MINI Buyers Guide
Click a car name to see the crash test details for that model.
Crash Test Data for 2002 MINI
| MINI Vehicle | Front Star Rating | Side Star Rating | Rollover Resistance Rating | ||
|---|---|---|---|---|---|
| Driver | Passenger | Front Seat | Rear Seat | ||
| 2002 Cooper |  | | | Not Tested | |
Service Bulletins for 2002 MINI
| 2002 MINI COOPER | |
|---|---|
| Bulletin Number: 110104 | |
| VOLUNTARY EMISSIONS RECALL CAMPAIGN 04E-A03 - REPLACE CRANKCASE BREATHER LINE. THE CRANKCASE VENTILATION BREATHER HOSE MAY SOFTEN AND EVENTUALLY MAY COLLAPSE AFTER EXTENDED TIME IN SERVICE. A HISSING OR HUMMING NOISE MAY BE NOTICED DURING | |
| Bulletin Number: 110202 | |
| LUBRICANT FOR WATER PUMP O-RING. *TT | |
| Bulletin Number: 11 02 15 | |
| MINI: A MECHANICAL FAILURE AND DME SOFTWARE ERROR OF THE VANOS ACTUATORS CAUSE THE ENGINE TO RUN ROUGH WHICH ACTIVATES THE MALFUNCTION WARNING LIGHT. *MA | |
| Bulletin Number: 11 06 15 | |
| MINI: DIFFERENT FAULTS ACTIVATES ENGINE MALFUNCTION AND OIL WARNING. *MA | |
| Bulletin Number: 120104 | |
| VOLUNTARY EMISSIONS RECALL CAMPAIGN 04E-A01 - REPROGRAM DME FOR TANK LEAKAGE DIAGNOSTICS. TANK LEAKAGE DIAGNOSTICS DOES NOT RUN CORRECTLY DUE TO AN ERROR IN THE DME SOFTWARE. AS A RESULT, THE CHECK ENGINE SOON LIGHT WILL NOT BE ILLUMINATE | |
| Bulletin Number: 120302 | |
| ENGINE SPEED FLUCTUATION WHILE COASTING DOWN COOPER WITH MANUAL TRANSMISSION PRODUCED UP TO 07/02. *TT | |
| Bulletin Number: 12 05 15 | |
| MINI: DUE TO FAULTY DME SOFTWARE, THE SERVICE ENGINE LIGHTS COMES ON, INCLUDING THE CHECK CONTROL MESSAGE FOR MOTOR FORCE DECREASE. *MA | |
| Bulletin Number: 12 06 15 | |
| MINI: BECAUSE OF THE DME SOFTWARE, AND A DAMAGED CLUTCH, THE DRIVETRAIN MALFUNCTION CHECK MESSAGE APPEAR. *MA | |
| Bulletin Number: 12 07 15 | |
| MINI: FAULTY SOFTWARE CAUSES THE CHECK CONTROL AND ENGINE POWER REDUCED LIGHT TO APPEAR. *MA | |
| Bulletin Number: 12 09 15 | |
| MINI: FAULTY SOFTWARE FOR THE TANK VENTILATION CONTROL DISPLAYS ENGINE THROTTLE REACTION WHEN TEMPERATURE IS HIGH OUTSIDE, AND MORE OBVIOUS IF THE TANK IS ONLY PARTLY FILLED. *MA | |
| Bulletin Number: 240102 | |
| SERVICE ACTION TO FLUSH AND REPLACE INCORRECT CVT TRANSMISSION OIL. PRODUCED FROM 2002. *TT | |
| Bulletin Number: 360106 | |
| NITROGEN INFLATED TIRES. *TT | |
| Bulletin Number: 410102 | |
| RATTLES FROM REAR HATCH. *TT | |
| Bulletin Number: 520102 | |
| FRONT SEAT BACKREST WILL NOT HOLD WHEN ADJUSTED TO THE DESIRED POSITION. *TT | |
| Bulletin Number: 610102 | |
| BATTERY MAINTENANCE REQUIREMENTS. *TT | |
| Bulletin Number: M010113 | |
