. *JD |
| Bulletin Number: BC5180961001 |
| OWNERS GUIDE ADVISES TO USE A FL-1A OIL FILTER, FL-1A IS INCORRECT. THE CORRECT FILTER IS FL-820. *TT |
| Bulletin Number: BC5188961001 |
| CONCERN OF A TENSIONER RATTLE W/ 4.0L SOHC, INSTALL A 1 INCH SHORTER MOTORCRAFT BELT (P/N F19Z-8620-C). *TT |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5225961001 |
| VEHICLES MAY EXPERIENCE A VIBRATION DURING WIDE OPEN THROTTLE ACCELERATION OR WHILE CRUISING AT HIGHWAY SPEEDS. REVISED FRONT DRIVESHAFT. *TT |
| Bulletin Number: BC5231961101 |
| VEHICLE LEAN. *TW |
| Bulletin Number: BC5238961101 |
| VEHICLE MAY EXHIBIT AN EXHAUST MANIFOLD IMPINGEMENT NOISE. *TW |
| Bulletin Number: RCDNN-00V402-817 |
| This recall action involves replacement of the front stabilizer bar links in certain 1995 through 1997 model year Explorer and Mountaineer vehicles. Under certain conditions, predominantly in cold weather areas, a front stabilizer bar |
| 1997 FORD EXPLORER SPORT |
|---|
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 0186 |
| ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT |
| Bulletin Number: 0232 |
| SOME VEHICLES EQUIPPED WITH THE 4.0L SOHC ENGINE MAY EXHIBIT A CHECK ENGINE LIGHT ON WITH DIAGNOSTIC TROUBLE CODES P0300 (RANDOM MISFIRE) OR P0301. *TT |
| Bulletin Number: 04217 |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 15006 |
| SOME VEHICLES WITH 4.0L SOHC ENGINES MAY MAKE A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT |
| Bulletin Number: 15040 |
| SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT |
| Bulletin Number: 15910 |
| CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT |
| 1997 FORD EXPLORER SPORT TRAC |
|---|
| Bulletin Number: 0186 |
| ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT |
| Bulletin Number: 15040 |
| SOME VEHICLES INCLUDING 1997 THROUGH 1999 EXPLORER SPORT TRAC EQUIPPED WITH A 4.0L SOHC ENGINE MAY EXHIBIT A START-UP NOISE FROM THE LEFT FRONT OF THE ENGINE. *TT |
| Bulletin Number: 15910 |
| CONCERNS WITH BRAKE VIBRATION, ROUGHNESS AND / OR GRINDING NOISE, AND EXCESSIVE BRAKE ROTOR CORROSION. *TT |
| 1997 FORD F-150 |
|---|
| Bulletin Number: 0014 |
| VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL. *MJS |
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 0017 |
| SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 00238 |
| SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT |
| Bulletin Number: 00239 |
| A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT |
| Bulletin Number: 00261 |
| SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT |
| Bulletin Number: 0038 |
| VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS |
| Bulletin Number: 00611 |
| SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS |
| Bulletin Number: 01111 |
| SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01166 |
| SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01182 |
| SOME VEHICLES MAY EXPERIENCE A COSMETIC CRACK IN THE OUTER DOOR PANEL AT THE LOWER REAR CORNER OF WINDOW OPENING.*JB |
| Bulletin Number: 01192 |
| SOME VEHICLES MAY EXHIBIT A GRABBING CONDITION FROM THE REAR DRUM BRAKES DURING THE FIRST FEW BRAKE APPLICATIONS AFTER EXTENDED HUMIDITY EXPOSURE. *TT |
| Bulletin Number: 01201 |
| SOME VEHICLES MAY EXHIBIT HIGH IDLE AND/OR PCV SYSTEM ICING AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES ON VEHICLES EQUIPPED WITH 4.2L ENGINE BUILT THORUGH 1/24/2000. *TT |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01215 |
| A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT |
| Bulletin Number: 01218 |
| SOME VEHICLES MAY EXHIBIT A NO CRANK, NO START CONDITION DUE TO CORROSION OF THE STARTER CABLE B+ TERMINAL AT THE STARTER SOLENOID. *TT |
| Bulletin Number: 01221 |
| SOME DEDICATED COMPRESSED NATURAL GAS (CNG) VEHICLES MAY EXHIBIT A ROUGH IDLE, OR NO START IN COLD CONDITIONS. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 0193 |
| A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. THIS MAY BE CAUSED BY THE EXTENSION HOUSING BUSHING OR SEAL WALKING / SPINNING OUT DUE T |
| Bulletin Number: 02105 |
| SOME BI-FUEL CANG AND LPG VEHICLES MAY EXHIBIT A NO START CONDITION. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02193 |
| DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ |
| Bulletin Number: 02221 |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ |
| Bulletin Number: 030402 |
| ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT |
| Bulletin Number: 03102 |
| COMPRESSED NATURAL GAS (CNG). ROUGH IDLE OR NO START WHEN COLD. VEHICLES EQUIPPED WITH CNG BI-FUEL ENGINE ONLY. *TT |
| Bulletin Number: 03103 |
| VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT |
| Bulletin Number: 031404 |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. |
| Bulletin Number: 03144 |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 031513 |
| TIE ROD END INSPECTION PROCEDURE. *TT |
| Bulletin Number: 03183 |
| DEDICATED COMPRESSED NATURAL GAS (CNG) ROUGH IDLE OR NO START WHEN COLD VEHICLES EQUIPPED WITH DEDICATED 4.6L OR 5.4L CNG ENGINE ONLY. *TT |
| Bulletin Number: 03206 |
| SOME DEDICATED CNG VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS DUE TO A LOSS OF INJECTOR PERFORMANCE, RESULTING FROM FUEL QUALITY. LOSS OF POWER AT HEAVY LOAD, DIAGNOSTIC TROUBLE CODES (DTCS) FOR LEAN FUEL, ROUGH IDLE, HARD START, |
| Bulletin Number: 032125 |
| AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT |
| Bulletin Number: 0324 |
| DRIVER'S SIDE DOOR GLASS THAT BINDS WHEN OPERATED. *TT |
| Bulletin Number: 0342 |
| POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB |
| Bulletin Number: 03610 |
| TIE ROD END INSPECTION PROCEDURE. CANADA VEHICLES ONLY. *TT *JB |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 0399 |
| TIE ROD END INSPECTION PROCEDURE. *TT |
| Bulletin Number: 041601 |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04217 |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04266 |
| A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT |
| Bulletin Number: 0457 |
| POP/THUMP NOISE AT END OF WINDOW MOVEMENT AND/OR DRIVER'S WINDOW BOUNCE BACK AND REVERSE TO MID-POSITION. *TT |
| Bulletin Number: 04L19 |
| CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT |
| Bulletin Number: 050618 |
| REAR AXLE NOISE REPAIR. *SC |
| Bulletin Number: 05417 |
| INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT |
| Bulletin Number: 0554 |
| USE OF STAINLESS STEEL EXHAUST STUDS IN SERVICE FOR 5.4L 2V ENGINE. *TT |
| Bulletin Number: 05618 |
| REAR AXLE NOISE REPAIR. *TT |
| Bulletin Number: 07212 |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE |
| Bulletin Number: 090308 |
| MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455 |
| Bulletin Number: 11794 |
| EXPERIENCING A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT |
| Bulletin Number: 11799 |
| SOME SUPERCAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT |
| Bulletin Number: 11811 |
| SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT |
| Bulletin Number: 11814 |
| SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT |
| Bulletin Number: 12071 |
| SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *MJS |
| Bulletin Number: 12139 |
| SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS |
| Bulletin Number: 12154 |
| SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS |
| Bulletin Number: 12161 |
| SOME VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *MJS |
| Bulletin Number: 12208 |
| SOME TEXAS DEPARTMENT OF TRANSPORTATION (DOT) TRUCKS MAY ENCOUNTER A RADIO FREQUENCY INTERFERENCE (RFI) CONDITION WHEN USING HAND HELD TWO-WAY RADIOS IN THE RANGE OF 47.18 MHZ. *TT |
| Bulletin Number: 12590 |
| SOME 4X4 VEHICLES MAY EXHIBIT A MOAN NOISE FROM THE FRONT DIFFERENTIAL WHEN THE VEHICLE IS OPERATING IN 4X2 MODE AND GOES AWAY WHEN OPERATING IN 4X4 MODE. *TT |
| Bulletin Number: 12601 |
| EXPERIENCING WHISTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AT HIGHWAY SPEEDS. *TT |
| Bulletin Number: 12720 |
| SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT |
| Bulletin Number: 12725 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT |
| Bulletin Number: 12738 |
| SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION. |
| Bulletin Number: 12879 |
| SUBJECT REGARDING REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING A REAR SPRING RATTLE. *TT |
| Bulletin Number: 12882 |
| SUBJECT REGARDING THE AVAILABILITY OF REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING REAR SPRING RATTLE. *TT |
| Bulletin Number: 12905 |
| SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT |
| Bulletin Number: 13054 |
| EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT |
| Bulletin Number: 13106 |
| ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT |
| Bulletin Number: 13186 |
| INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS |
| Bulletin Number: 13203 |
| INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS |
| Bulletin Number: 13219 |
| INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS. *MJS |
| Bulletin Number: 13238 |
| INFORMATION REGARDING VEHICLES THAT EXHIBIT CRACKS IN THE DOOR SHEET METAL. *MJS |
| Bulletin Number: 13412 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT |
| Bulletin Number: 13479 |
| SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT |
| Bulletin Number: 13505 |
| ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT |
| Bulletin Number: 13550 |
| SOME VEHICLES MAY EXHIBIT DENTS ON THE WHEEL WELL SHEET METAL OF THE PCIK-UP BOX AREA WHEN USED IN OFF-ROAD APPLICATIONS. *TT |
| Bulletin Number: 13745 |
| SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS |
| Bulletin Number: 13838 |
| CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT |
| Bulletin Number: 14365 |
| THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB |
| Bulletin Number: 14609 |
| SUBJECT REGARDING HIGH IDLE AND/OR CHECK ENGINE LIGHT CONDITION. *JB |
| Bulletin Number: 15113 |
| SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD |
| Bulletin Number: 15145 |
| SOME VEHICLES EQUIPPED WITH REMOTE LOCKING TAILGATES MAY EXHIBIT A TAILGATE LOCKING ITSELF WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS OR IS SLAMMED SHUT. *ET |
| Bulletin Number: 15260 |
| CONCERNS WITH CORRODED POSITIVE STARTER CABLE. *TT |
| Bulletin Number: 15271 |
| DEDICATED CNG REGULATOR BOWL KIT AVAILABLE. *JG |
| Bulletin Number: 15299 |
| SOME VEHICLES MAY EXHIBIT CORROSION AT THE ATTACHMENT POINT OF THE STARTER CABLE B+ TERMINAL, AT THE STARTER SOLENOID. *TT |
| Bulletin Number: 15570 |
| SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. *TT |
| Bulletin Number: 15692 |
| SOME VEHICLES MAY EXHIBIT A SQUEAK, SNAP, RATTLE, OR CLUNK IN THE FRONT END WHEN TURNING OR GOING OVER BUMPS. *TT |
| Bulletin Number: 15758 |
| SNOW PACKING OF THE AIR FILTER WHEN DRIVING IN SEVERE SNOW CONDITIONS MAY EXHIBIT LOSS OF POWER AND / OR THE MALFUNCTION INDICATOR LAMP ILLUMINATING. *TT |
| Bulletin Number: 16416 |
| NO/HARD START IN COLD AMBIENTS / NEW TWO-PIECE BLOCK HEATER CORD RELEASED. *MJ |
| Bulletin Number: 16602 |
| LOCKING TAILGATE LOCKS ITSELF. *TT |
| Bulletin Number: 16605 |
| REDUCED POWER STEERING ASSIST AND/OR POWER STEERING LEAKS WHEN DRIVEN IN TEMPERATURES EQUAL TO OR LESS THAN -25 DEGREES CELCIUS. *TT |
| Bulletin Number: 16835 |
| TAILGATE LOCKING BY ITSELF WHEN SLAMMED SHUT OR WHEN THE VEHICLE IS BEING DRIVEN OVER ROUGH ROADS. *TT |
| Bulletin Number: 16928 |
| VARIOUS INTERMITTENT ELECTRICAL CONCERNS INCLUDING BUT NOT LIMITED TO SOME ACCESSORIES REMAINING POWERED UP WITH THE KEY OUT OF THE IGNITION, MULTIPLE SYSTEM WARNING LIGHTS WITH SHORT TO POWER OR LOW BATTERY VOLTAGE DIAGNOSTIC TROUBLE CODES |
| Bulletin Number: 16969 |
| DAMAGED REAR LICENSE PLATE LAMPS DUE TO ROCKS AND/OR GRAVEL HITTING THE LAMP ASSEMBLIES. *TT |
| Bulletin Number: 17320 |
| BROKEN EXHAUST MANIFOLD STUDS. *TT |
| Bulletin Number: 17448 |
| REMOTE OIL FILTER ADAPTOR REPLACEMENT - NEW SERVICE PART. *TT |
| Bulletin Number: 17731 |
| WHINE FROM POWER STEERING. *TT |
| Bulletin Number: 17777 |
| REAR LEAF SPRING NOISE. *TT |
| Bulletin Number: 17823 |
| POWER STEERING LEAK - SERVICE TIP. *TT |
| Bulletin Number: 18466 |
| AXLE WHINE HOWL. THIS INCLUDES 1997-05 FORD VEHICLES. *EH |
| Bulletin Number: 4619 |
| SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT |
| Bulletin Number: 4628 |
| SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT |
| Bulletin Number: 4631 |
| BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT |
| Bulletin Number: 4635 |
| COLD ENGINE KNOCK. *TT |
| Bulletin Number: 4638 |
| MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT |
| Bulletin Number: 4682 |
| SOME SUPER CAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT |
| Bulletin Number: 4683 |
| SOME VEHICLES MAY EXHIBIT A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT |
| Bulletin Number: 4703 |
| SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT |
| Bulletin Number: 4981 |
| SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT |
| Bulletin Number: 5128 |
| SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. ENGINEERING IS INVESTIGATING. *TT |
| Bulletin Number: 5257 |
| INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT |
| Bulletin Number: 5258 |
| INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT |
| Bulletin Number: 5262 |
| INFORMATION ON DIAGNOSTICING ERRATIC WINDSHIELD WIPER OPERATION. *TT |
| Bulletin Number: 5267 |
| SUBJECT REGARDING MISFIRE CODES ON ALL ENGINES. *TT |
| Bulletin Number: 5955 |
| SUBJECT REGARDING FRONT DIFFERENTIAL NOISE INVESTIGATION. *TT |
| Bulletin Number: 6232 |
| SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT |
| Bulletin Number: 6242 |
| EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT |
| Bulletin Number: 6287 |
| SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT |
| Bulletin Number: 6477 |
| SUBJECT REGARDING REAR SPRING RATTLE. *TT |
| Bulletin Number: 6489 |
| SOME VEHICLES BUILT WITH 3-LEAF OR 4-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *TT |
| Bulletin Number: 6996 |
| INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT |
| Bulletin Number: 7022 |
| INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS |
| Bulletin Number: 7080 |
| INFORMATION REGARDING STEERING GEAR LEAKS FROM INPUT SHAFT SEALS. *MJS |
| Bulletin Number: 7100 |
| INFORMATION REGARDING TRANSMISSION TROUBLE CODES. *MJS |
| Bulletin Number: 7353 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT |
| Bulletin Number: 7821 |
| CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. |
| Bulletin Number: 870197 |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 962210 |
| WINDSHIELD WASHERS - WASHER HOSE TOO SHORT AND/OR IS TRAPPED BY THE HOOD - VEHICLES BUILT THROUGH 4/15/96. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96226 |
| AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW |
| Bulletin Number: 962410 |
| TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW |
| Bulletin Number: 962418 |
| TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962510 |
| MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307 AND/OR P0308 STORED IN MEMORY. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962518 |
| DOOR - POWER POINT ACCESS DOOR BREAKS - VEHICLES BUILT THROUGH 8/31/96. *TW |
| Bulletin Number: 96252 |
| LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW |
| Bulletin Number: 962523 |
| RUNS ROUGH - MALFUNCTION INDICATOR LAMP (MIL) ON - DIAGNOSTIC TROUBLE CODES (DTCS) P0300 THROUGH P0308 STORED IN MEMORY - VEHICLES BUILT THROUGH 10/14/96 WITH 4.6L ENGINE. *TW |
| Bulletin Number: 962525 |
| NOISE - RATTLE - SUMMARY OF CONCERNS - SERVICE TIPS. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96265 |
| MALFUNCTION INDICATOR LAMP (MIL) - DIAGNOSTIC TROUBLE CODES (DTCS) P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, AND/OR P0308 STORED IN MEMORY. *TW |
| Bulletin Number: 97090297183 |
| EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC |
| Bulletin Number: 97090297187 |
| SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC |
| Bulletin Number: 971110972313 |
| A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 97410 |
| TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD |
| Bulletin Number: 9747 |
| FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 976007 |
| BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT |
| Bulletin Number: 976011 |
| EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9779 |
| WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD |
| Bulletin Number: 980310 |
| EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC |
| Bulletin Number: 980317 |
| SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC |
| Bulletin Number: 9810569 |
| CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC |
| Bulletin Number: 98113 |
| SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT |
| Bulletin Number: 9811342 |
| INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT |
| Bulletin Number: 9811344 |
| SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT |
| Bulletin Number: 98123 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 981512 |
| A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK |
| Bulletin Number: 981517 |
| INSTALL A REVISED CHILD SEAT TETHER KIT. |
| Bulletin Number: 981610 |
| THE SEAT BACK MAY NOT LATCH/ LOCK IN THE DESIRED POSITION AND REMAIN FOLDED FORWARD OVER THE SEAT CUSHION. YD |
| Bulletin Number: 981612 |
| FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD |
| Bulletin Number: 981613 |
| TRANSMISSION FLUID LEAKS AT RADIATOR. YD |
| Bulletin Number: 981617 |
| FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98168 |
| INSTALLATION OF VINYL FLOOR MATS SERVICE TIP. AK |
| Bulletin Number: 98168 |
| TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD |
| Bulletin Number: 98169 |
| STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982110 |
| DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC |
| Bulletin Number: 982117 |
| A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC |
| Bulletin Number: 98231 |
| CONDITION WITH WATER INTRUSION INTO THE GENERIC ELECTRONIC MODULE ( GEM ) MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 982312 |
| ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 982325 |
| THE MALFUCNTION INDICATOR LAMP ( MIL ) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0455 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982512 |
| SOME VEHICLES WITH HIGHER ODOMETER READINGS MAY EXPERIENCE A HESITATION ON ACCELERATION JUST OFF IDLE AND MISFIRE COMPLAINTS WITH MALFUNCTION INDICATOR LALMP ( MIL ) ON. *YC |
| Bulletin Number: 982548 |
| BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 982673 |
| IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC |
| Bulletin Number: 983070 |
| SOMVE VEHICLES MAY EXHIBIT A BUZZ / LOW GROWL NOISE COMING FROM THE AREA OF THE TRANSFER CASE MANUAL SHIFT LEVER. *TT |
| Bulletin Number: 983074 |
| CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 983301 |
| THIS BULLETIN PROVIDES PROCEDURES ON NEUTRALIZING THE EXHAUST, TRANSMISSION AND ENGINE MOUNTS. *TT |
| Bulletin Number: 983302 |
| THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT |
| Bulletin Number: 983306 |
| CONCERNS OF FRAME STRIKE ON THE REAR AXLE. *TT |
| Bulletin Number: 983570 |
| SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT |
| Bulletin Number: 983573 |
| SOME VEHICLES MAY EXHIBIT CAB VIBRATION. *TT |
| Bulletin Number: 98417 |
| COLD AIR MAY BE FELT ON THE FLOOR WHILE IN HEAT MODE ON SOME VEHICLES. *YC |
| Bulletin Number: 98419 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98-4717 |
| VEHICLES EXHIBIT CRACKS IN DOOR SHEET METAL AT LOWER REAR OF THE WINDOW OPENING NEAR BELT MOLDING. *AK |
| Bulletin Number: 98-4725 |
| VIBRATION AT CRUISE OVER 50 MPH. *AK |
| Bulletin Number: 98-4738 |
| COLD ENGINE KNOCK 5.4L ACTION. *AK |
| Bulletin Number: 985028 |
| INFORMATION REGARDING A NEW SERVICE PART RELEASED FOR THE LICENSE PLATE LIGHT CIRCUIT WHICH WILL REDUCE THE COSE OF REPAIRS. *TT |
| Bulletin Number: 985029 |
| SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT |
| Bulletin Number: 985059 |
| EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT |
| Bulletin Number: 985062 |
| SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT |
| Bulletin Number: 985063 |
| SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT |
| Bulletin Number: 985128 |
| SOME VEHICLES WITH ELECTRONIC SHIFT ON THE FLY 4X4 SYSTEMS MAY STICK IN 4X4 LOW. *TT |
| Bulletin Number: 985185 |
| COLD START ENGINE NOISE |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985200 |
| VEHICLES BUILT WITH 3-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE *MJS |
| Bulletin Number: 9858 |
| THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A12 |
| RECOMMENDED GUIDELINES FOR TOWING BEHIND RECREATIONAL VEHICLES. *TT |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 985A51 |
| ON SOME VEHICLES REPEAT REPAIRS MAY BE MADE TO 4-WHEEL ANTI-LOCK BRAKING SYSTEMS (4WABS) DUE TO MISDIAGNOSIS OF 4WABS CONCERNS WHICH MAY RESULT IN REPLACEMENT OF FUNCTIONAL COMPONENTS. *TT |
| Bulletin Number: 98611 |
| CONCERNS WITH REDUCED POWER, STALLING, HESITATION, AND SURGE. *YC |
| Bulletin Number: 98613 |
| SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9869 |
| CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT |
| Bulletin Number: 98812 |
| A VIBRATION AT HIGHWAY SPEEDS MAY BE FELT ON SOME VEHICLES. *YC |
| Bulletin Number: 98B33 |
| OWNER NOTIFICATION FOR REPLACEMENT OF ENGINE CYLINDER HEADS. *TT |
| Bulletin Number: 98S14 |
| SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT |
| Bulletin Number: 99107 |
| CONDITIONS ON REAR DRUM GRABBING DURING FIRST FEW BRAKE APPLICATIONS WHILE BRAKES ARE COLD. *TT |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99128 |
| SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99131 |
| CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 9913125 |
| SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT |
| Bulletin Number: 991313 |
| SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99143 |
| SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT |
| Bulletin Number: 99144 |
| VEHICLES MAY EXPERIENCE A MOANING NOISE HEARD AT APPROXIMATELY 1100 RPM WITH THE A/C COMPRESSOR ENGAGED. *TT |
| Bulletin Number: 99164 |
| CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT |
| Bulletin Number: 99185 |
| VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT |
| Bulletin Number: 99188 |
| VEHICLES WITH 4.2L ENGINE (CANADIAN) MAY BACKFIRE ON ACCELERATION AT ALL AMBIENT TEMPERATURE. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99207 |
| SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99234 |
| INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 99411 |
| VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT |
| Bulletin Number: 996034 |
| EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT |
| Bulletin Number: 996042 |
| INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT |
| Bulletin Number: 996113 |
| EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT |
| Bulletin Number: 996139 |
| CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT |
| Bulletin Number: 996754 |
| THIS ONLINE BULLETIN ADDRESSES CONCERNS WITH CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT |
| Bulletin Number: 996780 |
| THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT |
| Bulletin Number: 996876 |
| INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 9996 |
| EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT |
| Bulletin Number: BC0053970201 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0053972301 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0056972301 |
| SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD |
| Bulletin Number: BC0120970201 |
| DIAGNOSIS WINDNOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD |
| Bulletin Number: BC0121970201 |
| DRIVELINE RATTLE OVER BUMPS. *JD |
| Bulletin Number: BC0124970201 |
| FOR CUSTOMER CONCERNS OF STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OF EXCESSIVE FUEL PRESSURE. *JD |
| Bulletin Number: BC0197970201 |
| ENGINE OVERHEATING- WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. *JD |
| Bulletin Number: BC0315961101 |
| FEAD BELT SQUEAL, COLD ONLY. *TW |
| Bulletin Number: BC0315970201 |
| FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD |
| Bulletin Number: BC0316961101 |
| DRIVELINE CLUNK OR ACCEL OR DECEL. *TW |
| Bulletin Number: BC0325961129 |
| SOME FRONT END SERPENTINE BELTS MAY MAKE NOISE WHEN BETWEEN 30 AND 50 DEGREES FAHRENHEIT. *TW |
| Bulletin Number: BC0325972301 |
| SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD |
| Bulletin Number: BC0340961127 |
| CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW |
| Bulletin Number: BC0345970201 |
| DRIVELINE CLUNK, 4.2L BACKFIRE, 4.6L LACK OF POWER, 4.6L MISFIRE/MIL LIGHT ISSUES, AND WINDNOISE. *JD |
| Bulletin Number: BC0477961114 |
| ENGINEERING IS INVESTIGATING DEALERSHIP CONCERNS WITH FOULED OR CRACKED SPARK PLUGS. *TW |
| Bulletin Number: BC0676961025 |
| INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS. *TT |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0694961023 |
| INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0697961023 |
| WINDNOISE CONCERNS IN THE RIGHT DOOR A-PILLAR AREA OF THE SUPERCAB. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0753961017 |
| 4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT |
| Bulletin Number: BC0765961016 |
| INFORMATION ON DIAGNOSING WIND NOISE & WATER LEAKS AT THE LOWER PASSENGER DOOR AREA & 3RD DOOR. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0823961010 |
| CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT |
| Bulletin Number: BC0841961008 |
| CONCERNS OF WINDSHIELD WIPER NOT CLEANING, STREAKING OR SMEARING. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0854961007 |
| REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC0950960927 |
| TECHNICIANS ARE EXPERIENCING DIFFICULTY REMOVING DOOR TRIM PANELS. *TW |
| Bulletin Number: BC0990961021 |
| INFORMATION ON ENGINE OIL LEAK AT THE OIL PAN, FRONT COVER &/OR THE FRONT & REAR CRANKSHAFT OIL SEAL. *TT |
| Bulletin Number: BC1012897020 |
| WIND NOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD |
| Bulletin Number: BC1012997020 |
| DRIVELINE RATTLE OVER BUMPS. *JD |
| Bulletin Number: BC1013297020 |
| STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OR EXCESSIVE FUEL PRESSURE AND/OR MIL ACTIVATION WITH DTCS. *JD |
| Bulletin Number: BC1015397020 |
| VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC1020097230 |
| THE SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES 4X4 LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD |
| Bulletin Number: BC1022797230 |
| THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC105849705 |
| VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW |
| Bulletin Number: BC2150970206 |
| INSTRUCTIONS FOR DIAGNOSING FUEL GUAGE CONCERNS. *TW |
| Bulletin Number: BC2301970501 |
| NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW |
| Bulletin Number: BC2360970501 |
| FOR CONCERNS OF NOISY/SQUEAKY STEERING AND DIAGNOSIS IS FOR THE PITMAN ARM, RECOMMENDED SERVICE IS TO REPLACE THE PITMAN ARM. *TW |
| Bulletin Number: BC2363970501 |
| THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME. *TW |
| Bulletin Number: BC2385970501 |
| F SERIES FLARESIDE WHEN EQUIPPED WITH THE CAB STEP, WILL NOT HAVE MUD FLAPS. *TW |
| Bulletin Number: BC2391970501 |
| ENGINEERING IS ADDRESSING THE ISSUE OF INTERMITTENT/UNABLE TO ADJUST MIRROR CONCERNS. *TW |
| Bulletin Number: BC3090970225 |
| VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE - CHECK FOR DAMAGE TO CAMSHAFT. *TW |
| Bulletin Number: BC3101970224 |
| SOFT BRAKE PEDAL. *TW |
| Bulletin Number: BC3153970219 |
| INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS. *TW |
| Bulletin Number: BC3242970210 |
| DRIVELINE CLUNKING OR GRUNTING NOISE. *TW |
| Bulletin Number: BC3279970207 |
| CONCERNS WITH THE MULTI-FUNCTION SWITCH. *TW |
| Bulletin Number: BC3282970206 |
| GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW |
| Bulletin Number: BC3363972301 |
| THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC3443972301 |
| SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD |
| Bulletin Number: BC3510972301 |
| CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS. *JD |
| Bulletin Number: BC5168961001 |
| PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: TSB-14-0147 |
| FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW |
| Bulletin Number: TSB-14-0164 |
| FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE, |
| 1997 FORD F-250 |
|---|
| Bulletin Number: 0014 |
| VEHICLES MAY EXPERIENCE INNER FENDER WELL- DENTED OR DINGED FROM STONES BEING THROWN INTO WHEELWELL. *MJS |
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 0017 |
| SUBJECT ON THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODES MAY APPEAR. *MJS |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 00238 |
| SOME VEHICLES MAY EXHIBIT A NO CRANK / NO START CONDITION IN TEMPERATURES BELOW 12 DEGREES C (10 DEGREES F). *TT |
| Bulletin Number: 00239 |
| A CONDITION MAY EXIST WITH POSSIBLE ELECTRONC DAMAGE OCCURING TO THE COMPUVALVE FROM VOLTAGE SPIKES BETWEEN THE COMPUVALVE CONNECTIONS WHEN CONNECTING OR DISCONNECTING THE MAIN COMPUVALVE HARNESS C4025. *TT |
| Bulletin Number: 00254 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE BUCK, SURGE, OR JERK (ALSO KNOWN AS HITCHING / HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT |
| Bulletin Number: 00261 |
| SOME VEHICLES EQUIPPED WITH A 4.6L, 5.4L, OR 6.8L ENGINE MAY EXHIBIT A ROUGH IDLE / MISS AFTER START-UP IN COLD AMBIENT TEMPERATURES. *TT |
| Bulletin Number: 0038 |
| VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS |
| Bulletin Number: 00611 |
| SOME BI-FUEL VEHICLES MAY REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT DURING SERVICE AND MAY NOT RUN ON CNG OR LPG., RECALIBRATION OF THE PCM/REPLACEMENT. *MJS |
| Bulletin Number: 01111 |
| SOME VEHICLES MAY EXHIBIT A WATER LEAK AROUND THE REAR (SLIDING) WINDOW. *TT |
| Bulletin Number: 01166 |
| SOME VEHICLES MAY EXHIBIT WATER IN THE TRANSFER CASE, THIS COULD CAUSE LOW RANGE 4X4 LAMP TO ILLUMINATE, SHORT OF TRANSFER CASE SWITCH, OR WINDSHIELD WIPERS TO BE ERRATIC OR INOPERATIVE. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01182 |
| SOME VEHICLES MAY EXPERIENCE A COSMETIC CRACK IN THE OUTER DOOR PANEL AT THE LOWER REAR CORNER OF WINDOW OPENING.*JB |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01215 |
| A CONDITION MAY EXIST, WHERE THROTTLE STICKING MAY OCCUR ON A FEW VEHICLES IN VERY COLD AMBIENT TEMPERATURES AFTER OPERATING AT STEADY SPEED OR EXTENDED IDLE FOR A PERIOD OF TIME. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 0193 |
| A CONDITION MAY EXIST WHERE A DRIVELINE VIBRATION AND / OR A TRANSMISSION FLUID LEAK FROM THE EXTENSION HOUSING SEAL AREA MAY OCCUR ON SOME VEHICLES. THIS MAY BE CAUSED BY THE EXTENSION HOUSING BUSHING OR SEAL WALKING / SPINNING OUT DUE T |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02193 |
| DRIVEABILITY-IDLE-HIGH IDLE SPEEDS-THROTTLE STICKS AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES-VEHICLES BUILT THROUGH 12/31/01 EQUIPPED WITH 4.6L ENGINE. *MJ |
| Bulletin Number: 02E17 |
| SUBJECT REGARDING HEATER HOSE TO FUEL RAIL FLEX LINE INSPECTION. *JG |
| Bulletin Number: 030402 |
| ON SOME DEDICATED CNG VEHICLES, A POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE. REVISED SERVICE PARTS. *TT |
| Bulletin Number: 03103 |
| VEHICLES WITHOUT THE COOLANT LOCK-OFF MAY EXHIBIT A NO START CONDITION. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 032119 |
| AN ENGINE VIBRATION AND/OR MOANING NOISE AT 2600-3000 RPM. *TT |
| Bulletin Number: 032120 |
| 7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TT |
| Bulletin Number: 032121 |
| A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT |
| Bulletin Number: 032123 |
| LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT |
| Bulletin Number: 032125 |
| AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT |
| Bulletin Number: 03213 |
| A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT |
| Bulletin Number: 032140 |
| ENGINE BUCK, SURGE OR JERK (ALSO KNOWN AS HITCHING/HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT |
| Bulletin Number: 0342 |
| POSSIBLE FUEL LEAK MAY OCCUR AT THE FUEL FILL VALVE, ON SOME DEDICATED CNG VEHICLES. *TT *JB |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04217 |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04L19 |
| CUSTOMER MAINTENANCE REMINDER - LITERATURE PROGRAM 04L19 - TIE ROD INSPECTION PROCEDURE. *TT |
| Bulletin Number: 05417 |
| INTERMITTENT ROUGH IDLE - NON-COMMANDED EGR (EXHAUST GAS RECIRCULATION VALVE) FLOW. *TT |
| Bulletin Number: 07212 |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE |
| Bulletin Number: 11794 |
| EXPERIENCING A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT |
| Bulletin Number: 11799 |
| SOME SUPERCAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT |
| Bulletin Number: 11811 |
| SOME VEHICLES BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT |
| Bulletin Number: 11814 |
| SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT |
| Bulletin Number: 12071 |
| SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *MJS |
| Bulletin Number: 12113 |
| SOME VEHICLES WITH E40D AND CALIFORNIA CALIBRATION 7-90P-R10/11 MAY STALL DURING LONG DECEL CONDITIONS WHILE IN MKANUAL 1 OR 2 GEAR. *MJS |
| Bulletin Number: 12139 |
| SOME VEHICLES EQUIPPED WITH 4.6L OR 6.8L ENGINES MAY EXHIBIT A COLD START ENGINE NOISE UNTIL WARMED UP. *MJS |
| Bulletin Number: 12154 |
| SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS |
| Bulletin Number: 12208 |
| SOME TEXAS DEPARTMENT OF TRANSPORTATION (DOT) TRUCKS MAY ENCOUNTER A RADIO FREQUENCY INTERFERENCE (RFI) CONDITION WHEN USING HAND HELD TWO-WAY RADIOS IN THE RANGE OF 47.18 MHZ. *TT |
| Bulletin Number: 12248 |
| SOME HEAVY DUTY AND SUPER DUTY VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT |
| Bulletin Number: 12590 |
| SOME 4X4 VEHICLES MAY EXHIBIT A MOAN NOISE FROM THE FRONT DIFFERENTIAL WHEN THE VEHICLE IS OPERATING IN 4X2 MODE AND GOES AWAY WHEN OPERATING IN 4X4 MODE. *TT |
| Bulletin Number: 12601 |
| EXPERIENCING WHISTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AT HIGHWAY SPEEDS. *TT |
| Bulletin Number: 12720 |
| SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE FLEXIBLE RUBBER COOLANT HOSE. *TT |
| Bulletin Number: 12738 |
| SOME VEHICLES MAY EXHIBIT A IDLE VIBRATION. |
| Bulletin Number: 12879 |
| SUBJECT REGARDING REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING A REAR SPRING RATTLE. *TT |
| Bulletin Number: 12882 |
| SUBJECT REGARDING THE AVAILABILITY OF REAR SPRING CLIP KITS FOR VEHICLES EXHIBITING REAR SPRING RATTLE. *TT |
| Bulletin Number: 12905 |
| SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT |
| Bulletin Number: 13054 |
| EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT |
| Bulletin Number: 13106 |
| ON SOME VEHICLES THE FRONT BUMPERS MAY EXHIBIT RED STAINING (SPOTS) ON THE BUMER WING ENDS. *TT |
| Bulletin Number: 13203 |
| INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS |
| Bulletin Number: 13238 |
| INFORMATION REGARDING VEHICLES THAT EXHIBIT CRACKS IN THE DOOR SHEET METAL. *MJS |
| Bulletin Number: 13412 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT |
| Bulletin Number: 13479 |
| SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT |
| Bulletin Number: 13505 |
| ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT |
| Bulletin Number: 13550 |
| SOME VEHICLES MAY EXHIBIT DENTS ON THE WHEEL WELL SHEET METAL OF THE PCIK-UP BOX AREA WHEN USED IN OFF-ROAD APPLICATIONS. *TT |
| Bulletin Number: 13745 |
| SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS |
| Bulletin Number: 13838 |
| CONCERNS WITH VEHICLES EXHIBITING A WINDSHIELD CREAK / SQUEAK. *TT |
| Bulletin Number: 14365 |
| THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB |
| Bulletin Number: 14455 |
| OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT |
| Bulletin Number: 15113 |
| SOME VEHICLES MAY EXHIBIT A FUEL FILL VALVE SEALING CONDITION. *YD |
| Bulletin Number: 15260 |
| CONCERNS WITH CORRODED POSITIVE STARTER CABLE. *TT |
| Bulletin Number: 15570 |
| SOME VEHICLES MAY EXHIBIT VARIOUS DRIVEABILITY CONDITIONS INCLUDING LACKS POWER, HESITATES, HARD TO START, AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED AND PRODUCE POSSIBLE DIAGNOSTIC TROUBLE CODES P0103, P0172 AND P0175. *TT |
| Bulletin Number: 16515 |
| OIL LEAK AT HIGH PRESSURE PUMP FITTINGS AND/OR PLUG. THIS INCLUDES SUPER DUTY F-SERIES. OASIS. *TT |
| Bulletin Number: 17571 |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT |
| Bulletin Number: 4614 |
| INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT |
| Bulletin Number: 4616 |
| BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT |
| Bulletin Number: 4617 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT |
| Bulletin Number: 4625 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT |
| Bulletin Number: 4628 |
| SOME VEHICLES MAY EXHIBIT REAR AXLE NOISE. *TT |
| Bulletin Number: 4629 |
| BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT |
| Bulletin Number: 4631 |
| BRIEF INFORMATION ON VEHICLES EXHIBIT VIBRATION AT CRUISE OVER 50 MPH. *TT |
| Bulletin Number: 4633 |
| REAR BRAKE DRAG OR EXCESSIVE WEAR ON REAR BRAKES. *TT |
| Bulletin Number: 4635 |
| COLD ENGINE KNOCK. *TT |
| Bulletin Number: 4638 |
| MALFUNCTION INDICATOR LAMP ON, WITH P0300 - P0308 MISFIRE DIAGNOSTIC TROUBLE CODES WITH A 4.6L ENGINE. *TT |
| Bulletin Number: 4682 |
| SOME SUPER CAB VEHICLES MAY EXHIBIT A MOAN / DROAN IN THE CAB AT 1500 - 1600 RPM OR A CAB VIBRATION AT 1800 - 1900 RPM. *TT |
| Bulletin Number: 4683 |
| SOME VEHICLES MAY EXHIBIT A RUBBING OR SQUEAK NOISE AS THE STEERING WHEEL IS TURNED. *TT |
| Bulletin Number: 4703 |
| SOME TRUCKS BUILT WITH 16 INCH CHROME STYLED STEEL WHEELS AND TRUCKS BUILT WITH 16 INCH STEEL WHEELS MAY EXHIBIT SIGNS OF RUST AROUND THE EDGES OF THE WHEELS. *TT |
| Bulletin Number: 4981 |
| SOME VEHICLES EQUIPPED WITH 5.4L ENGINES MAY EXHIBIT A COLD START ENGINE KNOCK CONCERN UNTIL WARMED UP. *TT |
| Bulletin Number: 5046 |
| REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT |
| Bulletin Number: 5047 |
| REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT |
| Bulletin Number: 5250 |
| INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT |
| Bulletin Number: 5251 |
| SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES. *TT |
| Bulletin Number: 5254 |
| INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT |
| Bulletin Number: 5257 |
| INFORMATION ON VEHICLES EXHIBITING COLD ENGINE KNOCK. *TT |
| Bulletin Number: 5258 |
| INFORMATION ON VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. *TT |
| Bulletin Number: 5262 |
| INFORMATION ON DIAGNOSTICING ERRATIC WINDSHIELD WIPER OPERATION. *TT |
| Bulletin Number: 5262 |
| SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT |
| Bulletin Number: 5267 |
| SUBJECT REGARDING MISFIRE CODES ON ALL ENGINES. *TT |
| Bulletin Number: 5316 |
| SOME SUPER DUTY 7.3L E4OD AND 7.3L 4R100 VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT |
| Bulletin Number: 5955 |
| SUBJECT REGARDING FRONT DIFFERENTIAL NOISE INVESTIGATION. *TT |
| Bulletin Number: 6232 |
| SOME VEHICLES MAY DEVELOP A COOLANT LEAK AT THE WORM GEAR CLAMP LOCATED AT THE JOINT BETWEEN THE METAL INTAKE COOLANT TUBE AND THE COIL RESULTING IN ENGINE MISFIRE WITH DIAGNOSTIC TROUBLE CODE P0304 AND / OR ROUGH IDLE. *TT |
| Bulletin Number: 6287 |
| SOME VEHICLES MAY EXPERIENCE AN IDLE VIBRATION. *TT |
| Bulletin Number: 6477 |
| SUBJECT REGARDING REAR SPRING RATTLE. *TT |
| Bulletin Number: 6489 |
| SOME VEHICLES BUILT WITH 3-LEAF OR 4-LEAF REAR SPRINGS MAY EXHIBIT A REAR SPRING RATTLE. *TT |
| Bulletin Number: 7022 |
| INFORMATION REGARDING OUTWARD DENTS IN PICKUP BOX WHEEL WELLS. *MJS |
| Bulletin Number: 7353 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT |
| Bulletin Number: 7821 |
| CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 962213 |
| EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96226 |
| AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW |
| Bulletin Number: 962410 |
| TRANSMISSION - E40D - 4R70W - 4R44E - 5R55E - NEW DIGITAL TRANSMISSION RANGE SENSOR - DIAGNOSIS SERVICE TIP. *TW |
| Bulletin Number: 962412 |
| BRAKES - REAR PARKING BRAKE CABLE BINDS - VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED. *TW |
| Bulletin Number: 962418 |
| TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962518 |
| DOOR - POWER POINT ACCESS DOOR BREAKS - VEHICLES BUILT THROUGH 8/31/96. *TW |
| Bulletin Number: 96252 |
| LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW |
| Bulletin Number: 962521 |
| STEERING - CLUNK NOISE FROM STEERING COLUMN ON ACCELERATING AND BRAKING. *TW |
| Bulletin Number: 962525 |
| NOISE - RATTLE - SUMMARY OF CONCERNS - SERVICE TIPS. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 97111097238 |
| SUBJECT ON REAR VIBRATION/SHUDDER WHEN APPLYING BRAKES. *YC |
| Bulletin Number: 97113 |
| AN ENGINE VIBRATION AND/OR "MOANING" NOISE AT 2600-3000 RPM MAY OCCUR ON SOME VEHICLES. *JD |
| Bulletin Number: 97214 |
| ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TW |
| Bulletin Number: 97215 |
| DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW |
| Bulletin Number: 97216 |
| LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 97410 |
| TRANSMISSION- E4OD- COOLER BYPASS VALVE SERVICE DURING TRANSMISSION OVERHAUL- SERVICE TIP. *JD |
| Bulletin Number: 9747 |
| FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 976007 |
| BRIEF INFORMATION REGARDING CYLINDER HEAD TEMPERATURE (CHT) AND FAIL SAFE COOLING. *TT |
| Bulletin Number: 976011 |
| CUSTOMER MAY COMPLAIN OF INTERMITTENT STALL / BUCKS / JERKS WHILE DRIVING. *TT |
| Bulletin Number: 97618 |
| LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD |
| Bulletin Number: 97627 |
| NOISE- "RATCHETING"- FRONT AXLE- 4X4- SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS- F-250 AND F-350 OVER 8500# GVW. *JD |
| Bulletin Number: 97629 |
| TRANSMISSION- E4OD- HARSH/DELAYED 2-3 UPSHIFTS- VEHICLES WITH 7.3L DIESEL AND 49-STATE CALIBRATION- F-SERIES BUILT THROUGH 2/3/97 AND ALL 1996 E-350. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 97713 |
| NOISE- "BUZZING"- UNDERHOOD WHEN AIR SUSPENSION IS IN OPERATION. *JD |
| Bulletin Number: 9778 |
| HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD |
| Bulletin Number: 9779 |
| WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD |
| Bulletin Number: 980298 |
| INFORMATION REGARDING THE HOTLINE SURVEY. *YC |
| Bulletin Number: 9803000 |
| HOTLINE CONTACT ID NUMBER ON OASIS. A NINE DIGIT CONTACT NUMBER IS ATTACHED TO THE OASIS INFORMATION WHEN A VIN AND SYMPTOM CODE IS ENTERED INTO OASIS. *YC |
| Bulletin Number: 980307 |
| VEHICLE STALLS/QUITS WHILE DRIVING. *AK |
| Bulletin Number: 980310 |
| EXPERIENCING VIBRATION AT CRUISE OVER 50 MPH. *YC |
| Bulletin Number: 980312 |
| EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT |
| Bulletin Number: 980317 |
| SYMPTOMS REGARDING P0300-P0308 MISFIRE DTCS WITH 4.6L ENGINES. *YC |
| Bulletin Number: 980323 |
| CONCERNS WITH EXTERNAL OIL LEAKS. *YC |
| Bulletin Number: 980323 |
| DTC'S P1211/1212 ICP PRESSURE HIGHER/LOWER THAN EXPECTED. |
| Bulletin Number: 980325 |
| COLD ENGINE UPPER KNOCK/TICK. *YC |
| Bulletin Number: 9810569 |
| CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC |
| Bulletin Number: 98113 |
| SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT |
| Bulletin Number: 9811335 |
| EXHIBITING A VIBRATION, NOISE OR GROUND OUT CONDITION WHEN TURNING OR UNDER LOAD. *TT |
| Bulletin Number: 9811342 |
| INFORMATION ON REMOVING THE RADIO CHASSIS FROM SOME VEHICLES. *TT |
| Bulletin Number: 9811344 |
| SOME VEHICLES MAY EXHIBIT LOOSE LUGNUTS AND / OR BROKEN WHEEL STUDS. *TT |
| Bulletin Number: 9811346 |
| SOME VEHICLES MAY EXPERIENCE AN INTERMITTENT STALL CONDITION AFTER A LONG DECELERATION WHEN USING THE M1 OR M2 GEAR ON THE E40D OR WHEN USING A LOWER GEAR WITH THE M50D FOR ENGINE BRAKING. *TT |
| Bulletin Number: 98151 |
| MALFUNCTION INDICATOR LAMP FAILED. YD |
| Bulletin Number: 981512 |
| A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK |
| Bulletin Number: 981517 |
| INSTALL A REVISED CHILD SEAT TETHER KIT. |
| Bulletin Number: 98158 |
| FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. SHIMMY IS NOT ALWAYS VERIFIED DURING ROAD TEST. *AK |
| Bulletin Number: 981610 |
| THE SEAT BACK MAY NOT LATCH/ LOCK IN THE DESIRED POSITION AND REMAIN FOLDED FORWARD OVER THE SEAT CUSHION. YD |
| Bulletin Number: 981612 |
| FUEL MAY LEAK FROM THE SPRING LOCK COUPLINGS. YD |
| Bulletin Number: 981613 |
| TRANSMISSION FLUID LEAKS AT RADIATOR. YD |
| Bulletin Number: 981617 |
| FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98168 |
| INSTALLATION OF VINYL FLOOR MATS SERVICE TIP. AK |
| Bulletin Number: 98168 |
| TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD |
| Bulletin Number: 98169 |
| STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982110 |
| DURING HIGH IDLE SPEEDS THROTTLE STICKS AFTER STEADY STATE DRIVING IN COLD AMBIENT TEMPERATURES. *YC |
| Bulletin Number: 982117 |
| A NEW PARKING BRAKE CONTROL RUBBER BUMPER STOP IS NOW AVAILABLE FOR SERVICE. *YC |
| Bulletin Number: 98231 |
| CONDITION WITH WATER INTRUSION INTO THE GENERIC ELECTRONIC MODULE ( GEM ) MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982312 |
| ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 982313 |
| SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION. |
| Bulletin Number: 982314 |
| PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982512 |
| SOME VEHICLES WITH HIGHER ODOMETER READINGS MAY EXPERIENCE A HESITATION ON ACCELERATION JUST OFF IDLE AND MISFIRE COMPLAINTS WITH MALFUNCTION INDICATOR LALMP ( MIL ) ON. *YC |
| Bulletin Number: 982548 |
| BRIEF INFORMATION GIVING THE CORRECT PART NUMBER FOR TSB 98-3-12. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 982673 |
| IF YOU ENCOUNTER A VEHICLE WITH A MISSING WHEEL HUB O-RING, DO NOT INSTALL A NEW O-RING. *YC |
| Bulletin Number: 982740 |
| CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC |
| Bulletin Number: 983070 |
| SOMVE VEHICLES MAY EXHIBIT A BUZZ / LOW GROWL NOISE COMING FROM THE AREA OF THE TRANSFER CASE MANUAL SHIFT LEVER. *TT |
| Bulletin Number: 983074 |
| CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 983301 |
| THIS BULLETIN PROVIDES PROCEDURES ON NEUTRALIZING THE EXHAUST, TRANSMISSION AND ENGINE MOUNTS. *TT |
| Bulletin Number: 983302 |
| THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT |
| Bulletin Number: 983564 |
| EXPERIENCING A SQUEALING NOISE FROM THE FRONT BRAKES WHEN APPLYING THE BRAKES ON SOME VEHICLES. *TT |
| Bulletin Number: 983570 |
| SOME ENGINES MAY EXHIBIT OIL LEAKAGE. *TT |
| Bulletin Number: 98413 |
| A GRABBING CONDITION AND / OR SQUEAL NOISE FROM THE REAR BRAKES DURING FIRST FEW BRAKE APPLICATIONS AFTER RAINFALL AND / OR WHILE BRAKES ARE COLD. *TT |
| Bulletin Number: 98419 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98-4717 |
| VEHICLES EXHIBIT CRACKS IN DOOR SHEET METAL AT LOWER REAR OF THE WINDOW OPENING NEAR BELT MOLDING. *AK |
| Bulletin Number: 98-4722 |
| REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK |
| Bulletin Number: 98-4725 |
| VIBRATION AT CRUISE OVER 50 MPH. *AK |
| Bulletin Number: 98-4726 |
| REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK |
| Bulletin Number: 98-4734 |
| LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST |
| Bulletin Number: 98-4738 |
| COLD ENGINE KNOCK 5.4L ACTION. *AK |
| Bulletin Number: 98-4742 |
| VEHICLE STALLS UPON ACCELERATION. *AK |
| Bulletin Number: 985028 |
| INFORMATION REGARDING A NEW SERVICE PART RELEASED FOR THE LICENSE PLATE LIGHT CIRCUIT WHICH WILL REDUCE THE COSE OF REPAIRS. *TT |
| Bulletin Number: 985029 |
| SOME VEHICLES MAY EXHIBIT CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT |
| Bulletin Number: 985042 |
| REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT |
| Bulletin Number: 985058 |
| SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT |
| Bulletin Number: 985059 |
| EXPERIENCING COLD ENGINE KNOCK (REPEAT / REVISED MESSAGE). *TT |
| Bulletin Number: 985062 |
| SUBJECT REGARDING IDLE VIBRATION (REPEAT MESSAGE). *TT |
| Bulletin Number: 985063 |
| SUBJECT REGARDING VEHICLES EXHIBITING VIBRATION AT CRUISE OVER 50 MPH. (REPEAT MESSAGE). *TT |
| Bulletin Number: 985185 |
| COLD START ENGINE NOISE |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 9858 |
| THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE AND DIAGNOSTIC TROUBLE CODE (DTC) P0503 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A23 |
| A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN HELPING TO RESOLVE PULL OR DRIFT CONDITIONS. *TT |
| Bulletin Number: 985A25 |
| A VIBRATION OR SHUDDER MAY BE FELT DURING BRAKING ON SOME VEHICLES. *YC |
| Bulletin Number: 985A35 |
| THE REAR PARKING BRAKE CABLES MAY BIND AND NOT ALLOW THE REAR BRAKE SHOES TO RETURN FULLY TO THE ANCHOR PINS AFTER THE PARKING BRAKE IS APPLIED. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 98611 |
| CONCERNS WITH REDUCED POWER, STALLING, HESITATION, AND SURGE. *YC |
| Bulletin Number: 98613 |
| SUBJECT REGARDING COLD AIR FELT ON THE FLOOR WHILE IN HEAT MODE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9869 |
| CONCERNS WITH HESITATION, STUMBLE, SURGE, MISS, ROUGH IDLE, STALL AT IDLE. *TT |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 98S14 |
| SAFETY RECALL UPDATE TO REPLACE LOCKING LUG NUTS. *TT |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99128 |
| SOME VEHICLES MAY EXHIBIT A WHISTLING NOISE WHILE DRIVING WITH A/C IN THE OFF POSITION AT SPEEDS ABOVE 64 KM/H (40 MPH). *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 991313 |
| SUBJECT REGARDING ANTI-LOCK BRAKE LAMP ILLUMINATION, INCREASED BREAK PEDAL EFFORT AND / OR FALSE ANTI-LOCK BRAKE SYSTEM (ABS) CYCLING AT LOW SPEEDS. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99143 |
| SOME 4X4 VEHICLES BUILT WITH CENTER DISCONNECT FRONT AXLES MAY EXHIBIT A MOANING NOISE FROM THE FRONT DIFFERENTIAL WHILE OPERATING IN 4X2 MODE. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99164 |
| CONCERNS WITH A HARD TO TURN IGNITION KEY AND / OR A HARD TO REMOVE KEY FROM IGNITION CYLINDER. *TT |
| Bulletin Number: 99185 |
| VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99234 |
| INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 99411 |
| VEHICLES EXPERIENCING INCREASED BRAKE PEDAL EFFORT AND / OR FALSE ABS CYCLING AT LOW SPEEDS, OR ABS LAMP ILLUMINATION. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT |
| Bulletin Number: 996034 |
| EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT |
| Bulletin Number: 996042 |
| INFORMATION ON USING 1999 PROCEDURES MANUAL FOR SIDE MIRROR REPLACEMENT. *TT |
| Bulletin Number: 996113 |
| EXPERIENCING FRONT DIFFERENTIAL NOISE. *TT |
| Bulletin Number: 996128 |
| SUBJECT REGARDING RIGHT REAR BRAKE CONCERNS UNDER INVESTIGATION. *TT |
| Bulletin Number: 996139 |
| CONCERNS WITH FRONT DIFFERENTIAL NOISE. *TT |
| Bulletin Number: 996754 |
| THIS ONLINE BULLETIN ADDRESSES CONCERNS WITH CRACKS IN THE DOOR SHEET METAL AT THE LOWER REAR OF THE WINDOW OPENING NEAR THE BELT MOLDING. *TT |
| Bulletin Number: 996780 |
| THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT |
| Bulletin Number: 996876 |
| INFORMATION PERTAINING TO CONDITIONS WITH RED STAINING (SPOTS) ON THE FRONT BUMPER WING ENDS. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 9996 |
| EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT |
| Bulletin Number: BC0053970201 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0053972301 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0056972301 |
| SOME VEHICLES WITH AIR CONDITIONING CAN EXHIBIT A COLD START ACCESSORY DRIVE BELT NOISE (CHIRP) CONCERN. *JD |
| Bulletin Number: BC0120970201 |
| DIAGNOSIS WINDNOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD |
| Bulletin Number: BC0121970201 |
| DRIVELINE RATTLE OVER BUMPS. *JD |
| Bulletin Number: BC0124970201 |
| FOR CUSTOMER CONCERNS OF STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OF EXCESSIVE FUEL PRESSURE. *JD |
| Bulletin Number: BC0256970201 |
| A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD |
| Bulletin Number: BC0315961101 |
| FEAD BELT SQUEAL, COLD ONLY. *TW |
| Bulletin Number: BC0315970201 |
| FEAD BELT SQUEAL, COLD ONLY. REVISED BELT RELEASED. *JD |
| Bulletin Number: BC0321961101 |
| POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *TW |
| Bulletin Number: BC0321970201 |
| POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD |
| Bulletin Number: BC0321972301 |
| POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD |
| Bulletin Number: BC0325972301 |
| SOME 5.4L FRONT END SERPETNTINE BELTS MAY MAKE SOME NOISE BETWEEN TEMPERATURES FO 30 F-50 F. *JD |
| Bulletin Number: BC0340961127 |
| CERTAIN 1997 VEHCILES MAY HAVE BEEN BUILT WITH THE 240 SECOND MISFIRE DELAY. *TW |
| Bulletin Number: BC0345970201 |
| DRIVELINE CLUNK, 4.2L BACKFIRE, 4.6L LACK OF POWER, 4.6L MISFIRE/MIL LIGHT ISSUES, AND WINDNOISE. *JD |
| Bulletin Number: BC0676961025 |
| INFORMATION WHEN ELECTRONIC/HYDRAULIC CONTROL UNIT (EHCU) MALFUNCTIONS. *TT |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0694961023 |
| INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0697961023 |
| WINDNOISE CONCERNS IN THE RIGHT DOOR A-PILLAR AREA OF THE SUPERCAB. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0753961017 |
| 4X4 VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE SHIFTING INTO 4L. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0823961010 |
| CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT |
| Bulletin Number: BC0841961008 |
| CONCERNS OF WINDSHIELD WIPER NOT CLEANING, STREAKING OR SMEARING. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0854961007 |
| REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC1012897020 |
| WIND NOISE AT THE INNER BELT, RAISE DOOR GLASS TO FULL UP POSITION. *JD |
| Bulletin Number: BC1012997020 |
| DRIVELINE RATTLE OVER BUMPS. *JD |
| Bulletin Number: BC1013297020 |
| STALL, ROUGH IDLE, LACKS POWER, POOR FUEL ECONOMY, BACKFIRE, SURGE UNDER HEAVY ACCELERATION, LOSS IN FUEL PRESSURE UNDER ACCELERATION OR EXCESSIVE FUEL PRESSURE AND/OR MIL ACTIVATION WITH DTCS. *JD |
| Bulletin Number: BC1015397020 |
| VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC1020097230 |
| THE SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES 4X4 LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD |
| Bulletin Number: BC1020897230 |
| AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNTIONING HAS BEEN DELAYED TO LATE FEBRUARY FORM THE ORIGINAL JANUARY 1997 DATE. *JD |
| Bulletin Number: BC1022797230 |
| THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC105849705 |
| VEHICLES WITH PREMIUM RADIOS WILL BE EQUIPPED WITH VOLUME CONTROL/ON-OFF SWITCH. *TW |
| Bulletin Number: BC2297970501 |
| WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS. *TW |
| Bulletin Number: BC2301970501 |
| NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW |
| Bulletin Number: BC2360970501 |
| FOR CONCERNS OF NOISY/SQUEAKY STEERING AND DIAGNOSIS IS FOR THE PITMAN ARM, RECOMMENDED SERVICE IS TO REPLACE THE PITMAN ARM. *TW |
| Bulletin Number: BC2363970501 |
| THE ONLY AUTHORIZED REPAIR FOR A FRONT FRAME BUMPER MOUNTING BRACKET NEEDING REPLACEMENT IS TO REPLACE THE FRAME. *TW |
| Bulletin Number: BC2391970501 |
| ENGINEERING IS ADDRESSING THE ISSUE OF INTERMITTENT/UNABLE TO ADJUST MIRROR CONCERNS. *TW |
| Bulletin Number: BC3090970225 |
| VEHICLES WITH A ROUGH RUNNING/MISS SYMPTOM WITH A MISFIRE DTC ON A PARTICULAR CYLINDER WHERE NORMAL DIAGNOSIS DOES NOT PINPOINT A CAUSE - CHECK FOR DAMAGE TO CAMSHAFT. *TW |
| Bulletin Number: BC3101970224 |
| SOFT BRAKE PEDAL. *TW |
| Bulletin Number: BC3130970221 |
| DIESEL EXHAUST SMELL IN PASSENGER CABIN MAY BE DUE TO POOR CONNECTION AT THE INLET OR OUTLET TO/FROM THE TURBO. *TW |
| Bulletin Number: BC3153970219 |
| INOPERATIVE OR ERRATIC CRUISE CONTROL OPERATION ALONG WITH HARSH TRANSMISSION SHIFTS. *TW |
| Bulletin Number: BC3171970217 |
| UNEXPLAINED GLASS BREAKAGE OF THE LEFT FRONT DOOR. *TW |
| Bulletin Number: BC3212970213 |
| CAMSHAFT POSITION SENSOR INFORMATION . *TW |
| Bulletin Number: BC3241970210 |
| EXHAUST LEAKS OR NOISE AT THE JOINT BETWEEN THE Y-PIPE AND THE EXHAUST MANIFOLD. *TW |
| Bulletin Number: BC3242970210 |
| DRIVELINE CLUNKING OR GRUNTING NOISE. *TW |
| Bulletin Number: BC3279970207 |
| CONCERNS WITH THE MULTI-FUNCTION SWITCH. *TW |
| Bulletin Number: BC3287970206 |
| THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW |
| Bulletin Number: BC3363972301 |
| THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC3440972301 |
| AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVEMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNCTIONING HAS BEEN DELAYED. *JD |
| Bulletin Number: BC3443972301 |
| SECOND PRINTING OF THE 1997 OWNERS GUIDE STATES THAT THE VEHICLES LONG WHEELBASE MAY HAVE A SNOWPLOW INSTALLED- THIS IS INCORRECT. *JD |
| Bulletin Number: BC3510972301 |
| CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON 1997 5.4L VEHICLE APPLICATIONS. *JD |
| Bulletin Number: BC5168961001 |
| PROCEDURE FOR RESOLVING THE CONCERN OF WATER ENTRY INTO THE TRANSFER CASE. *TT |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BPI9905 |
| CUSTOMER MAY COMPLAIN THAT THE RAYBESTOS ELECTRONIC BRAKE CONTROLLER DOES NOT WORK, WORKS INCORRECTLY, WORKS INTERMITTENTLY, PULSES THE 4-WAY FLASHERS, AND / OR INTERFERS WITH ANTILOCK BRAKES OPERATION. *TT |
| Bulletin Number: TSB-14-0147 |
| FORD/LINCOLN: SAFETY RECALL ISSUED DUE TO ONE OR BOTH FUEL TANK STRAPS FRACTURING DUE TO BEING IN HIGH CORROSION AREAS FOR AN EXTENDED PERIOD AND DISLODGING FUEL TANK. MODEL 1997-99 F250, 1997-03 F150, 2004 F150 HERITAGE, 2002-2003 BLACKW |
| Bulletin Number: TSB-14-0164 |
| FORD/LINCOLN: SAFETY RECALL REGARDING HIGH CORROSION AREAS FOR OPERATING, FOR AN EXTENDED TIME, VEHICLES WHERE BOTH OR ONE STRAP OF FUEL TANK CAN FRACTURE, AFTER CONTACTING GROUND. MODEL 1997-99 F250 LD, 1997-03 F150, 2004 F150 HERITAGE, |
| 1997 FORD F-250 SD |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 0038 |
| VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03211 |
| LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT |
| Bulletin Number: 032126 |
| MOANING NOISE DURING 1500-2000 RPM ON NEUTRAL ENGINE RUN-UP, OR WHILE DRIVING UNDER LOAD. *TT |
| Bulletin Number: 032131 |
| ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 98113 |
| SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT |
| Bulletin Number: 98119 |
| CONDITIONS WITH ENGINE STALLING DURING LONG DECEL WHILE IN MANUAL 1 OR MANUAL 2 GEAR ON SOME VEHICLES. *TT |
| Bulletin Number: 98122 |
| INFORMATION ON THE DEFROSTER PERFORMANCE ENHANCEMENT. |
| Bulletin Number: 98156 |
| EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98168 |
| TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD |
| Bulletin Number: 98205 |
| EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982721 |
| SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC |
| Bulletin Number: 98414 |
| EXPERIENCING AN ENGINE STALL CONDITION ON 1997 CALIFORNIA F SERIES 7.3L DIESEL E40D VEHICLES AFTER A LONG DECEL WHEN USING M1 GEAR FOR ENGINE BRAKING. *YC |
| Bulletin Number: 98419 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 985176 |
| SOME TRUCKS WITH E40D AND CALIFORNIA CALIBRATION 7-90P-R10/11 MAY STALL DURING LONG DECEL CONDITIONS WHILE IN MANUAL 1 OR 2 GEAR. *TT |
| Bulletin Number: 985A23 |
| A COMPREHENSIVE PULL AND DRIFT DIAGNOSTIC PROCEDURE HAS BEEN DEVELOPED TO ASSIST TECHNICIANS IN HELPING TO RESOLVE PULL OR DRIFT CONDITIONS. *TT |
| Bulletin Number: 985A25 |
| A VIBRATION OR SHUDDER MAY BE FELT DURING BRAKING ON SOME VEHICLES. *YC |
| Bulletin Number: 985A27 |
| LUBRICANT LEAKING FROM REAR AXLE SEAL CONTAMINATING BRAKE SHOES. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 98810 |
| SOME CUSTOMERS MAY REQUIRE A HEAVY DUTY 7-WAY TRAILER WIRING CONNECTOR SYSTEM WHEN THE VEHICLE IS EQUIPPED WITH A 4-WAY CONNECTOR. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99236 |
| SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| 1997 FORD F-350 |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 00254 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE BUCK, SURGE, OR JERK (ALSO KNOWN AS HITCHING / HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT |
| Bulletin Number: 0038 |
| VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03211 |
| LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT |
| Bulletin Number: 032119 |
| AN ENGINE VIBRATION AND/OR MOANING NOISE AT 2600-3000 RPM. *TT |
| Bulletin Number: 032120 |
| 7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TT |
| Bulletin Number: 032121 |
| A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT |
| Bulletin Number: 032123 |
| LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT |
| Bulletin Number: 032125 |
| AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT |
| Bulletin Number: 032126 |
| MOANING NOISE DURING 1500-2000 RPM ON NEUTRAL ENGINE RUN-UP, OR WHILE DRIVING UNDER LOAD. *TT |
| Bulletin Number: 03213 |
| A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT |
| Bulletin Number: 032131 |
| ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *TT |
| Bulletin Number: 032140 |
| ENGINE BUCK, SURGE OR JERK (ALSO KNOWN AS HITCHING/HESITATION) WHILE THE SPEED CONTROL IS ACTIVE THROUGH ALL ENGINE TEMPERATURES. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 12113 |
| SOME VEHICLES WITH E40D AND CALIFORNIA CALIBRATION 7-90P-R10/11 MAY STALL DURING LONG DECEL CONDITIONS WHILE IN MKANUAL 1 OR 2 GEAR. *MJS |
| Bulletin Number: 12248 |
| SOME HEAVY DUTY AND SUPER DUTY VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT |
| Bulletin Number: 12905 |
| SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT |
| Bulletin Number: 14455 |
| OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT |
| Bulletin Number: 17571 |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT |
| Bulletin Number: 4614 |
| INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT |
| Bulletin Number: 4616 |
| BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT |
| Bulletin Number: 4617 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT |
| Bulletin Number: 4625 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT |
| Bulletin Number: 4629 |
| BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT |
| Bulletin Number: 4633 |
| REAR BRAKE DRAG OR EXCESSIVE WEAR ON REAR BRAKES. *TT |
| Bulletin Number: 5046 |
| REPEAT MESSAGE REGARDING VEHICLES EXHIBITING A LACK OF POWER. *TT |
| Bulletin Number: 5047 |
| REPEAT MESSAGE REGARDING A HARD START / NO START CONDITION. *TT |
| Bulletin Number: 5250 |
| INFORMATION ON SUPER DUTY MODELS WITH 7.3L DIESEL ENGINES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT |
| Bulletin Number: 5251 |
| SOME SUPER DUTY VEHICLES WITH 7.3L DIT DIESEL ENGINES MAY EXHIBIT 4X4 LIGHTS ON, 4X4 INOPERATIVE AND / OR MULTIPLE GEM CODES. *TT |
| Bulletin Number: 5254 |
| INFORMATION ON SUPER DUTY 7.3 DIT DIESEL ENGINE VEHICLES EXHIBITI LACK OF POWER. *TT |
| Bulletin Number: 5262 |
| SERVICE INFORMATION FOR VEHICLES EXHIBITING STALL ON DECELERATION CONDITION. *TT |
| Bulletin Number: 5316 |
| SOME SUPER DUTY 7.3L E4OD AND 7.3L 4R100 VEHICLES MAY EXHIBIT VARIOUS TRANSMISSION CONCERNS, INCLUDING STALL ON TRANSMISSION ENGAGEMENT AND / OR A BUZZ NOISE ON ENGAGEMENT. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 962213 |
| EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96226 |
| AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW |
| Bulletin Number: 962412 |
| BRAKES - REAR PARKING BRAKE CABLE BINDS - VEHICLES BUILT BEFORE 8/20/96 - ALL CHASSIS CAB VEHICLES ARE EXCLUDED. *TW |
| Bulletin Number: 962418 |
| TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96252 |
| LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962621 |
| VIBRATION- DRIVELINE RESONANCE/VIBRATION BETWEEN 1400 AND 2000 RPM WITH CONVERTER CLUTCH ENGAGED DURING MEDIUM TO HEAVY THROTTLE CONDITIONS- VEHICLES WITH 7.3L DI TURBO ENGINE AND TRANSMISSION BUILT PRIOR TO 11/13/95 (5L13) TRANSMISSION- E4 |
| Bulletin Number: 97050110621 |
| PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER. *TW |
| Bulletin Number: 97090297187 |
| SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC |
| Bulletin Number: 971110972313 |
| A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC |
| Bulletin Number: 97111097238 |
| SUBJECT ON REAR VIBRATION/SHUDDER WHEN APPLYING BRAKES. *YC |
| Bulletin Number: 97113 |
| AN ENGINE VIBRATION AND/OR "MOANING" NOISE AT 2600-3000 RPM MAY OCCUR ON SOME VEHICLES. *JD |
| Bulletin Number: 97214 |
| ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TW |
| Bulletin Number: 97215 |
| DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW |
| Bulletin Number: 97216 |
| LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW |
| Bulletin Number: 97310 |
| NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9747 |
| FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 97618 |
| LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD |
| Bulletin Number: 97627 |
| NOISE- "RATCHETING"- FRONT AXLE- 4X4- SELF-ENGAGEMENT OF AUTOMATIC HUB LOCKS- F-250 AND F-350 OVER 8500# GVW. *JD |
| Bulletin Number: 97629 |
| TRANSMISSION- E4OD- HARSH/DELAYED 2-3 UPSHIFTS- VEHICLES WITH 7.3L DIESEL AND 49-STATE CALIBRATION- F-SERIES BUILT THROUGH 2/3/97 AND ALL 1996 E-350. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9778 |
| HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD |
| Bulletin Number: 9779 |
| WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD |
| Bulletin Number: 980307 |
| VEHICLE STALLS/QUITS WHILE DRIVING. *AK |
| Bulletin Number: 980312 |
| EXCESSIVE WHITE SMOKE. VERIFY GLOW PLUG OPERATION BY PERFORMING GLOW PLUG SYSTEM OPERATION CHECK ON THE HARD START/NO START DIAGNOSTIC SHEET. *TT |
| Bulletin Number: 980323 |
| CONCERNS WITH EXTERNAL OIL LEAKS. *YC |
| Bulletin Number: 980325 |
| COLD ENGINE UPPER KNOCK/TICK. *YC |
| Bulletin Number: 98113 |
| SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT |
| Bulletin Number: 9811335 |
| EXHIBITING A VIBRATION, NOISE OR GROUND OUT CONDITION WHEN TURNING OR UNDER LOAD. *TT |
| Bulletin Number: 9811346 |
| SOME VEHICLES MAY EXPERIENCE AN INTERMITTENT STALL CONDITION AFTER A LONG DECELERATION WHEN USING THE M1 OR M2 GEAR ON THE E40D OR WHEN USING A LOWER GEAR WITH THE M50D FOR ENGINE BRAKING. *TT |
| Bulletin Number: 98115 |
| INFORMATION REGARDING RANDOM HAIRLINE CRACKS, "STAR CRACKING" IN REAR SHEET MOLDING COMPOSITE (SMC) FENDERS - DUAL REAR VEHICLES OPERATING IN SEVERE DUTY CONDITIONS. *TT |
| Bulletin Number: 98119 |
| CONDITIONS WITH ENGINE STALLING DURING LONG DECEL WHILE IN MANUAL 1 OR MANUAL 2 GEAR ON SOME VEHICLES. *TT |
| Bulletin Number: 98122 |
| INFORMATION ON THE DEFROSTER PERFORMANCE ENHANCEMENT. |
| Bulletin Number: 98122 |
| PERFORMANCE ENHANCEMENT FOR DEFROSTER. *TT |
| Bulletin Number: 98123 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 98151 |
| MALFUNCTION INDICATOR LAMP FAILED. YD |
| Bulletin Number: 98156 |
| EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK |
| Bulletin Number: 98158 |
| FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. SHIMMY IS NOT ALWAYS VERIFIED DURING ROAD TEST. *AK |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98168 |
| TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 98205 |
| EXHIBITING ROUGH IDLE AND ENGINE MISS DUE TO INJECTOR BORE SCUFFING AT GREEN ENGINE BREAK-IN. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982313 |
| SOME VEHICLES WITH A 7.3L DIRECT INJECTION (DI) TURBO DIESEL ENGINE, ONE OR MORE OF THE FOLLOWING CONCERNS MAY BE PRESENT: ROUGH IDLE, STALLING, HESITATION/ STUMBLE, LOSS / LACK OF POWER, POOR FUEL ECONOMY, AND EXCESSIVE OIL CONSUMPTION. |
| Bulletin Number: 982314 |
| PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982740 |
| CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC |
| Bulletin Number: 983074 |
| CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT |
| Bulletin Number: 983564 |
| EXPERIENCING A SQUEALING NOISE FROM THE FRONT BRAKES WHEN APPLYING THE BRAKES ON SOME VEHICLES. *TT |
| Bulletin Number: 98413 |
| A GRABBING CONDITION AND / OR SQUEAL NOISE FROM THE REAR BRAKES DURING FIRST FEW BRAKE APPLICATIONS AFTER RAINFALL AND / OR WHILE BRAKES ARE COLD. *TT |
| Bulletin Number: 98414 |
| EXPERIENCING AN ENGINE STALL CONDITION ON 1997 CALIFORNIA F SERIES 7.3L DIESEL E40D VEHICLES AFTER A LONG DECEL WHEN USING M1 GEAR FOR ENGINE BRAKING. *YC |
| Bulletin Number: 98419 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98-4722 |
| REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK |
| Bulletin Number: 98-4726 |
| REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK |
| Bulletin Number: 98-4734 |
| LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST |
| Bulletin Number: 98-4742 |
| VEHICLE STALLS UPON ACCELERATION. *AK |
| Bulletin Number: 985042 |
| REPEAT MESSAGE REGARDING VEHICLES EXHIBITING ROUGH IDLE / MISS CONDITION. *TT |
| Bulletin Number: 985058 |
| SUBJECT REGARDING EXTERNAL OIL LEAKS - REPEAT MESSAGE. *TT |
| Bulletin Number: 985176 |
| SOME TRUCKS WITH E40D AND CALIFORNIA CALIBRATION 7-90P-R10/11 MAY STALL DURING LONG DECEL CONDITIONS WHILE IN MANUAL 1 OR 2 GEAR. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A25 |
| A VIBRATION OR SHUDDER MAY BE FELT DURING BRAKING ON SOME VEHICLES. *YC |
| Bulletin Number: 985A27 |
| LUBRICANT LEAKING FROM REAR AXLE SEAL CONTAMINATING BRAKE SHOES. *YC |
| Bulletin Number: 985A35 |
| THE REAR PARKING BRAKE CABLES MAY BIND AND NOT ALLOW THE REAR BRAKE SHOES TO RETURN FULLY TO THE ANCHOR PINS AFTER THE PARKING BRAKE IS APPLIED. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 98810 |
| SOME CUSTOMERS MAY REQUIRE A HEAVY DUTY 7-WAY TRAILER WIRING CONNECTOR SYSTEM WHEN THE VEHICLE IS EQUIPPED WITH A 4-WAY CONNECTOR. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99236 |
| SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: BC0053970201 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0053972301 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0256970201 |
| A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD |
| Bulletin Number: BC0321961101 |
| POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *TW |
| Bulletin Number: BC0321970201 |
| POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD |
| Bulletin Number: BC0321972301 |
| POP/CLUNK FROM STEERING LINKAGE OVER BUMPS. *JD |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0854961007 |
| REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC1015397020 |
| VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC1020897230 |
| AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNTIONING HAS BEEN DELAYED TO LATE FEBRUARY FORM THE ORIGINAL JANUARY 1997 DATE. *JD |
| Bulletin Number: BC2301970501 |
| NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW |
| Bulletin Number: BC3130970221 |
| DIESEL EXHAUST SMELL IN PASSENGER CABIN MAY BE DUE TO POOR CONNECTION AT THE INLET OR OUTLET TO/FROM THE TURBO. *TW |
| Bulletin Number: BC3171970217 |
| UNEXPLAINED GLASS BREAKAGE OF THE LEFT FRONT DOOR. *TW |
| Bulletin Number: BC3212970213 |
| CAMSHAFT POSITION SENSOR INFORMATION . *TW |
| Bulletin Number: BC3241970210 |
| EXHAUST LEAKS OR NOISE AT THE JOINT BETWEEN THE Y-PIPE AND THE EXHAUST MANIFOLD. *TW |
| Bulletin Number: BC3287970206 |
| THE CLUTCH MAY BE HARD TO DEPRESS DUE TO DUST/CONTAMINATION ENTERING THE SLAVE CYLINDER. *TW |
| Bulletin Number: BC3440972301 |
| AVAILABLITY OF THE SBDS "RED DISC" WITH IMPROVEMENTS TO 7.3L/E40D 2-3 SHIFT QUALITY AND ENHANCED APCM FUNCTIONING HAS BEEN DELAYED. *JD |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BPI9905 |
| CUSTOMER MAY COMPLAIN THAT THE RAYBESTOS ELECTRONIC BRAKE CONTROLLER DOES NOT WORK, WORKS INCORRECTLY, WORKS INTERMITTENTLY, PULSES THE 4-WAY FLASHERS, AND / OR INTERFERS WITH ANTILOCK BRAKES OPERATION. *TT |
| 1997 FORD F-350 SD |
|---|
| Bulletin Number: 982721 |
| SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC |
| 1997 FORD F-450 SD |
|---|
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 14455 |
| OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT |
| Bulletin Number: 17571 |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT |
| Bulletin Number: 982740 |
| CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC |
| 1997 FORD F47 |
|---|
| Bulletin Number: 96226 |
| AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW |
| Bulletin Number: 97310 |
| NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD |
| Bulletin Number: 9747 |
| FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| 1997 FORD F-53 |
|---|
| Bulletin Number: 4626 |
| INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728. *TT |
| Bulletin Number: 962413 |
| SUSPENSION - FRONT OR REAR - SIDE-TOSIDE LEVELING PROCEDURES AND ATTITUDE SERVICE KITS FOR F53 RV BASIC STRIPPED CHASSIS. *TW |
| Bulletin Number: 962414 |
| STEERING - STEERING WHEEL ALIGNMENT - CLEAR VISION. *TW |
| Bulletin Number: 962418 |
| TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW |
| Bulletin Number: 97090297187 |
| SOME VEHICLES MAY STALL WHEN THE TRANSMISSION IS PLACED INTO GEAR. *YC |
| Bulletin Number: 97515 |
| SPEEDOMETER- SPEEDOMETER/ODOMETER INOPERATIVE/ERRATIC AND/OR HARSH TRANSMISSION SHIFTS- F-53 CLASS "A" F-SUPER DUTY MOTORHOME CHASSIS. *JD |
| 1997 FORD F-550 SD |
|---|
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 14455 |
| OIL LEAK FROM THE FRONT OR REAR CYLINDER HEAD OIL SUPPLY RAIL END PLUGS. *TT |
| Bulletin Number: 17571 |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES P0603 (POWERTRAIN CONTROL MODULE KEEP ALIVE MEMORY ERROR) OR P0605 ( POWERTRAIN CONTROL MODULE READ ONLY MEMORY ERROR). *TT |
| Bulletin Number: 982721 |
| SOME VEHICLES MAY EXPERIENCE A POPPING / SQUEAKING NOISE IN THE STEERING COLUMN WHILE TURNING. *YC |
| Bulletin Number: 982740 |
| CONCERNS WITH HIGH PRESSURE OIL PUMPS ARE NOT SERVICEABLE. *YC |
| 1997 FORD F600 |
|---|
| Bulletin Number: 01127 |
| SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT |
| 1997 FORD F700 |
|---|
| Bulletin Number: 01127 |
| SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT |
| Bulletin Number: 11817 |
| SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT |
| Bulletin Number: 4709 |
| SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT |
| Bulletin Number: 962213 |
| EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW |
| Bulletin Number: 98156 |
| EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK |
| Bulletin Number: 991311 |
| CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT |
| 1997 FORD F800 |
|---|
| Bulletin Number: 01127 |
| SOME VEHICLES EQUIPPED WITH 26 INCH DIAMETER FANS MAY EXHIBIT AN ENGINE OVERHEAT CONDITION. *TT |
| Bulletin Number: 11817 |
| SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT |
| Bulletin Number: 4709 |
| SOME MEDIUM DUTY TRUCKS MAY HAVE A CONCERN WITH A WORN OR BINDING CLUTCH ROD BALL END. *TT |
| Bulletin Number: 4751 |
| VEHICLE EXHIBITING SIGNS OF FRONT BRAKE HOSE NOT ALIGNED PROPERLY. *TT |
| Bulletin Number: 962213 |
| EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW |
| Bulletin Number: 98156 |
| EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK |
| Bulletin Number: 991311 |
| CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT |
| 1997 FORD F900 |
|---|
| Bulletin Number: 991311 |
| CONDITIONS WITH POWER STEERING FLUID LEAKING FROM THE BRAKE PUMP RESERVOIR AT 90 DEGREE ELBOW ON SOME VEHICLES. *TT |
| 1997 FORD FIESTA |
|---|
| Bulletin Number: 12528 |
| SOME VEHICLES MAY EXHIBIT HESITATION OR STUMBLE AT AROUND 2000 RPM DURING WARM UP. *TT |
| 1997 FORD FORD |
|---|
| Bulletin Number: 011801 |
| SUBJECT REGARDING INADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *JG |
| Bulletin Number: 012112 |
| CONCERNS WITH THROTTLE STICKING AFTER STEADY STATE DRIVING IN EXTREME COLD AMBIENT TEMPERATURES ON VEHICLES BUILT 12/21/1997 THORUGH 7/15/1999. *TT |
| Bulletin Number: 13047 |
| ENGINEERING IS INVESTIGATING HIGH MILEAGE SUSPENSION PART RETURN. *TT |
| Bulletin Number: 13458 |
| SUBJECT REGARDING WHEEL VIBRATION DIAGNOSIS - SERVICE TIP. *TT |
| Bulletin Number: 5253 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXPERIENCE A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. *TT |
| Bulletin Number: 7434 |
| SOME VEHICLES MAY EXHIBIT WHEEL / TIRE RELATED VIBRATION THAT IS DIFFICULT TO DIAGNOSE. *TT |
| Bulletin Number: 9705013528 |
| DISCONNECTION WITH THE AIR BAG AND CLOCKSPRING THE SHORTING BARS SHORT THESE TERMINALS. *YC |
| Bulletin Number: 9705014116 |
| NEW REAR MAIN SEAL TOOL HAS BEEN RELEASED. *YC |
| Bulletin Number: 9705018818 |
| INFORMATION ON OPERATING THE ENGINE'S COOLANT TEMPERATURE GAUGE. *YC |
| Bulletin Number: 976011 |
| INFORMATION SBTS / NGS FUNCTIONALITY ENHANCEMENT. *TT |
| Bulletin Number: 980321 |
| INFORMATION REGARDING THE PATS KEY PROGRAMMING REGARDING PASSIVE ANTI-THEFT SYSTEM. *AK |
| Bulletin Number: 982035 |
| FOR AVAILABILITY OF MAJOR ASSEMBLIES, PLEASE REFER TO THE EXCHANGE PROGRAM GUIDE. *TT |
| Bulletin Number: 98-3425 |
| INFORMATION ON ON USING THE RELATIVE CAM TIMING TEST ON SBDS. *TT |
| Bulletin Number: 98-4718 |
| ALL VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM--- REPEAT MESSAGE REVISED (SYMPTOM-PATS KEY PROGRAMMING). *AK |
| Bulletin Number: 985041 |
| REPEAT MESSAGE REGARDING ALL VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM. *TT |
| Bulletin Number: 985074 |
| SOME 7.3 DIT ENGINES MAY EXHIBIT A ENGINE MISS AFTER EXTENDED IDLING IN COLD TEMPS. *TT |
| Bulletin Number: 985177 |
| SUBJECT REGARDING ALL 1996 THROUGH 1999 VEHICLES (EXCEPT ASPIRE, PROBE, AND VILLAGER) WITH EEC-V THAT REQUIRE POWERTRAIN CONTROL MODULE (PCM) REPLACEMENT. *TT |
| Bulletin Number: 9912651 |
| WHEN USING THE NGS WITH THE 5.0 SERVICE CARD ON SOME VEHICLES, THE HELP SELECTION HAS BEEN DELETED FROM THE INITIAL SCREEN. *TT |
| Bulletin Number: 99-4597 |
| INFORMATION ON PROGRAMMING PCMS. *TT |
| Bulletin Number: 996103 |
| INFORMATION ON REVISED NGS 5.0 HELP MENU SELECTION. *TT |
| Bulletin Number: 996765 |
| ENGINEERING IS INVESTIGATING HIGH MILEAGE FIELD DURABILITY ON SHOCKS, BALL JOINTS, CONTROL ARMS, SPRINGS, STA-BAR LINKS, AND STRUTS ON VEHICLES WITH MORE THAN 36K MILES IN SERVICE. IF REPLACING ONE OF THESE COMPONENTS, ENGINEERING WOULD |
| Bulletin Number: BC0073961101 |
| THE REAR MAIN SEAL REMOVAL TOOL LISTED IN THE SERVICE MANUAL FOR THE 3.0L 4V DURATEC AND 4.6L 4V CONTINENTAL ENGINES IS INCORRECT. *TW |
| Bulletin Number: BC0111970201 |
| UNITS WITH CATALTYIC CONVERTER/MUFFLERS THAT OPERATE IN COLD WEATHER MAY EXHIBIT LOW POWER DUE TO A PLUGGED CATALYST. *JD |
| Bulletin Number: BC0845961001 |
| CLARIFIED TECHNICAL INSTRUCTIONS FOR SAFETY RECALL - RCL/96S54 (ATTACHMENT III, DEALER LETTER). *TT |
| Bulletin Number: BC0846961001 |
| INFORMATION ON PART NUMBER FOR THE ROTUNDA TOOL THAT IS STATED IN SAFETY RECALL RCL/96S48-RCL/96S99. *TT |
| Bulletin Number: BC1010597020 |
| 1995 AND LATER BUILT VEHICLES DO NOT REQUIRE UNDER-DOOR WEATHER STRIPS ENEN THOUGH ATTACHING HOLES FOR THE WEATHER STRIPS MAY OR MAY NOT BE PRESENT. *JD |
| Bulletin Number: BC1014397020 |
| IGNITION PULSE WHEEL WITH TWO CRANKSHAFT KEY SLOTS- DURATEC ENGINES USE A BLUE PAINT STRIPE- KEY SLOT WITH ORANGE STRIPE. *JD |
| Bulletin Number: BC1032597020 |
| SPARK PLUGS MAY EXHIBIT A LOW FREQUENCY CONCERN OF AN OPEN CIRCUIT CAUSED BY AN INTERNAL CRACK. *JD |
| Bulletin Number: BC105779705 |
| NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL TO BE RELEASED IN 3RD QUARTER OF 1997. *TW |
| Bulletin Number: BC1661970201 |
| REPAIR KIT BOX 4 IS AVAILABLE TO SERVICE 93 AND NEWER VEHICLES WHICH ARE NOT COVERED BY REPAIR KIT BOX 1, 2, & 3. *JD |
| Bulletin Number: BC5200961001 |
| VEHICLES MAY EXPERIENCE UNEXPLAINED MIL LIGHT CODES &/OR IRREGULAR SHIFTING (A4LD). THE -12A581- (95-96) OR -12B637- (97) WIRE LOOM IS COMING INTO CONTACT W/ THE CENTER WIPER ACCESS PLATE LWR CTR. *TT |
| Bulletin Number: BC5220961001 |
| INFORMATION ON SERVICING VEHICLES WITH FLUID LEAK FROM THE FRONT AXLE VENT. REVISED COVER PT# F6TZ-4033-BA. *TT |
| Bulletin Number: BC5221961001 |
| REVISED HOSE PART# F6HZ-9J291-A HAS BEEN DEVELOPED TO REPLACE HOSE THAT SHOWS SIGNS OF DETERIORATION, CRACKS MAY APPEAR IN THE OUTER COVERING OF THE HOSE. *TT |
| Bulletin Number: BC9685961001 |
| PARTS INFORMATION FOR REPLACING THE MAIN CONTROL. *TT |
| Bulletin Number: BC9705970201 |
| VEHICLES WITH WATER IN THE ABS CONNECTOR (C1057), BLOW THE WATER AND/OR CORROSION OUT WITH COMPRESSED AIR. *JD |
| 1997 FORD FORD TRUCK |
|---|
| Bulletin Number: 4751 |
| VEHICLE EXHIBITING SIGNS OF FRONT BRAKE HOSE NOT ALIGNED PROPERLY. *TT |
| Bulletin Number: 982035 |
| FOR AVAILABILITY OF MAJOR ASSEMBLIES, PLEASE REFER TO THE EXCHANGE PROGRAM GUIDE. *TT |
| Bulletin Number: 983302 |
| THIS BULLETIN MENTIONS HOW SOME HUB O-RINGS MAY BE CUT DURING THE INSTALLATION OF THE WHEELS. *TT |
| Bulletin Number: BC0014961101 |
| TRUCKS WITH 7.3L ENGINES WITH HARD STARTING CONCERN AND DTC OF 340, 341 OR 344 MAY HAVE A DAMAGED CMP SENSOR. *TW |
| Bulletin Number: BC0015961101 |
| GLOW PLUG DIAGNOSTIC CHANGES. *TW |
| Bulletin Number: BC0141970201 |
| VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD |
| Bulletin Number: BC0845961001 |
| CLARIFIED TECHNICAL INSTRUCTIONS FOR SAFETY RECALL - RCL/96S54 (ATTACHMENT III, DEALER LETTER). *TT |
| Bulletin Number: BC0846961001 |
| INFORMATION ON PART NUMBER FOR THE ROTUNDA TOOL THAT IS STATED IN SAFETY RECALL RCL/96S48-RCL/96S99. *TT |
| Bulletin Number: BC5200961001 |
| VEHICLES MAY EXPERIENCE UNEXPLAINED MIL LIGHT CODES &/OR IRREGULAR SHIFTING (A4LD). THE -12A581- (95-96) OR -12B637- (97) WIRE LOOM IS COMING INTO CONTACT W/ THE CENTER WIPER ACCESS PLATE LWR CTR. *TT |
| Bulletin Number: BC5220961001 |
| INFORMATION ON SERVICING VEHICLES WITH FLUID LEAK FROM THE FRONT AXLE VENT. REVISED COVER PT# F6TZ-4033-BA. *TT |
| Bulletin Number: BC5221961001 |
| REVISED HOSE PART# F6HZ-9J291-A HAS BEEN DEVELOPED TO REPLACE HOSE THAT SHOWS SIGNS OF DETERIORATION, CRACKS MAY APPEAR IN THE OUTER COVERING OF THE HOSE. *TT |
| 1997 FORD F SERIES |
|---|
| Bulletin Number: 01B77 |
| OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT |
| Bulletin Number: 02169 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03261 |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04217 |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 11675 |
| ROUGH IDLE, MISS AND VARIOUS OTHER DRIVEABILITY CONCERNS ON VEHICLES WITH 7.3L DIT ENGINE. THIS MAY BE RELATED TO INJECTOR BORE SCUFFING CAUSED BY FUEL QUALITY ISSUES. *TT |
| Bulletin Number: 11776 |
| SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT |
| Bulletin Number: 11781 |
| INFORMATION ON SETTING THE CHECK ENGINE LIGHT AND SETTING DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK). *TT |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12230 |
| ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12261 |
| SUBJECT REGARDING ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIMBURSEMENT. *TT |
| Bulletin Number: 12298 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT |
| Bulletin Number: 12556 |
| SUBJECT REGARDING TECHNICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES. *TT |
| Bulletin Number: 12564 |
| SUBJECT REGARDING PROPER OPERATION AND INTERPRETATION OF DUAL AIR PRESSURE GAUGE READINGS. *TT |
| Bulletin Number: 12743 |
| EXHIBITING MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODES (DTC(S) PO351 AND / OR P0356 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT |
| Bulletin Number: 12744 |
| SOME VEHICLES MAY RETREIEVE MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0351 AND / OR P0357 (COIL PRIMARY CIRCUIT MALFUNCTION). *TT |
| Bulletin Number: 12767 |
| EXHIBITING A VIBRATION THAT MAY BE INTERPRETED AS AN NVH CONDITION. *TT |
| Bulletin Number: 12798 |
| SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 12890 |
| BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE THREAD. *TT |
| Bulletin Number: 13180 |
| INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS |
| Bulletin Number: 13285 |
| EXPERIENCING ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 13322 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 13331 |
| SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 13342 |
| VEHICLES WITH 2.4L, 4.6L, AND 5.4L ENGINES MAY EXHIBIT AN A/C MOAN AT IDLE. *TT |
| Bulletin Number: 13832 |
| SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT |
| Bulletin Number: 14484 |
| SOME CALIFORNIA 7.3L ENGINE EQUIPPED VEHICLES MAY EXHIBIT A BUCK / SURGE / JERK (ALSO KNOWN AS HITCHING) DURING HIGHWAY DRIVING AT SPEEDS 40 MPH OR GREATER WITH THE CRUISE CONTROL ENGAGED. *TT |
| Bulletin Number: 15225 |
| SOME VEHICLES MAY EXHIBIT A DIFFICULT TO REMOVE WHEEL RIM CONDITION. *TT |
| Bulletin Number: 15355 |
| SOME VEHICLES EQUIPPED WITH 7.3L DI ENGINE MAY EXHIBIT FALSE DIAGNOSTIC TROUBLE CODES P1105, P1106 (UPPER AND LOWER ALTERNATOR FAULTS). *TT |
