Hyundai Buyers Guide

 

Click a car name to see the crash test details for that model.

 

 

 

Crash Test Data for 2000 Hyundai

Hyundai Vehicle Front Star Rating Side Star Rating Rollover Resistance Rating
Driver Passenger Front Seat Rear Seat
2000 ElantraNot
Tested
2000 SonataNot
Tested
Not
Tested
Not
Tested

 

Service Bulletins for 2000 Hyundai

2000 HYUNDAI ACCENT
Bulletin Number: 0030004
SUBJECT REGARDING (DIAGNOSTIC TROUBLE CODE) DTC DIAGNOSTIC FLOW CHART FOR P1611 AND P1613. *TT
Bulletin Number: 0030005
INFORMATION REGARDING THE FUEL PUMP ASSEMBLY. *TT
Bulletin Number: 0036009
SUBJECT REGRDING DIAGNOSING TPS RELATED CODES SHOP MANUAL CORRECTION. *TT
Bulletin Number: 0040008
SUBJECT REGARDING THE AUTOMATIC TRANSAXLE TESTER I DESIGNED TO TROUBLESHOOT THE NEW GENERATION TRANSAXLE FOR ALL 2000 MODELS. *TT
Bulletin Number: 0040016
SUBJECT REGARDING MANUAL TRANSAXLE SHIFT FEEL IMPROVEMENT - SERVICE KIT PARTS. *TT
Bulletin Number: 0040017
SUBJECT REGARDING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 0050004
THIS BULLETIN PROVIDES INSTALLATION PROCEDURES FOR THE MOUNTING BUSHINGS FITTED TO THE FRONT SUSPENSION CROSS MEMBER. *TT
Bulletin Number: 0060003
THIS BULLETIN DESCRIBES THE REPAIR FOR A RATTLE OR CREAK NOISE HEARD INSIDE THE VEHICLE FROM THE DOOR HINGE AREAS. *TT
Bulletin Number: 00600031
THIS REVISED BULLETIN DESCRIBES THE REPAIR FOR A RATTLE OR CREAK NOISE HEARD INSIDE THE VEHICLE FROM THE DOOR HINGE AREAS. THE NOISE MAY OCCUR ON ALL FOUR DOORS. *TT
Bulletin Number: 0090001
INFORMATION ON REVERSING THE WIRES IN THE SPOILER EXTENSION WIRE HARNESS TO MATCH THE VOLTAGE POLARITY OF THE LIGHT EMITTING DIODES (LEDS) IN THE SPOILER BRAKE LIGHT. FAILURES TO REVERSE THE WIRES WILL RESULT IN AN INOPERABLE SPOILER BR
Bulletin Number: 0097001
THIS BULLETIN PROVIDES UPDATED INFORMATION AND CORRECTIONS TO THE 2000MY ACCENT AIR CONDITIONER KIT INSTALLATION PROCEDURES. *TT
Bulletin Number: 010101
INFORMATION ON PERFORMING A TEST DRIVE FOR TRANSAXLE SHIFT QUALITY. *TT
Bulletin Number: 0136010
INFORMATION REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH
Bulletin Number: 01360101
SUBJECT REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH
Bulletin Number: 0136013
SUBJECT ON REGARDING ECM REPROGRAMMING FOR POOR ACCELERATION CONDITION. *YH
Bulletin Number: 0136014
SOME VEHICLES MAY EXPERIENCE VERY INTERMITTENT CRANK-NO-START; THE CHECK ENGINE LIGHT DOES NOT LIGHT UP AS NORMALLY IS DOES; THE HI-SCAN PRO CANNOT COMMUNICATE WITH THE ENGINE CONTROL MODULE. *TT
Bulletin Number: 01400061
AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 AND P0722 - REVISED. *JG
Bulletin Number: 0201010
FRONT A-PILLAR BRACKET INSTALLATION (CAMPAIGN 055). *TT
Bulletin Number: 02010101
FRONT A-PILLAR BRACKETS - (CAMPAIGN 055). *TT
Bulletin Number: 0236018
SUBJECT REGARDING ELECTRONIC CONTROL MODULE REPROGRAMMING TO IMPROVE ACCELERATION AFTER AN INITIAL COLD START. *JG
Bulletin Number: 0240010
SUBJECT ON AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK REVERSE OR PARK DRIVE ENGAGEMENT. *YH
Bulletin Number: 0240012
SUBJECT REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH
Bulletin Number: 0240014
SUBJECT REGARDING AUTOMATIC TRANSAXLE BELLHOUSING COVER. *JG
Bulletin Number: 0240017
SUBJECT REGARDING DIAGNOSTIC TROUBLE CODE P0722 - PULSE GENERATOR - B INSPECTION AND TRANSMISSION CONTROL MODULE REPROGRAMMING INSTRUCTIONS. *JG
Bulletin Number: 0240020
SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG
Bulletin Number: 0336017
SLOWER THAN USUAL ACCELERATION AFTER AN INITIAL COLD START; GREATER THAN USUAL RPM DROP WHEN ENGAGING DRIVE OR REVERSE; CHECK ENGINE LIGHT ON AND P0116 STORED. *TT
Bulletin Number: 0336024
RESISTANCE VALUES FOR IDLE SPEED CONTROL ACTUATOR (ISCA). VARIOUS MODELS INCLUDING THE 2004 SONATA. *TT
Bulletin Number: 0340001
ATM DIODE PIN CORROSION IN THE CONTROL WIRING HARNESS LOCATED BEHIND THE DASH PANEL. *TT
Bulletin Number: 0340007
ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0745, P0747, P0748, P0750, P0752, P0753, P0755, P0757, P0758, P0760, P0765. *TT *MJ