| Electro-Hydraulic Power-Assist Steering Pump (EHPS) and Cooling Fan: Limited Warranty Extension to 13 Years/150,000 Miles. On affected vehicles, the electro-hydraulic power steering (EHPS) pump can fail. | |
| Bulletin Number: M010113 | |
| Electro-Hydraulic Power-Assist Steering Pump (EHPS) and Cooling Fan: Warranty Extension to 13 years/150,000 miles. On affected vehicles, the electro-hydraulic power steering (EHPS) pump can fail. | |
| Bulletin Number: M010514 | |
| MINI CVT Replacement Parts Warranty Extension: Additional 12 Months with Up to 50,000 Accumulated Miles. A MINI vehicle's CVT assembly or component that was previously repaired and/or replaced by an authorized MINI dealer or BMW center may | |
| Bulletin Number: M120213 | |
| State Inspection and Emission (I/M) Test Fails Due to an Invalid VIN Number. The affected vehicle may fail to pass a State Inspection and Emission (I/M) test due to a noncompliant 17-digit vehicle identification number (VIN) stored in the D | |
| Bulletin Number: M120213 | |
| State Inspection and Emission (I/M) Test Fails to Read 17-Character VIN. An affected vehicle may fail to pass a state-mandated Inspection and/or Emission (I/M) test due to a noncompliant 17-character vehicle identification number (VIN) bein | |
| Bulletin Number: M120817 | |
| W10 ENGINE: EMS2K - COMPREHENSIVE COMPONENT OBD READINESS MONITOR NOT COMPLETED: An affected vehicle fails to pass a state Inspection and Emission (I/M) test due to the ÒComprehensive ComponentÓ OBD readiness monitor status is Ònot complete | |
| Bulletin Number: M320214 | |
| Installation of Right-Hand Drive Steering Spindle in Left-Hand Drive Vehicle. Supply shortage of left-hand drive steering spindles | |
| Bulletin Number: M320214 | |
| This Service Information bulletin supersedes SI 32 02 14 dated August 2014. SUBJECT Installation of Right-Hand Drive Steering Spindle in Left-Hand Drive Vehicle is No Longer Required. Left-hand drive steering spindles are currently availabl | |
| Bulletin Number: MC-10113 | |
| MINI: WARRANTY COVERAGE EXTENSION/REPAIR EXPENSE REIMBURSEMENT FOR THE ELECTRO HYDRAULIC POWER (ASSIST) STEERING (EHPS) PUMP, WHICH HAS ITS OWN COOLING FAN, ON SOME VEHICLES AND NOT THE ELECTRIC POWER (ASSIST) STEERING (EPS) SYSTEM ON OTHE | |
| Bulletin Number: SI M01 01 13 | |
| MINI: MODELS R50, R52, AND R53 WITH THE ELECTRO-HYDRAULIC POWER-ASSIST STEERING PUMP AND COOLING FANS WILL HAVE AN LIMITED WARRANTY EXTENSION TO 13 YEARS/150,000 MILES. *TA | |
| Bulletin Number: SIM-01-01-13 | |
| MINI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A WARRANTY EXTENSION FOR CERTAIN VEHICLES WITH POTENTIAL PROBLEM WITH COOLING FAN AND THE DURABILITY OF ELECTRO HYDRAULIC POWER (ASSIST) STEERING (EHPS) PUMP. MODELS 2002-2005 R50, R52, | |