| Bulletin Number: 15373 |
| SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT |
| Bulletin Number: 15397 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF OIL CONTAMINATION IN COOLING SYSTEM. *TT |
| Bulletin Number: 15504 |
| SOME VEHICLES MAY EXHIBIT DRIVEABILTY CONDITIONS AND/OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P0455 (GROSS LEAK DETECTED). *TT |
| Bulletin Number: 15605 |
| SOME VEHICLES MAY EXHIBIT DRIVEABILITY CONDITIONS AND / OR CHECK ENGINE LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE P0455 (GROSS LEAK DETECTED). *TT |
| Bulletin Number: 15708 |
| SOME VEHICLES MAY EXHIBIT WHEELS THAT SEIZE TO THE HUBS AND ARE DIFFICULT TO REMOVE DURING SERVICE. *TT |
| Bulletin Number: 15901 |
| THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT |
| Bulletin Number: 16683 |
| FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB |
| Bulletin Number: 4658 |
| SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT |
| Bulletin Number: 4664 |
| THIS BULLETIN STATES THAT FOR CERTAIN VEHICLES IT IS NOT POSSIBLE TO SET THE CHECK ENGINE LIGHT AND SET DIAGNOSTIC TROUBLE CODE P0455 (EVAPORATIVE EMISSIONS GROSS LEAK) IF A CUSTOMER REFUELS THE VEHICLE WITH THE ENGINE RUNNING. * |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 5343 |
| THIS BULLETIN STATES THAT REPLACEMENT UNDER WARRANTY OF CERTAIN SPECIFIED COMPONENTS ON ANY 7.3L DIT DIESEL VEHICLE, REQUIRES THAT THE REPLACED COMPONENT BE RETURNED WITH THE APPROPRIATE YEAR DIESEL ENGINE DIAGNOSTIC GUIDE FOR WARRANTY REIM |
| Bulletin Number: 5892 |
| SUBJECT REGARDING TECHINICAL HOTLINE ASSISTANCE FOR BI-FUEL VEHICLES WITH GFI ALTERNATE FUEL SYSTEMS. *TT |
| Bulletin Number: 5899 |
| CLARIFICATION PERTAINING TO THE DUAL AIR PRESSURE GAUGE FUNCTION. *TT |
| Bulletin Number: 6350 |
| SOME VEHICLES EQUIPPED WITH ENGINES PRODUCED BY WINDSOR ENGINE PLANT MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 6473 |
| SOME MEDIUM TRUCKS PRODUCED AT KENTUCKY ASSEMBLY PLANT MAY EXHIBIT OIL LEAKING OUT OF THE TRANSMISSION SHIFT LEVER. *TT |
| Bulletin Number: 6505 |
| BRIEF INFORMATION ON REMOVING THE FUEL TANK SOLENOID VALVE ON NATURAL GAS VEHICLES. *TT |
| Bulletin Number: 6585 |
| SOME VEHICLES EQUIPPED WITH 7.3L DIT DIESEL ENGINES MAY DEVELOP A CRACKED FLEXPLATE. *TT |
| Bulletin Number: 6997 |
| SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT |
| Bulletin Number: 7155 |
| VEHICLES EQUIPPED WITH WINDSOR ENGINES ONLY MAY EXHIBIT AN ENGINE KNOCK AT INITIAL COLD STARTUP. *TT |
| Bulletin Number: 8058 |
| SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. **MR |
| Bulletin Number: 8058 |
| SOME VEHICLES WITH 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER KNOCK SENSOR THREADED HOLE THAN THAT IN ORIGINAL EQUIPPED ENGINE ASSEMBLIES. *TT |
| Bulletin Number: 962218 |
| STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW |
| Bulletin Number: 962420 |
| LACK OF POWER - ACCELERATOR CABLE DISLODGES FROM ACCELERATOR PEDAL - VEHICLES WITH 7.0L ENGINE - VEHICLES BUILT FROM 8/1/90 THROUGH 6/3/96. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 962529 |
| FEAD BELT - HIGH WEAR AND/OR COMES OFF THE DRIVE PULLEY - VEHICLES BUILT FROM 4/1/92 THROUGH 9/1/96 WITH FD1060 ENGINE. *TW |
| Bulletin Number: 97050110607 |
| ENGINEERING IS INVESTIGATING CONCERNS OF THE REAR ABS LIGHT COMING ON WHEN THE IGNITION IS IN THE ON POSITION. |
| Bulletin Number: 97050110608 |
| VEHICLES BUILT WITH 4R70W TRANSMISSIONS BEARING A PREFIX OF F7 MUST BE OVERHAULED OR REPLACED WITH A NEW ASSEMBLY AS NO FQR ASSEMBLIES ARE AVAILABLE. *TW |
| Bulletin Number: 97115 |
| SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD |
| Bulletin Number: 97117 |
| HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97118 |
| ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD |
| Bulletin Number: 97315 |
| NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97411 |
| FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97517 |
| ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD |
| Bulletin Number: 97630 |
| HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 97716 |
| FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD |
| Bulletin Number: 980301 |
| EXPERIENCING ROUGH IDLE/MISS. *AK |
| Bulletin Number: 980302 |
| SOME VEHICLES EXPERIENCING HARD START/ NO START. *YC |
| Bulletin Number: 980303 |
| SYMPTOMS WITH LACK OF POWER. VERIFY ACTUAL ENGINE TURBO-BOOST AS OUTLINED ON THE DIAGNOSTIC SHEET. *AK |
| Bulletin Number: 980304 |
| COMPLAINTS REGARDING THE FUEL ECONOMY. *YC |
| Bulletin Number: 980307 |
| CONDITIONS WITH PRESSURE BEING HIGHER/LOWER THAN EXPECTED. *YC |
| Bulletin Number: 980323 |
| CONCERNS WITH EXTERNAL OIL LEAKS. *YC |
| Bulletin Number: 9811337 |
| SUBJECT REGARDING CHANGES TO THE MIDLINE RADIO. *TT |
| Bulletin Number: 9811339 |
| INFORMATION ON THE REVISED FUEL INJECTOR O-RING KIT. *TT |
| Bulletin Number: 981511 |
| HARD TO START VEHICLE AT COLD TEMPERATURE.*AK |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98217 |
| EXPERIENCING FLUID ON BRAKE SHOES AND REAR AXLE SEAL LEAK. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982544 |
| SOME MOTOR HOME VEHICLES EQUIPPED WITH E4OD TRANSMISSIONS MAY EXPERIENCE HYDRAULIC SYSTEM MALFUNCTIONS AFTER REPLACING THE TRANSMISSION CASE. *YC |
| Bulletin Number: 982691 |
| CONCERNS OF ENGINE CHECKLIGHT ON AND DTC P1506 ( IDLE AIR CONTROL OVER SPEED ERROR ) AND/OR FAST IDLE. *YC |
| Bulletin Number: 982733 |
| VEHICLES WITH THE E4OD ARE ADDED TO THE FQR ( FORD QUALITY RENEWAL ) ASSEMBLY PROGRAM. *YC |
| Bulletin Number: 983106 |
| INFORMATION REGARDING ENGINE ASSEMBLIES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) PROGRAM. *TT |
| Bulletin Number: 983170 |
| CONCERNS WITH CODES P0500, P0503, P1501 OR P1503 WHICH MAY BE CAUSED MY A LOOSE SPEEDOMETER DRIVE GEAR. *TT |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 983592 |
| SUBJECT PERTAINING TO RADIO INOPERATIVE CONDITIONS. *TT |
| Bulletin Number: 985072 |
| SOME VEHICLES WITH 7.3L DIT ENGINE MAY EXHIBIT A NO START / HARD START AND / OR LONG CRANK TIME. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 98614 |
| THE COOLANT TEMPERATURE GAUGE READING MAY BE INACCURATE. *YC |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99133 |
| SUBJECT REGARDING INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED. *TT |
| Bulletin Number: 991413 |
| VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99205 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 996130 |
| INFORMATION ON THE IMPROVED LOWER INTAKE MANIFOLD SIDE GASKETS. *TT |
| Bulletin Number: 9983 |
| EXPERIENCING VARIOUS INTERMITTENT CONCERNS, SUCH AS LOW COOLANT LEVEL SENSOR LEAKING COOLANT INTO WIRING HARNESS. *TT |
| Bulletin Number: 99B29 |
| SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT |
| Bulletin Number: 99B29#1 |
| INFORMATION REGARDING REPLACMENT OF ENGINE FRONT COVER GASKET. **MR |
| Bulletin Number: 99E03 |
| EMISSION RECALL FOR VEHICLES THAT WERE BUILT WITH A FUEL FILLER-VALVE WHICH COULD LEAK WHILE THE VEHICLE IS BEING OPERATED WHICH CAN EXCEED EVAPORATIVE EMISSIONS STANDARDS. *TT |
| Bulletin Number: BC0053970201 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E40D TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0054961101 |
| VEHICLES MAY HAVE BEEN BUILT WITH A 240 SECOND MISFIRE DELAY. *TW |
| Bulletin Number: BC0255970201 |
| 4X4 FRONT AXLE IS LEAKING THROUGH THE VENT TUBE. *JD |
| Bulletin Number: BC0256970201 |
| A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD |
| Bulletin Number: BC0322961101 |
| HARD STARTING WITH DTC'S P0341, P0344. *TW |
| Bulletin Number: BC0322970201 |
| 1600-1900 RPM MOAN/DRONE WHILE DRIVING. *JD |
| Bulletin Number: BC0322972301 |
| 1600-1900 RPM MOAN/DRONE WHILE DRIVING. *JD |
| Bulletin Number: BC0601961101 |
| MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW |
| Bulletin Number: BC0602961101 |
| INSTRUCTIONS ON SECURING SPARE TIRE TO UNDERBODY OF VEHICLE. *TW |
| Bulletin Number: BC0604961101 |
| NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0694961023 |
| INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0854961007 |
| REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC1011097020 |
| OVERHEATING ON 4.6/5.4L VEHICLES MAY BE CAUSED BY POSSIBLE WATER PUMP CONCERN DUE TO FREE SPINNING WATER PUMP IMPELLER. |
| Bulletin Number: BC1017697230 |
| CHECK ENGINE LIGHT ON WITH DTC P0455 IN CONTINUOUS MEMORY ON VEHICLE APPLICATIONS. *JD |
| Bulletin Number: BC1018797230 |
| DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| Bulletin Number: BC1022497230 |
| INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD |
| Bulletin Number: BC1026797230 |
| FD 1060 ENGINE HARD START OR NO START IN EXTREMELY COLD AMBIENTS. *JD |
| Bulletin Number: BC1029097020 |
| ILLUMINATION OF THE CHECK ENGINE LIGHT MAY OCCUR. *JD |
| Bulletin Number: BC1029697020 |
| FD 1060 ENGINES THE LOWER COOLANT PIPE, BASE PART NUMBER -8291- WAS CHANGED. *JD |
| Bulletin Number: BC1033797020 |
| CONDENSATE FORMING ON THE OUTSIDE OF THE EVAPORATOR. *JD |
| Bulletin Number: BC2232970501 |
| ENGINEERING IS INVESTIGATING CONDITIONS THAT CAUSE THE ABS LIGHT (RABS) TO ILLUMINATE. *TW |
| Bulletin Number: BC2233970501 |
| 1997 F SERIES TRUCKS EQUIPPED WITH TRANSMISSIONS BEARING F7 PREFIXES DO NOT HAVE ASSEMBLIES AVAILABLE -REPAIR BY OVERHAUL OR USE NEW ASSEMBLY. *TW |
| Bulletin Number: BC2308970501 |
| NEW VOLUME CONTROL/ON-OFF SWITCH. *TW |
| Bulletin Number: BC2312970501 |
| NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW |
| Bulletin Number: BC2370970501 |
| CUSTOMER COMPLAINTS OF POOR HEATER PERFORMANCE. *TW |
| Bulletin Number: BC3070970227 |
| CONCERNS OF CONDENSATE FORMING ON OUTSIDE OF EVAPORATOR CASE. *TW |
| Bulletin Number: BC3071970227 |
| DIAGNOSTICS FOR POOR HEATER PERFORMANCE CONCERNS. *TW |
| Bulletin Number: BC3172970217 |
| CLUNK/GRUNT NOISE ON 5.4L F-SERIES 3.55 LIMITED SLIP AXLES. *TW |
| Bulletin Number: BC3230970211 |
| CHECK ENGINE LIGHT - DTC P1450 - CHECK FOR MOLD FLASHING CAUSING A FLOW RESTRICTION IN THE 90 DEGREE ELBOW EVAP LINE COMING OUT OF THE CANNISTER ASSEMBLY AND GOING TO THE FUEL TANK . *TW |
| Bulletin Number: BC3360972301 |
| INOPERATIVE FLOOR MODE CONCERNS MAY BE DUE TO THE PANEL/FLOOR DOOR VACUUM ACTUATOR LINKAGE DISCONNECTING FROM THE DOOR PIVOT. *JD |
| Bulletin Number: BC3505972301 |
| THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: TB-08-258 |
| JERR-DAN: ANTI STALL FEATURE FOR FORD F SERIES LIGHT DUTY CHASSIS WITH V10 GAS ENGINE AND AN ENGINE DRIVE CLUTCH PUMP. MODEL YEARS UNKNOWN. *PE |
| 1997 FORD F SERIES (LIGHT) |
|---|
| Bulletin Number: 12069 |
| INFORMATION REGARDING A NEW SERVICE PART THAT HAS BEEN RELEASED FOR THE LICENSE PLATE LIGHT CIRCIUT WHICH WILL REDUCE THE COST OF REPAIR. *MJS |
| Bulletin Number: 12227 |
| FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 15517 |
| SUBJECT REGARDING EXAGGERATED ENGINE BRAKING ON DECELERATION. *YD |
| Bulletin Number: 962528 |
| BRAKES - AIR COMPRESSOR/AIR PUMP SUPPORT BRACKET BROKEN - VEHICLES WITH 7.0L ENGINE - ENGINE - 7.0L - ACCESSORY DRIVE BELT ROLL - NOISE - RATTLE - AIR BRAKE COMPRESSOR/AIR PUMP SUPPORT BRACKET CRACKED- VEHICLES WITH 7.0L ENGINE. *TW |
| Bulletin Number: 99-6172 |
| INFORMATION REGARDING STEERING WHEEL LEATHER REPAIR. *TT |
| Bulletin Number: BC0602961101 |
| INSTRUCTIONS ON SECURING SPARE TIRE TO UNDERBODY OF VEHICLE. *TW |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0694961023 |
| INFORMATION FOR RECREATIONAL TOWING (ALL WHEELS ON THE GROUND). *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0854961007 |
| REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC0884961004 |
| FOR MISFIRE CONCERNS ON 4.2L/4.6L/5.4L/6.8L ENGINES. *TT |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: ONP96B05 |
| OWNER NOTIFICATION PROGRAM 96B05 - SPARE TIRE AND WHEEL ASSEMBLY REPLACEMENT FOR CERTAIN 1997 F150 TRUCKS WITH OFF-ROAD OPTION. *TW |
| 1997 FORD F SERIES (MEDIUM) |
|---|
| Bulletin Number: 13736 |
| SOME VEHICLES MAY EXPERIENCE OIL LEAKING FROM THE SHIFT LEVER. *MJS |
| Bulletin Number: 97218 |
| SUSPENSION - NOISE FROM FRONT SPRING REAR HANGER - REVISED REAR SPRING HANGER INSULATOR PAD - VEHICLES EQUIPPED WITH 6000, 7000 OR 9000 LB AXLES BUILT THROUGH 10/1/97. *TW |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0750961017 |
| SPADE TERMINAL BETWEEN SENDER & FUEL PUMP HAS BEEN CHANGED TO A EYELET TERMINAL. *TT |
| Bulletin Number: BC0782961014 |
| CONCERNS OF CHECK ENGINE LIGHT 'ON'. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC0854961007 |
| REATTACHMENT OF HEATER HOSE FITTINGS FOR CONCERN OF NO HEAT, OVERHEAT, OR COOLANT LOSS MAY OCCUR DUE TO HEATER HOSES NOT PROPERLY CONNECTED AT THEIR QUICK-CONNECT FITTINGS. *TT |
| Bulletin Number: BC0883961004 |
| VEHICLES MAY EXHIBIT AN EXHAUST LEAK &/OR NOISE DUE TO WARPED EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC3236970211 |
| FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC5201961001 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| 1997 FORD F SUPER DUTY |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 0038 |
| VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03211 |
| LOSS OF POWER AND MALFUNCTION INDICATOR LAMP MAY ALSO ILLUMINATE WITH DIAGNOSTIC TROUBLE CODES 128 AND 845 OR P0236 AND P0238 STORED IN MEMORY. *TT |
| Bulletin Number: 032120 |
| 7.3L DIT GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TT |
| Bulletin Number: 032121 |
| A HIGH NUMBER OF HIGH PRESSURE REXROTH PUMPS AND INJECTION PRESSURE REGULATORS (IPR) ARE BEING REPLACED DUE TO OIL LEAKING, WHEN ALL THAT IS REQUIRED IS A NEW GASKET OR SEAL ON EITHER THE PUMP OR IPR. *TT |
| Bulletin Number: 032123 |
| LOW RPM, NO START, RUNS POORLY, STALL. 7.3L DIT ENGINE. *TT |
| Bulletin Number: 032125 |
| AFTERMARKET WIRING ALTERATIONS - SERVICE TIP. *TT |
| Bulletin Number: 03213 |
| A NO-START OR REDUCED POWER CONDITION MAY OCCUR INTERMITTENTLY. *TT |
| Bulletin Number: 032145 |
| EXTERNAL OIL LEAK DIAGNOSIS FOR 7.3L DIT ENGINES. VARIOUS MODELS INCLUDING 2003 SUPER DUTY F SERIES. *TT |
| Bulletin Number: 04266 |
| A DRIVELINE CLUNK OR BUMP WHEN STARTING FROM A STOP. *TT |
| Bulletin Number: 13412 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT |
| Bulletin Number: 15871 |
| SOME VEHICLES MAY EXHIBIT INTERFERENCE AND / OR STATIC IN THE LAND-MOBILE RADIO. *TT |
| Bulletin Number: 16697 |
| EXHAUST AIR RUSH NOISE AND LOWER POWER. *TT *JB |
| Bulletin Number: 4614 |
| INFORMATION ON VEHICLES EXHIBITING ROUGH IDLE / MISS. *TT |
| Bulletin Number: 4616 |
| BRIEF INFORMATION VEHICLES EXHIBITING HARD START / NO START CONDITION. *TT |
| Bulletin Number: 4617 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING LACK OF POWER CONDITION. *TT |
| Bulletin Number: 4625 |
| BRIEF INFORMATION ON VEHICLES EXHIBITING A STALL ON DECELERATION CONDITION. *TT |
| Bulletin Number: 4626 |
| INFORMATION ON VEHICLES EXHIBITING AND O/D OFF LAMP FLASHING WITH DIAGNOSTIC TROUBLE CODE 62 / 628 / 1728. *TT |
| Bulletin Number: 4629 |
| BRIEF INFORMATION CONCERN VEHICLES EXHBITING EXTERNAL OIL LEAKS. *TT |
| Bulletin Number: 4633 |
| REAR BRAKE DRAG OR EXCESSIVE WEAR ON REAR BRAKES. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 962213 |
| EXHAUST - EXHAUST LEAK AT EXHAUST MANIFOLDS - VEHICLES EQUIPPED WITH 7.0L OR 7.5L ENGINE. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 962413 |
| SUSPENSION - FRONT OR REAR - SIDE-TOSIDE LEVELING PROCEDURES AND ATTITUDE SERVICE KITS FOR F53 RV BASIC STRIPPED CHASSIS. *TW |
| Bulletin Number: 962418 |
| TRANSMISSION - E40D - REVISED DESIGN FORWARD PLANET THRUST WASHER - SERVICE TIP. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96B95 |
| OWNER NOTIFICATION PROGRAM 96B95 - ENGINE COOLING SYSTEM RADIATOR REPLACEMENTON CERTAIN 1997 F SUPER DUTY MOTORHOME STRIPPED CHASSIS. *TW |
| Bulletin Number: 97050110621 |
| PART NUMBER INFORMATION FOR THE USE OF A CHILD SEAT TETHER. *TW |
| Bulletin Number: 971110972313 |
| A NEW DESIGN TRANSMISSION CASE AND EXTENSION HOUSING HAS BEEN RELEASED. *YC |
| Bulletin Number: 97214 |
| ENGINE - 7.3L DIT - GLOW PLUG START-UP ON-TIME DURING COLD TEMPERATURE - SERVICE TIP. *TW |
| Bulletin Number: 97215 |
| DIAGNOSTIC GUIDES FOR OUT-OF-WARRANTY VEHICLES TO BE USED AS A MASTER COPY - DIAGNOSTIC GUIDES NO LONGER AVAILABLE FROM ADISTRA. *TW |
| Bulletin Number: 97216 |
| LEAK - OIL LEAKAT ENGINE VALLEY PAN AND/OR HIGH PRESSURE OIL PUMP - VEHICLES EQUIPPED WITH 7.3L DIESEL ENGINE. *TW |
| Bulletin Number: 97310 |
| NOISE- "POPPING/CREAKING"- FRONT FRAME OR SUSPENSION BRACKETS- FRAME- "POPPING/CREAKING"- FASTENER REPLACEMENT. *JD |
| Bulletin Number: 9747 |
| FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 97617 |
| STEERING- HIGH EFFORT DURING HIGHWAY DRIVING- F SUPER DUTY MOTORHOME CHASSIS VEHICLES BUILT FROM 7/1/93 THROUGH 8/9/96. *JD |
| Bulletin Number: 97618 |
| LOW RPM- 7.3L DIT ENGINE FAILS TO START- CODE 340 STORED IN MEMORY AND/OR ENGINE FAILS TO ACHIEVE RATED SPEED FOR 2-3 MINUTES AFTER EXTENDED COLD SOAK- F-SERIES BUILT THROUGH 2/9/96 AND ALL ECONOLINES. *JD |
| Bulletin Number: 97619 |
| FUEL PUMP- AVAILABILITY OF NEW STYLE FUEL PUMP AND SENDER- F SUPER DUTY MOTORHOME CHASSIS- SERVICE TIP. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9778 |
| HEADLAMP- HEADLAMP HOUSING MELTS- AMBULANCE AND EMERGENCY VEHICLES ONLY. *JD |
| Bulletin Number: 9779 |
| WIRING- AFTERMARKET WIRING ALTERATIONS- SERVICE TIP. *JD |
| Bulletin Number: 98123 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT |
| Bulletin Number: 98156 |
| EXHAUST LEAK AT EXHAUST MANIFOLDS--VEHICLE EQUIPPED WITH 7.0L 0R 7.5L ENGINE. *AK |
| Bulletin Number: 98168 |
| TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982119 |
| SOME VEHICLES MAY EXHIBIT ERRATIC 4-3 SHIFT HUNTING WHILE ASCENDING A GRADE AND/OR NO 3-4 UPSHIFT AFTER CRESTING A GRADE. *YC |
| Bulletin Number: 982120 |
| STEERING WHEEL ALIGNMENT- VEHICLES WITH MOTORHOME CHASSIS. |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982314 |
| PREMATURE WEAR OF THE BELT TENSIONER MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 982321 |
| SERVICE PROCEDURES AND VEHICLE ATTITUDE SERVICE KITS HAVE BEEN DEVELOPED TO ASSIST CUSTOMERS AND VEHICLE MODIFIERS WITH SIDE -TO- SIDE LEVELING CONCERNS RELATED TO WEIGHT DISTRIBUTION. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 98419 |
| SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98-4722 |
| REPEAT MESSAGE, NO CHANGE- ROUGH IDLE/MISS. *AK |
| Bulletin Number: 98-4726 |
| REPEAT MESSAGE, NO CHANGE: HARD START/ NO START. *AK |
| Bulletin Number: 98-4734 |
| LACK OF POWER DUE TO FAILURE OF ENGINE TURBO BOOST |
| Bulletin Number: 98-4742 |
| VEHICLE STALLS UPON ACCELERATION. *AK |
| Bulletin Number: 985185 |
| COLD START ENGINE NOISE |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99236 |
| SUBJECT REGARDING 4R100 TRANSMISSION FLEXPLATE REPLACEMENT FOR VEHICLES WITH 7.3L DIESEL ENGINE. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: BC0053972301 |
| SOME 1995 AND ALL 1996 AND 1997 VEHICLES WITH E4OD TRANSMISSIONS HAVE BEEN BUILT WITH A REUSABLE ELASTOMERIC TRANSMISSION FLUID PAN GASKET. *JD |
| Bulletin Number: BC0256970201 |
| A RUNNING CHANGE FOR THE 7.3L TO ALLOW BETTER DEFINITION ON CYLINDER CONTRIBUTION TESTS IN PROCESS. *JD |
| Bulletin Number: BC0693961023 |
| INVESTIGATING 7.3L IRREGULAR IDLE. *TT |
| Bulletin Number: BC0821961010 |
| CONCERNS W/ THE SPEEDOMETER/ODOMETER INDICATION PLUS TRANSMISSION SHIFT CONCERNS DUE TO FAILURE OF THE SPEEDOMETER DRIVE GEAR (E8TZ-2N598-A) LOCATED WITHIN THE TRANSMISSION MOUNTED PARKING BRAKE ASSY. *TT |
| Bulletin Number: BC0844961008 |
| E4OD TRANS MAY EMIT A TICK/RATTLE NOISE WHEN DRIVING AT LIGHT LOADS IN 1ST GEAR AT 1100 TO 1800 RPM RPM. *TT |
| Bulletin Number: BC2297970501 |
| WHEN THE AIR CLEANER IS BEING REPLACED, THE DRAIN MECHANISM ON THE BOTTOM OF THE AIR CLEANER CASE IS TO BE CLEANED OF OBSTRUCTIONS. *TW |
| Bulletin Number: BC3130970221 |
| DIESEL EXHAUST SMELL IN PASSENGER CABIN MAY BE DUE TO POOR CONNECTION AT THE INLET OR OUTLET TO/FROM THE TURBO. *TW |
| Bulletin Number: BC3212970213 |
| CAMSHAFT POSITION SENSOR INFORMATION . *TW |
| Bulletin Number: BC3241970210 |
| EXHAUST LEAKS OR NOISE AT THE JOINT BETWEEN THE Y-PIPE AND THE EXHAUST MANIFOLD. *TW |
| Bulletin Number: BC5166961001 |
| CONCERNS W/ THE SPEEDOMETER/ODOMETER INDICATION PLUS TRANS SHIFT CONCERNS DUE TO A FAILURE OF THE SPEEDOMETER DRIVE GEAR (E8TZ-2N598-A) LOCATED WITHIN THE TRANS MOUNTED PARKING BRAKE ASSY. *TT |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| 1997 FORD GRAND MARQUIS |
|---|
| Bulletin Number: 12154 |
| SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12178 |
| INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| 1997 FORD LOUISVILLE |
|---|
| Bulletin Number: 02169 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT |
| Bulletin Number: 11755 |
| SOME VEHICLES WITH THE CATERPILLAR 3306 ENGINE MAY EXHIBIT THE LOWER RADIATOR HOSE BEING DISCONNECTED FROM THE ENGINE WATER PUMP OUTLET. *TT |
| Bulletin Number: 11800 |
| SOME MODELS EQUIPPED WITH A 5.9L (FD1060) ENGINE MAY EXHIBIT A CRACKED ENGINE OIL DIPSTICK TUBE NEAR THE ENGINE PORT. *TT |
| Bulletin Number: 4687 |
| SOME VEHICLES EQUIPPED WITH A 5.9L (FD1060) ENGINE MAY EXHIBIT A CRACKED ENGINE OIL DIPSTICK TUBE NEAR THE ENGINE PORT. *TT |
| Bulletin Number: 962216 |
| STEP PLATE - FUEL TANK STEP PLATE VIBRATES - VEHICLES BUILT THROUGH 10/1/96 EQUIPPED WITH 70 AND/OR 120 GALLON REAR-MOUNTED CYLINDRICAL FUEL TANKS WITH TANK-MOUNTED STEP PLATE. *TW |
| Bulletin Number: 962527 |
| WINDNOISE - TOP CORNERS OF DRIVER AND PASSENGER DOORS - VEHICLES BUILT THROUGH 8/96. *TW |
| Bulletin Number: 97010510638 |
| THE VERTICAL EXHAUST HEAT SHIELD MAY EXHIBIT CRACKING AROUND ITS MOUNTING BOLT HOLE. *YC |
| Bulletin Number: 97050110609 |
| VEHICLES EQUIPPED WITH THE FD 1460 ENGINE MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTACHING BOLTS LOSSENING. *TW |
| Bulletin Number: 97050110623 |
| NEW DESIGN FOR THE GRILL MOUNTED BUG/DIRT SCREEN TO ALLEVIATE PROBLEM OF SCREENS RUBBING ON POWER STEERING COOLER. *TW |
| Bulletin Number: 97050110624 |
| NEW DESIGN FOR GRILL MOUNTED BUG/DIRT SCREEN TO ALLEVIATE PROBLEM OF SCREEN RUBBING AGAINST POWER STEERING COOLER. *TW |
| Bulletin Number: 970902971813 |
| UNDER CERTAIN CONDITIONS, ROAD SPLASH AND SPRAY MAY BUILD UP ON THE CAB SIDE WINDOWS. *YC |
| Bulletin Number: 970902971815 |
| SOME VEHICLES FAN CLUTCH MAY CYCLE ON WHEN ELECTRICAL ACCESSORIES, SUCH AS TURN SIGNALS, HEADLAMPS, ETC. ARE ACTIVATED. *YC |
| Bulletin Number: 970902971816 |
| THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY WEAR AND/OR COME OFF ON SOME VEHICLES EQUIPPED WITH A DETROIT DIESEL ENGINE AND AIR CONDITIONING. *YC |
| Bulletin Number: 970902971817 |
| SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC |
| Bulletin Number: 97117 |
| HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97119 |
| NOISE- AIR LEAK FROM BEHIND INSTRUMENT- PANEL- VEHICLES BUILT THROUGH 10/21/96. *JD |
| Bulletin Number: 97217 |
| DOORS - BATTERY ACCESS DOORS MAY COME LOOSE - NEW PART AVAILABILITY - VEHICLES BUILT THROUGH 9-96. *TW |
| Bulletin Number: 97412 |
| COOLING SYSTEM- ENGINE COOLING FAN CRACKS AT CENTER HUB. *JD |
| Bulletin Number: 97517 |
| ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD |
| Bulletin Number: 97518 |
| FRONT END ACCESSORY DRIVE BELT (FEAD)- FEAD BELT MAY WEAR AND/OR COME OFF- VEHICLES EQUIPPED WITH FD1460 ENGINE BUILT THROUGH 12/96. *JD |
| Bulletin Number: 97630 |
| HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD |
| Bulletin Number: 97715 |
| SUN VISOR- OPTIONAL ROOF-MOUNTED SUN VISOR VIBRATES AT HIGHWAY SPEEDS. *JD |
| Bulletin Number: 97716 |
| FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD |
| Bulletin Number: 97717 |
| WIRING- WIRE HARNESS GROUND- INTERMITTENT OR OPEN. *JD |
| Bulletin Number: 9811333 |
| ENGINEERING IS INVESTIGATING CONDITIONS ON THE HOOD SPRING CONTACTING THE HOOD CAUSING DAMAGE TO THE HOOD AND / OR INSULATION. *TT |
| Bulletin Number: 9811468 |
| SOME MODELS WITH CAT C10/C12 ENGINES MAY EXHIBIT CRACKS IN THE ENGINE FRONT COVER, NEAR THE FAN HUB PULLEY SUPPORT MOUNTING CONTAC STUDS. *TT |
| Bulletin Number: 98157 |
| FRONT ENGINE COVER CRACKS. YD |
| Bulletin Number: 98201 |
| INTERMITTENT ELECTRICAL ISSUES, SUCH AS DASH LIGHTS FLASHING WHEN THE TURN SIGNAL IS ACTIVATED MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 98202 |
| THE POWER DISTRIBUTION BOX COVER IS NOW AVAILABLE. *YC |
| Bulletin Number: 982022 |
| DELCO-REMY HAS MADE AVAILABLE A REVISED GENERATOR FOR SERVICE. *YC |
| Bulletin Number: 982023 |
| HINGES AND HINGE SPRINGS ARE NOW AVAILABLE FOR SERVICE FOR THE OPTIONAL READY LINE ACCESS DOOR, BUTTERFLY DOORS OR TRANSVERSE ACCESS DOORS. *YC |
| Bulletin Number: 982115 |
| A NEW SERVICE PARTS RELEASED. *YC |
| Bulletin Number: 982116 |
| THE LOWER RADITTOR HOSE IS BEING PULLED OFF AT THE ENGINE WATER PUMP ON SOME VEHICLES. *YC |
| Bulletin Number: 982118 |
| A NOISE HEARD DURING DRIVELINE TORQUE. |
| Bulletin Number: 982323 |
| THE MESSAGE CENTER MAY DISPLAY FALSE INFORMATION / ERRORS FROMTHE ANTI-LOCK BRAKE SYSTEM ( ABS). *YC |
| Bulletin Number: 98237 |
| SOME VEHICLES EXPERIENCE HEATER SUPPLY TUBES THAT MAY CRACK AND/ OR LEAK COOLANT. *YC |
| Bulletin Number: 98243 |
| CONCERNS REGARDING THE INSTRUMENT PANEL PLATE CRACKS AT PARKING BRAKE VALVE. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982520 |
| SOME VEHICLES EQUIPPED WITH FRAME-MOUNTED VERTICAL MUFFLER SUPPORTS MAY EXHIBIT A CRACK ALONG THE PIPE BEND. *YC |
| Bulletin Number: 98257 |
| CONCERNS WITH THE FRONT END ACCESSORY DRIVE BELT ( FEAD )-FEAD BELT MAY WEAR AND/OR COME OFF. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 98424 |
| CONDITION WITH TIRES BEING LOWER THAN EXPECTED TIRE LIFE. *YC |
| Bulletin Number: 98425 |
| DIAGNOSTIC INFORMATIN AND WIRING SCHEMATICS FOR BOTH THE HORTON AND KYSOR ENGINE COOLING FAN CLUTCHES. *YC |
| Bulletin Number: 98518 |
| THE OIL LEVEL INDICATOR MAY BE DIFFICULT TO INSTALL AND/OR WHEN INSTALLED MAY CONTACT THE CRAKSHAFT ON SOME VEHICLES. *YC |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 98711 |
| INFORMATION ON AVAILABILITY OF REVISED COOLANT LEVEL SENSOR. *YC |
| Bulletin Number: 99102 |
| INFORMATION REGARDING HIGH FLOOR HEAT DURING IDLE WITH PTO IN OPERATION. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99205 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT |
| Bulletin Number: 9944 |
| PROCEDURES ON REPAIRING BROKEN RADIATOR COOLANT SUPPLY TANK VENT HOSE NIPPLES. *TT |
| Bulletin Number: BC0191970201 |
| VEHICLE ELECTRICAL SYSTEM, SEVERAL MEGAFUSES ARE USED. NOW HAS A NEW PLASTIC COVER. *JD |
| Bulletin Number: BC0193970201 |
| REVISED FAN ASSEMBLIES FOR PREMIUM DIESEL ENGINES ARE NOW AVAILABLE. *JD |
| Bulletin Number: BC0200970201 |
| DASH MOUNTED AIR VALVE ASSEMBLIES, BASE PART #4484, MAY LEAK AIR. NEW VALVE PART. *JD |
| Bulletin Number: BC0205970201 |
| VEHICLES EQUIPPED WITH THE CUMMINS ELECTRONIC ENGINE THE TACHOMETER MAY BE INOPERATIVE OR ERRATIC. *JD |
| Bulletin Number: BC0323961101 |
| TACHOMETER INOPERATIVE. *TW |
| Bulletin Number: BC0323970201 |
| TACHOMETER INOPERATIVE. *JD |
| Bulletin Number: BC0323972301 |
| TACHOMETER INOPERATIVE. *JD |
| Bulletin Number: BC0480961113 |
| REPLACEMENT LEVELING VALVE EXTENTION ROD FOR HENDRICKSON AIR-RIDE SUSPENSION. *TW |
| Bulletin Number: BC0756961017 |
| INFORMATION WHEN TROUBLESHOOTING THE SPEEDOMETER & TACHOMETER. *TT |
| Bulletin Number: BC0831961009 |
| BATTERY ACCESS PANEL MAY BECOME LOOSE. *TT |
| Bulletin Number: BC0840961008 |
| COOLANT TEMP GAUGE MAY READ ON THE HIGH OR HOT SIDE OF NORMAL, CAUSED BY LOCATION OF COOLANT TEMP SENSOR. *TT |
| Bulletin Number: BC1009097020 |
| VEHICLES EQUIPPED WITH THE CUMMINS ELECTRONIC ENGINE THE TACHOMETER MAY BE INOPEATIVE OR ERRATIC. *JD |
| Bulletin Number: BC1018797230 |
| DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| Bulletin Number: BC1022997230 |
| IF ONE OF THE FOLLOWING SYMPTOMS IS REPROTED ON A VEHICLE EQUIPPED WITH AN ELECTRONIC ENGINE PLEASE CONTACT FORD HEAVY TRUCKS: INTERMITTENT SPEEDOMETER OR SPEED CONTROL FUNCTIONS. *JD |
| Bulletin Number: BC1023097230 |
| POOR OR INADEQUATE CAB HEAT ON VEHICLES WITH FD 1060 MAY BE DUE TO MISROUTED HEATER SYSTEM COMPONENTS. *JD |
| Bulletin Number: BC1026897020 |
| THE DIPSTICK RUBBING AGAINST THE ENGINE CRANKSHAFT. *JD |
| Bulletin Number: BC1031997020 |
