Mitsubishi Buyers Guide

 

Click a car name to see the crash test details for that model.

 

 

 

Crash Test Data for 2007 Mitsubishi

Mitsubishi Vehicle Front Star Rating Side Star Rating Rollover Resistance Rating
Driver Passenger Front Seat Rear Seat
2007 EclipseNot
Tested
Not
Tested
Not
Tested
Not
Tested
Not
Tested
2007 Eclipse SpyderNot
Tested
Not
Tested
Not
Tested
Not
Tested
Not
Tested
2007 EndeavorNot
Tested
Not
Tested
Not
Tested
Not
Tested
Not
Tested
2007 Galant
2007 Lancer
2007 Outlander
2007 Raider ClubNot
Tested
2007 Raider QuadNot
Tested
Not
Tested

 

Service Bulletins for 2007 Mitsubishi

2007 MITSUBISHI ECLIPSE
Bulletin Number: 0613006
INCORRECT SOFTWARE PARAMETERS IN THE PCM MAY CAUSE THE MIL TO ILLUMINATE AND DIAGNOSTIC TROUBLE CODE P0335 AND/OR P0340 (CRANKSHAFT OR CAMSHAFT POSITION SENSOR CIRCUIT) TO SET IN THE PCM. *TT
Bulletin Number: 125
CHILD RESTRAINT INSTALLATION. *TT
Bulletin Number: 137
REPROGRAMMING THE PCM DRIVABILITY OR SENSITIVITY ISSUES CAN BE CORRECTED. *KB
Bulletin Number: GRP-16
MITSUBISHI: IN CERTAIN MODEL/MODEL YEARS VEHICLES, THE COILS HAVE BEEN FOUND TO OVERHEAT AND POSSIBLY MELT; CHECK GROUND POINT #12 FOR SIGNS OF CORROSION, ESPECIALLY IF THE BATTERY HAS RECENTLY BEEN REPLACED. HIGH RESISTANCE AT THE GROUND
Bulletin Number: MEDICUpdate517
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
Bulletin Number: TSB-13-15-001
MITSUBISHI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN EXHAUST MANIFOLD MOUNTED CATALYTIC CONVERTERS WILL EXPERIENCE CATALYST LAYER SEPARATION DUE TO PRODUCTION VARIATIONS AND WILL CAUSE MALFUNCTION INDICATOR LAMP (MIL) TO ILLUM
Bulletin Number: TSB-19-00-008
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
Bulletin Number: TSB-19-34-001
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Rear Suspension section of the affected Service Manuals to update the special service tool used in replacement of the Toe Control Arm Ball Joint Dust Co
Bulletin Number: TT237
This is a service newsletter (Tech Talk) that was sent out to dealers.
2007 MITSUBISHI ECLIPSE SPYDER
Bulletin Number: 137
REPROGRAMMING THE PCM DRIVABILITY OR SENSITIVITY ISSUES CAN BE CORRECTED. *KB
Bulletin Number: GRP-16
MITSUBISHI: IN CERTAIN MODEL/MODEL YEARS VEHICLES, THE COILS HAVE BEEN FOUND TO OVERHEAT AND POSSIBLY MELT; CHECK GROUND POINT #12 FOR SIGNS OF CORROSION, ESPECIALLY IF THE BATTERY HAS RECENTLY BEEN REPLACED. HIGH RESISTANCE AT THE GROUND
Bulletin Number: MEDICUpdate517
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
Bulletin Number: TSB-13-15-001
MITSUBISHI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN EXHAUST MANIFOLD MOUNTED CATALYTIC CONVERTERS WILL EXPERIENCE CATALYST LAYER SEPARATION DUE TO PRODUCTION VARIATIONS AND WILL CAUSE MALFUNCTION INDICATOR LAMP (MIL) TO ILLUM
Bulletin Number: TSB-19-00-008
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
Bulletin Number: TSB-19-34-001
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Rear Suspension section of the affected Service Manuals to update the special service tool used in replacement of the Toe Control Arm Ball Joint Dust Co
Bulletin Number: TT237
This is a service newsletter (Tech Talk) that was sent out to dealers.
2007 MITSUBISHI ENDEAVOR
Bulletin Number: 137
REPROGRAMMING THE PCM DRIVABILITY OR SENSITIVITY ISSUES CAN BE CORRECTED. *KB
Bulletin Number: MEDICUpdate517
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
Bulletin Number: TSB-09-42A-006
MITSUBISHI: LIFTGATE GAS SPRING BOLT TORQUE SERVICE MANUAL REVISION. THE TIGHTENING TORQUE FOR THE LIFTGATE GAS SPRING BOLTS IS INCORRECTLY PRINTED IN HE AFFECTED SERVICE MANUAL PAGES. THIS BULLETIN CONTAINS THE CORRECT TORQUE SPECIFICATIO
Bulletin Number: TSB-12-35-002
MITSUBISHI: ON SOME VEHICLES, AN ACTIVE STABILITY CONTROL (ASC) STEERING WHEEL SENSOR HAS BEEN INSTALLED, REPLACING ORIGINAL SENSOR. NEW SENSOR NOT TO BE ROTATED BEFORE INSTALLATION. MODELS 2007-12 OUTLANDER, 2008-11 LANCER EVOLUTION, 2
Bulletin Number: TSB-14-54-007
MITSUBISHI: THIS BULLETIN IS AN INTRODUCTION TO MAPCARE AND THE MAP UPDATE PURCHASE FOR MITSUBISHI MULTI COMMUNICATIONS SYSTEM. THIS DOES NOT APPLY TO MITSUBISHI MULTI ENTERTAINMENT SYSTEM FOR THE 2014 AND LATER MIRAGE. INCLUDED IN THE MA
Bulletin Number: TSB-19-00-008
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
Bulletin Number: TSB-19-34-001
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Rear Suspension section of the affected Service Manuals to update the special service tool used in replacement of the Toe Control Arm Ball Joint Dust Co
Bulletin Number: TT237
This is a service newsletter (Tech Talk) that was sent out to dealers.
2007 MITSUBISHI GALANT
Bulletin Number: 07
EXTENDED WARRANTY FOR PARTIAL ZERO EMISSIONS. *KB
Bulletin Number: 137
REPROGRAMMING THE PCM DRIVABILITY OR SENSITIVITY ISSUES CAN BE CORRECTED. *KB
Bulletin Number: GRP-16
MITSUBISHI: IN CERTAIN MODEL/MODEL YEARS VEHICLES, THE COILS HAVE BEEN FOUND TO OVERHEAT AND POSSIBLY MELT; CHECK GROUND POINT #12 FOR SIGNS OF CORROSION, ESPECIALLY IF THE BATTERY HAS RECENTLY BEEN REPLACED. HIGH RESISTANCE AT THE GROUND
Bulletin Number: MEDICUpdate517
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
Bulletin Number: TSB-10-00-021
MITSUBISHI: THE THROTTLE ACTUATOR CONTROL MOTOR INITIALIZATION PROCEDURE FOR 2006-2011 GALANT. *RM
Bulletin Number: TSB-13-15-001
MITSUBISHI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. CERTAIN EXHAUST MANIFOLD MOUNTED CATALYTIC CONVERTERS WILL EXPERIENCE CATALYST LAYER SEPARATION DUE TO PRODUCTION VARIATIONS AND WILL CAUSE MALFUNCTION INDICATOR LAMP (MIL) TO ILLUM
Bulletin Number: TSB-14-54-007
MITSUBISHI: THIS BULLETIN IS AN INTRODUCTION TO MAPCARE AND THE MAP UPDATE PURCHASE FOR MITSUBISHI MULTI COMMUNICATIONS SYSTEM. THIS DOES NOT APPLY TO MITSUBISHI MULTI ENTERTAINMENT SYSTEM FOR THE 2014 AND LATER MIRAGE. INCLUDED IN THE MA
Bulletin Number: TSB-19-00-008
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
Bulletin Number: TSB-19-34-001
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Rear Suspension section of the affected Service Manuals to update the special service tool used in replacement of the Toe Control Arm Ball Joint Dust Co
Bulletin Number: TT237
This is a service newsletter (Tech Talk) that was sent out to dealers.
2007 MITSUBISHI LANCER
Bulletin Number: 0711001
HARD TO START ENGINE. DTC P0340 (AND P0335). COULD BE DUE TO ABNORMAL WEAR TO THE CAMSHAFT POSITION SENSOR. *KB
Bulletin Number: 137
REPROGRAMMING THE PCM DRIVABILITY OR SENSITIVITY ISSUES CAN BE CORRECTED. *KB
Bulletin Number: MEDICUpdate517
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
Bulletin Number: TIN-19-00-003
This is a Technical Information Notice sent to all dealers in the state of Mississippi. This notice informs dealers that MMNA will be mailing letters to owners, with Mississippi addresses, with open Takata airbag recalls. The notice instruc
Bulletin Number: TSB-15-52A-001
THIS TECHNICAL SERVICE BULLETIN, PROVIDED TO DEALERS, PROVIDES THE CORRECT TORQUE SPECIFICATION FOR THE 2012 OUTLANDER SPORT SERVICE MANUAL. OTHER MODELS' SERVICE MANUALS ARE UPDATED WITH INFORMATION FOR THE OUTER SEAT BELT ON THE FRONT PAS
Bulletin Number: TSB-19-00-008
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
Bulletin Number: TT237
This is a service newsletter (Tech Talk) that was sent out to dealers.
2007 MITSUBISHI LANCER EVOLUTION
Bulletin Number: MEDICUpdate517
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
Bulletin Number: TSB-19-00-008
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
Bulletin Number: TT237
This is a service newsletter (Tech Talk) that was sent out to dealers.
2007 MITSUBISHI OUTLANDER
Bulletin Number: 040108
ENGINE CONTROL MODULE REPROGRAMMING FOR POOR HEATER PERFORMANCE. *NJ
Bulletin Number: 0611005
REUSE LIMIT CHECKING PROCEDURES FOR CONNECTING ROD BOLTS. SERVICE MANUAL REVISION. *KB
Bulletin Number: 0651002
ACCESORY TOW HITCH INSTALLATION. *KB
Bulletin Number: 0713007
ENGINE CONTROL MODULE REPROGRAMMING FOR THROTTLE HESITATION. *KB
Bulletin Number: 0723006
TCM REPROGRAMMING FOR DTC P0712, P0713 & SERVICE REQUIRED DISPLAYED WITH NO MIL. *KB
Bulletin Number: 08-13-007
ENGINE CONTROL MODULE REPROGRAMMING FOR DTC'S P0300 - P0306 AND ROUGH IDLE. *NJ
Bulletin Number: 137
REPROGRAMMING THE PCM DRIVABILITY OR SENSITIVITY ISSUES CAN BE CORRECTED. *KB
Bulletin Number: FRONTWIPERSYSTEM
THIS IS AN EXAMPLE OF A COMPLETED WORKSHEET PROVIDED TO CERTAIN DEALERS TO PERFORM A STUDY OF THE DECK GARNISH GAPS, WIPER MOTOR CONNECTOR'S CONDITIONS, AND WIPER LINK BOOTS.
Bulletin Number: FRONTWIPERSYSTEM
THIS IS A WORKSHEET PROVIDED TO CERTAIN DEALERS TO PERFORM A STUDY OF THE DECK GARNISH, WIPER MOTOR CONNECTOR, AND WIPER LINK BOOTS. THE PARTS BEING STUDIED MUST ALSO BE SHIPPED TO MMNA FOR EXAMINATION.
Bulletin Number: MEDICUpdate517
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
Bulletin Number: TSB-09-23-007
MITSUBISHI: ON SOME AFFECTED VEHICLES, THE SHIFT LEVER MAY GET STUCK IN THE P (PARK) POSITION. THE CONDITION MAY OCCUR WITH THE IGNITION SWITCH IN THE ON POSITION, BRAKE PEDAL DEPRESSED AND STOP LAMPS ILLUMINATED. *PE
Bulletin Number: TSB-11-11-004
MITSUBISHI: INFORMATION PERTAINING TO SOME VEHICLES WHERE THE IGNITION SWITCH IS IN AN ON POSITION AND BRAKE PEDAL IS DEPRESSED AND STOP LAMPS ARE ILLUMINATED AND THE SHIFT LEVER MAY GET STUCK IN P (PARK) POSITION. *PE
Bulletin Number: TSB-12-35-002
MITSUBISHI: ON SOME VEHICLES, AN ACTIVE STABILITY CONTROL (ASC) STEERING WHEEL SENSOR HAS BEEN INSTALLED, REPLACING ORIGINAL SENSOR. NEW SENSOR NOT TO BE ROTATED BEFORE INSTALLATION. MODELS 2007-12 OUTLANDER, 2008-11 LANCER EVOLUTION, 2
Bulletin Number: TSB-13-13-008