| Bulletin Number: SIM-01-05-14 | |
| MINI: INFORMATION ON PARTS WARRANTY EXTENSION APPLYING TO PREVIOUS QUALIFYING REPAIRS AND NO IMMEDIATE REPAIR REQUIRED UNLESS CURRENTLY EXPERIENCING PROBLEM WITH CVT ASSEMBLY OR COMPONENT. MODEL 2005-2008 COOPER, COOPER S. *PE | |
| Bulletin Number: SIM-11-07-08 | |
| BMW: DESCRIPTION AND SPECIFICATIONS OF CRANKCASE VENTILATION SYSTEM. *RM | |
| Bulletin Number: SIM-11-10-14 | |
| MINI: SOME VEHICLES HAVE TURBOCHARGER NOISE AND A LACK OR LOSS OF PERFORMANCE, DUE TO RESTRICTION OF TURBOCHARGER OIL SUPPLY, RESULTING IN OIL STARVATION AND SEIZING OF TURBOCHARGER ASSEMBLY. MODEL ALL. *PE | |
| Bulletin Number: SIM-12-02-09 | |
| MINI: SERVICE ENGINE SOON OR CHECK GAS CAP WARNING IS ILLUMINATED: TANK LEAKAGE. LEAKAGE IS DETECTED IN THE TANK VENTILATION OR EVAPORATIVE SYSTEM. *PE | |
| Bulletin Number: SIM-12-02-11 | |
| BMW: A SOFTWARE ERROR IS CAUSING A HESITATION OR JERKING WHEN ACCELERATING UNDER HIGHER LOADS BETWEEN 3000 4000 RPM. *RM | |
| Bulletin Number: SI-M-13-01-13 | |
| MINI: THERE IS A PROCEDURAL ERROR IN THE REMOVING AND INSTALLING OR REPLACING HIGH PRESSURE PUMP CURRENT VERSION THAT HAS BEEN REPLACED WITH THE CORRECTED REPAIR INSTRUCTION PORTION FOR THE N14 AND N18 ENGINE. MODELS R55, 56, 57, 58, 59, 6 | |
| Bulletin Number: SIM-17-02-07 | |
| MINI: ELECTRIC COOLING FAN RUNS AFTER ENGINE IS SHUT OFF. AFTER THE ENGINE IS SHUT OFF, THE ELECTRIC COOLING FAN CONTINUES TO RUN. DUE TO THE OPERATING STRATEGY OF THE DME, THE ELECTRIC COOLING FAN MAY CONTINUE TO RUN AFTER THE ENGINE IS | |
| Bulletin Number: SI-M-18-01-09 | |
| MINI: DUE TO A FAILURE IN THE PRODUCTION PROCESS,THE CATALYTIC CONVERTER MAY DETERIORATE CAUSING AN INCREASED LEVEL OF VEHICLE EMISSIONS. THE CATALYST EFFICIENCY FAULT CODE (276A) WILL BE STORED IN THE DME MEMORY, AND THE SERVICE ENGINE S | |
| Bulletin Number: SI M21-03-08 | |
| MINI- R5 & R56 (COOPER; COOPER S) WITH GETRAG 6 SPEED MANUAL TRANSMISSION: COMPLAINT OF AN INTERMITTENT NO-CRANK, NO START SITUATION. THE CLUTCH SWITCH MODULE HAS NOT BEEN SECURED IN THE CORRECT POSITION ON THE CLUTCH MASTER CYLINDER. * | |
| Bulletin Number: SI M24 01 08 | |
| MINI: R55, R56 (COOPER, COOPER S) WITH F21 ASIN 6-SPEED AUTOMATIC TRANSMISSION - INCORRECT GEAR DISPLAY. *PE | |
| Bulletin Number: SIM-51-09-07 | |
| MINI: WATER LEAK FROM THE FRONT DOORS. AFTER HEAVY RAIN, THE CARPET MAY BE WET IN THE AREA NEAR THE REAR OF THE FRONT DOORS OR IN THE FOOTWELL AREA. WATER WHICH IS ALLOWED TO ENTER THE VEHICLE AT THE TOP REAR EDGE OF THE DOOR IS NOT ABLE | |
| Bulletin Number: SI-M61-01-12 | |
| MINI: AFTER DRIVE-AWAY LOCKING ACTIVATES, IT IS NOT POSSIBLE TO UNLOCK THE BOOT. *KB | |