Bulletin Number: 0340016
DIAGNOSTIC TROUBLE CODE (DTC) P0722 - PULSE GENERATOR-B INSPECTION AND TCM REPROGRAMMING. *TT
Bulletin Number: 0340022
AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 & P0722. 2004 ACCENT INCLUDED. *TT
Bulletin Number: 0497002
FD46XG PAG OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *TT
Bulletin Number: 0536003
DIAGNOSTIC TROUBLE CODE (DTC) P0130 (OXYGEN SENSOR MALFUNCTION); DIAGNOSTIC TROUBLE CODE (DTC) P0503 (SPEED SENSOR MALFUNCTION; REVERSE TO DRIVE LURCH WHILE ROLLING BACKWARDS (ON AUTOMATIC TRANSAXLE EQUIPPED VEHICLES ONLY). *TT
Bulletin Number: 05360031
2000-2004 1.5L & 1.6L ACCENT P0130 (OXYGEN SENSOR) AND P0530 (SPEED SENSOR). *SC
Bulletin Number: 0540018
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT
Bulletin Number: 0640019
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODE (DTC) LIST. *KB
Bulletin Number: 0804
FD46XG POLY ALKYLEN GLYCOL (PAG) OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *NM
Bulletin Number: 0804
REPLACEMENT CIGARETTE LIGHTER. *NM
Bulletin Number: 113
INFORMATION REGARDING CRANK-NO-START CAUSED BY SHORT IN THE MAIN HARNESS FOR DASH FUSE #5 CIRCUIT. *YH
Bulletin Number: 151
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT
Bulletin Number: 158
REPROGRAMS ARE AVAILABLE FOR AUTOMATIC TRANSAXLE DRIVEABILITY ISSUES. TECHNET TIMES. HYUNDAI. *TT
Bulletin Number: 9900007
THIS BULLETIN HAS PROCEDURES DESCRIBING HOW TO CONNECT THE POWER CONNECTOR DURING THE PDI PROCESS. *TT
Bulletin Number: 9930004
THIS BULLETIN PROVIDES FUEL PUMP CHECK CONNECTOR LOCATIONS FOR VARIOUS VEHICLES. *TT
Bulletin Number: TSB-09-AT-013
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP
2000 HYUNDAI ELANTRA
Bulletin Number: 0001006
SUBJECT REGARDING MASS AIR FLOW SENSOR CONNECTOR REPLACEMENT CAMPAIGN. *TT
Bulletin Number: 0020004
ON SOME VEHICLES, A NOISE MAY BE HEARD FOR THE FIRST FEW MINUTES AFTER STARTING AND DRIVING IN COLD WEATHER FROM THE ENGINE COMPARTMENT. *TT
Bulletin Number: 0040017
SUBJECT REGARDING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 010101
INFORMATION ON PERFORMING A TEST DRIVE FOR TRANSAXLE SHIFT QUALITY. *TT
Bulletin Number: 01400061
AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 AND P0722 - REVISED. *JG
Bulletin Number: 0236028
OBD-II READINESS TEST DRIVE CYCLE. *TT
Bulletin Number: 0240010
SUBJECT ON AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK REVERSE OR PARK DRIVE ENGAGEMENT. *YH
Bulletin Number: 0240012
SUBJECT REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH
Bulletin Number: 0240016
SUBJECT REGARDING AUTOMATIC TRANSAXLE OIL LEAKING FROM OIL PAN GASKET. *JG
Bulletin Number: 0240020
SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG
Bulletin Number: 0240024
IMPROVED CLUTCH RELEASE SHAFT UPPER AND LOWER BUSHING. *TT
Bulletin Number: 0250002
SUBJECT REGARDING FRONT BRAKE CALIPER RATTLE NOISE REPAIR KIT. *TT
Bulletin Number: 0290009
SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG
Bulletin Number: 0340007
ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0745, P0747, P0748, P0750, P0752, P0753, P0755, P0757, P0758, P0760, P0765. *TT *MJ
Bulletin Number: 0340022
AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 & P0722. 2004 ACCENT INCLUDED. *TT
Bulletin Number: 0380003
INTERIOR DOOR TRIM PANEL FABRIC REPAIR. *TT
Bulletin Number: 0501001
EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN - V04. *TT
Bulletin Number: 0501001
EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN. *EH
Bulletin Number: 0540018
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT
Bulletin Number: 061000
SUBJECT REGARDING CAMPAIGN 040 - MASS AIR FLOW SENSOR CONNECTION RECALL CAMPAIGN. *TT
Bulletin Number: 091000
SUBJECT REGARDING A VOLUNTARY CUSTOMER NOTIFICATION (MASS AIR FLOW SENSOR CONNECTION RECALL CAMPAIGN) ON CERTAIN VEHICLES MANUFACTURED BETWEEN JUNE 1, 1999 AND JUNE 16, 2000. *TT
Bulletin Number: 151
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT
Bulletin Number: 5NP-S9D9P-10
THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT).
Bulletin Number: 9901003