| VEHICLES EQUIPPED WITH THE HENDRICKSON AIR SUSPENSION, IT MAY BE DIFFICULT TO MAINTAIN THE CORRECT VEHICLE RIDE HEIGHT DUE TO THE CURRENT MOUNTING OF THE AIR LEVELING VALVE. *JD |
| Bulletin Number: BC2234970501 |
| VEHICLES MAY EXHIBIT REAR ENGINE SUPPORT BRACKET ATTATCHING BOLTS LOOSENING. *TW |
| Bulletin Number: BC2394970501 |
| THE AIR OPERATED COOLING FAN MAYU RUN CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW |
| Bulletin Number: BC2444970501 |
| VEHICLES EQUIPPED WITH CUMMINS M-11 AND N-14 SELECT PLUS ENGINES MAY EXHIBIT THE AIR OPERATED COOLING FAN RUNNING CONTINUOUSLY IF THE ENGINE ECM FAN CONTROL PARAMETERS ARE SET INCORRECTLY. *TW |
| Bulletin Number: BC3093970225 |
| A/C COMPRESSOR DRIVE BELT OR ALTERNATOR DRIVE BELT ROLLING OFF DRIVE PULLEYS. *TW |
| Bulletin Number: BC3157970219 |
| FEAD BELT MAY OR ROLL OFF - VEHICLES EQUIPPED WITH FD 1460 ENGINE. *TW |
| Bulletin Number: BC3163970218 |
| VEHICLES EQUIPPED WITH HENDRICKSON HAS SUSPENSION - MAY BE DIFFICULT TO MAINTAIN CORRECT VEHICLE RIDE HEIGHT. *TW |
| Bulletin Number: BC3200970214 |
| A SCRAPING NOISE MAY BE HEARD FROM THE LOWER CAB TO SLEEPER CONNECTION POINT. *TW |
| Bulletin Number: BC3202970214 |
| VEHICLES EQUIPPED WITH POWER STEERING AND A BUG/DIRT SCREEN - THE SCREEN MAY CONTACT THE POWER STEERING COOLER ON THE PASSENGER SIDE CAUSING A NOISE CONCERN AND OVER TIME, MAY WEAR A HOLE IN THE POWER STEERING COOLER, RESULTING IN A FLUID L |
| Bulletin Number: BC3222970212 |
| CONCERN WITH LOWER ROOF AIR DEFLECTOR SUPPORT BRACKETS. *TW |
| Bulletin Number: BC3223970212 |
| VEHICLES EQUIPPED WITH DETROIT DIESEL ENGINES MAY EXPERIENCE A CONCERN WITH ENGINE WARNING LAMPS COMING ON INTERMITTENTLY. *TW |
| Bulletin Number: BC3235970211 |
| FD 1060 ENGINES - DIPSTICK RUBBING AGAINST CRANKSHAFT. *TW |
| Bulletin Number: BC3244970210 |
| FD 1460 ENGINES - NON-FUNCTIONING AIR INTAKE HEATERS - ENSURE THAT THE DIAGNOSTIC SWITCH IS IN OFF POSITION. *TW |
| Bulletin Number: BC3275970207 |
| INOPERATIVE HORN OR HORN OPERATES EVEN THOUGH NOT PUSHED. *TW |
| Bulletin Number: BC3278970207 |
| AIR CONDITIONING COMPRESSOR BELT MAY COME OFF DRIVE PULLY. *TW |
| Bulletin Number: BC3350972301 |
| ENGINE DERATE (REDUCTION IN ENGINE-POWER) POSSIBLY INTERMITTENT- INTERMITTEN SPEEDOMETER OR SPEED CONTROL FUNCTION. *JD |
| Bulletin Number: BC3351972301 |
| POOR OR INADEQUATE CAB HEAT ON VEHICLE WITH FD 1060, MAY BE DUE TO MISROUTED HEATER SYSTEM COMPONENTS. *JD |
| Bulletin Number: BC3505972301 |
| THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| Bulletin Number: BC5189961001 |
| INFORMATION ON TROUBLESHOOTING THE SPEEDOMETER & TACHOMETER. *TT |
| 1997 FORD L SERIES |
|---|
| Bulletin Number: 02169 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE DEVELOPED FOR DIAGNOSING AND CORRECTING VEHICLE LEAN. *TT |
| Bulletin Number: 12116 |
| INFORMATION ON SERVICING THE AIR CLEANER ELEMENT ON ALL 1995- 1996-1997 L-SERIES EQUIPPED WITH CAT 3306 ENGINES. *MJS |
| Bulletin Number: 962217 |
| ENGINE - WILL NOT ACCELERATE ABOVE IDLE SPEED - VEHICLES EQUIPPED WITH CUMMINS M11, N14 OR DETROIT DIESEL SERIES 60 ENGINE. *TW |
| Bulletin Number: 962218 |
| STARTER - STARTER DOES NOT ENGAGE AND/OR STARTER MAY CYCLE (ENGAGE-DISENGAGE-ENGAGE) WHILE CRANKING - VEHICLES EQUIPPED WITH AN FD ENGINE AND AN ALLISON MD3000 TRANSMISSION BUILT THROUGH 8/1/96, *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 970902971817 |
| SOME ELECTRONICALLY CONTROLLED DIESEL ENGINES CAN BE MODIFIED TO INCREASE ENGINE OUTPUT BY ALTERING THE ORIGINAL ENGINE MANAGEMENT SYSTEM. *YC |
| Bulletin Number: 97115 |
| SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD |
| Bulletin Number: 97117 |
| HEATER- LACK OF HEAT IN PASSENGER COMPARTMENT- VEHICLES EQUIPPED WITH FD1060 ENGINE- COOLING SYSTEM- ENGINE DOES NOT REACH OPERATING TEMPERATURE- VEHICLES EQUIPPED WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97118 |
| ENGINE- FD1060 OR FD1460- HIGH VIBRATION AT LOW ENGINE RPM- VIBRATION- HIGH- AT LOW ENGINE RPM- VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD |
| Bulletin Number: 97315 |
| NO START- STARTER WILL NOT TURN ENGINE OVER- VEHICLES WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97411 |
| FEAD BELT- HIGH WEAR AND/OR COMES OFF OF THE DRIVE PULLEY- VEHICLES BUILT FROM 4/1/92 THROUGH 6/1/96 WITH FD1060 ENGINE. *JD |
| Bulletin Number: 97412 |
| COOLING SYSTEM- ENGINE COOLING FAN CRACKS AT CENTER HUB. *JD |
| Bulletin Number: 97517 |
| ENGINE- DIESEL- FD1060 AND FD1460- WHITE SMOKE FROM EXHAUST- SERVICE TIP. *JD |
| Bulletin Number: 97630 |
| HARD STARTING- POSSIBLE PLUGGED CATALYTIC CONVERTER/MUFFLER (CCM)- VEHICLES BUILT AFTER 11/29/93 EQUIPPED WITH 1994 EMISSION LEVEL FD1060 OR FD1460 DIESEL ENGINE. *JD |
| Bulletin Number: 97716 |
| FUEL INJECTION PUMP- BOSCH- SERVICE INFORMATION FOR FD1060/1460 DIESEL ENGINES. *JD |
| Bulletin Number: 98214 |
| CONCERNS OF AIR CLEANER COVER MAY RUB A HOLE IN THE HOOD AT THE FRONT EDGE OF THE AIR CLEANER INLET " WAGON WHEEL " ON SOME VEHICLES. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 991413 |
| VEHICLES EQUIPPED WITH FD1060 OR FD1460 MIDRANGE DIESEL ENGINES MAY EXPERIENCE A VIBRATION OR BUZZ THROUGH THE THROTTLE PEDAL. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99205 |
| SUBJECT REGARDING VEHICLE LEAN CORRECTION PROCEDURE. *TT |
| Bulletin Number: BC0018961101 |
| ON L SERIES EQUIPPED WITH CUSH-N-AIR SEATS, THE DRIVER MAY EXPERIENCE A SIDE TO SIDE MOVEMENT OR WOBBLE OF THE SEAT DUE TO INADEQUATE WELDS. *TW |
| Bulletin Number: BC0193970201 |
| REVISED FAN ASSEMBLIES FOR PREMIUM DIESEL ENGINES ARE NOW AVAILABLE. *JD |
| Bulletin Number: BC0465961115 |
| DRIVER MAY EXPERIENCE A SIDE TO SIDE MOVEMENT OR WOBBLE OF THE SEAT. *TW |
| Bulletin Number: BC0480961113 |
| REPLACEMENT LEVELING VALVE EXTENTION ROD FOR HENDRICKSON AIR-RIDE SUSPENSION. *TW |
| Bulletin Number: BC0601961101 |
| MANY MANUAL TRANSMISSIONS THAT ARE REPLACED/REPAIRED UNDER WARRANTY AND RETURNED TO THE WPRC SHOW SIGNS OF IMPROPER/LACK OF MAINTENANCE OR MISDIAGNOSIS. *TW |
| Bulletin Number: BC0604961101 |
| NEW FUEL HOSE TO REPLACE THE HOSE USED IN THE LOW PRESSURE FUEL RETURN SYSTEM - THE CURRENT HOSE MAY SHOW SIGHN OF DETERIOATION OR CRACKS. *TW |
| Bulletin Number: BC0813961011 |
| THROTTLE POSITION SENSOR &/OR IDLE VALIDATION SWITCH FAILS, IN MAY GENERATE ECM SERVICE CODES OR DRIVEABILITY CONCERNS. A REVISED ONE PIECE SENSOR & SWITCH IS NOW AVAILABLE. *TT |
| Bulletin Number: BC1018797230 |
| DIAGNOSE THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| Bulletin Number: BC2312970501 |
| NEW THROTTLE CABLE TO REDUCE VIBRATION ATTHE ACCELERATOR PEDAL. *TW |
| Bulletin Number: BC3201970214 |
| HENDRICKSON AIR RIDE SUSPENSION WITH TRANSVERSE MOUNTED TORQUE RODS- THE FLAT WASHERS USED ON THE ROD TO AXLE ATTATCHING BOLT MAY DEFORM. *TW |
| Bulletin Number: BC3236970211 |
| FD 1060 ENGINES - NEW DESIGN STARTER MOTOR TO ALLEVIATE HARD START/NO START CONCERNS IN COLD AMBIENTS. *TW |
| Bulletin Number: BC3505972301 |
| THE FUEL SHUTOFF SOLENOID ON THE P-7100 PUMP. *JD |
| 1997 FORD L SERIES (HEAVY) |
|---|
| Bulletin Number: BC0813961011 |
| THROTTLE POSITION SENSOR &/OR IDLE VALIDATION SWITCH FAILS, IN MAY GENERATE ECM SERVICE CODES OR DRIVEABILITY CONCERNS. A REVISED ONE PIECE SENSOR & SWITCH IS NOW AVAILABLE. *TT |
| 1997 FORD LTD |
|---|
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9666961001 |
| 2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT |
| 1997 FORD MOTOR HOME |
|---|
| Bulletin Number: 16683 |
| FALSE FAILURE OF THE VAPOR MANAGEMENT VALVE (VMV). *TT *JB |
| 1997 FORD MOUNTAINEER |
|---|
| Bulletin Number: 00M11 |
| INFORMATION REGARDING FRONT SWAY BAR LINK . *YH |
| Bulletin Number: 13745 |
| SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS |
| Bulletin Number: 13752 |
| SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION SEAL. *MJS |
| Bulletin Number: 7918 |
| FRONT AXLE PINION LIL SEAL LEAKS. |
| Bulletin Number: 981617 |
| FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98165 |
| EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD |
| Bulletin Number: RCDNN-00V402-817 |
| This recall action involves replacement of the front stabilizer bar links in certain 1995 through 1997 model year Explorer and Mountaineer vehicles. Under certain conditions, predominantly in cold weather areas, a front stabilizer bar |
| 1997 FORD MUSTANG |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 00212 |
| SOME VEHICLES MAY EXHIBIT A HOOD THAT IS HARD TO CLOSE. *JB |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 00241 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION THAT MAY BE HEARD OF FELT AT THE CLUTCH PEDAL BETWEEN IDLE AND 2300 RPM, AND GOES AWAY WHEN DEPRESSING THE CLUTCH AT LEAST 25MM. *TT |
| Bulletin Number: 00S37S1 |
| SUBJECT REGARDING PARKING BRAKE CONTROL ASSEMBLY MODIFICATION. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01235 |
| SOME VEHICLES EQUIPPED WITH THE T45 MANUAL TRANSMISSION MAY EXHIBIT A CONDITION OF BEING STUCK IN REVERSE, DIFFICULT TO SHIFT INTO REVERSE OR MAY POP OUT OF REVERSE. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 0162 |
| VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02208 |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH |
| Bulletin Number: 0222 |
| SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT |
| Bulletin Number: 02221 |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03261 |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 05N04 |
| EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF |
| Bulletin Number: 07212 |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE |
| Bulletin Number: 11530 |
| WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A |
| Bulletin Number: 11804 |
| SUBJECT REGARDING THE SUBWOOFER ENCLOSURE ON COUPES WITH THE MACH 460 AUDIO SYSTEM. *TT |
| Bulletin Number: 12073 |
| VEHICLES WITH FEDERAL EMISSION EQUIPPED 1998, MAY EXHIBIT A FUEL SMELL IN THE PASSENGER COMPARTMENT AT TIMES. *MJS |
| Bulletin Number: 12154 |
| SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12178 |
| INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS |
| Bulletin Number: 12195 |
| SOME VEHICLES MAY EXHIBIT A DRIVER AND / OR PASSENGER SIDE DOOR WINDOW THAT TRAVELS BEYOND THE UPSTOP AND EXITS THE GLASS RUN. *TT |
| Bulletin Number: 12298 |
| SOME VEHICLES EQUIPPED WITH 4R70W TRANSMISSIONS MAY EXHIBIT DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD. TRANSMISSION CONTROL INDICATOR LIGHT (TCIL) MAY ALSO FLASH WITH DIAGNOSTIC TROUBLE CODE P0782. *TT |
| Bulletin Number: 12523 |
| SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT ILLUMINATED ACCOMPANIED WITH OBD-II CODE P0340 SET IN THE PCM MEMORY. *TT |
| Bulletin Number: 12725 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT |
| Bulletin Number: 12742 |
| SOME VEHICLES WITH MANUAL TRANSMISSION EQUIPPED CONVERTIBLES MAY EXHIBIT A BODY VIBRATION / SHAKE. *TT |
| Bulletin Number: 12771 |
| SOME VEHICLES WITH A MANUAL TRANSMISSION MAY EXHIBIT A FEAD BELT CONCERN (FRONT END ACCESSORY DRIVE). *TT |
| Bulletin Number: 12899 |
| INFORMATION ON POWER SEAT SWITCH REPLACEMENT. *TT |
| Bulletin Number: 13061 |
| SOME VEHICLES MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT TOSS. *TT |
| Bulletin Number: 13180 |
| INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS |
| Bulletin Number: 13186 |
| INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS |
| Bulletin Number: 13240 |
| INFORMATION REGARDING VIBRATION/EXTENSION HOUSING BUSHING. *MJS |
| Bulletin Number: 13428 |
| SOME CONVERTIBLES MAY EXHIBIT A RATTLE NOISE FROMTHE DOOR WEDGE WHEN DRIVING ON ROUGH ROADS. *TT |
| Bulletin Number: 14149 |
| INFORMATION ON CASTER ADJUSTMENT WHEN PERFORMING A FRONT END ALIGNMENT. *TT |
| Bulletin Number: 14520 |
| INFORMATION PERTAINING TO 4.6L 4V PULLEY INSTRUCTIONS. *TT |
| Bulletin Number: 14520 |
| SUBJECT REGARDING INSTALLATION OF CRANKSHAFT PULLEY TORQUE SPECIFICATION. *TT |
| Bulletin Number: 15067 |
| SOME VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION MAY EXHIBIT A POWERTRAIN NOISE DESCRIBED AS A BRIEF ROAR, HOOT OR GROAN BETWEN 2500 - 3500 RPM WHEN THE CLUTCH PEDAL IS HALF WAY DOWN, DURING SHIFTING OR WHEN DEPRESSING AND RELEASING THE CL |
| Bulletin Number: 15158 |
| SOME VEHICLES MAY EXHIBIT A FEAD BELT JUMP-OFF TOSS. *YH |
| Bulletin Number: 15178 |
| SOME VEHICLES EXHIBIT THE DOOR GLASS POPPING OFF TRACK. *YH |
| Bulletin Number: 15205 |
| SOME VEHICLES MAY EXHIBIT THE DOOR GLASS COMING OFF OF THE WINDOW TRACK. *TT |
| Bulletin Number: 15702 |
| SUBJECT REGARDING SPEED CONTROL LAMP. *TT |
| Bulletin Number: 17868 |
| INTERMITTENT LOSS OF POWER OR CRANK NO START - POSSIBLE PATS LAMP FLASHING AND DIAGNOSTIC TROUBLE CODES (DTCS) U1147 AND/OR U1262. *TT |
| Bulletin Number: 4608 |
| SOME VEHICLES MAY EXPERIENCE PASSENGER AND / OR DRIVER SIDE FRONT WINDOW(S) THAT DO NOT ROLL PROPERLY. *TT |
| Bulletin Number: 4696 |
| SUBJECT REGARDING THE SUBWOOFER ENCLOSURE ON COUPES WITH THE MACH 460 AUDIO SYSTEM. *TT |
| Bulletin Number: 5031 |
| SOME VEHICLES AND CERTAIN FEDERAL EMISSION EQUIPPED VEHICLES MAY EXHIBIT A FUEL SMELL IN THE PASSENGER COMPARTMENT AT TIMES. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 5240 |
| SOME VEHICLES MAY EXHIBIT A DRIVER AND / OR PASSENGER SIDE DOOR WINDOW THAT TRAVELS BEYOND THE UPSTOP AND EXITS THE GLASS RUN. *TT |
| Bulletin Number: 5847 |
| SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT ILLUMINATED ACCOMPANIED WITH OBD-II CODE P0340 SET IN THE PCM MEMORY. *TT |
| Bulletin Number: 6242 |
| EXPERIENCING A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE. *TT |
| Bulletin Number: 6314 |
| SOME VEHICLES WITH MANUAL TRANSMISSION MAY EXHIBIT A FED BELT CONCERN. *TT |
| Bulletin Number: 6512 |
| SOME VEHICLES MAY EXHIBIT SOME NORMAL SERVICE CONCERNS WITH POWER SEAT OPERATION. *TT |
| Bulletin Number: 6996 |
| INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT |
| Bulletin Number: 6997 |
| SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT |
| Bulletin Number: 7854 |
| ABS DIAGNOSTIC TROUBLE CODES(DTCS) CAN ONLY BE RETRIEVED USING SUPER STARII TESTER OR THE FLASH OUT PROCEDURE BY GROUNDING OUT DIAGNOSTIC CIRCUIT AT TEST CONNECTOR. |
| Bulletin Number: 8485 |
| INFORMATION REGARDING FREE FLOOR MAT EXCHANGE. **MR |
| Bulletin Number: 870197 |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96226 |
| AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96253 |
| INTERIOR TRIM - CENTER CONSOLE - AVAILABILITY OF GAP HIDER FOR CENTER CONSOLE - VEHICLES BUILT FROM 6/1/96. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96268 |
| BLOWER MOTOR - INTERMITTENT OR INOPERATIVE - TEMPERATURES AT OR BELOW 0 DEGREES C (32 DEGREES F). *TW |
| Bulletin Number: 97111097234 |
| VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 97610 |
| BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9773 |
| VIBRATION- SHUDDER OR VIBRATION UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35 MPH) WHILE IN 3RD OR 4TH GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. *JD |
| Bulletin Number: 97M91 |
| INFORMATION REGARDING ADDITIONAL COVERAGE FOR INTAKE MANIFOLD MALFUNCTIONS. *TT |
| Bulletin Number: 980308 |
| VEHICLES WITH T45 MANUAL TRANSMISSIONS MAY JUMP OUT OF GEAR. *TT |
| Bulletin Number: 98110 |
| SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982018 |
| THE FRONT END ACCESSORY DRIVE ( FEAD ) BELT MAY BECOME BROKEN OR FRAYED AND / OR DETACH FROM ( OR ROLL OFF OF) THE ENGINE. *YC |
| Bulletin Number: 98222 |
| EXPERIENCING VIBRATION/ NOISE FELT IN CLUTCH PEDAL WHEN LIGHTLY TOUCHING CLUTCH PEDAL. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98241 |
| DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982464 |
| CONCERNS WITH VEHICLES WITH A T-45 TRANSMISSION MAY SHIFT FROM 4TH TO NEUTRAL WHEN THE CLUTCH IS RELEASED. *YC |
| Bulletin Number: 98253 |
| CONCERNS WITH THE FRONT WINDOW MAY TRAVEL BEYOND THE UPSTOP AND EXIT THE GLASS RUN ON SOME VEHICLES. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 982734 |
| SOME VEHICLES MAY EXHIBIT PARTIAL OR NO OPERATION OF THE POWER SEAT WHEN USING THE SEAT SWITCH. *YC |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983107 |
| BRIEF INFORMATION REGARDING ENGINES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT |
| Bulletin Number: 983108 |
| EFFECTIVE MARCH 2, 1998M3.8L ENGINE ASSEMBLY IS ADDED TO FQR(FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *AK |
| Bulletin Number: 983294 |
| SOME VEHICLES MAY HAVE AN EXCESSIVE AMOUNT OF SHIFT LEVER VIBRATION WHILE DRIVING IN 3RD GEAR. *TT |
| Bulletin Number: 983566 |
| INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT |
| Bulletin Number: 983566 |
| INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9874 |
| A NEW SILICONE GASKET AND SEALANT. *YC |
| Bulletin Number: 9887 |
| EXPERIENCING A TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 99101 |
| CONCERNS WITH ROAD NOISE MAY BE HEARD FROM THE REAR WHEEL AREA AS WELL AS DUST INTRUSION INTO THE LUGGAGE COMPARTMENT AND / OR EVIDENCE OF A WATER LEAK IN THE LUGGAGE COMPARTMENT. *TT |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 9912717 |
| SOME VEHICLES MAY EXHIBIT VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT SPPED AROUND 62 MPH / 100 KPH. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99131 |
| CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 9913125 |
| SONE POLICE VEHICLES AND OTHER VEHICLES WITH 4R70W MAY EXHIBIT A VIBRATION AND / OR TRANSMISSION EXTENSION HOUSING BUSHING DAMAGE FROM SUSTAINED HIGH SPEED OPERATION. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99185 |
| VEHICLES BUILT BETWEEN 3/15/1997 AND 12/31/1998 AND WITH 4R70W TRANSMISSIONS MAY EXPERIENCE DELAYED OR NO 2-3 UPSHIFT, TRANSMISSION CONTROL INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0782 STORED IN MEMORY. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99195 |
| SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99207 |
| SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99225 |
| CONCERNS WITH THE CONVERTIBLE TOP BOOT MAY FIT IMPROPERLY OR BE DIFFICULT TO INSTALL ON SOME VEHICLES DUE TO THE TOP NOT FOLDING DOWN ALL THE WAY INTO THE WELL. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT RADIATOR. *TT |
| Bulletin Number: 9946 |
| CONCERNS WITH TRANSMISSION FLUID LEAKING AT THE RADIATOR. *TT |
| Bulletin Number: 996795 |
| SUBJECT REGARDING VEHICLES EQUIPPED WITH 4.6L ENGINE REGARDLESS OF TRANSMISSION, MAY EXHIBIT A (FRONT END ACCESSORY DRIVE (FEAD) BELT- BELT NOISE, DAMAGE, AND / OR BELT COMES OFF). *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 9996 |
| EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT |
| Bulletin Number: 99B29 |
| SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT |
| Bulletin Number: 99B29#1 |
| INFORMATION REGARDING REPLACMENT OF ENGINE FRONT COVER GASKET. **MR |
| Bulletin Number: BC0040970201 |
| CURRENTLY INVESTIGATING CRUISE CONTROL SERVO ISSUES AND WOULD LIKE YOUR FEEDBACK. *JD |
| Bulletin Number: BC0079961101 |
| THE ABS SENSOR RESISTANCE READINGS PROVIDED IN THE 1997 MUSTANG SERVICE MANUAL ARE INCORRECT. *TW |
| Bulletin Number: BC0250970201 |
| ABS SENSOR RESISTANCE READINGS PROVIDED IN THE 1997 MUSTANG SERVICE MANUAL ARE INCORRECT. *JD |
| Bulletin Number: BC0314961101 |
| SERPENTINE ACCESSORY DRIVE BELT ROLL-OFF OR LOSS OF ALIGNMENT. *TW |
| Bulletin Number: BC0351961126 |
| FORD IMPROVEMENT PROGRAM REQUEST FOR INFORMATION ON OIL LEAK AT THE REAR CRANKSHAFT OIL SEAL. *TW |
| Bulletin Number: BC0351970201 |
| ENGINE OIL LEAK AT THE REAR CRANKSHAFT OIL SEAL. *JD |
| Bulletin Number: BC0351972301 |
| AN ENGINE OIL LEAK AT THE REAR CRANKSHAFT OIL SEAL. *JD |
| Bulletin Number: BC0407961115 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW |
| Bulletin Number: BC0490961112 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0810961011 |
| VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT |
| Bulletin Number: BC1015697020 |
| CRUISE CONTROL SERVO ISSUES AND WOULD LIKE FEEDBACK. *JD |
| Bulletin Number: BC1024497230 |
| THE PASSIVE ANTI THEFT SYSTEM IS NOW STANDARD ON ALL 1997 MUSTANGS. *JD |
| Bulletin Number: BC1025097230 |
| PASSIVE ANTI-THEFT SYSTEM. *JD |
| Bulletin Number: BC1031397020 |
| VEHICLES BUILT BETWEEN 8/15/96 AND 11/4/96 MAY EXPERIENCE A CONCERN WITH THE COOLING FAN TO THE ELECTRIC MOTOR RETAINER COMING LOOSE OR SEPARTING. *JD |
| Bulletin Number: BC105879705 |
| INSTRUCTIONS FOR ADJUSTING THE CASTER WHEN PERFORMING A FRONT END ALIGNMENT. *TW |
| Bulletin Number: BC105949705 |
| VEHICLES MAY ENCOUNTER DIFFICULTY GETTING THE SHIFT LEVER INTO GEAR WHEN THE CLUTCH DISC IS HOT. *TW |
| Bulletin Number: BC2292970501 |
| INSTRUCTIONS ON HOW TO ADJUST THE CASTER WHEN PERFORMING A FRONT END ALIGNMENT. *TW |
| Bulletin Number: BC2299970501 |
| VEHICLES BUILT PRIOR TO 3/1/97 MAY ENCOUNTER DIFFICULTY GETTING THE SHIFT LEVER INTO GEAR WHEN THE CLUTCH DISC IS HOT. *TW |
| Bulletin Number: BC2392970501 |
| VEHICLES EQUIPPED WITH A T-45 TRANSMISSION MAY EXHIBIT A SECOND GEAR TO NEUTRAL MOVEMENT CONDITION. *TW |
| Bulletin Number: BC3133970221 |
| CONCERN OF COOLING FAN TO ELECTRIC MOTOR COMING LOOSE. *TW |
| Bulletin Number: BC3221970212 |
| VIBRATION/NOISE FROM THE CLUTCH PEDAL. *TW |
| Bulletin Number: BC3272970207 |
| VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY. *TW |
| Bulletin Number: BC3286970206 |
| PASSIVE ANTI-THEFT SYSTEM NOW STANDARD ON ALL MUSTANGS - THE UNDERHOOD SWITCH FOR THE ACTIVE ALARM SYSTEM WAS ELIMINATED (INCORRECTLY INCLUDED IN 1997 MUSTANG SERVICE MANUAL). *TW |
| Bulletin Number: BC3288970206 |
| VEHICLES MAY EXHIBIT A COLD START ENGINE FEAD BELT CHIRP NOISE. *TW |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9690961001 |
| VEHICLES EQUIPPED W/ A MANUAL TRANS, THE ACCESSORY DRIVE BELT MAY COME OFF OF THE PULLEYS UNDER HIGH RPM CONDITIONS. *TT |
| Bulletin Number: BC9714961101 |
| DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW |
| 1997 FORD MUSTANG COBRA |
|---|
| Bulletin Number: 11504 |
| SOME VEHICLES WITH A T-45 TRANSMISSION MAY SHIFT FROM 4TH TO NEUTRAL (POP OUT) WHEN THE CLUTCH IS RELEASED. *TT |
| Bulletin Number: 13302 |
| SOME VEHICLES MAY EXHIBIT A NO CRANK CONDITION. *TT |
| Bulletin Number: 13950 |
| SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT |
| Bulletin Number: 13950 |
| SOME VEHICLES WITH MANUAL TRANSMISSION OR WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT |
| Bulletin Number: 15901 |
| THIS BULLETIN STATES THAT SOME 4.6L FQR ENGINE ASSEMBLIES MAY HAVE A SMALLER OR LARGER KNOCK SENSOR THREADED HOLD THAN THE ONE IN THE ORIGINAL ENGINE ASSEMBLY. *TT |
| Bulletin Number: 7236 |
| EXPERIENCING A NO CRANK CONDITION. *TT |
| Bulletin Number: 8106 |
| SOME VEHICLES MAY EXHIBIT A NO CRANK CONDITION. *TT |
| Bulletin Number: 8278 |
| SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT |
| Bulletin Number: 8278 |
| SOME VEHICLES WITH MANUAL AND AUTOMATIC TRANSMISSIONS MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACHED FROM THE ENGINE. *TT |
| 1997 FORD MUSTANG CONVERTIBLE |
|---|
| Bulletin Number: 0042 |
| VEHICLES MAY EXPERIENCE VIBRATION/SHAKE AT STEADY SPEED APPROXIMATELY 100 KM/H (62 MPS), VEHICLES WITH 3.8 L ENGINE AND CONVERTIBLE TOP. *MJS |
| Bulletin Number: 12093 |
| SOME VEHICLES MAY EXPERIENCE VIBRATION/SHAKE WHEN DRIVEN ON SMOOTH ROADS AT CONSTANT SPEEDS AROUND 62 MPH/100 KPH. *MJS |
| Bulletin Number: 12717 |
| EXPERIENCING VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT SPEED AROUND 62 MPH / 100 KPH. *TT |
| Bulletin Number: 5132 |
| SOME GT CONVERTIBLES MAY EXPERIENCES VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT CONSTANT SPEEDS AROUND 62 MPH / 100 KPH. THE CONDITION MAY BE DUE TO HARMONIC RESONANCE BETWEEN THE ENGINE, BODY AND SUSPENSION. *TT |
| Bulletin Number: 6227 |
| SOME VEHICLES MAY EXHIBIT CONCERNS OF VIBRATION / SHAKE. *TT |
| Bulletin Number: 7373 |
| SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM THE DOOR WEDGE WHEN DRIVING ON ROUGH ROADS. *TT |
| Bulletin Number: 985131 |
| SOME GT MODELS MAY EXPERIENCE VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT CONSTANT SPEEDS AROUND 62 MPH / 100 KPH. *TT |
| Bulletin Number: 9912717 |
| SOME VEHICLES MAY EXHIBIT VIBRATION / SHAKE WHEN DRIVEN ON SMOOTH ROADS AT SPPED AROUND 62 MPH / 100 KPH. *TT |
| 1997 FORD MUSTANG GT |
|---|
| Bulletin Number: 11504 |
| SOME VEHICLES WITH A T-45 TRANSMISSION MAY SHIFT FROM 4TH TO NEUTRAL (POP OUT) WHEN THE CLUTCH IS RELEASED. *TT |
| Bulletin Number: 13950 |
| SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT |
| Bulletin Number: 13950 |
| SOME VEHICLES WITH MANUAL TRANSMISSION OR WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT |
| Bulletin Number: 8278 |
| SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION AND WITH AUTOMATIC TRANSMISSION MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACH FROM THE ENGINE. *TT |
| Bulletin Number: 8278 |
| SOME VEHICLES WITH MANUAL AND AUTOMATIC TRANSMISSIONS MAY EXHIBIT A FRONT END ACCESSORY DRIVE (FEAD) BELT THAT HAS BECOME BROKEN OR FRAYED AND / OR DETACHED FROM THE ENGINE. *TT |
| 1997 FORD NAVIGATOR |
|---|
| Bulletin Number: 13712 |
| INFORMATION REGARDING VEHICLES THAT EXPERIENCE THE RADIOS THAT DISPLAY NO DJ-NO DISC OR CD WILL NOT EJECT. *MJS |
| Bulletin Number: 13745 |
| SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS |
| Bulletin Number: 13773 |
| INFORMATION FOR COMPACT DISC PLAYER PROBLEMS, RADIO MAY DISPLAY NO DJ- NO DUSC OR CD WILL NOT EJECT. *MJS |
| Bulletin Number: 15122 |
| SOME VEHICLES MAY EXHIBIT A VIBRATION AT IDLE AND/OR ENGINE DROANING NOISE ON ACCELERATION FROM A STOP. *SLC |
| Bulletin Number: 15123 |
| SOME VEHICLES MAY EXHIBIT A DRIVELINE VIBRATION AT SPEEDS BETWEEN 60-70 MPH. *SLC |
| Bulletin Number: 7929 |
| DIAGNOSTIC INFORMATION FOR COMPACT DISC PLAYER PROBLEMS. |
| Bulletin Number: 9810569 |
| CONCERNS OF SQUEAKY / NOISY PITMAN ARM. *YC |
| Bulletin Number: 98169 |
| STEERING -ALIGNMENT-TOE SET PROCEDURE SERVICE TIP. YD |
| 1997 FORD PROBE |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 00182 |
| SOME VEHICLES MAY EXHIBIT NO FORWARD GEAR RANGES DUE TO THE MISALIGNMENT OF THE FORWARD / COAST CLUTCH CYLINDER SNAP RING WITH RESPECT TO THE LEGS OF THE FORWARD CLUTCH PISTON. *JB |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 0224 |
| SOME VEHICLES EQUIPPED WITH THE CD4E TRANSAXLE MAY EXHIBIT HARSH AND DELAYED 1-2/2-3 UPSHIFTS AFTER TRANSAXLE OR TURBINE SHAFT SPEED SENSOR REPLACEMENT, POSSIBLE DIAGNOSTIC TROUBLE CODES 628, 642, 645, 646, 647, 648, P0731, P0732, P0734, P0 |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 11791 |
| SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT |
| Bulletin Number: 14936 |
| SOME VEHICLES EQUIPPED WITH CD4E AUTO TRANSAXLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODES FOR GEAR RATIO OR HARSH AND DELAYED 1-2 / 2-3 UPSHIFTS AFTER TRANSAXLE OR TURBINE SPEED SENSOR (TSS) REPLACEMENT. *TT |
| Bulletin Number: 4674 |
| SOME VEHICLES WITH CD4E TRANSMISSION MAY EXHIBIT A CONDITION OF NO CRANK / NO START IN PARK. VEHICLE WILL CRANK AND START IN NEUTRAL. *TT |
| Bulletin Number: 6583 |
| INFORMATION ON SERVICING THE LEFT STEERING RACK BUSHING. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 962411 |
| TRANSAXLE - CD4E - NEW DESIGN PARKING PAWL RATCHET SPRING AND PARKING CAM ACTUATING LEVER ASSEMBLY. *TW |
| Bulletin Number: 96245 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION - DIAGNOSTIC TROUBLE CODE (DTC) P1794 STORED IN CONTINUOUS MEMORY - PROBE WITH 2.5L, ESCORT WITH 1.8L AND ASPIRE. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96254 |
| RESTRAINT SYSTEM - AIR BAG MODULE - DIAGNOSTIC FAULT CODE 51 - IMPROVED DIAGNOSTICS AND REPAIR. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962614 |
| TRANSAXLE - CD4E - HARSH SHIFT AND/OR ENGAGEMENT - DIAGNOSTIC TROUBLE CODE 628 OR P0741. *TW |
| Bulletin Number: 97111097235 |
| SUBJECT REGARDING MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) P0505. *YC |
| Bulletin Number: 9729 |
| NOISE - BUZZ/VIBRATION IN REVERSE AND/OR CLICKING NOISE ACCOMPANIED BY VIBRATION ON RIGHT HAND TURNS DURING ACCLERATION - VEHICLES BUILT THROUGH 1/6/97 WITH 2.0L ENGINE AND CD4E TRANSAXLE. *TW |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9746 |
| TRANSAXLE- CD4E- HARSH SHIFT AND/OR ENGAGEMENT- DIAGNOSTIC TROUBLE CODE (DTC) 628 OR P0741- SERVICE TIP. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 9759 |