MITSUBISHI: SOME VEHICLES MAY DISPLAY AN ILLUMINATED MIL STATING TO SERVICE THE ENGINE SOON WITH DTCS STORED IN THE ECM MEMORY AND/OR REDUCED ENGINE PERFORMANCE. WATER MAY ACCUMULATE AT THE BOTTOM OF THE AIR CLEANER FROM SNOW BUILD UP. VE
Bulletin Number: TSB-13-35-006
MITSUBISHI MOTORS: IMPROVEMENTS MADE TO THE SERVICE MANUAL IN REFERENCE TO FASTENER TIGHTENING TORQUE SPECIFICATIONS. MODELS INCLUDE OUTLANDER MY2007-2014, OUTLANDER SPORT/RVR 2011-2014, LANCER 2008-2014, LANCER EVOLUTION 2008-2014, AND LAN
Bulletin Number: TSB-14-33-002
MITSUBISHI: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. DUE TO EXPOSURE TO ANTI FREEZING AGENTS (CALCIUM CHLORIDE) USED IN COLD STATES FOR CLEARING ICE AND SNOW FROM ROADWAYS, THE FRONT COIL SPRINGS CAN CORRODE AND FRACTURE. MODEL 2007
Bulletin Number: TSB-14-35-003
MITSUBISHI 2007-2009 OUTLANDER: CUSTOMERS MAY EXPERIENCE DEFECTS WITH ASC OFF IS ILLUMINATED ON THE MID. TO CORRECT THIS CONDITION ABS- ECU IS REQUIRED. *LJ
Bulletin Number: TSB-14-37-005
MITSUBISHI: UPDATED INFORMATION PROVIDED ON REMOVAL SERVICE POINTS, IN THE SERVICE MANUAL, FOR THE POWER STEERING HOSES. MODEL 2007-13 OUTLANDER. *PE
Bulletin Number: TSB-14-54-007
MITSUBISHI: THIS BULLETIN IS AN INTRODUCTION TO MAPCARE AND THE MAP UPDATE PURCHASE FOR MITSUBISHI MULTI COMMUNICATIONS SYSTEM. THIS DOES NOT APPLY TO MITSUBISHI MULTI ENTERTAINMENT SYSTEM FOR THE 2014 AND LATER MIRAGE. INCLUDED IN THE MA
Bulletin Number: TSB-15-52A-001
THIS TECHNICAL SERVICE BULLETIN, PROVIDED TO DEALERS, PROVIDES THE CORRECT TORQUE SPECIFICATION FOR THE 2012 OUTLANDER SPORT SERVICE MANUAL. OTHER MODELS' SERVICE MANUALS ARE UPDATED WITH INFORMATION FOR THE OUTER SEAT BELT ON THE FRONT PAS
Bulletin Number: TSB-17-54-004
This is a Technical Service Bulletin, sent to dealers, providing updates to the Chassis Electrical section of the affected Service Manuals, to provide replacement instructions when installing the new ETACS ECU to replace the old ETACS ECU.
Bulletin Number: TSB-18-13-003
This is a Technical Service Bulletin sent to dealers. The bulletin instructs dealers to confirm a list of specific Diagnostic Trouble Codes (DTCs) if vehicle experiences the following symptoms in cold weather: the check engine light illumi
Bulletin Number: TSB-18-52A-001
This is a Technical Service Bulletin sent to dealers. Customers may report the front seat belt fraying as a result of being caught under the seat reclining adjusting lever. This TSB instructs dealers how to replace the front seat belt and r
Bulletin Number: TSB-18-54-003
This is a Technical Service Bulletin sent to dealers. It provides dealers instructions for reprogramming the ETACS ECU with updated software to resolve the issue on certain vehicles experiencing dome light flickering when the vehicle's door
Bulletin Number: TSB-19-00-008
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
Bulletin Number: TSB-19-13-003
This is a Technical Service Bulletin sent to dealers. The bulletin instructs dealers to confirm a list of specific Diagnostic Trouble Codes (DTCs) if vehicle experiences the following symptoms in cold weather: the check engine light illumi
Bulletin Number: TSB-19-23-001
This is a Technical Service Bulletin sent to dealers. This bulletin updates the Automatic Transmission section of the affected Service Manual, to correct information in the diagnosis data list reference table for automatic transmissions F6A
Bulletin Number: TSB-19-25-001
This is Technical Service Bulletin sent to dealers. This bulletin updates the Propeller Shaft section of the affect Service Manuals, to correct the propeller shaft assembly removal procedure.
Bulletin Number: TSB-19-33-001
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Front Suspension section of the affected Service Manuals to update the special service tool used in replacement of the Lower Arm Ball Joint Dust Cover.
Bulletin Number: TSB-19-33-002
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Front Suspension section of the affected Service Manuals to correct the starting torque of the Lower Arm Ball Joint rotation.
Bulletin Number: TSB-19-37-001
This is a Technical Service Bulletin that was sent to dealers. The bulletin updates the Steering section of the affected Service Manuals to update the lubricant, sealant, special tools, and procedures used in replacement of the Tie Rod End
Bulletin Number: TSB-19-42B-001
This is a Technical Service Bulletin that was sent to dealers. This bulletin instructs dealers how to re-register vehicle keys for affected vehicles. Affected vehicles may experience a condition of the door(s) inability to be locked or unlo
Bulletin Number: TSB1942B003
This is a Technical Service Bulletin sent to dealers. This bulletin updates the Body section of the affected Service Manuals to update diagnostics for ETACS-ECU CAN timeout with DTC U0141.
Bulletin Number: TSB1952B005
This is a Technical Service Bulletin sent to dealers. This bulletin updates the Supplemental Restraint System (SRS) section of the affected Service Manuals to update diagnostics for ETACS-ECU CAN timeout diagnostics with DTC U0141.
Bulletin Number: TSB1954008
This is a Technical Service Bulletin sent to dealers. This bulletin updates the Chassis Electrical section of the affected Service Manuals to update diagnostics for ETACS-ECU CAN timeout diagnostics with DTC U0141.
Bulletin Number: TSB1954009
This is a Technical Service Bulletin sent to dealers. This bulletin updates the Circuit Diagrams section of the affected Service Manuals for the following areas: Taillight, Position Light, Rear Side Marker Light, License Plate Light, Light
Bulletin Number: TSB-19-54-010
This is a Technical Bulletin sent to dealers. This bulletin provides dealers with a basic description of the hands-free systems used in Mitsubishi built vehicles. The bulletin covers components and operation, system layouts showing the diff
Bulletin Number: TT237
This is a service newsletter (Tech Talk) that was sent out to dealers.
Bulletin Number: TT-C1219-C2205
MITSUBISHI: IF THE CLOCKSPRING HAS BEEN REPLACED FOR THE SUBJECT DTCS AND THE DTCS RESET, NOTE THAT THE STEERING ANGLE SENSOR (SAS) IS NOT PART OF THE CLOCKSPRING. *PE
2007 MITSUBISHI RAIDER
Bulletin Number: 0723005
TORQUE CONVERTER SHUDDER. *KB
Bulletin Number: 137
REPLACE THE PCM OR ELECTRONICALLY CONTROLLED THROTTLE. *KB
Bulletin Number: 137
REPROGRAMMING THE PCM DRIVABILITY OR SENSITIVITY ISSUES CAN BE CORRECTED. *KB
Bulletin Number: MEDICUpdate517
This is a message sent to dealers, to inform them that an update for MEDIC will be available.
Bulletin Number: TAKATADEALERUPDA
This is a letter that was sent to dealers, informing them of Takata's decision to perform a national recall of certain types of air bag inflators, and of MMNA's ongoing impact evaluation.
Bulletin Number: TIN-19-00-003
This is a Technical Information Notice sent to all dealers in the state of Mississippi. This notice informs dealers that MMNA will be mailing letters to owners, with Mississippi addresses, with open Takata airbag recalls. The notice instruc
Bulletin Number: TSB-08-23-007
MITSUBISHI: TORQUE CONVERTOR CLUTCH (TCC) SHUDDER OR 1-2 OR 2-3 SHIFT HARSHNESS. AFFECT VEHICLES WITH AUTOMATIC TRANSMISSION. *PE
Bulletin Number: TSB-10-042A-004
MITSUBISHI: WATER LEAK ON PASSENGER FLOORBOARD. AFFECTED VEHICLES MAY HAVE A WATER LEAK ON THE PASSENGER SIDE FLOOR. IF THE VEHICLE IS PARKED FACING UPHILL WHILE RAINING OR WHEN THE VEHICLE IS WASHED, WATER CAN LEAK PAST THE COWL TRIM W
Bulletin Number: TSB-19-00-008
This is a Technical Service Bulletin sent to dealers. This bulletin supersedes TSB-18-00-003, issued April, 2018, to add updated information for Carrying Capacity Reduced Label.
Bulletin Number: TT237
This is a service newsletter (Tech Talk) that was sent out to dealers.
2007 MITSUBISHI FUSO FE639
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FE83D
Bulletin Number: 06003
BOSCH AND DENSO COMMON RAIL FUEL SUPPLY PUMP TIGHTENING TORQUE SPECIFICATIONS. *TT
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FE84D
Bulletin Number: 06003
BOSCH AND DENSO COMMON RAIL FUEL SUPPLY PUMP TIGHTENING TORQUE SPECIFICATIONS. *TT
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FE85D
Bulletin Number: 06003
BOSCH AND DENSO COMMON RAIL FUEL SUPPLY PUMP TIGHTENING TORQUE SPECIFICATIONS. *TT
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FG84D
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FK617
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FK61F
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FK65F
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FM617
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FM61F
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FM64F
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FM657
Bulletin Number: 1002810
PRODUCT IMPROVEMENT CAMPAIGN C1002810-FM65 A/T OIL COOLER -- CERTAIN 2001-2007 MODEL YEAR FM657 & FM65F TRUCKS PRODUCED FROM JAN. 7, 2000 THROUGH DEC. 22, 2006 EQUIPPED WITH AN ALLISON MD3060 TRANSMISSION. *NJ
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER
2007 MITSUBISHI FUSO FM65F
Bulletin Number: 1002310
PRODUCT IMPROVEMENT CAMPAIGN C1002310 - FM65F BRAKE EXPANDER -- CERTAIN 2007 MODEL YEAR FM65F TRUCKS PRODUCED FROM JANUARY 12, 2006 THROUGH OCTOBER 23, 2006. *NJ
Bulletin Number: 1002810
PRODUCT IMPROVEMENT CAMPAIGN C1002810-FM65 A/T OIL COOLER -- CERTAIN 2001-2007 MODEL YEAR FM657 & FM65F TRUCKS PRODUCED FROM JAN. 7, 2000 THROUGH DEC. 22, 2006 EQUIPPED WITH AN ALLISON MD3060 TRANSMISSION. *NJ
Bulletin Number: SC-C-0040690
MITSUBISHI TRUCK: DPF CAUTION LABEL. ENCLOSED IS A REPLACEMENT SELF ADHESIVE DIESEL PARTICULATE FILTER (DPF) CAUTION LABEL TO INSTALL OVER THE EXISTING LABEL AND A REPLACEMENT DPF HANG TAG FOR THE TRUCK. THE NEW LABEL AND HANG TAG BETTER