THIS TSB PROVIDES INFORMATION REGARDING THE LOCATION AND CORRECT INFORMATION OF THE EMISSION LABELS. *TT
Bulletin Number: TSB-09-AT-013
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP
Bulletin Number: V04
EXHAUST NOISE COMING FROM THE ENGINE COMPARTMENT. VOLUNTARY SERVICE CAMPAIGN V04 INVOLVES INSPECTING AND, IF NECESSARY, REPLACING THE EXHAUST MANIFOLD. *TT
2000 HYUNDAI HYUNDAI
Bulletin Number: 0097002
INFORMATION DESCRIBING THE REVISED SYSTEM OPERATION OF THE DEFROST AND DEFROST / FLOOR MODES FOR ALL 2000 MODELS. *TT
Bulletin Number: 14092001
INFORMATION REGARDING ALIGNMENT SPECIFICATIONS(DEGREES)CHART. ALL MODELS. *YD
Bulletin Number: 9900005
INFORMATION CONCERNING THE VEHICLE IDENTIFICATION NUMBERS OF ALL MODELS THAT HAVE BEEN SOLD IN THE UNITED STATES. *TT
Bulletin Number: 9900006
INFORMATION REGARDING A CHANGE IN SHOP MANUAL FORMAT FOR MANUAL AND AUTOMATIC TRANSAXLES. *TT
Bulletin Number: 990312
SUBJECT REGARDING SP-IIM AUTOMATIC TRANSAXLE FLUID TO IMPROVE TRANSFER DRIVE CLUTCH PERFORMANCE ON 4WD VEHICLES. *TT
Bulletin Number: 9909010
INFORMATION DESCRIBING AN AUDIO SYSTEM CONNECTOR REPLACEMENT. *TT
Bulletin Number: 9940016
INFORMATION REGARDING A CHANGE IN THE SHOP MANUAL FORMAT FOR MANUAL AND AUTOMATIC TRANSAXLES. *TT
Bulletin Number: 9950008
INFORMATION ISSUED TO COMMUNICATE, IN CHART FORM, THE FINAL 1999 AND THE INITIAL 2000 MODEL YEAR VEHICLE ALIGNMENT SPECIFICATIONS. *TT
Bulletin Number: 9950009
SUBJECT REGARDING TIRE INFLATION PRESSURE PRE-DELIVERY INSPECTION (PDI) INSPECTION. *TT
Bulletin Number: 9990012
HYUNDAI HAS MADE A CHANGE IN THE CONNECTOR NUMBERING FORMAT FOR ELECTRICAL TROUBLESHOOTING MANUALS. *TT
Bulletin Number: TSB-09-AT-013
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP
2000 HYUNDAI SANTA FE
Bulletin Number: DOR-T5K8Y-01
This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causin
Bulletin Number: DOR-Y5Q6Z-01
This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causin
2000 HYUNDAI SONATA
Bulletin Number: 0001005
SUBJECT REGARDING MASS AIR FLOW SENSOR CONNECTION CAMPAIGN. *TT
Bulletin Number: 0020003
EXPERIENCING A CRANK NO START, HARD STARTING AFTER FILLING WITH FUEL, OR ERRATIC IDLE SPEEDS. *TT
Bulletin Number: 0040014
INFORMATION ON DIAGNOSING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 0040015
SUBJECT REGARDING MANUAL TRANSAXLE SHIFT FEEL IMPROVEMENT KIT SERVICE PARTS. *TT
Bulletin Number: 0050006
SOME OWNERS MAY EXPERIENCE A METALLIC RUBBING NOISE HEARD FROM THE REAR SUSPENSION WHILE DRIVING THE VEHICLE OVER BUMPS OR AN UNEVEN ROUGH ROAD WITH OCCUPANTS IN THE REAR SEAT. *TT
Bulletin Number: 010101
INFORMATION ON THE ACUOSTIC WARNING SYSTEM. *TT
Bulletin Number: 01011901
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *NM
Bulletin Number: 0136009
INFORMATION REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH
Bulletin Number: 01360091
SUBJECT REGARDING SHOP MANUAL CORRECTION FOR IDLE SPEED ACTUATOR RESISTANCE CHECK. *YH
Bulletin Number: 0136016
SUBJECT REGARDING ECM NON-INTERCHANGEABILITY. *YH
Bulletin Number: 0136026
SUBJECT REGARDING V6 NITROGEN OXIDE NOX DIAGNOSIS. *JG
Bulletin Number: 0140015
SUBJECT REGARDING DUAL MASS FLYWHEEL, CLUTCH AND STARTER MOTOR PARTS INFORMATION. *YH
Bulletin Number: 0140017
SUBJECT ON REGARDING MANUAL TRANSAXLE SHIFT FEEL IMPROVEMENT. *YH
Bulletin Number: 0140018
SUBJECT REGARDING SHUDDER OR VIBRATION DURING ACCELERATION. *YH
Bulletin Number: 0140023
SUBJECT REGARDING AUTOMATIC TRANSAXLE OIL DRAIN PLUG. *YD
Bulletin Number: 01500041
SUBJECT REGARDING NOISE FROM REAR WHEELS. *YH
Bulletin Number: 0201005
SUBJECT REGARDING SIDE IMPACT AIR BAG WIRE HARNESS ROUTING CAMPAIGN. *JG
Bulletin Number: 020402
INFORMATION REGARDING SHUDDER OR VIBRATION DESCRIPTION SLIGHTLY DURING MEDIUM TO FULL THROTTLE ACCELERATION.
Bulletin Number: 0236010
SOME VEHICLES MAY EXPERIENCE CHECK ENGINE LIGHT ILLUMINATION OR DIAGNOSTIC TROUBLE CODES P0133, P0134, P1134, P0153, P0154, OR P1154. *SLC
Bulletin Number: 0236022
SUBJECT REGARDING ENGINE RPM FLUCTUATION - CRUISE CONTROL CABLE ADJUSTMENT PROCEDURE. *JG