| Bulletin Number: SIM-61-05-14 | |
| MINI: THERE IS A DISCONNECTION OR KINK, IN WNIDSHIELD WASHER HOSE, WHICH IS TOO SHORT, CAUSING WINDSHIELD FRONT WASHER JET TO FAIL. MODEL F56 (COOPER, COOPER S). *PE | |
| Bulletin Number: SI M64-02-08 | |
| MINI: DRIVER FOOTWELL AREA BECOMES HOT. THE HEARTER CORE PIPES ARE POORLY INSULATED. MODEL R56. *PE | |
| Bulletin Number: SI-M-65-05-08 | |
| MINI: CHECK SVS FUNCTION. ON CERTAIN VEHICLES, THE VOICE INPUT SYSTEM (SVS SA 620) DOES NOT FUNCTION. THE SVS WAS NOT INSTALLED IN THE VEHICLES. *PE | |
| 2002 MINI COOPER S | |
| Bulletin Number: 11 02 15 | |
| MINI: A MECHANICAL FAILURE AND DME SOFTWARE ERROR OF THE VANOS ACTUATORS CAUSE THE ENGINE TO RUN ROUGH WHICH ACTIVATES THE MALFUNCTION WARNING LIGHT. *MA | |
| Bulletin Number: 11 06 15 | |
| MINI: DIFFERENT FAULTS ACTIVATES ENGINE MALFUNCTION AND OIL WARNING. *MA | |
| Bulletin Number: 12 05 15 | |
| MINI: DUE TO FAULTY DME SOFTWARE, THE SERVICE ENGINE LIGHTS COMES ON, INCLUDING THE CHECK CONTROL MESSAGE FOR MOTOR FORCE DECREASE. *MA | |
| Bulletin Number: 12 06 15 | |
| MINI: BECAUSE OF THE DME SOFTWARE, AND A DAMAGED CLUTCH, THE DRIVETRAIN MALFUNCTION CHECK MESSAGE APPEAR. *MA | |
| Bulletin Number: 12 07 15 | |
| MINI: FAULTY SOFTWARE CAUSES THE CHECK CONTROL AND ENGINE POWER REDUCED LIGHT TO APPEAR. *MA | |
| Bulletin Number: M010113 | |
| Electro-Hydraulic Power-Assist Steering Pump (EHPS) and Cooling Fan: Limited Warranty Extension to 13 Years/150,000 Miles. On affected vehicles, the electro-hydraulic power steering (EHPS) pump can fail. | |
| Bulletin Number: M010113 | |
| Electro-Hydraulic Power-Assist Steering Pump (EHPS) and Cooling Fan: Warranty Extension to 13 years/150,000 miles. On affected vehicles, the electro-hydraulic power steering (EHPS) pump can fail. | |
| Bulletin Number: M120213 | |
| State Inspection and Emission (I/M) Test Fails Due to an Invalid VIN Number. The affected vehicle may fail to pass a State Inspection and Emission (I/M) test due to a noncompliant 17-digit vehicle identification number (VIN) stored in the D | |
| Bulletin Number: M120213 | |
| State Inspection and Emission (I/M) Test Fails to Read 17-Character VIN. An affected vehicle may fail to pass a state-mandated Inspection and/or Emission (I/M) test due to a noncompliant 17-character vehicle identification number (VIN) bein | |
| Bulletin Number: M240112 | |
| Programming a Replacement EGS Module with ISTA/P. Programming a replacement electronic transmission control module (EGS) with ISTA/P requires the manual entry of the correct target basic and programmed part numbers. Programming concept. | |
| Bulletin Number: M320214 | |