 

Recalls for 2007 Mitsubishi

2007 MITSUBISHI ECLIPSE
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:03/17/2005 - 02/28/2007
Potential Units Affected:45988

Defect Description:

MITSUBISHI IS RECALLING 45,988 MY 2005-2007 ENDEAVOR, GALANT, ECLIPSE COUPE, AND MY 2007 ECLIPSE SPYDER VEHICLES. THE BRACKET THAT IS THE ATTACHMENT POINT FOR THE LEFT REAR FUEL TANK MOUNTING STRAP MAY HAVE BEEN IMPROPERLY FORMED DURING A METAL STAMPING PROCESS. THE PROCESS MAY HAVE CAUSED THE METAL TO HAVE A SPLIT IN THE AREA WHERE THE BOLT THAT HOLDS ONE OF THE TWO FUEL TANK STRAPS TO THE UNDERSIDE OF THE VEHICLE IS LOCATED. IN THE EVENT THE FUEL TANK IS FULL AND THE VEHICLE IS SUBJECT TO A SEVERE COLLISION, THE BRACKET MAY BREAK AND ALLOW THE FUEL TANK TO DROP DOWN, POSSIBLY CAUSING A FUEL LEAK.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT TO SEE IF THE LEFT REAR FUEL TANK STRAP MOUNTING BRACKET HAS SPLITTING BEYOND A SPECIFIC LIMIT. VEHICLES WITH MODERATE TO SEVERE SPLITTING WILL BE REPAIRED USING A REINFORCEMENT CAP, A SPECIAL STRUCTURAL ADHESIVE, AND A RIVET TO REINFORCE THE FUEL TANK MOUNTING BRACKET. THE RECALL BEGAN ON SEPTEMBER 20, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
2007 MITSUBISHI ECLIPSE
NHTSA Campaign ID:STRUCTURE:FRAME AND MEMBERS
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:06/21/2006 - 07/19/2006
Potential Units Affected:1516

Defect Description:

ON CERTAIN PASSENGER VEHICLES, THE METAL FORMING PART OF THE FRONT CROSSMEMBER MAY HAVE BEEN IMPROPERLY STAMPED RESULTING IN THE METAL BECOMING THINNER IN THE CROSS-SECTION THAN SPECIFIED. THIS COULD, OVER TIME, RESULT IN BREAKAGE OF THE CROSSMEMBER.