Bulletin Number: 02360221
VEHICLES MAY EXPERIENCE ENGINE RPM FLUCTUATION - CRUISE CONTROL CABLE ADJUSTMENT PROCEDURE. *TT
Bulletin Number: 0236027
VERY BRIEF, SLIGHT HEADLAMP DIMMING CONDITION. *TT
Bulletin Number: 0236037
ECM (ENGINE CONTROL MODULE) REPROGRAMMING FOR ENGINE HESITATION IN THE MORNING AND DIAGNOSTIC TROUBLE CODE P0139. *TT
Bulletin Number: 0240005
SUBJECT REGARDING DUAL MASS FLYWHEEL, BOLT, CLUTCH AND STARTER MOTOR PARTS INFORMATION. *SLC
Bulletin Number: 0240008
VEHICLES MAY EXPERIENCE A HARSH OR DELAYED PARK-REVERSE OR PARK-DRIVE ENGAGEMENT IN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. *SLC
Bulletin Number: 0240011
INFORMATION REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH
Bulletin Number: 0240019
SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG
Bulletin Number: 0240024
IMPROVED CLUTCH RELEASE SHAFT UPPER AND LOWER BUSHING. *TT
Bulletin Number: 0240026
ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0743, P0750, P0755, P0760, P0765, P0770. *TT
Bulletin Number: 0250012
THIS BULLETIN INVOLVES INFORMATION RELATING TO A CHANGE IN THE REAR DRUM BRAKES TO REDUCE BRAKE SQUEAL/SQUEAK NOISE. *JG
Bulletin Number: 0280001
A CONDITION MAY EXIST WHERE THE FRONT DOOR GLASS DOES NOT RAISE PROPERLY OR WILL NOT STAY FULLY CLOSED AND / OR DOES NOT LOWER PROPERLY. *TT
Bulletin Number: 0290009
SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG
Bulletin Number: 03010111
2.5/2.7L V6 ENGINE TITANIUM O2 SENSORS (CAMPAIGN V01) - REVISED TSB. *TT
Bulletin Number: 03010112
2.5/2.7L V6 ENGINE TITANIUM O2 SENSORS (CAMPAIGN V01) - REVISED TSB VERSION 2. *TT
Bulletin Number: 0336019
ECM (ENGINE CONTROL MODULE) REPROGRAMMING FOR ENGINE HESITATION IN THE MORNING AND DIAGNOSTIC TROUBLE CODE P0139. *TT
Bulletin Number: 0336024
RESISTANCE VALUES FOR IDLE SPEED CONTROL ACTUATOR (ISCA). VARIOUS MODELS INCLUDING THE 2004 SONATA. *TT
Bulletin Number: 0340006
ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0750, P0755, P0760, P0765, P0770. *TT
Bulletin Number: 0340014
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODE (DTC) P1723 ACCOMPANIED WITH MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATED; TRANSAXLE HELD IN 2RD GEAR FAIL-SAFE; HARSH SHIFTS INTO REVERSE OR DRIVE. *TT
Bulletin Number: 0436006
UNSTABLE IDLE (SIMPLE DIAGNOSIS PROCEDURE FOR INTERMITTENTLY STUCK CLOSED EGR SOLENOID VALVE). *TT
Bulletin Number: 0450006
ANTI-LOCK BRAKING SYSTEM (ABS)TCS ACTIVATION MAY RESULT FROM UNDERINFLATED COMPACT SPARE TIRE. *TT
Bulletin Number: 0497002
FD46XG PAG OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *TT
Bulletin Number: 0540008
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *SC
Bulletin Number: 0550004
ABS PUMP SELF CHECK NOISE. ALSO INCLUDED: 2003-2005 MODEL XG AND 1999, 2000, 2001, 2003, 2004 AND 2005 MODEL SANTA FE. *SC
Bulletin Number: 061000
HYUNDAI MOTOR AMERICA IS CONDUCTING A VOLUNTARY CUSTOMER NOTIFICATION (SAFETY RECALL) ON CERTAIN VEHICLES EQUIPPED WITH 2.5L V-6 ENGINES PRODUCED FROM THE START OF PRODUCTION THROUGH JULY 4, 2000 INCLUSIVE, TO MAKE REPAIRS AFFECTING THE MAF
Bulletin Number: 061101
SUBJECT REGARDING FINAL DRIVE GEAR WHINE NOISE. *YH
Bulletin Number: 0636006
EXHAUST GAS RECIRCULATION (EGR) SYSTEM DIAGNOSIS. *KB
Bulletin Number: 0640018
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES (DTC) LIST. *KB
Bulletin Number: 0650003
ABS PUMP SELF-CHECK NOISE. *TT
Bulletin Number: 0804
FD46XG POLY ALKYLEN GLYCOL (PAG) OIL SPECIFICATIONS FOR AIR CONDITIONING COMPONENT REPLACEMENT. *NM
Bulletin Number: 091000
SUBJECT REGARDING A VOLUNTARY CUSTOMER NOTIFICATION (MASS AIR FLOW SENSOR CONNECTION RECALL CAMPAIGN) ON CERTAIN VEHICLES WITH V-6 ENGINES, MANUFACTURED FROM START OF PRODUCTION THROUGH JULY 4, 2000, INCLUSIVE. *TT
Bulletin Number: 117
INFORMATION ON EXHAUST GAS RECIRCULATION. *SLC
Bulletin Number: 122
SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK-REVERSE OR PARK-DRIVE ENGAGEMENT. *SLC
Bulletin Number: 133
THIRD GEAR FAIL-SAFE INFORMATION. *TT
Bulletin Number: 200502
SUBJECT REGARDING SIDE IMPACT AIR BAG WIRE HARNESS ROUTING. *JG