| Installation of Right-Hand Drive Steering Spindle in Left-Hand Drive Vehicle. Supply shortage of left-hand drive steering spindles | |
| Bulletin Number: M320214 | |
| This Service Information bulletin supersedes SI 32 02 14 dated August 2014. SUBJECT Installation of Right-Hand Drive Steering Spindle in Left-Hand Drive Vehicle is No Longer Required. Left-hand drive steering spindles are currently availabl | |
| Bulletin Number: M650610 | |
| NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance: | |
| Bulletin Number: MC-10113 | |
| MINI: WARRANTY COVERAGE EXTENSION/REPAIR EXPENSE REIMBURSEMENT FOR THE ELECTRO HYDRAULIC POWER (ASSIST) STEERING (EHPS) PUMP, WHICH HAS ITS OWN COOLING FAN, ON SOME VEHICLES AND NOT THE ELECTRIC POWER (ASSIST) STEERING (EPS) SYSTEM ON OTHE | |
| Bulletin Number: SI M01 01 13 | |
| MINI: MODELS R50, R52, AND R53 WITH THE ELECTRO-HYDRAULIC POWER-ASSIST STEERING PUMP AND COOLING FANS WILL HAVE AN LIMITED WARRANTY EXTENSION TO 13 YEARS/150,000 MILES. *TA | |
| Bulletin Number: SIM-01-01-13 | |
| MINI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A WARRANTY EXTENSION FOR CERTAIN VEHICLES WITH POTENTIAL PROBLEM WITH COOLING FAN AND THE DURABILITY OF ELECTRO HYDRAULIC POWER (ASSIST) STEERING (EHPS) PUMP. MODELS 2002-2005 R50, R52, | |
| Bulletin Number: SIM -01-04-10 | |
| BMW: SERVICE ENGINE SOON LIGHT MAY BE ON WITH STORED TROUBLE CODES AND REDUCED ENGINE POWER. THE HIGH PRESSURE FUEL PUMP MALFUNCTIONS. *RM | |
| Bulletin Number: SI-M-11-01-09 | |
| MINI: WHEN REPLACING THE CYLINDER HEAD COVER ON A VEHICLE EQUIPPED WITH THE NEW N14 ENGINE, THE COVER WILL LOOK DIFFERENT IN APPEARANCE. THE REPLACEMENT COVER IS NOW EQUIPPED WITH A CRANKCASE VENTILATION SYSTEM PRESSURE RELIEF VALVE. NO | |
| Bulletin Number: SI M11 02 07 | |
| RATTLE NOISE FROM ENGINE. FROM START OF PRODUCTION UP TO APRIL 11, 2007. WITH N14 ENGINE. *NJ | |
| Bulletin Number: SIM-11-03-08 | |
| MINI: TURBOCHARGER FAILURE; OIL SUPPLY LINE BLOCKAGE. LOSS OF PERFORMANCE AND TURBOCHARGER NOISE. *PE UPDATED 8/16/11. *PE | |
| Bulletin Number: SIM-11-07-08 | |
| BMW: DESCRIPTION AND SPECIFICATIONS OF CRANKCASE VENTILATION SYSTEM. *RM | |
| Bulletin Number: SIM-11-10-14 | |
| MINI: SOME VEHICLES HAVE TURBOCHARGER NOISE AND A LACK OR LOSS OF PERFORMANCE, DUE TO RESTRICTION OF TURBOCHARGER OIL SUPPLY, RESULTING IN OIL STARVATION AND SEIZING OF TURBOCHARGER ASSEMBLY. MODEL ALL. *PE | |
| Bulletin Number: SIM-12-02-09 | |
| MINI: SERVICE ENGINE SOON OR CHECK GAS CAP WARNING IS ILLUMINATED: TANK LEAKAGE. LEAKAGE IS DETECTED IN THE TANK VENTILATION OR EVAPORATIVE SYSTEM. *PE | |
| Bulletin Number: SI-M-13-01-08 | |