Consequence:

BREAKAGE OF THE CROSSMEMBER MAY ALLOW SEPARATION OF THE PASSENGER SIDE LOWER CONTROL ARM, WHICH MAY RESULT IN THE LOSS OF STEERING CONTROL INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT AND REPLACE THE CROSSMEMBER FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 21, 2006. OWNERS MAY CONTACT MITSUBISHI AT 888-648-7820.
2007 MITSUBISHI ECLIPSE
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:08/23/2006 - 09/11/2006
Potential Units Affected:1772

Defect Description:

ON CERTAIN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE KEY LOCK CABLE WAS IMPROPERLY MANUFACTURED AND MAY NOT ALLOW THE CABLE END TO LOCK INTO THE FLOOR SHIFTER MECHANISM. THIS CAN RESULT IN THE INTERLOCK SYSTEM TO BECOME INOPERATIVE AND ALLOW THE IGNITION KEY TO BE REMOVED WITHOUT THE GEARSHIFT MECHANISM BEING PLACED IN THE PARK POSITION.

Consequence:

IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.

Action:

DEALERS WILL INSPECT THE IGNITION INTERLOCK CABLE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 20, 2006. OWNERS MAY CONTACT MITSUBISHI AT 1-888-648-7820.
2007 MITSUBISHI ECLIPSE
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:04/20/2005 - 02/13/2009
Potential Units Affected:74836

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2006-2009 Eclipse vehicles manufactured April 20, 2005, to February 13, 2009, and 2007-2009 Eclipse Spyder vehicles manufactured December 23, 2005, to February 13, 2009. Due to corrosion inside the antil-lock brake system (ABS) unit, one or more of the internal valves may seize. In a braking event that uses the ABS, a seized valve would increase brake pedal travel and reduce braking ability.

Consequence:

A sudden reduction of braking performance may increase the risk of a crash.

Action:

MMNA will notify owners, and dealers will inspect, flush and clean the ABS hydraulic unit using high grade brake fluid, free of charge. If the inspection shows that the valves may seize, the ABS unit will be replaced. The recall began on July 21, 2015. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-15-004.
2007 MITSUBISHI ECLIPSE SPYDER
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:03/17/2005 - 02/28/2007
Potential Units Affected:45988

Defect Description:

MITSUBISHI IS RECALLING 45,988 MY 2005-2007 ENDEAVOR, GALANT, ECLIPSE COUPE, AND MY 2007 ECLIPSE SPYDER VEHICLES. THE BRACKET THAT IS THE ATTACHMENT POINT FOR THE LEFT REAR FUEL TANK MOUNTING STRAP MAY HAVE BEEN IMPROPERLY FORMED DURING A METAL STAMPING PROCESS. THE PROCESS MAY HAVE CAUSED THE METAL TO HAVE A SPLIT IN THE AREA WHERE THE BOLT THAT HOLDS ONE OF THE TWO FUEL TANK STRAPS TO THE UNDERSIDE OF THE VEHICLE IS LOCATED. IN THE EVENT THE FUEL TANK IS FULL AND THE VEHICLE IS SUBJECT TO A SEVERE COLLISION, THE BRACKET MAY BREAK AND ALLOW THE FUEL TANK TO DROP DOWN, POSSIBLY CAUSING A FUEL LEAK.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT TO SEE IF THE LEFT REAR FUEL TANK STRAP MOUNTING BRACKET HAS SPLITTING BEYOND A SPECIFIC LIMIT. VEHICLES WITH MODERATE TO SEVERE SPLITTING WILL BE REPAIRED USING A REINFORCEMENT CAP, A SPECIAL STRUCTURAL ADHESIVE, AND A RIVET TO REINFORCE THE FUEL TANK MOUNTING BRACKET. THE RECALL BEGAN ON SEPTEMBER 20, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
2007 MITSUBISHI ECLIPSE SPYDER
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:12/23/2005 - 02/13/2009
Potential Units Affected:74836

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2006-2009 Eclipse vehicles manufactured April 20, 2005, to February 13, 2009, and 2007-2009 Eclipse Spyder vehicles manufactured December 23, 2005, to February 13, 2009. Due to corrosion inside the antil-lock brake system (ABS) unit, one or more of the internal valves may seize. In a braking event that uses the ABS, a seized valve would increase brake pedal travel and reduce braking ability.

Consequence:

A sudden reduction of braking performance may increase the risk of a crash.

Action:

MMNA will notify owners, and dealers will inspect, flush and clean the ABS hydraulic unit using high grade brake fluid, free of charge. If the inspection shows that the valves may seize, the ABS unit will be replaced. The recall began on July 21, 2015. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-15-004.
2007 MITSUBISHI ECLIPSE SPYDER
NHTSA Campaign ID:STRUCTURE:FRAME AND MEMBERS
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:06/21/2006 - 07/19/2006
Potential Units Affected:1516

Defect Description:

ON CERTAIN PASSENGER VEHICLES, THE METAL FORMING PART OF THE FRONT CROSSMEMBER MAY HAVE BEEN IMPROPERLY STAMPED RESULTING IN THE METAL BECOMING THINNER IN THE CROSS-SECTION THAN SPECIFIED. THIS COULD, OVER TIME, RESULT IN BREAKAGE OF THE CROSSMEMBER.

Consequence:

BREAKAGE OF THE CROSSMEMBER MAY ALLOW SEPARATION OF THE PASSENGER SIDE LOWER CONTROL ARM, WHICH MAY RESULT IN THE LOSS OF STEERING CONTROL INCREASING THE RISK OF A CRASH.

Action:

DEALERS WILL INSPECT AND REPLACE THE CROSSMEMBER FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 21, 2006. OWNERS MAY CONTACT MITSUBISHI AT 888-648-7820.
2007 MITSUBISHI ECLIPSE SPYDER
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:08/23/2006 - 09/11/2006
Potential Units Affected:1772

Defect Description:

ON CERTAIN VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE KEY LOCK CABLE WAS IMPROPERLY MANUFACTURED AND MAY NOT ALLOW THE CABLE END TO LOCK INTO THE FLOOR SHIFTER MECHANISM. THIS CAN RESULT IN THE INTERLOCK SYSTEM TO BECOME INOPERATIVE AND ALLOW THE IGNITION KEY TO BE REMOVED WITHOUT THE GEARSHIFT MECHANISM BEING PLACED IN THE PARK POSITION.

Consequence:

IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.

Action:

DEALERS WILL INSPECT THE IGNITION INTERLOCK CABLE AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 20, 2006. OWNERS MAY CONTACT MITSUBISHI AT 1-888-648-7820.
2007 MITSUBISHI ENDEAVOR
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:03/17/2005 - 02/28/2007
Potential Units Affected:45988

Defect Description:

MITSUBISHI IS RECALLING 45,988 MY 2005-2007 ENDEAVOR, GALANT, ECLIPSE COUPE, AND MY 2007 ECLIPSE SPYDER VEHICLES. THE BRACKET THAT IS THE ATTACHMENT POINT FOR THE LEFT REAR FUEL TANK MOUNTING STRAP MAY HAVE BEEN IMPROPERLY FORMED DURING A METAL STAMPING PROCESS. THE PROCESS MAY HAVE CAUSED THE METAL TO HAVE A SPLIT IN THE AREA WHERE THE BOLT THAT HOLDS ONE OF THE TWO FUEL TANK STRAPS TO THE UNDERSIDE OF THE VEHICLE IS LOCATED. IN THE EVENT THE FUEL TANK IS FULL AND THE VEHICLE IS SUBJECT TO A SEVERE COLLISION, THE BRACKET MAY BREAK AND ALLOW THE FUEL TANK TO DROP DOWN, POSSIBLY CAUSING A FUEL LEAK.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT TO SEE IF THE LEFT REAR FUEL TANK STRAP MOUNTING BRACKET HAS SPLITTING BEYOND A SPECIFIC LIMIT. VEHICLES WITH MODERATE TO SEVERE SPLITTING WILL BE REPAIRED USING A REINFORCEMENT CAP, A SPECIAL STRUCTURAL ADHESIVE, AND A RIVET TO REINFORCE THE FUEL TANK MOUNTING BRACKET. THE RECALL BEGAN ON SEPTEMBER 20, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
2007 MITSUBISHI ENDEAVOR
NHTSA Campaign ID:ELECTRICAL SYSTEM: SOFTWARE
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:05/16/2006 - 01/28/2008
Potential Units Affected:19410

Defect Description:

MITSUBISHI IS RECALLING CERTAIN MODEL YEAR 2006-2008 ENDEAVOR WITH MANUAL AIR CONDITIONING. DUE TO AN INCORRECT HEATER (HVAC) CONTROLLER SIGNAL, THE AIR FLOW FROM THE AIR VENTS MAY RANDOMLY CHANGE DIRECTION AND/OR THE TEMPERATURE MAY BRIEFLY CYCLE BETWEEN HOT AND COLD.