Bulletin Number: 24092001
INFORMATION REGARDING NOISE FROM REAR WHEELSD ,PARKING BRAKE ADJUSTMENT. *YD
Bulletin Number: 5NP-S9D9P-10
THIS BULLETIN PROVIDES INFORMATION ON COMPONENTS, ATTRIBUTES, AND PRECAUTIONS OF THE 7-SPEED DRY-TYPE DUAL CLUTCH TRANSMISSION (DCT).
Bulletin Number: 9960001
THIS TSB IS BEING ISSUED TO PROVIDE BODY DIMENSION INFORMATION. *TT
Bulletin Number: DOR-T5K8Y-01
This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causin
Bulletin Number: DOR-Y5Q6Z-01
This SKU is an Air Conditioning Bypass Pulley. The Customer communication requested return of unsold inventory to inspect for potential bracket cracking. Bracket cracks may cause the engine drive belt to slip or jump off the pulley causin
Bulletin Number: TSB-09-AT-013
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP
Bulletin Number: TSB-09-AT-018
HYUNDAI: ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0746, P0748, P0750, P0755, P0760, P0765, P0770. INCORRECT OPERATION OF THE TRANSAXLE SOLENOIDS MAY RESULT IN THE FOLLOWING SYMPTOMS-CHECK ENGINE LIGHT ILLUMINATED
Bulletin Number: TSB-11-BR-002
HYUNDAI: ALL SONATA HYBRIDS. BRAKE BLEEDING PROCEDURE. *RM
2000 HYUNDAI TIBURON
Bulletin Number: 0040008
SUBJECT REGARDING THE AUTOMATIC TRANSAXLE TESTER I DESIGNED TO TROUBLESHOOT THE NEW GENERATION TRANSAXLE FOR ALL 2000 MODELS. *TT
Bulletin Number: 0040017
SUBJECT REGARDING TRANSAXLE DIAGNOSTIC TROUBLE CODES. *TT
Bulletin Number: 0101006
SUBJECT REGARDING TIBURON SEAT BELT D-RING GUIDE STOPPER. *YD
Bulletin Number: 010101
INFORMATION ON PERFORMING A TEST DRIVE FOR TRANSAXLE SHIFT QUALITY. *TT
Bulletin Number: 01400061
AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 AND P0722 - REVISED. *JG
Bulletin Number: 0236028
OBD-II READINESS TEST DRIVE CYCLE. *TT
Bulletin Number: 0240010
SUBJECT ON AUTOMATIC TRANSAXLE HARSH OR DELAYED PARK REVERSE OR PARK DRIVE ENGAGEMENT. *YH
Bulletin Number: 0240012
SUBJECT REGARDING AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *YH
Bulletin Number: 0240016
SUBJECT REGARDING AUTOMATIC TRANSAXLE OIL LEAKING FROM OIL PAN GASKET. *JG
Bulletin Number: 0240020
SUBJECT REGARDING AUTOMATIC TRANSAXLE HARSH AND/OR DELAYED SHIFTS. *JG
Bulletin Number: 0240024
IMPROVED CLUTCH RELEASE SHAFT UPPER AND LOWER BUSHING. *TT
Bulletin Number: 0250002
SUBJECT REGARDING FRONT BRAKE CALIPER RATTLE NOISE REPAIR KIT. *TT
Bulletin Number: 0290003
INFORMATION ON RHEOSTAT ASSEMBLY REPLACEMENT. *YH
Bulletin Number: 0290009
SUBJECT REGARDING DIAGNOSTIC GUIDE FOR CLIFFORD AND DEI SECURITY SYSTEM. *JG
Bulletin Number: 0340007
ATA SOLENOID DIAGNOSTIC TROUBLE CODES P0740, P0741, P0742, P0743, P0745, P0747, P0748, P0750, P0752, P0753, P0755, P0757, P0758, P0760, P0765. *TT *MJ
Bulletin Number: 0340022
AUTOMATIC TRANSAXLE PULSE GENERATOR DIAGNOSTIC TROUBLE CODES P0717 & P0722. 2004 ACCENT INCLUDED. *TT
Bulletin Number: 0501001
EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN. *EH
Bulletin Number: 0501001
EXHAUST MANIFOLD ASSEMBLY INSPECTION AND REPLACEMENT CAMPAIGN - V04. *TT
Bulletin Number: 0540018
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT
Bulletin Number: 0804
REPLACEMENT CIGARETTE LIGHTER. *NM
Bulletin Number: 151
AUTOMATIC TRANSAXLE DIAGNOSTIC TROUBLE CODES LIST. *TT
Bulletin Number: 9901003
THIS TSB PROVIDES INFORMATION REGARDING THE LOCATION AND CORRECT INFORMATION OF THE EMISSION LABELS. *TT
Bulletin Number: TSB-09-AT-013
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP
Bulletin Number: V04
EXHAUST NOISE COMING FROM THE ENGINE COMPARTMENT. VOLUNTARY SERVICE CAMPAIGN V04 INVOLVES INSPECTING AND, IF NECESSARY, REPLACING THE EXHAUST MANIFOLD. *TT
2000 HYUNDAI XG
Bulletin Number: 0550004
ABS PUMP SELF CHECK NOISE. ALSO INCLUDED: 2003-2005 MODEL XG AND 1999, 2000, 2001, 2003, 2004 AND 2005 MODEL SANTA FE. *SC
Bulletin Number: TSB-09-AT-013
HYUNDAI: AUTOMATIC TRANSAXLE RANGE SWITCH DIAGNOSTIC TROUBLE CODES P0705 (RANGE SWITCH SIGNAL PROBLEMS), P0707 (RANGE SWITCH OPEN CIRCUIT), AND P0708 (RANGE SWITCH SHORT CIRCUIT OR MULTIPLE INPUTS). AN IMPROPERLY ADJUSTED OR IMPROPERLY OP