| MINI: FUEL ODOR FROM THE ENGINE COMPARTMENT. THE HIGH PRESSURE PUMP (HDP) AND/OR THE LOW PRESSURE SUPPLY HOSE CONNECTION CAN ALLOW FUEL SEEPAGE, RESULTING IN THE FUEL ODOR. *PE | |
| Bulletin Number: SI-M-13-01-13 | |
| MINI: THERE IS A PROCEDURAL ERROR IN THE REMOVING AND INSTALLING OR REPLACING HIGH PRESSURE PUMP CURRENT VERSION THAT HAS BEEN REPLACED WITH THE CORRECTED REPAIR INSTRUCTION PORTION FOR THE N14 AND N18 ENGINE. MODELS R55, 56, 57, 58, 59, 6 | |
| Bulletin Number: SIM-17-02-07 | |
| MINI: ELECTRIC COOLING FAN RUNS AFTER ENGINE IS SHUT OFF. AFTER THE ENGINE IS SHUT OFF, THE ELECTRIC COOLING FAN CONTINUES TO RUN. DUE TO THE OPERATING STRATEGY OF THE DME, THE ELECTRIC COOLING FAN MAY CONTINUE TO RUN AFTER THE ENGINE IS | |
| Bulletin Number: SI M21-03-08 | |
| MINI- R5 & R56 (COOPER; COOPER S) WITH GETRAG 6 SPEED MANUAL TRANSMISSION: COMPLAINT OF AN INTERMITTENT NO-CRANK, NO START SITUATION. THE CLUTCH SWITCH MODULE HAS NOT BEEN SECURED IN THE CORRECT POSITION ON THE CLUTCH MASTER CYLINDER. * | |
| Bulletin Number: SI M24 01 08 | |
| MINI: R55, R56 (COOPER, COOPER S) WITH F21 ASIN 6-SPEED AUTOMATIC TRANSMISSION - INCORRECT GEAR DISPLAY. *PE | |
| Bulletin Number: SIM-51-09-07 | |
| MINI: WATER LEAK FROM THE FRONT DOORS. AFTER HEAVY RAIN, THE CARPET MAY BE WET IN THE AREA NEAR THE REAR OF THE FRONT DOORS OR IN THE FOOTWELL AREA. WATER WHICH IS ALLOWED TO ENTER THE VEHICLE AT THE TOP REAR EDGE OF THE DOOR IS NOT ABLE | |
| Bulletin Number: SI-M-51-09-08 | |
| MINI: REAR SPLIT DOOR OPENING PROBLEMS. ONE OR BOTH OF THE REAR SPLIT DOORS INTERMITTENTLY HAVE FUNCTIONAL PROBLEMS. THE DOOR(S) MAY NOT UNLATCH WHEN THE LEVER ON THE HANDLE IS PULLED OR THE LATCH MAY RELEASE UNEXPECTEDLY WITHOUT BEING PUL | |
| Bulletin Number: SI-M61-01-12 | |
| MINI: AFTER DRIVE-AWAY LOCKING ACTIVATES, IT IS NOT POSSIBLE TO UNLOCK THE BOOT. *KB | |
| Bulletin Number: SIM-61-05-14 | |
| MINI: THERE IS A DISCONNECTION OR KINK, IN WNIDSHIELD WASHER HOSE, WHICH IS TOO SHORT, CAUSING WINDSHIELD FRONT WASHER JET TO FAIL. MODEL F56 (COOPER, COOPER S). *PE | |
| Bulletin Number: SI M64-02-08 | |
| MINI: DRIVER FOOTWELL AREA BECOMES HOT. THE HEARTER CORE PIPES ARE POORLY INSULATED. MODEL R56. *PE | |
| Bulletin Number: SI-M-65-05-08 | |
| MINI: CHECK SVS FUNCTION. ON CERTAIN VEHICLES, THE VOICE INPUT SYSTEM (SVS SA 620) DOES NOT FUNCTION. THE SVS WAS NOT INSTALLED IN THE VEHICLES. *PE | |
Recalls for 2002 MINI
| 2002 MINI COOPER | |
|---|---|
| NHTSA Campaign ID: | POWER TRAIN:MANUAL TRANSMISSION:FLOOR SHIFT ASSEMBLY |
| Manufacturer: | BAYERISCHE MOTOREN WERKE |
| Manufacture Dates: | 09/29/2001 - 05/10/2002 |
| Potential Units Affected: | 3531 |