Consequence:

THIS CONDITION COULD AFFECT DEFROSTER PERFORMANCE, RESULTING IN POOR WINDSHIELD VISIBILITY AND POTENTIALLY CAUSE A CRASH.

Action:

DEALERS WILL INSPECT FOR DAMAGE AND IF NECESSARY REPAIR THE MODE DOOR SHAFT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 7, 2010. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
2007 MITSUBISHI ENDEAVOR
NHTSA Campaign ID:SEAT BELTS:FRONT
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:07/10/2006 - 02/16/2007
Potential Units Affected:7340

Defect Description:

ON CERTAIN PASSENGER VEHICLES, THE RIGHT SIDE LOWER SEAT BELT ANCHOR MAY SEPARATE DURING A SEVERE VEHICLE CRASH.

Consequence:

BREAKAGE OF THE MOUNTING BRACKET IN A SEVERE CRASH COULD ALLOW THE SEAT BELT TO NOT PROPERLY RESTRAIN THE PASSENGER AND POTENTIALLY RESULT IN INJURY OR DEATH.

Action:

DEALERS WILL REPLACE THE FRONT PASSENGER SIDE SEAT BELT AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 17, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
2007 MITSUBISHI ENDEAVOR
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates: -
Potential Units Affected:108147

Defect Description:

MITSUBISHI IS RECALLING CERTAIN MODEL YEAR 2004-2010 ENDEAVOR VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND WASHINGTON D.C. COLD STATES INCLUDE NORTH DAKOTA, SOUTH DAKOTA, NEBRASKA, KANSAS, OKLAHOMA, COLORADO, WYOMING, MONTANA, IDAHO, WASHINGTON, OREGON, AND UTAH. ADJOINING STATES INCLUDE ARKANSAS, TENNESSEE, AND NORTH CAROLINA. IN SEVERE CORROSIVE ENVIRONMENTS WHERE ROAD SALTS ARE FREQUENTLY USED IN WINTER VEHICLES MAY BE EXPOSED TO ROAD DEBRIS (MUD) MIXED WITH ROAD SALT. THIS MATERIAL CAN BECOME TRAPPED BETWEEN A REINFORCING BRACKET AND THE FUEL FILLER PIPE, POTENTIALLY CAUSING CORROSION. OVER TIME, CORROSION COULD CREATE A LEAK IN THE FUEL FILLER PIPE THAT COULD RESULT IN A FUEL LEAKAGE WHEN FUELING THE VEHICLE.

Consequence:

FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Action:

DEALERS WILL REPLACE THE FUEL FILLER PIPE WITH A NEW IMPROVED PART FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 5, 2010. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
2007 MITSUBISHI ENDEAVOR
NHTSA Campaign ID:ELECTRICAL SYSTEM:IGNITION
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates: -
Potential Units Affected:116600

Defect Description:

MITSUBISHI IS RECALLING 120,000 MY 2004-2006 ENDEAVOR PASSENGER VEHICLES. DURING VEHICLE USE, THE IGNITION KEY INTERLOCK CABLE (WHICH IS A COMPONENT OF THE INTERLOCK SYSTEM) MAY ALLOW THE INTERLOCKING CAM TO FALL FORWARD AND ALLOW THE IGNITION KEY TO BE REMOVED FROM THE IGNITION SWITCH WHEN THE GEARSHIFT MECHANISM IS NOT IN THE PARK POSITION.

Consequence:

IF THE DRIVER DOES NOT SHIFT TO PARK BEFORE REMOVING THE KEY AND FAILS TO ENGAGE THE PARKING BRAKE, THE VEHICLE COULD ROLL AND A CRASH COULD OCCUR.

Action:

DEALERS WILL INSPECT AND CORRECT THESE VEHICLES FOR THE REPORTED CONDITION. THE RECALL WILL BEGIN ON JULY 7, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-888-648-7820.
2007 MITSUBISHI GALANT
NHTSA Campaign ID:FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:03/17/2005 - 02/28/2007
Potential Units Affected:45988

Defect Description:

MITSUBISHI IS RECALLING 45,988 MY 2005-2007 ENDEAVOR, GALANT, ECLIPSE COUPE, AND MY 2007 ECLIPSE SPYDER VEHICLES. THE BRACKET THAT IS THE ATTACHMENT POINT FOR THE LEFT REAR FUEL TANK MOUNTING STRAP MAY HAVE BEEN IMPROPERLY FORMED DURING A METAL STAMPING PROCESS. THE PROCESS MAY HAVE CAUSED THE METAL TO HAVE A SPLIT IN THE AREA WHERE THE BOLT THAT HOLDS ONE OF THE TWO FUEL TANK STRAPS TO THE UNDERSIDE OF THE VEHICLE IS LOCATED. IN THE EVENT THE FUEL TANK IS FULL AND THE VEHICLE IS SUBJECT TO A SEVERE COLLISION, THE BRACKET MAY BREAK AND ALLOW THE FUEL TANK TO DROP DOWN, POSSIBLY CAUSING A FUEL LEAK.

Consequence:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Action:

DEALERS WILL INSPECT TO SEE IF THE LEFT REAR FUEL TANK STRAP MOUNTING BRACKET HAS SPLITTING BEYOND A SPECIFIC LIMIT. VEHICLES WITH MODERATE TO SEVERE SPLITTING WILL BE REPAIRED USING A REINFORCEMENT CAP, A SPECIAL STRUCTURAL ADHESIVE, AND A RIVET TO REINFORCE THE FUEL TANK MOUNTING BRACKET. THE RECALL BEGAN ON SEPTEMBER 20, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
2007 MITSUBISHI LANCER
NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:06/29/2005 - 06/19/2007
Potential Units Affected:38628

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2006-2007 Lancer and Lancer Evolution vehicles manufactured June 29, 2005, to June 19, 2007, equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating air bag deployment, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence:

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Action:

MMNA will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on July 19, 2016. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-002.
2007 MITSUBISHI LANCER
NHTSA Campaign ID:SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:06/29/2001 - 06/14/2007
Potential Units Affected:194674

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.

Consequence:

A detached front control arm can result in the loss of control of the vehicle, increasing the risk of a crash.

Action:

MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one that has a sealing/anti-corrosion agent applied to it. These repairs will be performed free of charge. The recall began January 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-003.
2007 MITSUBISHI LANCER EVOLUTION
NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:06/29/2005 - 06/19/2007
Potential Units Affected:38628

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2006-2007 Lancer and Lancer Evolution vehicles manufactured June 29, 2005, to June 19, 2007, equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating air bag deployment, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence:

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Action:

MMNA will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on July 19, 2016. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-002.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:09/08/2006 - 12/28/2006
Potential Units Affected:21493

Defect Description:

MITSUBISHI IS RECALLING 21,493 MY 2007-2008 OUTLANDER VEHICLES EQUIPPED WITH LED TYPE STOP LAMPS AND DISTRIBUTED IN THE UNITED STATES AND PUERTO RICO. THE BRAKE LAMP SWITCH MAY MALFUNCTION AND CAUSE THE STOP LAMPS TO NOT ILLUMINATE DURING BRAKE APPLICATION.

Consequence:

THE FAILURE OF THE BRAKE LAMPS TO ILLUMINATE WHEN THE BRAKES ARE APPLIED WILL NOT PROVIDE WARNING TO FOLLOWING TRAFFIC AND COULD RESULT IN A CRASH.

Action:

DEALERS WILL REPLACE THE STOP LAMP SWITCH. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2009. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:SEATS
Manufacturer:MITSUBISHI MOTORS NORTH AMERICA, INC.
Manufacture Dates:09/08/2006 - 01/28/2008
Potential Units Affected:5400

Defect Description:

MITSUBISHI IS RECALLING 5,400 MY 2007-2008 OUTLANDER PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. FOR VEHICLES WITHOUT AN ELECTRIC POWER SEAT, THE FLOOR HARNESS CONNECTOR FOR THE POWER SEAT IS PLACED DIRECTLY ON THE FLOORBOARD UNDERNEATH THE CARPETING (VEHICLES WITH POWER SEATS ALREADY HAVE THE HARNESS ELEVATED). IF A VEHICLE OCCUPANT ENTERS THE VEHICLE WITH A SUFFICIENT AMOUNT OF SNOW ON THEIR FEET CONTAINING ROAD SALT, IT IS POSSIBLE FOR THE MELTED SNOW MIXTURE TO SOAK THE CARPET AND ALLOW THE SALT-WATER SOLUTION TO COME INTO CONTACT WITH THE UNUSED POWER SEAT HARNESS CONNECTOR.