 

Recalls for 2000 Hyundai

2000 HYUNDAI ACCENT
NHTSA Campaign ID:VEHICLE SPEED CONTROL
Manufacturer:HYUNDAI MOTOR COMPANY
Manufacture Dates:08/30/1999 - 06/05/2001
Potential Units Affected:49371

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH 1.5 LITER OR 1.6 LITER ENGINES THAT WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, MAINE, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WHILE DRIVING AT A STEADY THROTTLE OPENING FOR AN EXTENDED PERIOD OF TIME DURING EXTREMELY COLD AMBIENT TEMPERATURES (BELOW APPROXIMATELY -5 DEGREES FAHRENHEIT WITH HIGH HUMIDITY), MOISTURE IN THE COMBUSTION CHAMBER BLOWBY GASES CAN FREEZE AND BLOCK THE POSITIVE CRANKCASE VENTILATION (PCV) VALVE AND HOSE. IF THE PCV HOSE FREEZES, COMBUSTION CHAMBER GASES ARE FORCED THROUGH THE BREATHER HOSE INTO THE AIR INTAKE HOSE AND THEN INTO THE THROTTLE BODY.

Consequence:

MOISTURE IN THE COMBUSTION CHAMBER BLOWBY GASES MAY FREEZE INSIDE THE THROTTLE BODY BORE AND THROTTLE BODY IDLE SPEED CONTROL CIRCUIT RESULTING IN THE THROTTLE VALVE NOT CLOSING FULLY AND A HIGHER THAN NORMAL IDLE SPEED WHEN THE ACCELERATOR PEDAL IS RELEASED.

Action:

DEALERS WILL INSTALL A NEW, RELOCATED PCV HOSE AND WILL ADDITIONALLY INSTALL A HEATED THROTTLE BODY ON THE 2000-2001 ACCENTS EQUIPPED WITH 1.5 LITER ENGINES THAT WERE PRODUCED THROUGH JANUARY 31, 2001. OWNER NOTIFICATION BEGAN APRIL 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
2000 HYUNDAI ACCENT
NHTSA Campaign ID:VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
Manufacturer:HYUNDAI MOTOR COMPANY
Manufacture Dates:11/11/1999 - 01/15/2000
Potential Units Affected:16264

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE PROTECTIVE RUBBER BOOT WHICH COVERS THE BALL JOINT CONNECTION BETWEEN THE WINDSHIELD WIPER MOTOR DRIVE ARM AND THE WINDSHIELD WIPER DRAG LINK CAN STICK TO THE SURFACE OF THE DRIVE ARM. IF THE RUBBER BOOT STICKS AND THE WIPER MOTOR IS TURNED ON, BINDING OF THE INTERFACE BETWEEN THE DRIVE ARM AND DRAG LINK RESULTS, CAUSING THE BALL JOINT CONNECTION TO DISENGAGE.

Consequence:

IF THE CONNECTION DISENGAGES, THE WINDSHIELD WIPERS ARE INOPERATIVE. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER.

Action:

DEALERS WILL REPLACE THE PROTECTIVE RUBBER BOOT AND WILL LUBRICATE THE NEW PROTECTIVE RUBBER BOOT WHERE IT CONTACTS THE DRIVE ARM.
2000 HYUNDAI ACCENT
NHTSA Campaign ID:STRUCTURE:FRAME AND MEMBERS
Manufacturer:HYUNDAI MOTOR COMPANY
Manufacture Dates:09/16/1999 - 10/19/2001
Potential Units Affected:67565

Defect Description:

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE 3-DOOR HATCHBACK EXCEEDED THE PERFORMANCE CRITERION IN THE STANDARD MIDWAY ALONG THE LENGTH OF THE WINDSHIELD SUPPORT PILLAR (A-PILLAR).

Consequence:

AN OCCUPANT'S HEAD THAT CONTACTS THE A-PILLAR DURING A CRASH COULD EXPERIENCE AN INCREASED RISK OF A HEAD INJURY AS A RESULT OF THIS CONDITION.