Defect Description:ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE TRANSMISSION SHIFT CABLE CONNECTS THE GEARSHIFT LEVER IN THE VEHICLE INTERIOR TO THE SHIFT LINKAGE ON THE TRANSMISSION. IT IS POSSIBLE FOR THE SHIFT CABLE TO DETACH FROM THE TRANSMISSION SHIFT LINKAGE WHILE THE DRIVER IS ATTEMPTING TO CHANGE GEARS. IF THE CABLE DETACHES FROM THE SHIFT LINKAGE, GEAR CHANGES WILL NO LONGER BE POSSIBLE AND THE TRANSMISSION WILL REMAIN IN THE LAST GEAR SELECTED. Consequence:IF SHIFT CABLE DETACHMENT OCCURS AND THE TRANSMISSION REMAINS IN ANY FORWARD GEAR, THE VEHICLE CAN STILL BE DRIVEN IN THAT GEAR ONLY. HOWEVER, IF THE TRANSMISSION MOVES INTO NEUTRAL AND REMAINS THERE, THE ABILITY TO ACCELERATE OR MAINTAIN SPEED WILL BE LOST, INCREASING THE RISK OF A CRASH. Action:DEALERS WILL INSPECT THE SHIFT CABLE AND, IF NECESSARY, INSTALL A RETAINING CLIP OVER THE END OF THE SHIFT CABLE TO PREVENT IT FROM DETACHING FROM THE TRANSMISSION. OWNER NOTIFICATION BEGAN AUGUST 6, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-866-ASK-MINI (1-866-275-6464). | |
| 2002 MINI COOPER | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT:OTHER:LABELS |
| Manufacturer: | BMW OF NORTH AMERICA, LLC |
| Manufacture Dates: | 06/06/2002 - 07/12/2002 |
| Potential Units Affected: | 960 |
Defect Description:CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS.' THE STANDARD REQUIRES THAT THE RELATIONSHIP BETWEEN THE TIRE SIZE AND MAXIMUM TIRE PRESSURE BE INDICATED ON THE VEHICLE'S TIRE INFORMATION LABEL. THIS RELATIONSHIP IS NOT PRESENT. Consequence:TOO LOW OR TOO HIGH TIRE PRESSURE CAN CAUSE PREMATURE WEAR AND/OR TIRE DAMAGE, AND COULD LEAD TO UNFAVORABLE DRIVING CONDITIONS. Action:OWNERS WILL BE PROVIDED WITH NEW TIRE INFORMATION PLACARDS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT MINI AT 1-866-275-6464. | |
| 2002 MINI COOPER | |
|---|---|
| NHTSA Campaign ID: | STEERING:ELECTRIC POWER ASSIST SYSTEM |
| Manufacturer: | BMW of North America, LLC |
| Manufacture Dates: | 09/19/2001 - 02/09/2005 |
| Potential Units Affected: | 86018 |
Defect Description:BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance. Consequence:If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash. Action:MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525. | |
| 2002 MINI COOPER S | |
|---|---|
| NHTSA Campaign ID: | STEERING:ELECTRIC POWER ASSIST SYSTEM |
| Manufacturer: | BMW of North America, LLC |
| Manufacture Dates: | 07/18/2001 - 02/09/2005 |
| Potential Units Affected: | 86018 |
Defect Description:BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance. Consequence:If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash. Action:MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525. | |