Consequence:

THE CONNECTOR TERMINAL MAY CORRODE AND ALLOW CURRENT TO FLOW, RESULTING IN THE GRADUAL HEATING AND MELTING OF THE CONNECTOR AND MAY RESULT IN A FIRE.

Action:

DEALERS WILL RELOCATE THE FLOOR HARNESS FROM BENEATH BOTH THE PASSENGER AND DRIVER SEATS TO ABOVE THE CARPET AND AWAY FROM THE BOTTOM OF THE FLOORBOARD TO PREVENT CONTACT WITH ANY FUTURE MELT SOLUTION. THE RECALL BEGAN ON APRIL 7, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates: -
Potential Units Affected:203

Defect Description:

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2013 Outlander vehicles equipped with a 6-speed automatic transmission. Additionally, Mitusbishi is recalling certain 2007-2012 Outlander vehicles that received replacement 6-speed automatic transmissions during servicing. The transmissions in these vehicles have insufficient clearance between the power steering pressure tube and the converter housing of the automatic transmission. As a result of the contact, the power steering pressure tube may develop a hole and leak power steering fluid.

Consequence:

A power steering fluid leak could result in a loss of steering assistance, increasing the risk of a crash.

Action:

Mitsubishi will notify owners, and dealers will replace the power steering pressure tube and return tube, free of charge. The recall began in August 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-006.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:POWER TRAIN:AUTOMATIC TRANSMISSION
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates: -
Potential Units Affected:5

Defect Description:

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2007 and 2009 Outlander vehicles. During servicing, the affected vehicles were repaired with replacement transfer case assemblies whose oil seal may come out of position.

Consequence:

If the oil seal dislodges, automatic transmission fluid (ATF) may enter the transfer case assembly, reducing the ATF pressure in the transmission, resulting in poor transmission shifting or the inability of the vehicle to be driven, increasing the risk of a crash.

Action:

Mitsubishi will notify owners, and dealers will replace the transfer assembly, as necessary, free of charge. The recall began on July 30, 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-005.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates: -
Potential Units Affected:5

Defect Description:

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2007 and 2009 Outlander vehicles. During servicing, the affected vehicles were repaired with replacement transfer case assemblies whose oil seal may come out of position.

Consequence:

If the oil seal dislodges, automatic transmission fluid (ATF) may enter the transfer case assembly, reducing the ATF pressure in the transmission, resulting in poor transmission shifting or the inability of the vehicle to be driven, increasing the risk of a crash.

Action:

Mitsubishi will notify owners, and dealers will replace the transfer assembly, as necessary, free of charge. The recall began on July 30, 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-005.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:09/08/2006 - 03/11/2013
Potential Units Affected:194674

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.

Consequence:

A detached front control arm can result in the loss of control of the vehicle, increasing the risk of a crash.

Action:

MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one that has a sealing/anti-corrosion agent applied to it. These repairs will be performed free of charge. The recall began January 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-003.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:12/15/2006 - 08/22/2009
Potential Units Affected:37145

Defect Description:

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2007-2009 Outlander vehicles manufactured December 15, 2006, to October 31, 2007, and April 16, 2008, to August 22, 2009. In the affected vehicles, the brake light switch may malfunction causing the brake lights to not illuminate during brake application.

Consequence:

Brake lights that are inoperative would not warn other drivers that the vehicle is stopping, increasing the risk of a crash.

Action:

Mitsubishi will notify owners, and dealers will replace the brake light switch with a new one, free of charge. The recall began in mid-October 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-010. Note: This recall is an expansion of recall 08V-680 and does not include any vehicles that were previously recalled.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:09/08/2006 - 03/29/2013
Potential Units Affected:100082

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2007-2013 Outlander vehicles. In the affected vehicles, water may drop between the hood and the windshield and leak into the wiper motor breathing hole. The water may cause internal corrosion of the windshield wiper motor and the possible failure of the motor.

Consequence:

Failure of the wiper motor can cause a loss of visibility, increasing the risk of a crash.

Action:

MMNA will notify owners, and dealers will replace the wiper motor, free of charge. The recall began July 28, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-003.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:09/08/2006 - 03/29/2013
Potential Units Affected:100082

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2007-2013 Outlander vehicles manufactured September 8, 2006, to March 29, 2013. In the affected vehicles, water may enter between the hood and windshield and cause the front wiper link ball joint to corrode, possibly resulting in the wiper link separating and the wipers becoming inoperative.

Consequence:

Loss of wiper function can reduce visibility and increase the risk of a crash.

Action:

MMNA will notify owners, and dealers will replace the rubber boot on the ball joint to prevent water intrusion. Additionally, they will inspect the wiper motor crank arm for excessive play, replacing it as necessary. These repairs will be done free of charge. The recall began on July 28, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-009.
2007 MITSUBISHI OUTLANDER
NHTSA Campaign ID:VISIBILITY:SUN ROOF ASSEMBLY
Manufacturer:Mitsubishi Motors North America, Inc.
Manufacture Dates:09/08/2006 - 11/03/2009
Potential Units Affected:56641

Defect Description:

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2007-2010 Outlander, 2008-2010 Lancer, 2009-2010 Lancer Evolution, and 2010 Lancer Sportback vehicles equipped with sunroofs. The sunroof glass may detach from the sunroof assembly, becoming a road hazard to other vehicles.

Consequence:

If the sunroof glass detaches from the assembly while driving, it can become a road hazard, increasing the risk of a crash.

Action:

MMNA will notify owners, and dealers will replace the sunroof glass assembly, free of charge. The recall began on February 27, 2018. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-18-003.
2007 MITSUBISHI RAIDER
NHTSA Campaign ID:AIR BAGS:PASSENGER SIDE FRONTAL
Manufacturer:Chrysler (FCA US LLC)
Manufacture Dates:01/01/2005 - 01/01/2009
Potential Units Affected:4648270

Defect Description:

Chrysler (FCA US LLC) expanded the affected population to include 73,712 2005-2009 RAM 2500 trucks produced at the St. Louis North Assembly Plant. With this change, Chrysler is recalling certain model year 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2010 RAM 3500 Cab Chassis, 2008-2010 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2012 Jeep Wrangler, 2008-2012 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2012 Chrysler 300, 2006-2012 Dodge Charger, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AL, CA, FL, GA, HI, LA, MS, SC, TX, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Chrysler is also recalling 2004-2008 RAM 1500, 2005-2009 RAM 2500, 2006-2009 RAM 3500, 2007-2009 RAM 3500 Cab Chassis, 2008-2009 RAM 4500 and 5500 Cab Chassis, 2004-2009 Dodge Durango, 2007-2009 Chrysler Aspen, 2007-2009 Jeep Wrangler, 2008-2009 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2009 Chrysler 300, 2006-2009 Dodge Charger, 2005-2009 Dodge Dakota and 2006-2009 Mitsubishi Raider vehicles originally sold, or ever registered, in AZ, AR, DE, Washington D.C., IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Chrysler is recalling certain 2005-2008 RAM 2500, 2006-2008 RAM 3500, 2007-2008 RAM 3500 Cab Chassis, 2008 RAM 4500 and 5500 Cab Chassis, 2004-2008 Dodge Durango, 2007-2008 Chrysler Aspen, 2007-2008 Jeep Wrangler, 2008 Dodge Challenger, 2005-2008 Dodge Magnum, 2005-2008 Chrysler 300, 2006-2008 Dodge Charger, 2005-2008 Dodge Dakota, and 2006-2008 Mitsubishi Raider vehicles originally sold, or registered, in AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY.

Consequence:

These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. These inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling. An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Action:

Chrysler will notify the Chrysler, Dodge, Jeep and RAM owners. Mitsubishi owners will be notified by their company. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began on March 27, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S43. Note: This recall supersedes recall 14V-7700.
2007 MITSUBISHI RAIDER
NHTSA Campaign ID:AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE
Manufacturer:Chrysler (FCA US LLC)
Manufacture Dates:01/01/2005 - 12/31/2009
Potential Units Affected:4077169

Defect Description:

Chrysler (FCA US LLC) is recalling certain model year 2005-2009 Dodge Ram 2500, 2004-2008 Dodge Ram 1500 and Durango, 2006-2009 Dodge Ram 3500, 2008-2010 Dodge Ram 4500 and 5500, 2007-2008 Chrysler Aspen, 2005-2010 Chrysler 300, 300C, 300S, and SRT8, 2006-2010 Dodge Charger, 2005-2008 Magnum, 2005-2011 Dodge Dakota, and 2006-2009 Mitsubishi Raider vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture.