Action:

DEALERS WILL INSTALL NEW ENERGY MANAGEMENT BRACKETS TO SUPPORT THE A-PILLAR COVERS AND INCREASE THE ENERGY ABSORBING PERFORMANCE OF THE A-PILLAR IN THE RELEVANT AREA. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
2000 HYUNDAI ACCENT
NHTSA Campaign ID:VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
Manufacturer:HYUNDAI CARIBBEAN-PUERTO RICO
Manufacture Dates:11/11/1999 - 01/15/2000
Potential Units Affected:400

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE PROTECTIVE RUBBER BOOT WHICH COVERS THE BALL JOINT CONNECTION BETWEEN THE WINDSHIELD WIPER MOTOR DRIVE ARM AND THE WINDSHIELD WIPER DRAG LINK CAN STICK TO THE SURFACE OF THE DRIVE ARM. IF THE RUBBER BOOT STICKS AND THE WIPER MOTOR IS TURNED ON, BINDING OF THE INTERFACE BETWEEN THE DRIVE ARM AND DRAG LINK RESULTS, CAUSING THE BALL JOINT CONNECTION TO DISENGAGE.

Consequence:

IF THE CONNECTION DISENGAGES, THE WINDSHIELD WIPERS ARE INOPERATIVE. INOPERATIVE WINDSHIELD WIPERS CAN CONTRIBUTE TO REDUCED VISIBILITY DURING INCLEMENT WEATHER.

Action:

DEALERS WILL REPLACE THE PROTECTIVE RUBBER BOOT AND WILL LUBRICATE THE NEW PROTECTIVE RUBBER BOOT WHERE IT CONTACTS THE DRIVE ARM.
2000 HYUNDAI ELANTRA
NHTSA Campaign ID:ELECTRICAL SYSTEM:WIRING
Manufacturer:HYUNDAI MOTOR COMPANY
Manufacture Dates:06/01/1999 - 06/16/2000
Potential Units Affected:165977

Defect Description:

VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS.

Consequence:

THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS.
2000 HYUNDAI LD15 BERING
NHTSA Campaign ID:TIRES:VALVE
Manufacturer:HYUNDAI TRUCK AMERICA
Manufacture Dates:07/14/1999 - 01/19/2000
Potential Units Affected:1401

Defect Description:

ON CERTAIN CAB-OVER CLASS 4 TRUCKS, THE SNAP-IN TIRE VALVE STEMS IN THE WHEELS OF THESE TRUCKS CAN LEAK AIR.

Consequence:

THIS CAN CAUSE A LOSS OF TIRE AIR PRESSURE, LEAD TO A RUPTURE OF THE TIRE, AND CAUSE A LOSS OF CONTROL OF THE VEHICLE.

Action:

DEALERS WILL INSTALL NEW TIRE VALVE STEMS. OWNER NOTIFICATION BEGAN DECEMBER 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI TRUCK AT 1-609-395-2300.
2000 HYUNDAI SONATA
NHTSA Campaign ID:SUSPENSION
Manufacturer:Hyundai Motor Company
Manufacture Dates:09/15/1998 - 11/20/2003
Potential Units Affected:188282

Defect Description:

HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE JURISDICTIONS DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUB-FRAME ON THE VEHICLES, AND MAY RESULT IN THINNING OR PERFORATION OF THE SUB-FRAME STEEL. THE CORROSION IS FREQUENTLY VISIBLE AND OFTEN DISCOVERED DURING INSPECTION OR ROUTINE MAINTENANCE, AND OWNERS MAY ALSO HEAR NOISES OR NOTICE TIRE MISALIGNMENT AND STEERING PULL. IF THESE SIGNALS ARE UNDETECTED OR UNHEEDED, THE CORROSION MAY PROGRESS AND THE FORWARD MOUNTING OF THE LOWER CONTROL ARM MAY DETACH FROM THE SUB-FRAME.

Consequence:

IF THAT HAPPENS, THE VEHICLE MAY LOSE DRIVE POWER TO THE WHEELS, AND THE FRONT WHEEL MAY MAKE CONTACT WITH THE FENDER OR WHEEL WELL, THEREBY INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL MEASURE THE THICKNESS OF THE FRONT SUB-FRAME AND INSPECT THE FRONT SUB-FRAME FOR CORROSION DAMAGE AND, IF NECESSARY, THE FRONT SUB-FRAME WILL BE REPLACED WITH A NEW SUB-FRAME THAT INCORPORATES ADDITIONAL HOLES IN THE UPPER AND LOWER PANELS. IF THE FRONT SUB-FRAME DOES NOT REQUIRE REPLACEMENT, THE DEALER WILL ADD DRAINAGE HOLES TO THE SUB-FRAME AND WILL TREAT THE SUB-FRAME WITH RUST-PROOFING MATERIAL TO STOP THE CORROSION PROCESS. THIS PROCEDURE WILL BE PERFORMED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT THE HYUNDAI CUSTOMER ASSISTANCE CENTER AT 1-800-633-5151.
2000 HYUNDAI SONATA
NHTSA Campaign ID:ELECTRICAL SYSTEM:WIRING
Manufacturer:HYUNDAI MOTOR COMPANY
Manufacture Dates:07/01/1998 - 07/04/2000
Potential Units Affected:165977

Defect Description:

VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS.

Consequence:

THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS.
2000 HYUNDAI SONATA
NHTSA Campaign ID:AIR BAGS:SIDE/WINDOW
Manufacturer:HYUNDAI MOTOR COMPANY
Manufacture Dates:03/01/1998 - 07/23/2001
Potential Units Affected:145355

Defect Description:

ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE SIDE IMPACT AIR BAGS AND COULD PREVENT AIR BAG DEPLOYMENT DURING A CRASH WHERE SUCH DEPLOYMENT SHOULD OCCUR.

Consequence:

NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAG COULD INCREASE THE RISK OF INJURY DURING A SIDE IMPACT CRASH.