| LEAK- AUTOMATIC TRANSMISSION FLUID- CD4E TRANSAXLE IN FLUID COLLECTION ON MAIN CONTROL ASSEMBLY. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9812016 |
| SOME VEHICLES MAY EXHIBIT A CONCERN WHERE THE CHECK ENGINE FALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE IN BELOW FREEZING TEMPERATURES AND DIAGNOSTIC TROUBLE CODE (DTC) P1407 IS STORED IN CONTINUOUS MEMORY. |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 981510 |
| REVISED OIL PUMP INSTALLATION PROCEDURE. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982311 |
| MINIMAL CLEARANCE OF THE CD4E TRANSAXLE TO SUBFRAME MAKES TRANSAXLE INSTALLATION AND REMOVAL MORE DIFFICULT. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 985016 |
| SOME VEHICLES MAY EXHIBIT A CONCERN WHERE THE CHECK ENGINE MALFUNCTION INDICATOR LAMP MAY ILLUMINATE IN BELOW FREEZING TEMPERATURES AND DIAGNOSTIC TROUBLE CODE P1407 IS STORED IN CONTINUOUS MEMORY. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9874 |
| A NEW SILICONE GASKET AND SEALANT. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99129 |
| INFORMATION ON "WHINING" / "BUZZING" NOISE COMING THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER CAUSED BY THE FUEL PUMP. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99249 |
| THIS BULLETIN ADDRESSES AN ISSUE WITH THE AUTOMATIC TRANSMISSION FLUID SEEPING FROM THE VENT, RESULTING IN FLUID COLLECTING ON THE MAIN CONTROL ASSEMBLY. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: BC0045970201 |
| BEGINNING DECEMBER 2, 1996 ALL CD4E TRANSAXLES ARE BUILT WITH A REDESIGNED PUMP BODY SEPARATOR PLATE AND PUMP BODY SEPARATOR PLATE GASKET. *JD |
| Bulletin Number: BC0045972301 |
| BEGINNING DECEMBER 2, 1996 (BEGINNING TRAN SERIAL NUMBER (6337-0001)) ALL CD4E TRANSAXLES ARE BUILT WITH A REDESIGNED PUMP BODY SEPARATOR PLATE AND PUMP BODY SEPARATOR PLATE GASKET. *JD |
| Bulletin Number: BC0132970201 |
| A CLUNK ON LEFT HAND TURNS WHILE ACCELERATING. THIS MAY BE CAUSED BY IMPROPER ALIGNMENT OF THE #1 ENGINE MOUNT. *JD |
| Bulletin Number: BC0422961119 |
| CONCERNS OF TRANSMISSION POPPING OUT OF 3RD OR 5TH GEAR. *TW |
| Bulletin Number: BC0760961016 |
| WAVE SPRING LOCATED UNDER THE FORWARD ONE-WAY CLUTCH IN NO LONGER ONE PIECE. IT HAS BEEN 'SPLIT'. *TT |
| Bulletin Number: BC0763961016 |
| SHOULDER BELT THAT IS SLOW TO RETRACT MAY BE CAUSED BY A TWIST IN THE SEAT BELT WEBBING BEHIND THE 'B' PILLAR TRIM. *TT |
| Bulletin Number: BC1010397020 |
| HARD TO START/LONG CRANK TIME CONCERN ON 96-97 VEHICLES DUE TO FUEL PRESSURE LEAK DOWN. *JD |
| Bulletin Number: BC1012697020 |
| CLUNK ON LEFT HAND TURNS WHILE ACCELERATING ON 1997 PROBE 2.0L CD4E VEHICLES. MAY BE CAUSED BY IMPROPER ALIGNMENT OF THE ENGINE MOUNT. *JD |
| Bulletin Number: BC1017597230 |
| THE LUMBAR BAG INFLATES BUT DOES NOT APPLY ADEQUATE PRESSURE TO THE SEAT BACK MAY BE CAUSED BY IMPROPER POSITIONING OF THE LUMBAR BAG SUPPORT RODS. *JD |
| Bulletin Number: BC1019097230 |
| OIL PUMP TO CYLINDER BLOCK ALIGNMENT CONCERN ON VEHICLE BUILT BETWEEN 9/5/96 AND 12/9/96 WITH ENGINE SERIAL NUMBER FS200304 THROUGH FS209265. JD |
| Bulletin Number: BC1026697230 |
| VEHICLES EXHIBITING HARSH SHIFTS AND/OR HARSH ENGAGEMENT ACCOMPANIED BY DTCS 628 OR P0741. *JD |
| Bulletin Number: BC1030597020 |
| PAINT BLISTER, PEEL OR CRACK CONCERNS. *JD |
| Bulletin Number: BC1033497020 |
| THE MALFUNCTION INDICATOR LAMP (MIL) ON WITH CODE P0441 STORED IN MEMORY. *JD |
| Bulletin Number: BC2372970501 |
| A HARD TO START/LONG CRANK TIME CONCERN ON 96-97 PROBE VEHICLES MAY BE DUE TO FUEL PRESSURE LEAK DOWN. *TW |
| Bulletin Number: BC3081970226 |
| PARTIALLY RESTRICTED VACUUM HOSE TO CANNISTER MAY BE CAUSE OF MALFUNCTION INDICATOR LAMP (MIL) CODE P0441. *TW |
| Bulletin Number: BC3162970218 |
| CLICKING NOISE CAUSED BY DIFFERENTIAL LUBE TUBE CONTACTING DIFFERENTIAL CASE. *TW |
| Bulletin Number: BC3204970214 |
| HARSH SHIFTS AND/OR HARSH ENGAGEMENT ACCOMPANIED BY DTC'S 628 OR P0741. *TW |
| Bulletin Number: BC3492972301 |
| AN OIL PUMP TO CYLINDER BLOCK ALIGNMENT CONCERN ON VEHICLES BUILT BETWEEN 9/5/96 AND 12/9/96 WITH ENGINE SERIAL NUMBER FS200304 THROUGH FS209265. *JD |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9666961001 |
| 2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT |
| 1997 FORD RANGER |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 01124 |
| ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01186 |
| INFORMATION ON CLIMATE CONTROL, LOUD A/C CLUTCH CYCLING NOISE.*JB |
| Bulletin Number: 01197 |
| SOME VEHICLES EQUIPPED WITH THE 4.0L OHV ENGINE MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / ONNECTING ROD BEARING KNOCK. *TT |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01212 |
| SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT A LOUD A/C CLUTCH ENGAGEMENT. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0146 |
| SOME VEHICLES MAY EXHIBIT A CHATTER OR BINDING CONDITION WHEN OPERATING THE POWER SIDE WINDOWS EITHER IN THE DOWN OR UP MODE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 0186 |
| ON SOME VEHICLES, INCLUDING SPORT AND SPORT TRAC, THE FRONT AXLE LEAKS FLUID FROM THE VENT TUBE. *TT |
| Bulletin Number: 01B77 |
| OWNER NOTIFICATION PROGRAM SUPPLEMENT 7 REVISED INFORMATION - REGARDING REPLACEMENT OF WILDERNESS AT TIRES. *TT |
| Bulletin Number: 02138 |
| LOW LINE PRESSURE READING AT WIDE OPEN THROTTLE (WOT), SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS WITH POSSIBLE DIAGNOSTIC TROUBLE CODES P0732, P0733, P1762 SET ON VEHICLES BUILT BEFORE 12/1/2001. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02221 |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ |
| Bulletin Number: 0242 |
| CERTAIN VEHICLES WITH 4X4 OR ALL-WHEEL DRIVE MAY HAVE A FLUID LEAK FROM THE FRONT AXLE VENT TUBE. *TT |
| Bulletin Number: 0282 |
| SOME VEHICLES BUILT PRIOR TO 9/15/2001 MAY EXHIBIT LOW LINE PRESSURE READINGS WHILE IN DRIVE, NO 2ND GEAR, NO 3RD GEAR, NO ENGINE BRAKING IN MANUAL 1ST AND SLIPPING SHIFTS AND / OR DELAYED ENGAGEMENTS. *TT |
| Bulletin Number: 030508 |
| FRONT AXLE LEAKS FLUID FROM VENT TUBE - VEHICLES EQUIPPED WITH 4X4 OR AWD. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03203 |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT |
| Bulletin Number: 0358 |
| FLUID MAY LEAK OUT OF THE FRONT AXLE VENT TUBE. *TT *JB |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04217 |
| GENERAL POWER TRAIN CONTROL MODULE (PCM) PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 1014997020 |
| UPDATE TO TSB 96-21-9 ADDITIONAL CALIBRATION ADDED- ANY CALIBRATION REVISION LEVEL FOR A VEHICLE WITH A MANUAL TRANSMISSION THAT IS NOT CALLED OUT IN TSB 96-21-9 SHOULD ALSO BE INCLUDED AS PART OF THAT TSB. *JD |
| Bulletin Number: 11512 |
| ENGINEERING IS INVESTIGATING CONCERNS OF NOISY FRONT SYSTEM BLOWER MOTORS ON CERTAIN VEHICLES. *TT |
| Bulletin Number: 11761 |
| SOME VEHICLES WITH 2.3L ENGINES MAY EXPERIENCE A MALFUNCTION INDICATOR LAMP LIGHT WITH DIAGNOSTIC TROUBLE CODE P0340. *TT |
| Bulletin Number: 12138 |
| VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *MJS |
| Bulletin Number: 12152 |
| SOME VEHICLES WITH 4 X 4 OPTION OPERATING IN 4 X 2 MODE MAY EXHIBIT A PING SOUND ON SLIGHT TO MODERATE ACCELERATION IN FORWARD OR REVERSE. *MJS |
| Bulletin Number: 12154 |
| SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12230 |
| ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12518 |
| CONCERNS WITH THE IN-DASH CD STOPS OPERATING WHEN HOT / RADIO DISPLAY READS CD TOO HOT. *TT |
| Bulletin Number: 12905 |
| SOME VEHICLES MAY EXPERIENCE AXLE WIND UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS ON VEHICLES EQUIPPED WITH A FOUR WHEEL DRIVE HI OR LOW RANGE MODE. *TT |
| Bulletin Number: 13054 |
| EXPERIENCING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT |
| Bulletin Number: 13118 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT |
| Bulletin Number: 13154 |
| SUBJECT REGARDING 4.0L ENGINE HOTLINE PHONE NUMBERS. *TT |
| Bulletin Number: 13154 |
| SUBJECT REGARDING ENGINE HOTLINE PHONE NUMBERS. *TT |
| Bulletin Number: 13180 |
| INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS |
| Bulletin Number: 13244 |
| INFORMATION REGARDING WINDNOISE FROM WINDSHIELD/COWL AREA. *MJS |
| Bulletin Number: 13412 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO (DTC) DIAGNOSTIC TROUBLE CODE STORED IN THE GEM. *TT |
| Bulletin Number: 13423 |
| VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL AND CLUTCH ENGAGED. *TT |
| Bulletin Number: 13426 |
| EXHIBITING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS. *TT |
| Bulletin Number: 13440 |
| EXPERIENCING VERY LIGHT STEERING VIBRATION / SHIMMY / NIBBLE AT ENGINE IDLE OR LOW SPEEDS (PARKING LOT TYPE MANEUVERS). *TT |
| Bulletin Number: 13484 |
| VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT |
| Bulletin Number: 13505 |
| ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT |
| Bulletin Number: 13745 |
| SOME VEHICLES MAY EXPERIENCE A CONDITION OF NO 4 X 4 LOW RANGE ENGAGEMENT OR A STUCK IN 4 X 4 LOW RANGE. *MJS |
| Bulletin Number: 14056 |
| SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR |
| Bulletin Number: 14583 |
| CONCERNS WITH BROKEN THERMOSTATS ON ENGINES. *JB |
| Bulletin Number: 14617 |
| SUBJECT PERTAINING TO BROKEN THERMOSTAT. *JB |
| Bulletin Number: 14847 |
| CONCERNS WITH VEHICLES EXHBIT FLUID LEAKAGE FROM THE FRONT AXLE VENT TUBE. *TT |
| Bulletin Number: 15167 |
| SOME VEHICLES MAY EXHIBIT A LOUD COMPRESSOR CYCLING NOISE. *YH |
| Bulletin Number: 15198 |
| SOME VEHICLES MAY EXHIBIT LOUD A/C CLUTCH CYCLING NOISE CONDITION. *JG |
| Bulletin Number: 15887 |
| SOME VEHICLES MAY EXHIBIT A NO 1-2 UPSHIFT, NO 2-3 UPSHIFT, A NO ENGINE BRAKING CONDITION IN MANUAL 1 OR DIAGNOSTIC TROUBLE CODE P0732 (GEAR 2 INCORRECT RATIO) OR P0733 (GEAR 3 INCORRECT RATIO). *TT |
| Bulletin Number: 16040 |
| EXPERIENCING A CLICKING / POPPING NOISE FROM THE UPPER STEERING COLUMN AREA WHEN TURNING THE STEERING WHEEL. *TT |
| Bulletin Number: 17254 |
| CLICKING/POPPING NOISE FROM UPPER STEERING COLUMN AREA WHEN TURNING. 2004 E SERIES AND EXPLORER SPORT TRAC ALSO INCLUDED. *TT |
| Bulletin Number: 17777 |
| REAR LEAF SPRING NOISE. *TT |
| Bulletin Number: 4634 |
| STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT |
| Bulletin Number: 4644 |
| SOME VEHICLES WITH 2.3L ENGINES MAY EXPERIENCE A MALFUNCTION INDICATOR LIGHT WITH DIAGNOSTIC TROUBLE CODE P0340. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 5249 |
| INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT |
| Bulletin Number: 5518 |
| INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT |
| Bulletin Number: 5652 |
| COMPLAINTS THAT THE IN-DASH CD STOPS OPERATING WHEN HOT. *TT |
| Bulletin Number: 6574 |
| SOME VEHICLES MAY EXHIBIT AN OCCASIONAL HOOT / MOAN FROM THE IDLE AIR CONTROL (IAC) VALVE. *TT |
| Bulletin Number: 6603 |
| SOME VEHICLES MAY EXHIBIT AN AUDIBLE PINGING OR CREAKING NOISE THAT MAY BE HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE. *TT |
| Bulletin Number: 6896 |
| SOME VEHICLES MAY EXHIBIT AN ENGINE NOISE WHICH MAY BE PERCEIVED BY THE CUSTOMER AS A PISTON / CONNECTING ROD BEARING KNOCK. *TT |
| Bulletin Number: 6926 |
| SUBJECT REGARDING THE ENGINE HOTLINE PHONE NUMBERS FOR 1997 - 2000 MODEL YEAR VEHICLES. *TT |
| Bulletin Number: 6997 |
| SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT |
| Bulletin Number: 7126 |
| SOME VEHICLES MAY EXHIBIT WINDNOISE HEARD FROM THE COWL / WINDSHIELD AREA. *TT |
| Bulletin Number: 7353 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT |
| Bulletin Number: 7366 |
| SOME VEHICLES EQUIPPED WITH MANUAL TRANSMISSION MAY EXHIBIT NEUTRAL GEAR ROLLOVER NOISE (A LIGHT METALLIC RATTLING SOUND FROM THE TRANSMISSION) WHICH OCCURS AT IDLE WITH TRANSMISSION IN NEUTRAL CLUTCH ENGAGED (CLUTCH PEDAL UP). *TT |
| Bulletin Number: 7471 |
| SOME VEHICLES EQUIPPED WITH 4.0L OHV ENGINES MAY EXHIBIT EXCESSIVE OIL CONSUMPTION AS REPORTED BY THE CUSTOMER. *TT |
| Bulletin Number: 8164 |
| INFORMATION ON 5R55E - 4R55E - 4R44E PUMP ALIGNMENT TOOLS. *TT |
| Bulletin Number: 8164 |
| INFORMATION REGARDING PUMP ALIGNMENT TOOLS. **MR |
| Bulletin Number: 8512 |
| SOME VEHICLES MAY EXHIBIT AN OIL LEAK FROM THE FRONT AXLE PINION OIL SEAL AREA. **MR |
| Bulletin Number: 870197 |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 962215 |
| FLUID - NEW MERCON V REQUIRED - TRANSMISSION - 4R44E - DESCRIPTION OF FEATURES AND MAJOR COMPONENTS. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96226 |
| AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 97050110607 |
| ENGINEERING IS INVESTIGATING CONCERNS OF THE REAR ABS LIGHT COMING ON WHEN THE IGNITION IS IN THE ON POSITION. |
| Bulletin Number: 97050110627 |
| ROUGH IDLE ACCOMPANIED BY STALLS/ QUITS AT IDLE. *YC |
| Bulletin Number: 9705014158 |
| VEHICLES INCLUDES GRAPHICS FOR A SPEED CONTROL INDICATOR LIGHT. *YC |
| Bulletin Number: 97090297189 |
| EXPERIENCING A "THUMPING" NOISE OR TEMPEATURE GAUGE FLUCTATION WITH SOME VEHICLES. *YC |
| Bulletin Number: 971110972312 |
| CONCERNS WITH "PINGING" OR "CREAKING" BEING HEARD FROM THE DRIVELINE WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE, OR WHEN ENGAGING THE CLUTCH. *YC |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9737 |
| DOOR HANDLE- OUTSIDE DOOR HANDLE HAS EXTENDED TRAVEL- VEHICLES BUILT THROUGH 11/1/96. *JD |
| Bulletin Number: 9747 |
| FRAME- RIVET REPLACEMENT WITH BOLTS- SERVICE TIPS. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 97615 |
| BRAKES- "SQUEALING" NOISE AND/OR STICKING DURING FIRST FEW BRAKE APPLICATIONS AFTER A RAINFALL AND/OR WHEN BRAKES ARE COLD. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 980319 |
| CONCERNS WITH FALSE ABS ACTIVATION WHILE LIGHT BRAKING AT LOW SPEEDS. *YC |
| Bulletin Number: 980324 |
| CONCERNS OF COLD ENGINE UPPER KNOCK / TICK. *YC |
| Bulletin Number: 98112 |
| SUBJECT REGARDING A NEW SERVICE CENTER SUPPORT THAT USES A THRUST BEARING (#3 AND #4) IN PLACE OF THRUST WASHERS HAS BEEN RELEASED. *TT |
| Bulletin Number: 9811284 |
| EXPERIENCING A LONG CRANK HARD START CONDITION. *TT |
| Bulletin Number: 9811488 |
| SOME VEHICLES EQUIPPED WITH A CTM (CENTRAL TIMER MODULE) MAY EXPERIENCE INTERMITTENT WIPER OPERATION WITHOUT COMMAND; DOME LIGHTS REMAINING ON; OR THE DOOR CHIMES REMAINING ON. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 981516 |
| OUTSIDE REARVIEW MIRROR MANUAL REPLACEMENT. |
| Bulletin Number: 98158 |
| THE DRIVER'S AND PASSENGER'S DOOR GLASS CHATTER WHEN OPERATING THE WINDOW IN DOWN MODE. |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98165 |
| EVAPORATOR CORE FAILED, CAUSING THE AIR CONDITIONER TO DRIP ON TO PASSENGER FLOOR. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982111 |
| HIGHTER THAN EXPECTED ENGINE RPMS DURING A 2-3 PARTIAL BACKOUT UPSHIFT OR AFTER A 3-2 OR4-2 WIDE OPEN THROTTLE DOWNSHIFT MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982312 |
| ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98238 |
| CONDENSATE MAY LEAK ONTO THE PASSENGER FLOOR ON SOME VEHICLES. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982526 |
| SOME VEHICLES MAY EXPERIENCE VARIOUS CONCERNS SUCH AS INTERMITTENT WINDSHIELD WIPER OPERATION WITHOUT COMMAND, DOME LIGHTS REMAINING ON, AND/OR THE DOOR CHIMES REMAING ON. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 982671 |
| SOME VEHICLES MAY EXPERIENCE POOR RADIO RECEPTION ( AM/FM). *YC |
| Bulletin Number: 983071 |
| BRIEF INFORMATION REGARDING THE IMPROVED SAIL MOUNT MANUAL MIRROR. *TT |
| Bulletin Number: 983074 |
| CONCERNS WITH AXLE WIND-UP AND / OR CLUNKING, POPPING, RATCHETING TYPE NOISES WHEN MAKING CORNERING MANEUVERS. *TT |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983226 |
| EXPERIENCING A LONG CRANK HARD START CONDITIONS. *TT |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 9839 |
| THE DRIVER'S AND/OR PASSENGER DOOR GLASS MAY |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98-4732 |
| STEERING WHEEL SHIMMIES, VIBRATION OR GRUNT ON SLOW SPEED TURNS.. |
| Bulletin Number: 985045 |
| REVISED MESSAGE REGARDING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS ACTION ON SOHC EQUIPPED VEHICLES, PERFORM TSB 98-21-01. *TT |
| Bulletin Number: 985085 |
| SOME VEHICLES WITH POWER WINDOWS MAY EXHIBIT WINDOW CHATTERING OR JERKING MOTION WHEN OPERATING IN THE DOWN MODE. *AK *TT |
| Bulletin Number: 98514 |
| CONCERNS WITH A WHISTLING OR HISSING NOISE FROM THE MAIN CONTROL AREA OCCURING WHILE IDLING IN DRIVE AND / OR REVERSE ON SOME VEHICLES. *TT |
| Bulletin Number: 985174 |
| SOME VEHICLES WITH 4X4 OPTION IN 4X2 MODE MAY EXHIBIT A PING SOUND ON SLIGHT TO MODERATE ACCELERATION IN FORWARD OR REVERSE. *TT |
| Bulletin Number: 985178 |
| SOME VEHICLES MAY EXHIBIT A CLIMATE CONTROL ISSUE OF LACK OF HEAT. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 9856 |
| SOME VEHICLES MAY EXPERIENCE A HARD START/LONG CRANK TIME AND/OR A STUMBLE/HESITATION AFTER COLD START ON ACCELERATION. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A21 |
| ISSUES WITH THE REAR ANTI-LOCK BRAKE SYSTEM ( RABS ) LAMP MAY ILLUMINATE AFTER FRONT WHEEL LOCK UP DURING 4X4 OPERATION. *YC |
| Bulletin Number: 985A36 |
| A GRABBING AND/OR STICKING CONDITION DURING THE FIRST FEW BRAKE APPLICATIONS WHEN THE BRAKES ARE COLD OR IN THE MORNING AFTER AN OVERNIGHT RAIN MAY OCCUR ON SOME VEHICLES. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9867 |
| INFORMATION ON THE REVISED MANUAL OUTSIDE REARVIEW MIRRORS BUILT THROUGH 2/13/98. *TT |
| Bulletin Number: 9868 |
| A ROUGH IDLE, STALLING AT AN IDLE AND/OR DIAGNOSTIC TROUBLE CODES (DTCS) P0171, P0174, AND/OR P1151 MAY BE STORED IN MEMORY ON SOME VEHICLES WITH A 4.OL ENGINE. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99161 |
| EXPERIENCING AN AUDIBLE PINGING OR CREAKING (NOT A CLUNKING NOISE) HEARD FROM THE DRIVELINE WHEN ENGINE TORQUE IS INITIALLY APPLIED TO THE DRIVELINE SUCH AS WHEN SHIFTING FROM PARK TO DRIVE OR REVERSE, BETWEEN DRIVE AND REVERSE. *TT |
| Bulletin Number: 99162 |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0125 STORED IN MEMORY, AND / OR LACK OF HEAT WITH THE CLIMATE CONTROL. *TT |
| Bulletin Number: 99183 |
| SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99235 |
| DURING EXTREME COLD AMBIENT TEMPERATURES AND UNDER CERTAIN DRIVING CONDITIONS, MOISTURE IN THE CRANKCASE MAY ENTER THE PCV SYSTEM, FREEZE AND CAUSE PRESURE IN THE ENGINE CRANKCASE. THE PCV FITTING IN THE UPPER INTAKE MANIFOLD MAY FREEZE OR |
| Bulletin Number: 99238 |
| A TEMPERATURE GAUGE FLUCTUATION AND / OR A KNOCKING / THUMPING NOISE MAY BE AUDIBLE INTHE PASSENGER COMPARTMENT ON SOME VEHICLES. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 995157 |
| INFORMATION ON MAINTAINING TIRE PRESSURE. *TT |
| Bulletin Number: 996125 |
| SUBJECT REGARDING FUEL SYSTEM DIAGNOSTIC. *TT |
| Bulletin Number: 996780 |
| THIS ONLINE SERVICE BULLETIN INVOLVES VEHICLES EXHIBITING WINDNOISE AT THE TOP OF THE DOOR GLASS SEAL / WEATHERSTRIP MOLDING AREA. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: BC0185970201 |
| SOME VEHICLES MAY NOT BE PUT INTO ALIGNMENT- CAMBER READINGS. *JD |
| Bulletin Number: BC0324961101 |
| COLD ENGINE KNOCK/TICK NOISE. *TW |
| Bulletin Number: BC0324970201 |
| COLD ENGINE KNOCK/TICK NOISE. *JD |
| Bulletin Number: BC0324972301 |
| REAR BRAKES "GRAB" WHEN COLD OR DAMP. *JD |
| Bulletin Number: BC0407961115 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW |
| Bulletin Number: BC0490961112 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW |
| Bulletin Number: BC0692961023 |
| VEHICLES MAY EXPERIENCE UNEXPLAINED MIL LIGHT CODES &/OR IRREGULAR SHIFTING (A4LD). *TT |
| Bulletin Number: BC0764961016 |
| THE OIL INDICATOR TUBE (DIP STICK) IS COMING INTO CONTACT W/ THE CRANK SHAFT, CAUSING A TICKING SOUND. *TT |
| Bulletin Number: BC1018997230 |
| BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD |
| Bulletin Number: BC1019197230 |
| EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD |
| Bulletin Number: BC1019797230 |
| THE VEHICLES WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSITION. *JD |
| Bulletin Number: BC1019997230 |
| 4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPNIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSES WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD |
| Bulletin Number: BC1021097230 |
| SOME VEHICLES WITH 4R44E TRANSMISSION MAY HAVE INCORRECT ID TAG NUMBERS ON THE MAIN CONTROLS. *JD |
| Bulletin Number: BC1022797230 |
| THE NGS DISPLAYS INCORRECT DATA FOR THE IGN GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC105889705 |
| 1997 RANGER VEHICLES DO NOT HAVE TAILGATE TAPE STRIPES. *TW |
| Bulletin Number: BC105939705 |
| VEHICLES MAY EXPERIENCE A MOAN IN THE PASSENGER COMPARTMENT AT OR NEAR 2800 RPM. *TW |
| Bulletin Number: BC105979705 |
| UPDATE INFORMATION FOR 1997 4R44E AND 5R55E TRANSMISSIONS - THERE ARE TWO (2) DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW |
| Bulletin Number: BC106009705 |
| 1997 4X4 RANGERS RABS (REAR ANTI LOCK BRAKING SYSTEM) LAMP MAY ILLUMINATE AFTER FRONT WHEEL LOCK-UP DURING 4X4 OPERATION. *TW |
| Bulletin Number: BC2226970501 |
| SERVICING TIP - TRANSMISSION - THERE ARE TWO DIFFERENT SIZE DIRECT CLUTCH STEEL PLATES WHEN SERVICING 4R44E OR 5R55E TRANSMISSIONS. *TW |
| Bulletin Number: BC2232970501 |
| ENGINEERING IS INVESTIGATING CONDITIONS THAT CAUSE THE ABS LIGHT (RABS) TO ILLUMINATE. *TW |
| Bulletin Number: BC2242970501 |
| RABS (REAR ANTI LOCK BRAKING SYSTEM) LAMP MAY ILLUMINATE AFTER FRONT WHEEL LOCK-UP DURING 4X4 OPERATION. *TW |
| Bulletin Number: BC2293970501 |
| 1997 RANGERS ARE NOT EQUIPPED WITH TAILGATE STRIPES. *TW |
| Bulletin Number: BC2298970501 |
| VEHICLES MAY EXPERIENCE A MOAN IN THE PASSENGER COMPARTMENT NEAR 2800 RPM - TO FIX, INSTALL A VIBRATION DAMPER TO A/C SUCTION LINE. *TW |
| Bulletin Number: BC2301970501 |
| NEW CLUTCH SLAVE CYLINDER WITH A REDESIGNED LIP SEAL. *TW |
| Bulletin Number: BC2361970501 |
| AUTHORIZED WARRANTY PART REPLACEMENT OF BRAKE PADS TO CORRECT EXCESSIVE BRAKE NOISE. *TW |
| Bulletin Number: BC2381970501 |
| WHEN REMOVING STICKERS/LABELS FROM THE PRIVACY QUARTER GLASS WINDOWS, DO NOT USE ANY SHARP OR RAZOR LIKE EDGES. *TW |
| Bulletin Number: BC3170970217 |
| RANGER 4X4 WITH REAR ANTI-LOCK BRAKING SYSTEM - VEHICLES MAY EXPERIENCE ILLUMINATION OF THE ABS WARNING LIGHT WHEN BRAKING UNDER 4X4 MODE ON SLIPPERY/ICY SURFACES WITH FRONT WHEEL LOCK UP. *TW |
| Bulletin Number: BC3282970206 |
| GEM CONCERN - CHECK FOR MORE THAN ONE GEM CONTROLLED COMPONENT THAT IS INOPERATIVE OR FOR A STRING OF FALSE GEM DTC'S RECEIVED IN MEMORY. *TW |
| Bulletin Number: BC3363972301 |
| THE NGS DISPLAYS INCORRECT DATE FOR THE ING GEM PID ON THE VEHICLES. *JD |
| Bulletin Number: BC3382972301 |
| VEHICLES WITH AN UNUSUAL NEGATIVE CAMBER READING, AND CANNOT BE ADJUSTED TO WITHIN THE PROPER CAMBER SPECIFICATION, CAN BE REPAIRED BY NEW SPRINGS. *JD |
| Bulletin Number: BC3441972301 |
| AS OF 1/7/97 THE AUTOMATIC SHIFT LOCK FEATURE TAG THAT WAS AFFIXED AROUND THE GEAR SELECTOR, HAS BEEN DISCONTINUED FOR PRODUTION. *JD |
| Bulletin Number: BC3442972301 |
| SOME 1997 2.3L RANGERS WITH 4R44E TRANSMISSION MAY HAVE INCORRECT ID TAG NUMBERS ON THE MAIN CONTROLS. *JD |
| Bulletin Number: BC3483972301 |
| THE VEHICLE WILL SHIFT 1,2,3,4,5 REGARDLESS OF THROTTLE POSTION. *JD |
| Bulletin Number: BC3485972301 |
| 4.0L EQUIPPED VEHICLES MAY EXPERIENCE TEMPERATURE GAUGE FLUCTUATION THAT MAY BE ACCOMPANIED WITH A THUMPING NOISE OR FEEL IN THE COOLANT HOSE WITH THE ENGINE AT NORMAL OPERATING TEMPERATURE. *JD |
| Bulletin Number: BC3491972301 |
| SOME 4.0L ENGINES WITH BLOCK HEATERS MAY EXPERIENCE COOLANT LEAKS DUE TO INTERFERENCE WITH THE BLOCK. *JD |
| Bulletin Number: BC3493972301 |
| VEHICLES EXHIBITING A PULSATING, CYCLICAL TYPE OF NOISE COMING FROM THE FRONT AXLE TUBE AREA FROM 0 TO 45 MPH. *JD |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9666961001 |
| 2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BC9714961101 |
| DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW |
| 1997 FORD SUPER DUTY F SERIES |
|---|
| Bulletin Number: 00610 |
| INFORMATION ON THE 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PRUCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *MJS |
| Bulletin Number: 032137 |
| FOR 7.3L DIT ENGINES, ROTUNDA TOOL HAS ISSUED AN INJECTOR PERFORMANCE ANALYZER THAT MAY NOW BE PURCHASED AS AN EFFECTIVE AID IN HELPING TO RESOLVE ROUGH IDLE CONCERNS. *TT |
| Bulletin Number: 13488 |
| SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT |
| Bulletin Number: 13505 |
| ALL 4X4 VEHICLES WITH ELECTRONIC SHIFT ONTHE FLY TRANSFER CASES WILL DISPLAY CONTACT PLATE PIDS OPPOSITE OF THE 1999 OR EARLIER WORKSHOP MANUAL INDICATES WHEN USING NGS WITH 15.0 LEVEL OR LATER SOFTWARE. *TT |
| Bulletin Number: 16480 |
| DIAGNOSTIC TROUBLE CODE (DTC) P0340, POSSIBLE FALSE CODE. VARIOUS MODELS INCLUDING 1994-1996 FORD EXCURSION. *TT |
| Bulletin Number: 16945 |
| AN OIL LEAK AT THE TURBOCHARGER PEDESTAL AROUND THE EXHAUST BACKPRESSURE ACTUATOR. *TT |
| Bulletin Number: 16999 |
| HIGH PRESSURE OIL PUMP LEAK. *TT |
| Bulletin Number: 17777 |
| REAR LEAF SPRING NOISE. *TT |
| Bulletin Number: 7353 |
| SOME VEHICLES MAY EXHIBIT A CONDITION OF NO 4X4 LOW RANGE ENGAGEMENT OR A STUCK IN 4X4 LOW RANGE, WITH NO DIAGNOSTIC TROUBLE CODES STORED IN THE GEM MODULE. *TT |
| Bulletin Number: 7475 |
| SOME VEHICLES EQUIPPED WITH 73L DIT ENGINE MAY EXHIBIT A ROUGH ENGINE IDLE. *TT |
| Bulletin Number: 996034 |
| EXPERIENCING A ENGINE KNOCK AT COLD START-UP. *TT |
| 1997 FORD TAURUS |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 00191 |
| SOME VEHICLES MAY EXPERIENCE A SEPARATION BETWEEN LAYERS OF THE INSTRUMENT PANEL. *JB |
| Bulletin Number: 00203 |
| A SEPARATION BETWEEN LAYERS OF THE INSTRUMENT PANEL.*JB |
| Bulletin Number: 00263 |
| SOME VEHICLES MAY EXHIBIT A POWER WINDOW THAT WILL NOT OPERATE DOWNWARD BECAUSE IT'S STUCK / BOUND TO THE WEATHERSHIP HEADER. *TT |
| Bulletin Number: 00E11 |
| SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT |
| Bulletin Number: 00E11 |
| SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT |
| Bulletin Number: 01116 |
| SOME VEHICLES MAY EXHIBIT COOLING SYSTEM CONDITIONS SUCH CONTAMINATED / CORRODED COOLANT; LEAKING / DISCOLORED COOLANT OVERFLOW BOTTLES; VIBRATION FROM ENGINE; LEAKING HEATER CORE; COOLANT OVERFLOW; HIGH TEMPERATURE GAUGE READINGS, ETC. |
| Bulletin Number: 01124 |
| ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 0162 |
| VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02153 |
| SOME VEHICLES EQUIPPED WITH THE 3.0L 4V DURATEC ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH A DIAGNOSTIC TROUBLE CODE P1518, INTAKE MANIFOLD RUNNER CONTROL. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02183 |
| EXHAUST SYSTEM Y-PIPE CRACK AT THE NOISE VIBRATION HARNESS BRACKET. *MJ |
| Bulletin Number: 02208 |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH |
| Bulletin Number: 02221 |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ |
| Bulletin Number: 02236 |
| ERRATIC OPERATION OF THE COOL/WARM FUNCTION OF THE TEMPERATURE CONTROL SYSTEM - REPAIR PROCEDURE FOR STRATIFICATION (SECONDARY) TEMPERATURE BLEND DOOR. *TT |
| Bulletin Number: 03123 |
| TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT |
| Bulletin Number: 031404 |
| ENGINE MISFIRE OR RUNNING - COIL ON PLUG (COP) IGNITION SYSTEMS - WDS COP KIT DIAGNOSTIC TIPS. TO INCLUDE VARIOUS 2005 MODELS. * AR THIS ARTICLE 04161 SUPERSEDES TSB 03-14-04. |
| Bulletin Number: 03141 |
| IN VEHICLE LOCTITE SERVICE PROCEDURE FOR CAMSHAFT TUBE AND GEAR. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 041601 |
| WDS COP KIT DIAGNOSTIC TIP - COIL ON PLUG (COP) IGNITION SYSTEMS - ENGINE MISFIRE OR ROUGH RUNNING. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 090308 |
| MIL LIGHT ON WITH EVAPORATIVE DTC P0442, P0455 |
| Bulletin Number: 11530 |
| WHEN DIAGNOSING CRANK / NO START ON CERTAIN VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT (PATS) CHECK THE CUSTOMERS KEY RING FOR ANY MAGNETIC OBJECTS LIKE THE MOBILE SPEEDPASS KEY WHICH MAY AFFECT THE SIGNAL TRANSMISSION BETWEEN THE PATS KEY A |
| Bulletin Number: 11773 |
| SUBJECT REGARDING SERVICE EVAPORATOR ASSEMBLIES. *TT |
| Bulletin Number: 11793 |
| SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF FUEL AND FOR AN EXTENDED PERIOD OF TIME. *TT |
| Bulletin Number: 12079 |
| VEHICLES MAY EXHIBIT A BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEAD SPEED. *MJS |
| Bulletin Number: 12154 |