Consequence:

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Action:

Chrysler will notify the affected Chrysler and Dodge owners and Mitsubishi will notify the affected Raider owners. Dealers will replace the driver's frontal air bag inflator, free of charge. The recall began for Chrylser on June 8, 2015. The recall for Mitsubishi started on June 24, 2015. Chrysler and Dodge owners may contact Chrysler customer service at 1-800-853-1403. Mitsubishi owners may call 1-888-648-7820. Chrysler's number for this recall is R25. Note: This recall supersedes recall 14V817 in its entirety. Vehicles that have had their driver side frontal air bag replaced previously need to have their air bag replaced under this recall as well.
2007 MITSUBISHI FUSO FE83D
NHTSA Campaign ID:EQUIPMENT
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:05/27/2004 - 09/28/2009
Potential Units Affected:16384

Defect Description:

MITSUBISHI FUSO IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2010 FE83D, FE84D, FE85D AND FG84D VEHICLES. THE WEATHER RESISTANCE PROPERTIES OF THE AIR INTAKE DUCT RUBBER CUSHIONS IS INSUFFICIENT. DURING NORMAL VEHICLE OPERATION, THE RUBBER CUSHIONS DETERIORATE AND CRACK, CAUSING ABNORMAL NOISE.

Consequence:

ALL OF THE RUBBER CUSHIONS COULD CRACK, ALLOWING THE AIR INTAKE DUCT TO FALL OFF OF THE TRUCK INCREASING THE RISK OF CRASH.

Action:

DEALERS WILL REPLACE ALL OF THE AIR INTAKE DUCT RUBBER CUSHIONS WITH COMPONENTS MANUFACTURED TO PROPER SPECIFICATIONS. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 19, 2010. OWNERS MAY CONTACT MITSUBISHI FUSO AT 1-856-467-4500.
2007 MITSUBISHI FUSO FE83D
NHTSA Campaign ID:FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:05/27/2004 - 04/27/2007
Potential Units Affected:13644

Defect Description:

Mitsubishi Fuso Truck of America (MFTA) is recalling certain model year 2005-2007 FE83D, FE84D, FE85D, and FG84D trucks; manufactured from May 27, 2004, through May 14, 2007. The fuel pipes may crack due to an improper manufacturing process. Additionally, the fuel pipe flare nuts may have been insufficiently tightened.

Consequence:

Cracked fuel pipes or loose fuel pipe flare nuts may leak fuel. A fuel leak in the presence of an ignition source may result in a vehicle fire.

Action:

MFTA will notify owners, and dealers will inspect the fuel pipes and tighten or replace them as needed, free of charge. The safety recall began on January 21, 2013. Owners may contact MFTA at 1-856-467-4500.
2007 MITSUBISHI FUSO FE84D
NHTSA Campaign ID:EQUIPMENT
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:05/27/2004 - 09/30/2009
Potential Units Affected:16384

Defect Description:

MITSUBISHI FUSO IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2010 FE83D, FE84D, FE85D AND FG84D VEHICLES. THE WEATHER RESISTANCE PROPERTIES OF THE AIR INTAKE DUCT RUBBER CUSHIONS IS INSUFFICIENT. DURING NORMAL VEHICLE OPERATION, THE RUBBER CUSHIONS DETERIORATE AND CRACK, CAUSING ABNORMAL NOISE.

Consequence:

ALL OF THE RUBBER CUSHIONS COULD CRACK, ALLOWING THE AIR INTAKE DUCT TO FALL OFF OF THE TRUCK INCREASING THE RISK OF CRASH.

Action:

DEALERS WILL REPLACE ALL OF THE AIR INTAKE DUCT RUBBER CUSHIONS WITH COMPONENTS MANUFACTURED TO PROPER SPECIFICATIONS. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 19, 2010. OWNERS MAY CONTACT MITSUBISHI FUSO AT 1-856-467-4500.
2007 MITSUBISHI FUSO FE84D
NHTSA Campaign ID:EQUIPMENT
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:04/03/2003 - 03/03/2017
Potential Units Affected:1153

Defect Description:

Mitsubishi Fuso Truck of America, Inc. (MFTA) is recalling certain 2004-2017 FE84D, FE85D, FEC52, FEC72, FEC92, FGB72, FK61F and FM657 trucks. These trucks are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence:

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Action:

MFTA will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 11, 2018. Owners may contact MFTA customer service at 1-877-711-0707, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. MFTA's number for this recall is MFV00001.
2007 MITSUBISHI FUSO FE84D
NHTSA Campaign ID:FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:05/27/2004 - 05/14/2007
Potential Units Affected:13644

Defect Description:

Mitsubishi Fuso Truck of America (MFTA) is recalling certain model year 2005-2007 FE83D, FE84D, FE85D, and FG84D trucks; manufactured from May 27, 2004, through May 14, 2007. The fuel pipes may crack due to an improper manufacturing process. Additionally, the fuel pipe flare nuts may have been insufficiently tightened.

Consequence:

Cracked fuel pipes or loose fuel pipe flare nuts may leak fuel. A fuel leak in the presence of an ignition source may result in a vehicle fire.

Action:

MFTA will notify owners, and dealers will inspect the fuel pipes and tighten or replace them as needed, free of charge. The safety recall began on January 21, 2013. Owners may contact MFTA at 1-856-467-4500.
2007 MITSUBISHI FUSO FE84D
NHTSA Campaign ID:SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:07/21/2005 - 09/04/2006
Potential Units Affected:5466

Defect Description:

ON CERTAIN TRUCKS, THE BRAKE VACUUM HOSE MAY HAVE BEEN MANUFACTURED WITH INSUFFICIENT WALL THICKNESS, ALLOWING THE HOSE TO COLLAPSE DURING NORMAL VEHICLE OPERATION.

Consequence:

CONTINUED OPERATION OF THE VEHICLE IN THIS CONDITION COULD RESTRICT PROPER OPERATION OF THE BRAKE POWER-ASSIST AND COMPROMISE BRAKING PERFORMANCE; OR RESTRICT PROPER OPERATION OF THE EXHAUST BRAKE SYSTEM. EITHER OCCURRENCE COULD LEAD TO COMPROMISED BRAKING PERFORMANCE AND INCREASED BRAKING DISTANCE, WHICH COULD CAUSE A CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE BRAKE VACUUM HOSE AND WILL REPLACE THE HOSE. THE RECALL BEGAN ON DECEMBER 21, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 877-711-0707.
2007 MITSUBISHI FUSO FE85D
NHTSA Campaign ID:EQUIPMENT
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:05/27/2004 - 09/30/2009
Potential Units Affected:16384

Defect Description:

MITSUBISHI FUSO IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2010 FE83D, FE84D, FE85D AND FG84D VEHICLES. THE WEATHER RESISTANCE PROPERTIES OF THE AIR INTAKE DUCT RUBBER CUSHIONS IS INSUFFICIENT. DURING NORMAL VEHICLE OPERATION, THE RUBBER CUSHIONS DETERIORATE AND CRACK, CAUSING ABNORMAL NOISE.

Consequence:

ALL OF THE RUBBER CUSHIONS COULD CRACK, ALLOWING THE AIR INTAKE DUCT TO FALL OFF OF THE TRUCK INCREASING THE RISK OF CRASH.

Action:

DEALERS WILL REPLACE ALL OF THE AIR INTAKE DUCT RUBBER CUSHIONS WITH COMPONENTS MANUFACTURED TO PROPER SPECIFICATIONS. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 19, 2010. OWNERS MAY CONTACT MITSUBISHI FUSO AT 1-856-467-4500.
2007 MITSUBISHI FUSO FE85D
NHTSA Campaign ID:FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:05/27/2004 - 04/27/2007
Potential Units Affected:13644

Defect Description:

Mitsubishi Fuso Truck of America (MFTA) is recalling certain model year 2005-2007 FE83D, FE84D, FE85D, and FG84D trucks; manufactured from May 27, 2004, through May 14, 2007. The fuel pipes may crack due to an improper manufacturing process. Additionally, the fuel pipe flare nuts may have been insufficiently tightened.

Consequence:

Cracked fuel pipes or loose fuel pipe flare nuts may leak fuel. A fuel leak in the presence of an ignition source may result in a vehicle fire.

Action:

MFTA will notify owners, and dealers will inspect the fuel pipes and tighten or replace them as needed, free of charge. The safety recall began on January 21, 2013. Owners may contact MFTA at 1-856-467-4500.
2007 MITSUBISHI FUSO FE85D
NHTSA Campaign ID:EQUIPMENT
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:04/03/2003 - 03/03/2017
Potential Units Affected:1153

Defect Description:

Mitsubishi Fuso Truck of America, Inc. (MFTA) is recalling certain 2004-2017 FE84D, FE85D, FEC52, FEC72, FEC92, FGB72, FK61F and FM657 trucks. These trucks are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence:

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Action:

MFTA will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 11, 2018. Owners may contact MFTA customer service at 1-877-711-0707, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. MFTA's number for this recall is MFV00001.
2007 MITSUBISHI FUSO FE85D
NHTSA Campaign ID:SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:07/21/2005 - 09/04/2006
Potential Units Affected:5466

Defect Description:

ON CERTAIN TRUCKS, THE BRAKE VACUUM HOSE MAY HAVE BEEN MANUFACTURED WITH INSUFFICIENT WALL THICKNESS, ALLOWING THE HOSE TO COLLAPSE DURING NORMAL VEHICLE OPERATION.