Action:

DEALERS WILL MORE SECURELY FASTEN THE SIDE IMPACT AIR BAG WIRING HARNESSES AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION BEGAN MAY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
2000 HYUNDAI SONATA
NHTSA Campaign ID:AIR BAGS
Manufacturer:HYUNDAI MOTOR COMPANY
Manufacture Dates:03/01/1998 - 11/22/2000
Potential Units Affected:86513

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT COULD ILLUMINATE DUE TO MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR THAT MOUNT TO THE ADJUSTABLE SEAT CUSHION ASSEMBLY. THIS CONDITION ONLY RELATES TO THE DRIVER AND/OR PASSENGER SEAT-MOUNTED SIDE IMPACT AIR BAG(S).

Consequence:

THIS CONDITION COULD PREVENT SEAT MOUNTED SIDE IMPACT AIR BAG DEPLOYMENT DURING AN ACCIDENT WHERE SUCH DEPLOYMENT SHOULD OCCUR. NON-DEPLOYMENT OF THE SRS SIDE IMPACT AIR BAGS COULD INCREASE THE RISK OF INJURY DURING AN ACCIDENT WHERE SIDE IMPACT AIR BAG DEPLOYMENT IS INTENDED.

Action:

DEALERS WILL MORE SECURELY FASTEN THE FRONT SEAT SIDE IMPACT AIR BAG WIRING HARNESS AND CONNECTORS TO THE VEHICLE'S FRONT SEAT CUSHION FRAMES. OWNER NOTIFICATION WILL OCCUR IN SIX MAILINGS ON MAY 27, JUNE 3, JUNE 10, JUNE 17, JUNE 24, AND JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
2000 HYUNDAI TIBURON
NHTSA Campaign ID:SEAT BELTS:FRONT:WEBBING
Manufacturer:HYUNDAI MOTOR COMPANY
Manufacture Dates:03/01/1996 - 08/28/2000
Potential Units Affected:42782

Defect Description:

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE DRIVER AND FRONT PASSENGER SEAT BELTS MAY NOT EXTEND AND RETRACT SMOOTHLY THROUGH THE D-RING GUIDES MOUNTED ON THE BODY PILLARS AFT OF THE DOORS. IF THE SEAT BELTS DO NOT EXTEND AND RETRACT SMOOTHLY, THEY MAY TWIST IN THE D-RING GUIDES AND MAKE IT INCONVENIENT TO EXTEND AND RETRACT THE SEAT BELTS.

Consequence:

IF THE SEAT BELTS ARE INCONVENIENT TO USE, THE SEAT OCCUPANT MAY NOT BE INCLINED TO WEAR THE SEAT BELTS PROPERLY, INCREASING THE RISK OF INJURY IN THE EVENT OF A CRASH.

Action:

DEALERS WILL INSTALL A STOPPER OVER EACH FRONT SEAT BELT D-RING GUIDE TO ASSIST THE SEAT BELT TO SMOOTHLY EXTEND AND RETRACT. OWNER NOTIFICATION BEGAN DECEMBER 10, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-633-5151.
2000 HYUNDAI CARIBBEAN ELANTRA
NHTSA Campaign ID:ELECTRICAL SYSTEM:WIRING
Manufacturer:HYUNDAI CARIBBEAN-PUERTO RICO
Manufacture Dates:06/01/1999 - 06/16/2000
Potential Units Affected:1421

Defect Description:

VEHICLE DESCRIPTION: SOME SONATA VEHICLES EQUIPPED WITH 2.5 LITER V-6 ENGINES AND ALL ELANTRA MODEL VEHICLES MAY HAVE EXPERIENCED INTERMITTENT LOW-SPEED ENGINE STALLING, WHICH COULD OCCUR IF THE MAF (MASS AIR FLOW) SENSOR ELECTRICAL SIGNAL IS INTERRUPTED AS A RESULT OF ENGINE VIBRATION TRANSMITTED TO THE MAF SENSOR CONNECTOR WIRING HARNESS.

Consequence:

THIS CONDITION CAN CAUSE THE ENGINE TO STALL, INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL RE-ROUTE THE MAF SENSOR CONNECTOR WIRING HARNESS.
2000 HYUNDAI TRANSLEAD TRAILER VAN
NHTSA Campaign ID:STRUCTURE:BODY
Manufacturer:HYUNDAI TRANSLEAD
Manufacture Dates:10/01/1996 - 12/31/2000
Potential Units Affected:2860

Defect Description:

VEHICLE DESCRIPTION: 53' DRY FREIGHT TRAILER VANS EQUIPPED WITH LASCO TRANSLUCENT FIBERGLASS ROOFS. THE ROOF PANELS CAN BECOME WHOLLY OR PARTIALLY DETACHED DURING OPERATION AND THE TRAILER BODIES COULD PARTIALLY COLLAPSE.

Consequence:

CONTINUED OPERATION OF A TRAILER WITH A ROOF HOLE, CRACK, TEAR, OR SEPARATION COULD RESULT IN A ROOF FAILURE, CAUSING DAMAGE TO THE VEHICLE, INJURY TO ITS OPERATOR, AND POSSIBLE INJURY AND DAMAGE TO ADJACENT VEHICLES AND THEIR PASSENGERS.

Action:

DEALERS WILL REPLACE THE LASCO FRPS WITH KEMLITE FRPS OR ALUMINUM PANELS. OWNER NOTIFICATION BEGAN AUGUST 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI TRANSLEAD AT 1-819-574-1500.