| SOME VEHICLES EQUIPPED WITH PATS (SECURILOCK) EXCEPT CERTAIN MODELS NOW HAVE AVAILABILITY OF FLEET KEYS THROUGH ROTUNDA. *MJS |
| Bulletin Number: 12163 |
| SOME VEHICLES MAY EXHIBIT A SLIGHT VIBRATION DURING ACCELERATION ONLY. *MJS |
| Bulletin Number: 12169 |
| SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE AFTER NGS/SBTS PCM REPROGRAMMING. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12178 |
| INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS |
| Bulletin Number: 12189 |
| INFORMATION ON INSTALLATION A NEW FUEL PUMP , ENSURE THAT THE PUMP HAS PLASTIC SHEATHING OVER THE WIRES. *MJS |
| Bulletin Number: 12238 |
| SOME VEHICLES MAY EXHIBIT AN INOPERATIVE POWER WINDOW CONCERNS. *TT |
| Bulletin Number: 12559 |
| CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT |
| Bulletin Number: 12570 |
| SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING. *TT |
| Bulletin Number: 12616 |
| INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT |
| Bulletin Number: 13180 |
| INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS |
| Bulletin Number: 13250 |
| INFORMATION REGARDING SLIGHT VIBRATION UPON ACCELERATION. *MJS |
| Bulletin Number: 13802 |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION. *MJS |
| Bulletin Number: 13802 |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. AUDIO AND CLIMATE CONTROLS CONTINUE TO OPERATE DURING THE ICP'S LOSS OF ILLUMINATION CONDITION. THIS MAY BE CAUSED BY A FAULTY INTERNAL RIBBO |
| Bulletin Number: 14087 |
| SOME VEHICLES MAY EXHIBIT DIAGNOSTIC TROUBLE CODE P1518 AND/OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC). **MR |
| Bulletin Number: 14584 |
| SUBJECT REGARDING FLEX FUEL VECHICLE OIL AND FUEL RECOMMENDATIONS. *JB |
| Bulletin Number: 14856 |
| SOME VEHICLES EQUPPED WITH 3.0L 2V VULCAN OR 4V DURATEC ENGINE MAY EXHIBIT AN EXHAUST RUST-THRU, WELD FATIGUE CONDITION BETWEEN THE TWO TOEBOARD CATALYSTS WHERE A TIE-IN BRACKET IS WELDED TO THE FORMED INLET PIPE OF THE REAR BANK TOEBOARD C |
| Bulletin Number: 15142 |
| SOME VEHICLES MAY EXHIBIT A HARSH 2-3 SHIFT AFTER INSTALLING A REMANUFACTURED AUTOMATIC TRANSAXLE. *YH |
| Bulletin Number: 15370 |
| SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT |
| Bulletin Number: 15390 |
| SOME VEHICLES MAY EXHIBIT A CHECK ENGINE LIGHT AND/OR EGR DIAGNOSTIC TROUBLE CODES 332, P0401, P1407 (LACKOF EGR FLOW). *TT |
| Bulletin Number: 15392 |
| SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT |
| Bulletin Number: 15879 |
| SOME SHO VEHICLES MAY EXHIBIT A TICKING NOISE ORIGINATING FROM THE VALVE COVER AREA. *TT |
| Bulletin Number: 17358 |
| GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT |
| Bulletin Number: 18614 |
| SURGE, IDLE ROLL, ROUGH IDLE ONLY WHEN THE ENGINE COOLING FANS ARE OPERATING. *TT |
| Bulletin Number: 4619 |
| SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON WITH EVAPORATIVE DIAGNOSTIC TROUBLE CODES P0442, P0455 SET. *TT |
| Bulletin Number: 4621 |
| SOME VEHICLES MAY EXHIBIT CONTAMINATED / CORRODED COOLANT, HIGH OR FLUCTUATING TEMP GAUGE, COOLANT ODOR, COOLANT OVERFLOW, BLOWN OR LEAKING HOSES, BLOWN HEAD GASKET, FAILED ENGINE, LACK OF HEAT. *TT |
| Bulletin Number: 4630 |
| SUBJECT REGARDING GENERAL STALLING CONCERNS. *TT |
| Bulletin Number: 4636 |
| DIAGNOSING HARD START / LONG CRANK CONDITION. *TT |
| Bulletin Number: 4655 |
| INFORMATION ON THE SERVICE EVAPORATOR ASSEMBLIES. *TT |
| Bulletin Number: 4676 |
| SOME VEHICLES MAY EXHIBIT A HARD / NO START CONCERN WHEN PARKED IN A STEEP NOSE-UP POSITION WITH LESS THAN 1/4 TANK OF FUEL AND FOR AN EXTENDED PERIOD OF TIME. *TT |
| Bulletin Number: 5048 |
| REPEAT MESSAGE REGARDING CONTAMINATED / CORRODED COOLANT, HIGH OR FLUCTUATING TEMP GAUGE; COOLANT ODOR, COOLANT OVERFLOW, BLOWN OR LEAKING HOSES, BLOWN HEAD GASKET, FAILED ENGINE, LACK OF HEAT. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 5205 |
| SOME VEHICLES MAY EXHIBIT A NGS ERROR MESSAGE, TOTAL CHECKSUM ERROR AFTER NGS / SBTS PCM REPROGRAMMING. *TT |
| Bulletin Number: 5226 |
| INFORMATION ON INSTALLING A NEW FUEL PUMP ON CERTAIN VEHICLES. *TT |
| Bulletin Number: 5255 |
| SOME VEHICLES MAY EXHIBIT CONTAMINATED / CORRODED COOLANT, HIGH OR FLUCTUATING TEMP GAUGE, COOLANT ODOR, COOLANT OVERFLOW, BLOWN OR LEAKING HOSES, BLOWN HEAD GASKET, FAILED ENGINE, AND OR LACK OF HEAT. *TT |
| Bulletin Number: 5301 |
| INFORMATION ON VEHICLES EXHIBITING AN INOPERATIVE POWER WINDOW. *TT |
| Bulletin Number: 5518 |
| INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT |
| Bulletin Number: 5897 |
| EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS. *TT |
| Bulletin Number: 6612 |
| SOME VEHICLES MAY EXHIBIT FRONT SUSPENSION NOISE DUE TO FRONT STRUT, FRONT SWAY BAR LINKS OR SYMPTOMS SUCH AS PREMATURE REAR BRAKE PAD WEAR DUE TO SEIZED REAR BRAKE CALIPERS OR SLIDES. *TT |
| Bulletin Number: 6997 |
| SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT |
| Bulletin Number: 7292 |
| NNERS OF THE EDSR-OF-THE-MONTH QUALITY AWARD ANNOUNCEMENT FOR SEPTEMBER. *TT |
| Bulletin Number: 7855 |
| VEHICLES MAY EXHIBIT INTERMITTENT INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION. |
| Bulletin Number: 8016 |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP). |
| Bulletin Number: 8016 |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. **MR** |
| Bulletin Number: 8199 |
| SOME VEHICLES MAY EXHIBIT A RATTLING OR CLUNKING NOISE FROM THE FRONT END (FRONT STABILIZER LINK) UNDER NORMAL DRIVING CONDITIONS. |
| Bulletin Number: 8316 |
| SOME VEHICLES EQUIPPED WITH COMPACT DISC CHANGER MAY EXHIBIT A 6 DISC CD CHANGER THAT IS NOT EJECTING THE MAGAZINE OR IS NOT RESPONDING TO COMMAND FROM THE RADIO. |
| Bulletin Number: 8583 |
| SOME VEHICLES MAY EXHIBIT DTC P1518 AND / OR P1519, RELATED TO INTAKE MANIFOLD RUNNER CONTROL (IMRC). *MR |
| Bulletin Number: 870197 |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962515 |
| NOISE-"CREAKING" IN A-PILLAR WHEN GOING OVER BUMPS AND/OR TURNING-VEHICLES BUILT THROUGH 12/31/96. *JD |
| Bulletin Number: 96261 |
| BODY - PRODUCT CHANGES FOR 1997 TAURUS/SABLE AND TAURUS SHO VEHICLES ELECTRICAL - PRODUCT CHANGES FOR 1997 TAURUS/SABLE AND TAURUS SHO VEHICLES MISCELLANEOUS - PRODUCT CHANGES FOR 1997 TAURUS/SABLE AND TAURUS SHO VEHICLES. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962613 |
| TRANSAXLE - AX4S - EXTENDED 2-3 SHIFT AND/OR HIGHER THAN EXPECTED ENGINE RPM DURING 2-3 SHIFT AT LIGHT TO MEDIUM THROTTLE AND/OR NO 2-3 SHIFT - VEHICLES EQUIPPED WITH 3.0L ENGINE - SERVICE TIP. *TW |
| Bulletin Number: 9705011635 |
| INFORMATION IN TSB 97-09-04 IS INCORRECT. *YC |
| Bulletin Number: 9705019584 |
| CONCERNS OF GRUNT OR GROAN DURING WHEEL RETURN. *YC |
| Bulletin Number: 97090297181 |
| SOME VEHICLES DURING WET WEATHER CONDITIONS AND/OR WHEN DRIVING THROUGH PUDDLES AND /OR THE CRANKSHAFT PULLEY MAY BE DAMAGED. *YC |
| Bulletin Number: 97090297183 |
| EXPERIENCING DIFFICULTIES WITH THE MALFUNCTION INDICATOR LAMP (MIL). *YC |
| Bulletin Number: 97090297184 |
| SOME VEHICLES MAY EXPERIENCE STATIC IN THE AM BAND OF THE RADIO WHILE DRIVING. *YC |
| Bulletin Number: 97111097231 |
| DIAGNOSTIC AND INSPECTION PROCEDURE FOR FRONT SUSPENSION NOISE. *YC |
| Bulletin Number: 97111097234 |
| VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC |
| Bulletin Number: 97111097237 |
| CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC |
| Bulletin Number: 9723 |
| FRAME - SUBFRAME INSULATORS - CLUNK ON HEAVY ACCELERATION AND/OR DECELERATION HEARD OR FELT IN FLOOR PAN AREA - VEHICLES BUILT THROUGH 2/28/97. *TW |
| Bulletin Number: 9724 |
| STEERING - GRUNTING OR GROANING NOISE DURING STEERING WHEEL RETURN FROM FULL RIGHT TURN - VEHICLES BUILT THROUGH 11/8/96. *TW |
| Bulletin Number: 9725 |
| SUSPENSION - CLUNKING NOISE FROM FRONT SUSPENSION - TAURUS SABLE BUILT THROUGH 1/14/97 - CONTINENTAL BUILT THROUGH 12/16/96. *TW |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 976011 |
| EXPERIENCING DIFFICULTY DIAGNOSING VEHICLES WITH EVAPORATIVE FUEL SYSTEM DIAGNOSTIC TROUBLE CODES. *TT |
| Bulletin Number: 9761 |
| LOCKS- REMOTE KEYLESS ENTRY (RKE)- LOCATION OF RKE FOBS- SERVICE TIP- VEHICLES BUILT AFTER 3/17/97. *JD |
| Bulletin Number: 97610 |
| BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD |
| Bulletin Number: 9763 |
| STEERING- STEERING COLUMN- AIR BAG SLIDING CONTACT SERVICING- SERVICE TIP. *JD |
| Bulletin Number: 9765 |
| HESITATION- ON ACCELERATION- VEHICLES WITH 3.0L 4-VALVE ENGINE. *JD |
| Bulletin Number: 9767 |
| MALFUNCTION INDICATOR LAMP (MIL)- DIAGNOSTIC TROUBLE CODES (DTCS) P0172, P0175, P1130, P1150 AND/OR P1152 STORED IN MEMORY AND/OR STALL ON LOW SPEED ACCELERATION OR DECELERATION- 3.4L SHO VEHICLES ONLY. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9772 |
| HESITATION- ON ACCELERATION- VEHICLES WITH 3.0L 4-VALVE ENGINE. *JD |
| Bulletin Number: 9802169837 |
| SOME VEHICLES MAY EXPERIENCE AN NO FORWARD OR REVERSE MOVEMENT. *YC |
| Bulletin Number: 9802169838 |
| TRANSAXLES USE A NEW TRANSMISSION FLUID. *YC |
| Bulletin Number: 980305 |
| VEHICLES EXPERIENCING COOLANT ODOR, COOLANT OVERFLOW, HIGH OR FLUCTUATING TEMP GAUGE READINGS, BLOWN OR LEAKING HOSES, BLOWN HEAD GASKET, FAILED ENGINE, AND LACK OF HEAT. *YC |
| Bulletin Number: 980312 |
| ENGINE CHECK LAMP ON WITH MISFIRE DTC(S). |
| Bulletin Number: 980314 |
| EXPERIENCING A HARD START / LONG CRANK. *YC |
| Bulletin Number: 98110 |
| SUBJECT REGARDING PASSIVE ANTI THEFT SYSTEM (PATS) DIAGNOSTIC SERVICE TIPS. *TT |
| Bulletin Number: 9811481 |
| SOME VEHICLES EQUIPPED WITH 3.0L 4-VALVE ENGINES MAY EXHIBIT A CUSTOMER CONCERN OF A MOAN NOISE AT IDLE. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 981512 |
| A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 98164 |
| A TRANSEAL COATING IS ON THE FRONT AND REAR BUMPERS. THIS COATING MUST BE REMOVED BEFORE DELIVERY TO THE CUSTOMER. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982112 |
| SOME VEHICLES EXPERIENCE A HARD START/LONG CRANK TIME CONDITION. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982320 |
| SOME VEHICLES WITH A VERY LOW ODOMETER READING MAY EXPERIENCE A LACK TEMPERATURE CONTROL. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98241 |
| DIAGNOSTIC SERVICE TIPS ON PASSIVE ANTI THEFT SYSTEM ( PATS ). *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 98251 |
| CONCERNS OF A POSSIBLE CHAFING OF THE FUEL PUMP ASSEMBLY WIRES RESULTING IN AN OPEN FUSE AND/OR INOPERABLE FUEL PUMP ASSEMBLY OR A NO START CONDITION. *YC |
| Bulletin Number: 982513 |
| EXHIBITING AN INOPERATIVE POWER WINDOW. *YC |
| Bulletin Number: 982514 |
| CONCERNS WITH THE TIMING ARROWS/FLAGS ON THE BACK OF THE CAMSHAFT SPROCKET (S) ARE MIS-MARKED BY AS MUCH AS 30 DEGREES ROTATION. *YC |
| Bulletin Number: 982523 |
| SOME ENGINE VALVES MAY EXHIBIT A CUSTOMER CONCERN OF A MOAN NOISE AT IDLE. *AK |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 982675 |
| A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC |
| Bulletin Number: 982742 |
| SOME VEHICLES MAY EXHIBIT A STEERING GROAN NOISE. *YC |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983112 |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT NEUTRAL CONDITION AFTER DRIVING AND COMING TO A STOP. *TT |
| Bulletin Number: 983221 |
| EXHIBITING A VIBRATION AT SPPEDS OF 45 MPH AND ABOVE WITH THE CRUISE ON. |
| Bulletin Number: 983496 |
| SOME VEHICLES MAY EXHIBIT B1522 OR GEM "HOOD SW" PID CONCERNS. *TT |
| Bulletin Number: 983566 |
| INFORMATION ON PROGRAMMING / DIAGNOSING ANY PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT |
| Bulletin Number: 983566 |
| INFORMATION REGARDING PROGRAMMING / DIAGNOSING PASSIVE ANTI-THEFT SYSTEM (PATS) RELATED ISSUES. *TT |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98-4724 |
| CONTAMINATED/CORRODED COOLANT, HIGH OR FLUCTUATING TEMPERATURE GAUGE. *AK |
| Bulletin Number: 98-4731 |
| CLUNK OR PLOP COMING FROM FRONT END. *AK |
| Bulletin Number: 98-4735 |
| HARD START/LONG CRANK. |
| Bulletin Number: 98-4737 |
| ENGINE SPARK KNOCK ON ACCELERATION. *AK |
| Bulletin Number: 98-4741 |
| FUEL GAUGE ACCURACY OR FUEL GAUGE ERRATIC OPERATION. *AK |
| Bulletin Number: 98-4803 |
| SOME 1996-1998 TAURUS/SABLE VEHICLES WITH 3.0L 4-V ENGINE MAY EXHIBIT A CONCERN OF MOAN NOISE AT IDLE. |
| Bulletin Number: 984984 |
| SOME VEHICLES EQUIPPED WITH 3.0L 2-VALVE ENGINES MAY EXHIBIT A SPARK KNOCK CONCERN ON ACCELERATION. *TT |
| Bulletin Number: 985065 |
| REPEAT MESSAGE REGARDING HARD START / LONG CRANK CONDITION. *TT |
| Bulletin Number: 985083 |
| SOME VEHICLES (3.0L 4 VALVE ONLY) MAY EXHIBIT A CATALYTIC CONVERTER BUZZ OR RATTLE CONDITION ON A COLD START OR DURING A LOW RPM STEADY SPEED. *TT |
| Bulletin Number: 9851 |
| EXERPEINCING A MOANING NOISE HEARD FROM THE POWER STEERING DURING ENGINE IDLE. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9865 |
| TORQUE CONVERTER CLUTCH NOT ENGAGING AND/OR DIAGNOSTIC TROUBLE CODE (DTC) P0741 OR P1744 STORED IN MEMORY. *YC |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9874 |
| A NEW SILICONE GASKET AND SEALANT. *YC |
| Bulletin Number: 9884 |
| THE MALFUNCTION INDICATOR LAMP (MIL) MAY ILLUMINATE FOR MISFIRES AT HIGH ENGINE RPMS DURNG ENGINE WARM UP. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 98B18 |
| OWNER NOTIFICATION PROGRAM 98B18- COOLING SYSTEM BY-PASS KIT INSTALLATION. *AK |
| Bulletin Number: 98B23 |
| THE OWNER NOTIFICATION PROGRAM 98B23 CONTAINED INCORRECT LABOR ALLOWANCE AND COOLANT PART NUMBER INFORMATION |
| Bulletin Number: 98B23S1 |
| INSTALLATION OF COOLING SYSTEM BY-PASS KIT. *TT |
| Bulletin Number: 98B26 |
| COOLING SYSTEM BY-PASS KIT INSTALLATION ON CERTAIN TAURUS VEHICLES EQUIPPED WITH 3.0L VULCAN METHANOL ENGINES. GASOLINE OR ETHANOL ENGINES ARE COVERED BY OWNER NOTIFICATION PROGRAM 98B23.*AK |
| Bulletin Number: 98B27 |
| COOLANT BY-PASS KIT REPLACEMENT ON CERTAIN TAURUS VEHICLES. ENGINES PREVIOUSLY REPAIRED WITH 98B18 SERVICE BY-PASS KIT. |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99127 |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P1135 OR P1155 STORED IN MEMORY AND / OR A LONG CRANK / SLOW START. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99183 |
| SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT |
| Bulletin Number: 99184 |
| SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99195 |
| SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99234 |
| INFORMATION ON DIAGNOSING A VEHICLE WITH MALFUNCTION INDICATOR LAMP ILLUMINATED AND DIAGNOSTIC TROUBLE CODES P0442 AND P0455 STORED IN CONTINUOUS MEMORY. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9941 |
| EXPERIENCING A MOANING NOISE FROM THE POWER STEERING DURING ENGINE IDLE. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 996123 |
| CONCERNS WITH BUZZ OR VIBRATION WITH THE GEAR SELECTOR IN PARK. *TT |
| Bulletin Number: 996735 |
| SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 99B01 |
| EXPERIENCING A LOSS OF AIR CONDITIONING FUNCTION, DUE TO A FRACTURE OF THE COMPRESSOR'S INTERNAL ROTOR. *TT |
| Bulletin Number: BC0011970201 |
| A BUZZ NOISE IN AX4S TRANSAXLES ON 1996/97 TAURUS/SABLE AND WINDSTARS. *JD |
| Bulletin Number: BC0011972301 |
| BUZZ NOISE IN AX4S TRANSAXLES. *JD |
| Bulletin Number: BC0042970201 |
| FOR 1996 3.OL 2-VALVE VEHICLES STOP UPDATING THE PROCESSOR TO THE R-12 CALIBRATION. *JD |
| Bulletin Number: BC0042972301 |
| FOR 1996 3.0L 2-VALVE VEHICLES STOP UPDATING THE PROCESSOR TO THE R-12 CALIBRATION. THIS UPDATE MAY CAUSE THE VEHICLE TO STALL ON COLD ENGAGEMENT. *JD |
| Bulletin Number: BC0130970201 |
| REMOVING OR REPLACING ONE OF THE FRONT STRUT SPRINGS ON A 1996/97 TAURUS OR SABLE VEHICLE USE ROTUNDA #014-00781 STRUT SPRING COMPRESSOR MASTER SET. *JD |
| Bulletin Number: BC0144970201 |
| RESIDUAL BRAKE PRESSURE ON THE REAR BRAKES OF A 1996-1997 TAURUS OR SABLE, MAKE SURE TO SUPPORT THE REAR CONTROL ARMS TO REMAIN AT THE NORMAL RIDE HEIGHT POSITION. IF THE REAR CONTRAL ARM ON THE DRIVERS SIDE IS ALLOWED TO HANG ALL THE WAY D |
| Bulletin Number: BC0152970201 |
| WATER LEAK IN THE REAR OF A TAURUS OR SABLE WAGON, CHECK FOR WATER ENTERING IN AT THE REAR HATCH HINGES. *JD |
| Bulletin Number: BC0180970201 |
| THE CRANKSHAFT DAMPER BOLT, FOUND UNDERNEATH THE PULLEY HAS A STANDARD RIGHT AND LEFT HAND THREAD. TO AVOID DAMAGE TO PLASTIC, AVOID USING HEAT. *JD |
| Bulletin Number: BC0196970201 |
| NOISY FUEL PUMPS ON 1996/1997 TAURUS/SABLE VEHICLES. REVISED FUEL PUMP TO ALEVIATE NOISE. *JD |
| Bulletin Number: BC0251970201 |
| ABS INDICATOR ILLUMINATION WITH DTC C1095. *JD |
| Bulletin Number: BC0252970201 |
| UNEVEN IDLE RPM, STALL, ROUGH RUNNING, SURGE, AND/OR SPARK KNOCK WHEN THE COOLING FANS COME ON AT A IDLE. *JD |
| Bulletin Number: BC0253970201 |
| OWNER GUIDE LISTS THAT THE 3.0L 2V VULCAN ENGINE USES A FL-400-S OIL FILTER AND THE 3.0L 4V DURATEC USES A FL-820-S FILTER. *JD |
| Bulletin Number: BC0264970201 |
| THE REAR MAIN SEAL REMOVAL TOOL LISTED IN THE SERVICE MANUAL FOR THE 3.0L 4V DURATIC AND 4.6L CONTINENTAL ENGINES, IS INCORRECT. *JD |
| Bulletin Number: BC0307972301 |
| BATTERY GOES DEAD- CHECK THE CURRENT DRAW WITH AN AMMETER. *JD |
| Bulletin Number: BC0307A97020 |
| BATTERY OES DEAD OVERNIGHT. *TW |
| Bulletin Number: BC0308961101 |
| THUMP/CLUNK NOISE FROM FRONT SUSPENSION AREA. *TW |
| Bulletin Number: BC0308970201 |
| THUMP/CLUNK NOISE FROM FRONT SUSPENSION AREA. *JD |
| Bulletin Number: BC0308972301 |
| THUMP/CLUNK NOISE FROM FRONT SUSPENSION AREA. *JD |
| Bulletin Number: BC0308A97020 |
| THUMP/KLUNK NOISE FROM FRONT SUSPENSION AREA. *TW |
| Bulletin Number: BC0309970201 |
| SURGE AT STEADY STATE CRUISE (POWER TRAIN SHUFFLE), MISFIRE CODES,STALLS AT HIGH AMBIENT TEMPERATURES. *TW |
| Bulletin Number: BC0309972301 |
| SURGE AT STEADY CRUISE (POWER TRAIN SHUFFLE), MISFIRE CODES, STALLS AT HIGH AMBIENT TEMPERATURES. *JD |
| Bulletin Number: BC0503961108 |
| DIAGNOSTIC PROCEDURE FOR SYSTEM INDICATORS KIT WITH DTCS C1165 AND/OR C1175. *TW |
| Bulletin Number: BC0535961108 |
| THE EGR TUBE TORQUE SPECIFICATIONS IN SERVICE MANUAL ARE INCORRECT. *TW |
| Bulletin Number: BC0541961107 |
| VEHICLES MAY EXHIBIT A WHISTLE CONDITION FROM THE A/C EVAPORATOR. *TW |
| Bulletin Number: BC0680961024 |
| VEHICLES SHIPPED W/ LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC0713961021 |
| CONCERNS OF A SURGE (POWERTRAIN SHUFFLE) AT 35-40 MPH. *TT |
| Bulletin Number: BC0762961016 |
| REPETITIVE THUMPING/KNOCKING NOISE PROPORTIONAL TO WHEEL SPEED WHEN BRAKING. *TT |
| Bulletin Number: BC0850961007 |
| CONCERNS OF VEHICLE STALL, HESITATION STUMBLE, ROUGH IDLE, MISSING, FUEL PRESSURE, OR FUEL PRESSURE RELATED CHECK THE REAR GROUND. *TT |
| Bulletin Number: BC0851961007 |
| PROCEDURE FOR CONCERNS OF RIDE QUALITY. *TT |
| Bulletin Number: BC1010197020 |
| NOISY FUEL PUMPS ON 1996/97 VEHICLES. A REVISED FUEL PUMP HAS BEEN RELEASED WITH A MODIFIED MANIFOLD OUTLET TO REDUCE NOISE. *JD |
| Bulletin Number: BC1010297020 |
| ENGINES ARE EQUIPPED WITH A UNIQUE CRANKSHAFT PULLEY ASSEMBLY WHICH THREADS INTO THE CRANKSHAFT DAMPER USING A LEFT-HANDED THREAD. HEATING THE CRANKSHAFT PULLEY WILL DAMAGE THE RUBBER COMPONENTS. *JD |
| Bulletin Number: BC101209702 |
| VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD |
| Bulletin Number: BC1012397020 |
| RESIDUAL BRAKE PRESURE ON THE REAR BRAKES OF A 1996-1997 VEHICLE, MAKE SURE TO SUPPORT THE REAR CONTROL ARMS TO REMAIN AT THE NORMAL RIDE HEIGHT POSITION- SUPPORT DURING LIFTING PROCESS. *JD |
| Bulletin Number: BC1012497020 |
| REMOVING OR REPLACING ONE OF THE FRONT STRUT SPRING ON A VEHICLE US A ROTUNDA #014-00781 STRUT SPRING COMPRESSOR MASTER SET. *JD |
| Bulletin Number: BC1013997010 |
| MAY HAVE NO AUDIO IN CDDJ MODE. *JD |
| Bulletin Number: BC1016397230 |
| BUZZ NOISE IN AX4S TRANSAXLES AT ALL SPEEDS OR IDLE ON VEHICLES. *JD |
| Bulletin Number: BC1019697230 |
| REPLACING FRONT OR REAR STRUTS ON A 1996/97 VEHICLE, THE REPLACEMENT STRUT MAY APPEAR TO BE APPROXIMATELY 2" TOO SHORT WHEN COMPARED TO THE STRUT IN THE VEHICLE. *JD |
| Bulletin Number: BC1021497230 |
| WATER LEAK AT THE RIGHT FRONT FLOOR, CHECK FOR A BROKEN COWL TOP INNER PANEL SHIELD. *JD |
| Bulletin Number: BC1025097230 |
| PASSIVE ANTI-THEFT SYSTEM. *JD |
| Bulletin Number: BC1029897020 |
| KNOCK OR WOP NOISE FROM THE ENGINE COMPARTMENT NEAR THE FRONT OF THE ENGINE. *JD |
| Bulletin Number: BC1030097020 |
| WHISTLE OR SQUEAL NOISE IN THE ENGINE COMPARTMENT ON 1997 VEHICLES BUILT BEFORE 11/1/96 WITH THE 2-VALVE ENGINE. *JD |
| Bulletin Number: BC1030697020 |
| GROAN OR MOAN NOISE FROM THE POWER STEERING WHEN RETURNING FROM A RIGHT TURN. *JD |
| Bulletin Number: BC1032697020 |
| VEHICLES HAVE A CABIN AIR FILTER THAT MUST BE CHANGED EVERY 15000 MILES. *JD |
| Bulletin Number: BC105739705 |
| WHEN PERFORMING THE AIR BAG DEACTIVATION PROCEDURE, THE SERVICE MANUALS DO NOT CLEARLY STATE WHICH SIMULATORS TO USE ON THE PASSENGER SIDE AIR BAG. *TW |
| Bulletin Number: BC2224970501 |
| VEHICLES MAY EXPERIENCE A KNOCK OR WOP NOISE IN THE PASSENGER COMPARTMENT. *TW |
| Bulletin Number: BC2310970501 |
| DEACTIVATION PROCEDURE - CLARIFICATION OF INSTRUCTIONS IN SERVICE MANUAL. *TW |
| Bulletin Number: BC2311970501 |
| SOME VEHICLES MAY EXHIBIT A CLUNKING NOISE FROM THE REAR SUSPENSION WHEN DRIVING OVER BUMPS. *TW |
| Bulletin Number: BC2380970501 |
| HARSH 1-2 UPSHIFT. *TW |
| Bulletin Number: BC3061970228 |
| REPEAT POWER STEERING GRUNT/GROAN AFTER COMPLETION OF TSB 97-02-04. *TW |
| Bulletin Number: BC3100970224 |
| MICRON FILTER - REMINDER THAT THE FILTER MUST BE CHANGED EVERY 15000 MILES - SYMPTOMS THAT MIGHT INDICATE NEED FOR CHANGE INCLUDE POOR A/C-HEATER PERFORMANCE AND/OR WINDOW FOGGING. *TW |
| Bulletin Number: BC3142970220 |
| GROAN OR MOAN NOISE FROM THE POWER STEERING WHEN RETURNING FROM A RIGHT TURN. *TW |
| Bulletin Number: BC3205970214 |
| CONCERN OF WATER INGESTION IN ENGINE. *TW |
| Bulletin Number: BC3272970207 |
| VEHICLES ARE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) - VEHICLE WILL NOT START WITHOUT THE CORRECT IGNITION KEY. *TW |
| Bulletin Number: BC3410972301 |
| WATER LEAK AT THE RIGHT FRONT FLOOR ON VEHICLES, CHECK FOR A BROKEN COWL TOP INNER PANEL SHIELD. *JD |
| Bulletin Number: BC3482972301 |
| REPLACING FRONT REAR STRUTS ON A VEHICLE, THE REPLACEMENT STRUT MAY APPEAR TO BE APPOXIMATELY 2" TOO SHORT. *JD |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9584961001 |
| INFORMATION FOR CONCERNS OF GRUNT OR GROAN DURING WHEEL RETURN FROM FULL RIGHT TURN. *TT |
| Bulletin Number: BC9683961001 |
| PROCEDURE FOR UPDATING THE CALIBRATION FROM R-11 TO R-12 FOR STALLING ON DECEL & MISFIRE CODES ON 3.0L VEHICLES. *TT |
| 1997 FORD TAURUS (SHO) |
|---|
| Bulletin Number: 8016 |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INTEGRATED CONTROL PANEL (ICP) ILLUMINATION. **MR** |
| 1997 FORD TAURUS SHO |
|---|
| Bulletin Number: 00E11 |
| SERVICE ACTION 00E11, SUPPLEMENT #1 - UPDATE INFORMATION REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT |
| Bulletin Number: 00E11 |
| SERVICE ACTION BULLETIN REGARDING ON-BOARD DIAGNOSTIC SYSTEM UPGRADE. *TT |
| Bulletin Number: 03144 |
| ENGINE MISFIRE OR ROUGH RUNNING CONDITION WITH COIL ON PLUG (COP) IGNITION SYSTEMS MAY BE MORE ACCURATELY DIAGNOSED USING THE OPTIONAL WORLDWIDE DIAGNOSTIC SYSTEM (WDS) COIL ON PLUG (COP) KIT. 2003 SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 12570 |
| SOME VEHICLES MAY EXHIBIT FRONT OUTER TIE RODS SQUEAK AND / OR POP NOISE OVER BUMPS AND / OR TURNING. *TT |
| Bulletin Number: 13802 |
| SOME VEHICLES MAY EXHIBIT AN INTERMITTENT LOSS OF INSTRUMENT CONTROL PANEL (ICP) ILLUMINATION. *MJS |
| Bulletin Number: 15128 |
| SOME VEHICLES MAY EXHIBIT A HARSH 2-3 SHIFT AFTER INSTALLING A REMANUFACTURED TRANSAXLE. *SLC |
| Bulletin Number: 5249 |
| INFORMATION ON VEHICLES EXHIBITING STEERING WHEEL SHIMMY, VIBRATION OR GRUNT ON SLOW SPEED TURNS. *TT |
| Bulletin Number: 5897 |
| EXPERIENCING A SQUEAKING AND / OR POPPING NOISE FROM THE FRONT OUTER TIRE RODS. *TT |
| Bulletin Number: 980314 |
| EXPERIENCING A HARD START / LONG CRANK. *YC |
| Bulletin Number: 99127 |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P1135 OR P1155 STORED IN MEMORY AND / OR A LONG CRANK / SLOW START. *TT |
| Bulletin Number: 996123 |
| CONCERNS WITH BUZZ OR VIBRATION WITH THE GEAR SELECTOR IN PARK. *TT |
| 1997 FORD TEMPO |
|---|
| Bulletin Number: BC3274970207 |
| REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9666961001 |
| 2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT |
| 1997 FORD THUNDERBIRD |
|---|
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 002310 |
| SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02208 |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH |
| Bulletin Number: 0222 |
| SOME VEHICLES MAY EXHIBIT AN INTAKE MANIFOLD CROSSOVER (FIRST RUNNER) COOLANT SEEPAGE CONDITION. *TT |
| Bulletin Number: 02221 |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03261 |
| NEW SERVICE PART - NUMBER 5 NEEDLE BEARING AND RACE KIT - 4R70W TRANSMISSION - SERVICE TIP. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 05N04 |
| EXTENDED COVERAGE PROGRAM 05N04 - EXTENDED COVERAGE FOR COMPOSITE INTAKE MANIFOLD. THIS PROGRAM IS BEING PROVIDED AS A SETTLEMENT TO A CLASS ACTION LAWSUIT. THE TERMS OF THE SETTLEMENT EXTEND THE COVERAGE OF THE ALL-COMPOSITE INTAKE MANIF |
| Bulletin Number: 07212 |
| SOME 1997-2008 VEHICLES EQUIPPED WITH A 4.6L 2V, 5.4L 2V, OR 6.8L 2V ENGINE--SPARK PLUG THREAD REPAIR PROCEDURE--NOT COVERED UNDER NEW VEHICLE LIMITED WARRANTY. *NJ THIS INCLUDES F-53 MOTORHOME CHASSIS. UPDATED 2/23/10. *PE |
| Bulletin Number: 12098 |
| SOME VEHICLES WITH NON-FUNCTIONAL WINDSHIELD WIPERS MAY REQUIRE WIPER MOTOR REPLACEMENT. *MJS |
| Bulletin Number: 13180 |
| INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS |
| Bulletin Number: 13186 |
| INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS |
| Bulletin Number: 6996 |
| INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT |
| Bulletin Number: 6997 |
| SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT |
| Bulletin Number: 870197 |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96226 |
| AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962511 |
| POWERTRAIN CONTROL MODULE -REPROGRAM POWERTRAIN CONTROL MODULE (PCM) - SERVICE PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 96252 |
| LOCKS - REPLACE AND/OR REPAIR ANY LOCK COMPONENT - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 97050110617 |
| VEHICLES MAY EXPERIENCE ILLUMINATION OF THE ENGINE COOLING INDICATOR LIGHT. *TW |
| Bulletin Number: 97090297184 |
| SOME VEHICLES MAY EXPERIENCE STATIC IN THE AM BAND OF THE RADIO WHILE DRIVING. *YC |
| Bulletin Number: 97111097234 |
| VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 9753 |
| VIBRATION- TIRES- VIBRATION FELT WHILE DRIVING AT HIGHWAY SPEEDS- VEHICLES BUILT THROUGH 12/20/96 EQUIPPED WITH 16 INCH GOODYEAR TIRES. *JD |
| Bulletin Number: 97610 |
| BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9773 |
| VIBRATION- SHUDDER OR VIBRATION UNDER LIGHT TO MODERATE ACCELERATION ABOVE 56 KM/H (35 MPH) WHILE IN 3RD OR 4TH GEAR- VEHICLES EQUIPPED WITH AODE OR 4R70W TRANSMISSION. *JD |
| Bulletin Number: 97M91 |
| INFORMATION REGARDING ADDITIONAL COVERAGE FOR INTAKE MANIFOLD MALFUNCTIONS. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 98163 |
| LOCKS FAILED. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 98216 |
| A STEERING WHEEL MOVEMENT FELT WHEN DRIVING OVER ROUGH SURFACES. |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 982312 |
| ISSUES REGAREDING DIAGNOSTIC TROUBLE CODES ( DTCS ) P0705, P0708, P1704, AND / OR P1705 MAY BE STORED IN MEMORY. *YC |
| Bulletin Number: 982323 |
| INFORMATION REGARDING REPLACEMENT AND / OR REPAIRS ON ANY LOCK COMPONENT. *YC |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983107 |
| BRIEF INFORMATION REGARDING ENGINES BEING ADDED TO THE FQR (FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *TT |
| Bulletin Number: 983108 |
| EFFECTIVE MARCH 2, 1998M3.8L ENGINE ASSEMBLY IS ADDED TO FQR(FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *AK |
| Bulletin Number: 983224 |
| SOME VEHICLES MAY HAVE WATER CONTAMINATION IN THE AIR FILTER AND / OR THE MASS AIR FLOW SENSOR. *TT |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 9834 |
| AIR INLET-WATER IN AIR INLET ELBOW-MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATES DUE TO WATER CONTAMINATION OF AIR FILTER AND/OR MASS AIR FLOW SENSOR (MAF)- VEHICLE SWITH 4.6L ENGINE. *AK |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 985111 |
| SOME VEHICLES WITH NON-FUNCTIONAL WINDSHIELD WIPERS MAY REQUIRE WIPER MOTOR REPLACEMENT. *TT |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A18 |
| SOME VEHICLES MAY EXHIBIT BRAKE ROUGHNESS (BRAKE PEDAL PULSATION, STEERING WHEEL SHAKE AND / OR NIBBLE) UNDER LIGHT BRAKE APPLICATIONS FROM 105 TO 0 KM/H (65 TO 0 MPH). *YC |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9874 |
| A NEW SILICONE GASKET AND SEALANT. *YC |
| Bulletin Number: 9887 |
| EXPERIENCING A TORQUE CONVERTER CLUTCH SHUDDER OR VIBRATION. *YC |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 99129 |
| INFORMATION ON "WHINING" / "BUZZING" NOISE COMING THROUGH ENTERTAINMENT OR TWO-WAY RADIO SPEAKER CAUSED BY THE FUEL PUMP. *TT |
| Bulletin Number: 99131 |
| CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99207 |
| SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 99242 |
| INFORMATION ON REPLACING AND / OR REPAIRING MALFUNCTIONING (DOOR, IGNITION AND DECKLID) LOCKS. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: 9996 |
| EXPERIENCING A DELAYED OR NO 2-3 UPSHIFT, PRIMARILY WHEN THE TRANSMISSION IS COLD ON VEHICLES WITH FORD QALITY REMANUFACTURED (FQR) 4R70W TRANSMISSION EXCHANGE UNITS WITH JULIAN BUILD BETWEEN 062-97 AND 040-99. *TT |
| Bulletin Number: 99B29 |
| SOME VEHICLES MAY EXPERIENCE ENGINE COOLANT LEAKS AT THE ENGINE FRONT COVER GASKET. OWNER NOTIFICATION PROGRAM PROVIDING REPLACEMENT OF THE ENGINE FRONT COVER GASKET. *TT |
| Bulletin Number: 99B29#1 |
| INFORMATION REGARDING REPLACMENT OF ENGINE FRONT COVER GASKET. **MR |
| Bulletin Number: BC0192970201 |
| LOW COOLANT LIGHT STAYS ON. THE LOW FLUIDS MODULE IN THE CLUSTER NOT MAKING ELECTRICAL CONTACT WTH THE FLEX CURCUIT IN THE CLUSTER. *JD |
| Bulletin Number: BC0226970201 |
| ERRATIC SHIFTHING OF THE TRANSMISSION. *JD |
| Bulletin Number: BC0407961115 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED PARTS. *TW |
| Bulletin Number: BC0490961112 |
| INSTRUCTIONS FOR REPLACING DIAGNOSED FAILED COMPONENT. *TW |
| Bulletin Number: BC0696961023 |
| CONCERNS OF CHECK ENGINE LIGHT (MIL) W/ CODES P0300 THRU P0308 & ENG RUNES ROUGH/MISSES. *TT |
| Bulletin Number: BC0810961011 |
| VEHICLES EQUIPPED W/ AN AODE OR 4R70W TRANS HAS A CONCERN OF SHUDDER FROM THE TRANSMISSION TORQUE CONVERTER CLUTCH IN 3RD OR 4TH GEAR OR DURING 3-4 SHIFT. *TT |
| Bulletin Number: BC1023897230 |
| VEHICLE EXHIBITS A PULL WHILE BRAKING, FOLLOW PROCEDURES OUTLINED IN 06-00-4 & PINPOINT TEST "A" ON 06-00-5 OF THE 1997 SERVICE MANUAL. *JD |
| Bulletin Number: BC1024397230 |
| VEHICLES BUILT BETWEEN AUGUST 1996 AND JANUARY 1997 MAY EXHIBIT FLASHING LOW COOLANT AND LOW WASHER FLUID LAMPS AFTER ENGINE START.JD |
| Bulletin Number: BC105709705 |
| INSTRUCTIONS FOR RE-INSTALLING LOOSE FENDER CLADDING. *TW |
| Bulletin Number: BC105869705 |
| OCCASIONAL FLASHING OF THE LOW COOLANT AND LOW WASHER FLUID WARNING LAMPS SIMULTANEOUSLY DURING LOW TEMPERATURES. *TW |
| Bulletin Number: BC2291970501 |
| COMPLAINTS OF FLASHING LOW COOLANT AND LOW WASHER FLUID WARNING LAMPS. *TW |
| Bulletin Number: BC2364970501 |
| INSTRUCTIONS FOR REMOVING AND REINSTALLING A LOOSE FENDER CLADDING. *TW |
| Bulletin Number: BC3243970210 |
| ENGINE COOLING LIGHT ON - POSSIBLE OIL LEAK AT UPPER JAM NUT ON THE UPPER TRANSMISSION COOLER LINE. *TW |
| Bulletin Number: BC3274970207 |
| REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A |
| Bulletin Number: BC3281970206 |
| VEHICLES EXHIBIT A PULL WHILE BRAKING - CHECK FOR KINKED BRAKE LINES , REPLACE IF NECESSARY - REPLACE LOWER ARM AND STRUT BUSHINGS ON THE SIDE THE VEHICLE PULL TO. *TW |
| Bulletin Number: BC3285970206 |
| VEHICLES MAY EXHIBIT FLASHINIG COOLANT AND LOW WASHER FLUID LAMPS AFTER ENGINE START AND DURING EXTREMELY LOW TEMPERATURES. *TW |
| Bulletin Number: BC3288970206 |
| VEHICLES MAY EXHIBIT A COLD START ENGINE FEAD BELT CHIRP NOISE. *TW |
| Bulletin Number: BC5195961001 |
| FIRESTONE P235 TIRES MAY EXHIBIT A HIGH FREQUENCY VIBRATION AT 65-75 MPH. *TT |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9714961101 |
| DIAGNOSTIC INSTRUCTIONS FOR SERVICING EVAPORATIVE EMISSION PURGE FLOW SYSTEM. *TW |
| 1997 FORD WINDSOR |
|---|
| Bulletin Number: 982515 |
| SOME VEHICLES MAY EXHIBIT A RATTLE NOISE FROM LH OR RH FRONT DOOR, GLASS-RUN RETAINER. *YC |
| Bulletin Number: 982675 |
| A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC |
| 1997 FORD WINDSTAR |
|---|
| Bulletin Number: |
| CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND OR BINDING BLEND DOORS ON SOME VEHICLES. *TT |
| Bulletin Number: 0015 |
| INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| Bulletin Number: 01124 |
| ON SOME VEHICLES, ENGINE OIL MAY CONTINUE TO LEAK FROM THE ENGINE OIL PAN GASKET AREA AFTER AN ENGINE OIL PAN GASKET REPAIR HAS BEEN PERFORMED. *TT |
| Bulletin Number: 01156 |
| SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| Bulletin Number: 01157 |
| INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| Bulletin Number: 011701 |
| INFORMATION REGARDING REPLACEMENT APPLICATION CHART. *ET |
| Bulletin Number: 01171 |
| TRANSAXLE - AX4S - REPLACEMENT APPLICATION CHART - WINDSTAR VEHICLES ONLY. *NLM |
| Bulletin Number: 01181 |
| BRAKE SHIFT INTERLOCK.*JB |
| Bulletin Number: 01205 |
| SOME VEHICLES MAY EXHIBIT VACUUM OR AIR LEAKS IN THE INTAKE MANIFOLD AND / OR ENGINE SYSTEM CAUSING DIAGNOSTIC TROUBLE CODES P0171 AND OR P0174. *TT |
| Bulletin Number: 01246 |
| ENGINE OIL SYSTEM PRIMING PROCEDURES, SERVICE TIPS FOR REPORTS OF PREMATURE ENGINE FAILURE. *TT |
| Bulletin Number: 0147 |
| SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT |
| Bulletin Number: 02132 |
| GRUNT / POPPING NOISE COMING FROM THE FRONT SUSPENSION AT SPEEDS BELOW 20 MPH WHEN TURNING. *TT |
| Bulletin Number: 0214 |
| SOME ENGINE ASSEMBLIES WITH ALUMINUM CYLINDER HEADS REPAIRED IN-VEHILE HAVE BEEN FOUND TO LEAK COOLANT AND/OR OIL FROM THE CYLINDER HEAD GASKET AREA. *TT |
| Bulletin Number: 02152 |
| SOME VEHICLES MAY EXHIBIT A POPPING / GRINDING NOISE FROM THE FRONT OF THE VEHICLE WHEN GOING OVER BUMPS OR MAKING TURNS. *TT |
| Bulletin Number: 02176 |
| LAMP-BRAKE-INVADVERTENT DISABLING OF BRAKE SHIFT INTERLOCK. *MJ |
| Bulletin Number: 02208 |
| CLIMATE CONTROL A/C SERVICE TECH TIPS. *EH |
| Bulletin Number: 02221 |
| ENGINE-GEAR DRIVEN SYNCHRONIZERS-INCORRECT INSTALLATION-CAMSHAFT POSITION SYNCHRONIZER (CMP) INSTALLATION TOOL CORRECT APPLICATION. *MJ |
| Bulletin Number: 03123 |
| TORQUE CONVERTER CLUTCH NOT ENGAGING WHEN COMMANDED AND/OR DIAGNOSTIC TROUBLE CODES P0741 OR P1744 STORED IN MEMORY. MODELS FROM 1996 TO 2003. *TT |
| Bulletin Number: 03148 |
| NEW TRANSMISSION COOLER FLUSHER - SERVICE TIPS. 2003 ESCORT AND SUPER DUTY F SERIES INCLUDED. *TT |
| Bulletin Number: 03181 |
| REMOTE KEYLESS ENTRY (RKE) - SERVICE TIPS. *TT |
| Bulletin Number: 03203 |
| MALFUNCTION INDICATOR LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0442, P0455, P0456, P0457 OR P1442 OR A CHECK FUEL CAP LAMP ILLUMINATED WITH DTC P0457 FOR THE EVAPORATIVE EMISSION SYSTEM. *TT |
| Bulletin Number: 0398 |
| MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATION WITH DIAGNOSTIC TROUBLE CODES P0442, P0455, P0456, P0457, P1442 OR CHECK FUEL CAP LAMP ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE P0457. *TT |
| Bulletin Number: 042107 |
| GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT |
| Bulletin Number: 04L23 |
| LITERATURE PROGRAM 04L23. CUSTOMER MAINTENANCE REMINDER - ALUMINUM WHEEL LUG NUT TORQUE. *TT |
| Bulletin Number: 11474 |
| SOME MODEL YEAR VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *TT |
| Bulletin Number: 11505 |
| SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT |
| Bulletin Number: 12099 |
| VEHICLES WITH THE AX4S TRANSAXLE HAVE AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *MJS |
| Bulletin Number: 12114 |
| SOME VEHICLES MAY EXHIBIT A FRONT END GRIND/CRUNCH NOISE DURING A SLOW SPEED TURN. *MJS |
| Bulletin Number: 12174 |
| SOME VEHICLES MAY EXHIBIT A HARD START/LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *MJS |
| Bulletin Number: 12178 |
| INFORMATION REGARDING TSB 98-5A-12 (TRANSAXLE/TRANSMISSION/TRANSFER CASE-VEHICLES TOWED BEHIND RECREATIONAL VEHICLES-RECOMMENDED GUIDELINES) DOES NOT LIST TOWING INFORMATION FOR CERTAIN MODEL VEHICLES. *MJS |
| Bulletin Number: 12227 |
| FOR ALL VEHICLES WITH GENERIC ELECTRONIC MODULE (GEM) CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12230 |
| ALL VEHICLES WITH ANTILOCK BRAKE MODULE CONCERNS THAT REQUIRE A MODULE REPLACEMENT, THE TECHNICIAN MUST CALL FOR APPROVAL BEFORE REMOVING AND / OR REPLACING THE MODULE. *TT |
| Bulletin Number: 12559 |
| CONCERNS WITH REVERSE CLUTCH THAT COULD BECOME SHEARED OR TORN IN EXTREMELY COLD TEMPERATURES. *TT |
| Bulletin Number: 12616 |
| INFORMATION ON TRANSAXLE SERVICE CASE REPLACEMENT WITH OSS (OUTPUT SHAFT SPEED SENSOR) HOLE. *TT |
| Bulletin Number: 12808 |
| SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO DTC (DIAGNOSTIC TROUBLE CODE). *TT |
| Bulletin Number: 13024 |
| SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT |
| Bulletin Number: 13180 |
| INFORMATION REGARDING CAMSHAFT POSITION (CMP) SENSOR ALIGNMENT TOOL CHART. *MJS |
| Bulletin Number: 13186 |
| INFORMATION REGARDING FRONT COVER & WATER PUMP BOLTS-TORQUE VALVE REVISION/3.8-4.2L. *MJS |
| Bulletin Number: 13242 |
| INFORMATION REGARDING TSB 97-20-08 FOR 3.8L ENGINES ONLY. *MJS |
| Bulletin Number: 13309 |
| SOME VEHICLES WITH 3.8L ENGINE MAY EXHIBIT BLACK SOOT ON THE LOWER SECTION OF THE RIGHT REAR QUARTER PANEL. *TT |
| Bulletin Number: 13931 |
| SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT |
| Bulletin Number: 14222 |
| CONCERNS WITH SUBFRAME CLUNK ON ACCELERATION / DECELERATION FROM FRONT OF VEHICLE. *TT |
| Bulletin Number: 14656 |
| SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT |
| Bulletin Number: 14773 |
| INFORMATION ON INDEXING ORANGE DOT ON TORQUE CONVERTER TO FLEXPLATE. *TT |
| Bulletin Number: 15370 |
| SOME VEHICLES MAY EXHIBIT A GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK. *TT |
| Bulletin Number: 15373 |
| SOME VEHICLES MAY RUN ROUGH AT CRUISE OR MOMENTARILY AFTER STOPPING, A CHECK ENGINE LIGHT,AND P030X CODES. *TT |
| Bulletin Number: 15392 |
| SOME VEHICLES MAY EXHIBIT A PARK PULLOUT CLUNK NOISE WHEN SHIFTING FROM PARK TO ANOTHER GEAR POSITION. *TT |
| Bulletin Number: 15682 |
| EXHIBITING INTERMITTENT ANTI-SKID BRAKE SYSTEM AND / OR RED BRAKE LAMP ON AT TIMES WHILE DRIVING. *TT |
| Bulletin Number: 15719 |
| SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEZING TEMPERATURES. *TT |
| Bulletin Number: 15767 |
| SUBJECT REGARDING POWER STEERING LINE PART ORDERING INFORMATION. *TT |
| Bulletin Number: 16987 |
| SLIGHT AMOUNT OF FLUID RESIDUE ON THE OUTSIDE OF THE REAR WHEEL CYLINDER DUST BOOT ON VEHICLES WITH REAR DRUM BRAKES. *TT |
| Bulletin Number: 17358 |
| GROAN/BUZZ/VIBRATION WHEN THE GEAR SELECTOR IS IN PARK WITH THE VEHICLE PARKED ON AN INCLINE. *TT THIS BULLETIN UPDATES PREVIOUS BULLETIN 17358, DATED 11/01/2003 TO INCLUDE 2005 MODELS. *TT |
| Bulletin Number: 4639 |
| INFORMATION ON DIAGNOSTIC PROCEDURES FOR VEHICLES EXHIBITING CHECK ENGINE LAMP ON AND MISFIRE DIAGNOSTIC TROUBLE CODES P0300 - P0306. *TT |
| Bulletin Number: 5131 |
| SUBJECT REGARDING VEHICLES WITH THE AX4S TRANSAXLE HAVING AN INLINE TRANSMISSION COOLER BYPASS VALVE LOCATED IN THE COOLER LINE NEAR THE RADIATOR COOLER. *TT |
| Bulletin Number: 5203 |
| SOME VEHICLES MAY EXHIBIT A HARD START / LONG CRANK, COLD START STALL, COLD ROUGH IDLE CONCERN. *TT |
| Bulletin Number: 5518 |
| INFORMATION ON SERVICING OIL PAN GASKET LEAKS. *TT |
| Bulletin Number: 6392 |
| SOME VEHICLES MAY EXHIBIT ABS (ANTI-LOCK BRAKE SYSTEM) LOW SPEED FALSE ACTIVATION WITH NO (DTC) DIAGNOSTIC TROUBLE CODE. *TT |
| Bulletin Number: 6996 |
| INFORMATION REGARDING A CHANGE IN THE TORQUE VALUES OF THE ENGINE FRONT COVER WATER PUMP BOLTS. *TT |
| Bulletin Number: 6997 |
| SOME SERVICE MANUALS MAY LIST THE INCORRECT CAMSHAFT POSITION SENSOR ALIGNMENT TOOL FOR VEHICLES WITH VARIOUS ENGINE SIZES. *TT |
| Bulletin Number: 7120 |
| SOME VEHICLES MAY EXHIBIT BLACK SOOT EMITTED FROM THE TAILPIPE LEAVING DEPOSITS ON RIGHT REARL LOWER QUARTER PANEL. *TT |
| Bulletin Number: 8249 |
| SOME VEHICLES MAY EXHIBIT THE METAL TABS ON THE LIFTGATE INNER PANEL THAT BOND TO THE OUTER SKIN SEPARATING AND CAUSING A RATTLE IN THE LIFTGATE. *TT |
| Bulletin Number: 870197 |
| INCORRECTLY INSTALLED GEAR DRIVEN CAMSHAFT POSITION (CMP) SENSOR SYNCHRONIZER ASSEMBLIES CAUSING SURGE, LOST OF POWER, MALFUNCTION INDICATOR LAMP ON AND DIAGNOSTIC TROUBLE CODES P1336, P1309 AND P0340. *TT |
| Bulletin Number: 96221 |
| WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW |
| Bulletin Number: 962214 |
| SERVICE MANUAL - POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON BOARD DIAGNOSIS II (OBD II) - COVER PAGE REPLACEMENT TO INCLUDE 1997 WINDSTAR. *TW |
| Bulletin Number: 96222 |
| BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW |
| Bulletin Number: 96225 |
| MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW |
| Bulletin Number: 96246 |
| WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW |
| Bulletin Number: 96249 |
| TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW |
| Bulletin Number: 962612 |
| TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW |
| Bulletin Number: 962613 |
| TRANSAXLE - AX4S - EXTENDED 2-3 SHIFT AND/OR HIGHER THAN EXPECTED ENGINE RPM DURING 2-3 SHIFT AT LIGHT TO MEDIUM THROTTLE AND/OR NO 2-3 SHIFT - VEHICLES EQUIPPED WITH 3.0L ENGINE - SERVICE TIP. *TW |
| Bulletin Number: 97110 |
| SUSPENSION-DIAGNOSTIC AAN INSPECTION FOR FRONT SUSPENSION NOISE (S)- SERVICE TIP. *AK TIP. |
| Bulletin Number: 971110972311 |
| CONDITIONS WITH NOISE COMING FROM THE RIGHT UPPER A-PILLAR AREA DURING TURNS. *YC |
| Bulletin Number: 97111097234 |
| VEHICLES EXHIBITING A "SQUEAKING" OR "CHIRPING" FROM THE BLOWER MOTOR AT LOW BLOWER MOTOR SPEEDS. *YC |
| Bulletin Number: 97111097237 |
| CONCERNS WITH HARSH ENGAGEMENTS AND HARSH SHIFTS WITH DIAGNOSTIC TROUBLE CODES (DTCS) 628, P0741 AND/OR P1744. *YC |
| Bulletin Number: 97115 |
| SERVICE MANUAL- POWERTRAIN CONTROL/EMISSIONS DIAGNOSIS (PC/ED) ON-BOARD DIAGNOSIS II (OBD II)- COVER PAGE REPLACEMENT TO INCLUDE 1997 VEHICLES WITH FD1060 OR FD1460 ENGINE. *JD |
| Bulletin Number: 97120897251 |
| THE FRONT END ACCESSORY DRIVE (FEAD) BELT MAY SLIP MOMENTARILY IN WET CONDITIONS CAUSING A REDUCTION IN POWER STEERING ASSIST OR THE GENERATOR LAMP. *YC |
| Bulletin Number: 97211 |
| BRAKES - ANTI-LOCK - ABS PUMP MOTOR ACTIVATION WHILE BRAKING OVER A BUMP OR AN INCLINE - VEHICLES WITH TRACTION CONTROL - VEHICLES BUILT THROUGH 9/15/96. *TW |
| Bulletin Number: 9735 |
| AIR CONDITIONING- R-134A TRACER DYE INSTALLED IN A/C SYSTEM AND THREE O-RING SPRING LOCK COUPLERS- SERVICE TIP. *JD |
| Bulletin Number: 9751 |
| INTERIOR- LEATHER SEAT CLEANING PROCEDURE- SERVICE TIP. *JD |
| Bulletin Number: 97511 |
| FLUID- TRANSMISSION FLUID USAGE CHARTS. *JD |
| Bulletin Number: 97516 |
| ENGINE- 3.8L - "CHIRPING" NOISE DURING NORMAL ENGINE OPERATION. *JD |
| Bulletin Number: 97610 |
| BLOWER MOTOR- "CHIRPING" OR "SQUEAKING" FROM BLOWER MOTOR AT LOW SPEEDS. *JD |
| Bulletin Number: 97624 |
| AIR CONDITIONING- WATER DRIPPING ONTO FLOOR DRAIN TUBE DURING A/C SYSTEM OPERATION. *JD |
| Bulletin Number: 9768 |
| FUEL ECONOMY- CUSTOMER EXPECTATIONS VERSUS VEHICLE USAGE. *JD |
| Bulletin Number: 9775 |
| HOOD- SERVICE REPAIR TIPS. *JD |
| Bulletin Number: 980304 |
| INTERMITTENT NO FORWARD ENGAGEMENT WITH OR WITHOUT DTC P1784 ACTION. *AK |
| Bulletin Number: 980311 |
| CHECK ENGINE LAMP ON AND MISFIRE DTC (S) P0300-P0306. *YC |
| Bulletin Number: 98-0316 |
| CONCERNS WITH SLOW FUEL FILL, DISTORTED FUEL TANK, FUEL GAGE ERRATIC, FUEL ODOR. *TT |
| Bulletin Number: 9811349 |
| VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT |
| Bulletin Number: 9811484 |
| SOME HIGH MILEAGE VEHICLE MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *TT |
| Bulletin Number: 98125 |
| VEHICLE MAY EXHIBIT A "WHISTLING" NOISE HEARD FROM THE A/C PLENUM. *TT |
| Bulletin Number: 98127 |
| EXPERIENCING ACCELERATOR PEDAL "BUZZING" NOISE AND / OR EXHAUST "DRONING" NOISE AT APPROXIMATELY 1700 RPM WHLE DRIVING. *TT |
| Bulletin Number: 9814 |
| SUBJECT REGARDING THE AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *TT |
| Bulletin Number: 981512 |
| A DIRECT REPLACEMENT PART FOR THE EVAPORATIVE EMISSION CANISTER AND BRACKET ASSEMBLY. AK |
| Bulletin Number: 981519 |
| TRACTION CONTROL LAMP FLASING INTERMITTENTLY WITH DIAGNOSTIC TROUBLE CODES U1009 AND/OR U1027. *AK |
| Bulletin Number: 98153 |
| THIS TSB IS BEING REPUBLISHED IN ITS ENTIRETY TO REVISE THE POWER TRAIN CONTROL MODULE (PCM) CALIBRATION CROSS REFERENCE AND REVISE PCM SERVICE PART NUMBERS. *AK |
| Bulletin Number: 981617 |
| FLOOR MAT INSTALLATION PROCEDURE SERVICE TIP. YD |
| Bulletin Number: 982010 |
| EXPERIENCING A " BUZZING " OR " RATTLING " NOISE FROM THE EXHAUST SYSTEM. *YC |
| Bulletin Number: 982011 |
| CONCERNS OF WEBBING TWISTS OR BINDS ON INTEGRATED CHILD SAFETY SEAT (ICS) BELT. *YC |
| Bulletin Number: 98221 |
| INTERMITTENT NEUTRAL CONDITION AFTER DRIVING AND COMING TO A STOP. *YC |
| Bulletin Number: 982310 |
| MASS AIR FLOW (MAF)- SENSOR CONTAMINATION- SERVICE TIP. *AK |
| Bulletin Number: 98246 |
| FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| Bulletin Number: 982465 |
| SOME VEHICLES MAY EXHIBIT REAR DRUM BRAKES THAT DRAG OR WILL NOT RELEASE PROPERLY WHEN OPERATED IN WET CONDITIONS AND / OR BELOW FREEEZING TEMPERATURES. *YC |
| Bulletin Number: 982511 |
| SERVICE TIPS ON COMPOSITE FUEL RAIL. *YC |
| Bulletin Number: 982512 |
| SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN OF INOPERATIVE OVERDRIVE CANCEL LIGHT. *YC |
| Bulletin Number: 982535 |
| EXHIBITING A CUSTOMER CONCERN OF REAR END NOISE OVER BUMPS. *YC |
| Bulletin Number: 98259 |
| SOME VINYL COVERED ITEMS SUCH AS DASH PANELS, DOOR TRIM PANELS, CONSOLES, ETC., MAY EXHIBIT A SMALL DENT, SCUFF, ABRASION AND/ OR DISCOLORATION RESULTING FROM ASSEMBLY, TRANSIT, DEALER PREP AND/OR CUSTOMER USAGE. *YC |
| Bulletin Number: 982675 |
| A REVISED FORWARD CLUTCH INNER SEAL FOR THE AXOD, AXODE, AX4S & AX4N TRANSAXLE IS AVAILABLE WITH IMPROVED SEALING AND REDUCED CHANCE OF THE SEAL ROLLING DURING INSTALLATION. *YC |
| Bulletin Number: 982677 |
| SOME VEHICLES MAY EXHIBIT A HIGH PITCH WHISTLE FROM THE HEATER CORE HOUSING CASE. *YC |
| Bulletin Number: 983094 |
| SOME VEHICLES WITH POWER DOOR LOCKS MAY EXHIBIT AN INTERMITTENT OPERATION OR GRIND WHEN CYCLED. *TT |
| Bulletin Number: 9831 |
| REPAIRS TO VINYL COVERED SURFACES. *YC |
| Bulletin Number: 983101 |
| SOME VEHICLES MAY EXHIBIT A NOISE WHILE TURNING OR BRAKING. *TT |
| Bulletin Number: 983108 |
| EFFECTIVE MARCH 2, 1998M3.8L ENGINE ASSEMBLY IS ADDED TO FQR(FORD QUALITY RENEWAL) ASSEMBLY PROGRAM. *AK |
| Bulletin Number: 9833 |
| SERVICE TIPS FOR SURFACE DEFECT REMOVAL WITHOUT REPAINTING. *YC |
| Bulletin Number: 983303 |
| CONCERNS OF BROKEN AND OR BINDING BLEND DOOR. *TT |
| Bulletin Number: 983581 |
| SOME VEHICLES MAY EXHIBIT CONDITIONS OF EXHAUST DRONE AT 1700 RPM. *TT |
| Bulletin Number: 98416 |
| EXPERIENCING A GRINDING NOISE OR INOPERATIVE DOOR LOCK MAY OCCUR WHEN CYCLING THE POWER FRONT DOOR LOCKS ON SOME VEHICLES. *TT |
| Bulletin Number: 9845 |
| AVAILABILITY OF HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT. *YC |
| Bulletin Number: 98-4723 |
| ENGINE CHECK LAMP ON, AND MISFIRE DTC (S) PO300-PO306 ACTION. |
| Bulletin Number: 985020 |
| SOME VEHICLES BUILT THROUGH 9/8/97 MAY EXHIBIT A CONDITION OF MULTIPLE DIAGOSTIC TROUBLE CODES. THIS MAY BE CAUSED BY BRAKE FLUID AND WATER CONTAMINATION OF CIRCUIT 361 AND CONNECTOR C102 UNDER THE MASTER CYLINDER. *AK |
| Bulletin Number: 985086 |
| SOME VEHICLES MAY EXHIBIT A CUSTOMER CONCERN DESCRIBED AS AN AIR CONDITIONER HISS NOISE. *TT |
| Bulletin Number: 985137 |
| SOME VEHICLES MAY EXHIBIT A FRONT END GRIND / CRUNCH NOISE DURING A SLOW SPEED TURN. *TT |
| Bulletin Number: 98515 |
| SOME VEHICLES MAY EXHIBIT A SQUEAKING, RATTLING, CHIRPING, TICKING AND / OR BUZZING NOISE HEARD FROM THE INSTRUMENT PANEL AREA. *YC |
| Bulletin Number: 9852 |
| INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| Bulletin Number: 9855 |
| WET CARPET AND/OR HEADLINER IN CARGO AREA. *YC |
| Bulletin Number: 985A11 |
| SERVICE TIP INFORMATION REGARDING ELIMINATION OF SANDING ROTORS AND DRUMS. *YC |
| Bulletin Number: 985A28 |
| SOME VEHICLES EXPERIENCE THE PARKING BRAKE MAY NOT RELEASE. *YC |
| Bulletin Number: 985A48 |
| ON SOME VEHICLES THE ANTI-LOCK BRAKE SYSTEM (ABS) PUMP MOTOR MAY RUN WHILE APPLYING THE BRAKE WHEN TURNING AND DRIVING OVER A BUMP. *TT |
| Bulletin Number: 985A5 |
| HUB-MOUNT BRAKE ROTOR MACHINING EQUIPMENT FROM ROTUNDA IS NOW APPROVED FOR WARRANTY AND SERVICE USE. *YC |
| Bulletin Number: 9864 |
| INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| Bulletin Number: 9873 |
| EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| Bulletin Number: 9888 |
| INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
| Bulletin Number: 99111 |
| INFORMATION DESIGNED TO AID IN THE DIAGNOSIS, TESTING AND REPAIR OF NOISE, VIBRATION AND HARSHNESS (NVH) CONCERNS. *TT |
| Bulletin Number: 991210 |
| FORD MOTOR COMPANY HAS RELEASED A PRIVATE LABELED MATERIAL TO BE USED FOR IRON PARTICLE / ACID RAIN SERVICE REPAIRS. *TT |
| Bulletin Number: 99129 |
| EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| Bulletin Number: 9913073 |
| CLIMATE CONTROL IS INVESTIGATING CONCERNS OF BROKEN AND / OR BINDING BLEND DOORS. *TT |
| Bulletin Number: 99131 |
| CONCERNS WITH ENGINE COOLANT LEAKING INTO ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 99139 |
| CONDITIONS WITH THE BRAKE LAMPS INADVERTENTLY DISABLING THE BRAKE SHIFT INTERLOCK. *TT |
| Bulletin Number: 99152 |
| INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| Bulletin Number: 99183 |
| SERVICE TIP INFORMATION ON REVISED OIL PAN GASKET REPLACEMENT PROCEDURE. *TT |
| Bulletin Number: 99184 |
| SOME VEHICLES EQUIPPED WITH AX4S TRANSAXLE, MAY EXHIBIT A HARSH 2-3 DOWNSHIFT MAY OCCUR WHEN COASTING AROUND A CORNER AND THEN ACCELERATING. *TT |
| Bulletin Number: 99194 |
| INFORMATION FOR SERVICING AND DIAGNOSING BRAKE VIBRATION, BRAKE INSPECTION, AND BRAKE FRICTION MATERIAL REPLACEMENT. *TT |
| Bulletin Number: 99195 |
| SERVICE INFORMATION FOR MUSTY AND MILDEW TYPE ODORS COMING FROM THE AIR CONDITIONING / HEATING SYSTEM. *TT |
| Bulletin Number: 99196 |
| INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| Bulletin Number: 99207 |
| SUBJECT ON ENGINE COOLANT LEAKING INTO THE ENGINE OIL ON SOME VEHICLES. *TT |
| Bulletin Number: 99222 |
| SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| Bulletin Number: 9943 |
| INFORMATION REGARDING REPROGRAMMING POWERTRAIN CONTROL MODULES (PCMS). *TT |
| Bulletin Number: 996735 |
| SOME VEHICLES EQUIPPED WITH THE AX4S TRANSAXLE MAY EXHIBIT A HARSH 3-2 DOWNSHIFT WHEN COASTING AROUND A CORNER AND THEN STEPPING INTO THE THROTTLE TO ACCELERATE AWAY FROM THE CORNER. *TT |
| Bulletin Number: 99-8-15 |
| SUBJECT REGARDING DOOR TRIM PANEL REPLACEMENT - SERVICE TIP. *TT |
| Bulletin Number: 99816 |
| FORD MOTOR COMPANY NOW RECOMMENDS SAE 5W-30 VISCOSITY GRADE FOR SERVICING ANY FORD GASOLINE-POWERED VEHICLE REGARDLESS OF MODEL YEAR. *TT |
| Bulletin Number: BC0011970201 |
| A BUZZ NOISE IN AX4S TRANSAXLES ON 1996/97 TAURUS/SABLE AND WINDSTARS. *JD |
| Bulletin Number: BC0011972301 |
| BUZZ NOISE IN AX4S TRANSAXLES. *JD |
| Bulletin Number: BC0083970201 |
| IF RED BRAKE LAMP OR THE YELLOW ABS LAMP IS ON, VERIFY THE MASTER CYLINDER IS FULL WITH BRAKE FLUID. *JD |
| Bulletin Number: BC0122970201 |
| UNIQUE COLD START UP STRATEGY THAT WILL RAISE INITIAL COLD FAST IDLE TO 2100 RPM. *JD |
| Bulletin Number: BC0141970201 |
| VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD |
| Bulletin Number: BC0680961024 |
| VEHICLES SHIPPED W/ LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC0990961021 |
| INFORMATION ON ENGINE OIL LEAK AT THE OIL PAN, FRONT COVER &/OR THE FRONT & REAR CRANKSHAFT OIL SEAL. *TT |
| Bulletin Number: BC101209702 |
| VERIFY THE TRANSAXLE INSTALLED IN THE VEHICLE IS THE CORRECT MODEL AND MODEL YEAR FOR THE VEHICLE. *JD |
| Bulletin Number: BC1013097020 |
| COLD START UP STRATEGY THAT WILL RAISE INITIAL COLD FAST IDLE TO 2100 RPM. *JD |
| Bulletin Number: BC1013697020 |
| INOPERTIVE AUTOLOCK SYSTEM. *JD |
| Bulletin Number: BC1014497020 |
| COMPLAINTS OF THE RED BRAKE LAMP OR THE YELLOW ABS LAMP ON, CHECKING THE MASTER CYLINDER BRAKE FLUID LEVEL SHOULD BE THE FIRST STEP. *JD |
| Bulletin Number: BC1016397230 |
| BUZZ NOISE IN AX4S TRANSAXLES AT ALL SPEEDS OR IDLE ON VEHICLES. *JD |
| Bulletin Number: BC1017197230 |
| VEHICLES BUILT BETWEEN 2/95 AND 9/01/96 MAY EXPERIENCE ROUGH/HARSH OR IRREGULAR SHIFTS DUE TO WATER ENTRY INTO THE TRANSAXLE RANGE SENSOR. *JD |
| Bulletin Number: BC1022097230 |
| ADAPTERS ARE AVAILABLE TO CONVERT WINDSTAR "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE TO ALLOW THE USE AFTER MARKET BOOTED WINTER BLADES. *JD |
| Bulletin Number: BC1024997230 |
| A HARSH 1-2 SHIFT ON LIGHT THROTTLE, AT NORMAL SHIFT SPEEDS OF 10-15 MPH. *JD |
| Bulletin Number: BC1031597020 |
| POWER STEERING LINE LEAKS ON 95/96 3.8L TRAILER TOW EQUIPPED TUBE AND FIN COOLER SYSTEMS SEE OASIS MESSAGE 4685. *JD |
| Bulletin Number: BC105909705 |
| INSTRUCTIONS ON HOW TO IDENTIFY FUEL TANK SIZES. *TW |
| Bulletin Number: BC2295970501 |
| INSTRUCTIONS ON HOW TO IDENTIFY 20 GALLON OR 25 GALLON FUEL TANKS - 1996 SERVICE MANUAL INCORRECTLY LISTS FUEL TANK AT 16 GALLONS. *TW |
| Bulletin Number: BC2380970501 |
| HARSH 1-2 UPSHIFT. *TW |
| Bulletin Number: BC3274970207 |
| REPLACEMENT HEADLAMP BULBS - SEVERAL AFTERMARKET COMPANIES ARE OFFERING REPLACEMENT BULBS WITH A HIGHER WATTAGE THAT ARE NOT DOT APPROVED - SOLD WITH DISCLAIMER OF "FOR OFF-ROAD USE ONLY" - THE BULBS DRAW MORE CURRENT THAN THE OEM BULBS A |
| Bulletin Number: BC3370972301 |
| THE ILLUMINATION OF MALFUNCTION INDICATOR LIGHT, ON AND DIAGNOSTIC TROUBLE CODES P1131, P1151, P1132, P1152. *JD |
| Bulletin Number: BC3381972301 |
| ADAPTERS ARE AVAILABLE TO CONVERT VEHICLE "J HOOK" WINDSHIELD WIPER ARMS TO A CONVENTIONAL PIN STYLE. *JD |
| Bulletin Number: BC5197961001 |
| SOME VEHICLES EQUIPPED W/ AN AX4S TRANSAXLE MAY HAVE BEEN SHIPPED W/ A LOW TRANSAXLE FLUID LEVEL. *TT |
| Bulletin Number: BC9666961001 |
| 2.5L DURATEC ENGINE EXCHANGES NO LONGER INCLUDE FRONT END ACCESSORY DRIVE COMPONENT, OIL LEVEL INDICATOR, WATER PUMP BELT/TENSIONER, EGR TUBE, LINKSHAFT BRACKET OR EXHAUST MANIFOLDS. *TT |
| Bulletin Number: BPI9904 |
| CONDITIONS WITH THE TRAC OFF LAMP ILLUMINATING INTERMITTENTLY AND THER MAY ALSO BE STORED TROUBLE CODES U1009 AND / OR U1027. |
| 1997 FORD ZX2 (ESCORT) |
|---|
| Bulletin Number: 0059 |
| SUBJECT CONCERNING THE IDLE-VIBRATION- 2.0L AND ZETEC ENGINES- SERVICE TIP. *MJS |
| Bulletin Number: 0069 |
| SOME VEHICLES MAY EXHIBIT A GRINDING NOISE WHILE BRAKING, BRAKE DRAG AND/OR UNEVEN FRONT BRAKE PAD WEAR MAY OCCUR. *MJS |
| Bulletin Number: 12295 |
| SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LIGHT ON, STALL AT TIP-IN FROM IDLE, ENGINE HESITATION, AND / OR SURGE CAUSED BY THE MASS AIR FLOW (MAF) SENSOR. *TT |
| Bulletin Number: 12594 |
| SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR (TR). *TT |
| Bulletin Number: 12834 |
| BRIEF INFORMATION REGARDING TRANSMISSION FLUID. *TT |
| Bulletin Number: 13160 |
| VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MALFUNCTION INDICATOR LAMP ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGER SENSOR (TRS). *TT |
| Bulletin Number: 13162 |
| SOME VEHICLES MAY EXHIBIT A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT |
| Bulletin Number: 15256 |
| SOME VEHICLES WITH AUTOMATIC TRANSAXLES MAY EXHIBIT A CLUNK NOISE ON INITIAL REVERSE ENGAGEMENT COLD. *TT |
| Bulletin Number: 5381 |
| BRIEF INFORMATION STATING THAT THE NGS FUEL ECONOMY TEST ON SOME VEHICLES MAY NOT FUNCTION PROPERLY. *TT |
| Bulletin Number: 6416 |
| BRIEF INFORMATION REGARDING TRANSMISSION FLUID APPEARANCE. *TT |
| Bulletin Number: 6932 |
| SOME VEHICLES MAY EXHIBIT TRANSMISSION AND / OR MIL ON CONCERNS RELATING TO THE DIAGNOSIS AND REPLACEMENT OF THE TRANSMISSION RANGE SENSOR. *TT |
| Bulletin Number: 6934 |
| CONCERNS WITH A MALFUNCTION INDICATOR LIGHT ON WITH A DIAGNOSTIC TROUBLE CODE P1744. *TT |
| Bulletin Number: 98204 |
| A PORTION OF FOAM TAPE AT THE WINDSHIELD AND INSTRUMENT PANEL (I/P) MAY BE STICKING OUT ON SOME VEHICLES. *YC |