Consequence:

CONTINUED OPERATION OF THE VEHICLE IN THIS CONDITION COULD RESTRICT PROPER OPERATION OF THE BRAKE POWER-ASSIST AND COMPROMISE BRAKING PERFORMANCE; OR RESTRICT PROPER OPERATION OF THE EXHAUST BRAKE SYSTEM. EITHER OCCURRENCE COULD LEAD TO COMPROMISED BRAKING PERFORMANCE AND INCREASED BRAKING DISTANCE, WHICH COULD CAUSE A CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE BRAKE VACUUM HOSE AND WILL REPLACE THE HOSE. THE RECALL BEGAN ON DECEMBER 21, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 877-711-0707.
2007 MITSUBISHI FUSO FEC52
NHTSA Campaign ID:EQUIPMENT
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:04/03/2003 - 03/03/2017
Potential Units Affected:1153

Defect Description:

Mitsubishi Fuso Truck of America, Inc. (MFTA) is recalling certain 2004-2017 FE84D, FE85D, FEC52, FEC72, FEC92, FGB72, FK61F and FM657 trucks. These trucks are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence:

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Action:

MFTA will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 11, 2018. Owners may contact MFTA customer service at 1-877-711-0707, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. MFTA's number for this recall is MFV00001.
2007 MITSUBISHI FUSO FEC72
NHTSA Campaign ID:EQUIPMENT
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:04/03/2003 - 03/03/2017
Potential Units Affected:1153

Defect Description:

Mitsubishi Fuso Truck of America, Inc. (MFTA) is recalling certain 2004-2017 FE84D, FE85D, FEC52, FEC72, FEC92, FGB72, FK61F and FM657 trucks. These trucks are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence:

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Action:

MFTA will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 11, 2018. Owners may contact MFTA customer service at 1-877-711-0707, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. MFTA's number for this recall is MFV00001.
2007 MITSUBISHI FUSO FEC92
NHTSA Campaign ID:EQUIPMENT
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:04/03/2003 - 03/03/2017
Potential Units Affected:1153

Defect Description:

Mitsubishi Fuso Truck of America, Inc. (MFTA) is recalling certain 2004-2017 FE84D, FE85D, FEC52, FEC72, FEC92, FGB72, FK61F and FM657 trucks. These trucks are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence:

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Action:

MFTA will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 11, 2018. Owners may contact MFTA customer service at 1-877-711-0707, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. MFTA's number for this recall is MFV00001.
2007 MITSUBISHI FUSO FG84D
NHTSA Campaign ID:EQUIPMENT
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:08/04/2004 - 09/30/2009
Potential Units Affected:16384

Defect Description:

MITSUBISHI FUSO IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2010 FE83D, FE84D, FE85D AND FG84D VEHICLES. THE WEATHER RESISTANCE PROPERTIES OF THE AIR INTAKE DUCT RUBBER CUSHIONS IS INSUFFICIENT. DURING NORMAL VEHICLE OPERATION, THE RUBBER CUSHIONS DETERIORATE AND CRACK, CAUSING ABNORMAL NOISE.

Consequence:

ALL OF THE RUBBER CUSHIONS COULD CRACK, ALLOWING THE AIR INTAKE DUCT TO FALL OFF OF THE TRUCK INCREASING THE RISK OF CRASH.

Action:

DEALERS WILL REPLACE ALL OF THE AIR INTAKE DUCT RUBBER CUSHIONS WITH COMPONENTS MANUFACTURED TO PROPER SPECIFICATIONS. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 19, 2010. OWNERS MAY CONTACT MITSUBISHI FUSO AT 1-856-467-4500.
2007 MITSUBISHI FUSO FG84D
NHTSA Campaign ID:FUEL SYSTEM, OTHER:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:08/04/2004 - 04/27/2007
Potential Units Affected:13644

Defect Description:

Mitsubishi Fuso Truck of America (MFTA) is recalling certain model year 2005-2007 FE83D, FE84D, FE85D, and FG84D trucks; manufactured from May 27, 2004, through May 14, 2007. The fuel pipes may crack due to an improper manufacturing process. Additionally, the fuel pipe flare nuts may have been insufficiently tightened.

Consequence:

Cracked fuel pipes or loose fuel pipe flare nuts may leak fuel. A fuel leak in the presence of an ignition source may result in a vehicle fire.

Action:

MFTA will notify owners, and dealers will inspect the fuel pipes and tighten or replace them as needed, free of charge. The safety recall began on January 21, 2013. Owners may contact MFTA at 1-856-467-4500.
2007 MITSUBISHI FUSO FG84D
NHTSA Campaign ID:SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:08/01/2005 - 08/31/2006
Potential Units Affected:5466

Defect Description:

ON CERTAIN TRUCKS, THE BRAKE VACUUM HOSE MAY HAVE BEEN MANUFACTURED WITH INSUFFICIENT WALL THICKNESS, ALLOWING THE HOSE TO COLLAPSE DURING NORMAL VEHICLE OPERATION.

Consequence:

CONTINUED OPERATION OF THE VEHICLE IN THIS CONDITION COULD RESTRICT PROPER OPERATION OF THE BRAKE POWER-ASSIST AND COMPROMISE BRAKING PERFORMANCE; OR RESTRICT PROPER OPERATION OF THE EXHAUST BRAKE SYSTEM. EITHER OCCURRENCE COULD LEAD TO COMPROMISED BRAKING PERFORMANCE AND INCREASED BRAKING DISTANCE, WHICH COULD CAUSE A CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT THE BRAKE VACUUM HOSE AND WILL REPLACE THE HOSE. THE RECALL BEGAN ON DECEMBER 21, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 877-711-0707.
2007 MITSUBISHI FUSO FGB72
NHTSA Campaign ID:EQUIPMENT
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:04/03/2003 - 03/03/2017
Potential Units Affected:1153

Defect Description:

Mitsubishi Fuso Truck of America, Inc. (MFTA) is recalling certain 2004-2017 FE84D, FE85D, FEC52, FEC72, FEC92, FGB72, FK61F and FM657 trucks. These trucks are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence:

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Action:

MFTA will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 11, 2018. Owners may contact MFTA customer service at 1-877-711-0707, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. MFTA's number for this recall is MFV00001.
2007 MITSUBISHI FUSO FK61F
NHTSA Campaign ID:EQUIPMENT
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:04/03/2003 - 03/03/2017
Potential Units Affected:1153

Defect Description:

Mitsubishi Fuso Truck of America, Inc. (MFTA) is recalling certain 2004-2017 FE84D, FE85D, FEC52, FEC72, FEC92, FGB72, FK61F and FM657 trucks. These trucks are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence:

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Action:

MFTA will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 11, 2018. Owners may contact MFTA customer service at 1-877-711-0707, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. MFTA's number for this recall is MFV00001.
2007 MITSUBISHI FUSO FK61F
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:01/06/2006 - 04/21/2006
Potential Units Affected:338

Defect Description:

ON CERTAIN TRUCKS, THE VIN LABEL WAS PRINTED WITH AN IMPROPER GROSS VEHICLE WEIGHT RATING (GVWR) AND GROSS AXLE WEIGHT RATING (GAWR) FOR BOTH THE FRONT AND REAR AXLES.

Consequence:

THE MANUFACTURER HAS NOT YET PROVIDED A CONSEQUENCE FOR THIS CAMPAIGN.

Action:

DEALERS WILL REPLACE THE VIN LABELS WITH CORRECTED GVWR AND GAWR VALUES FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 856-467-4500.
2007 MITSUBISHI FUSO FM61F
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:03/16/2006 - 04/11/2006
Potential Units Affected:69

Defect Description:

ON CERTAIN TRUCKS, AN EXCESSIVE AMOUNT OF WELD MATERIAL MAY BE PRESENT ON THE REAR AXLE HOUSING AT THE JOINT RETAINER. THE CLEARANCE BETWEEN THE JOINT RETAINER AND BRAKE CONNECTOR MAY BE BEYOND SPECIFICATION AND COULD CAUSE THE ATTACHING BOLT TO LOOSEN ALLOWING THE BRAKE PIPE TO VIBRATE.

Consequence:

THE BRAKE PIPE COULD CRACK, ALLOWING BRAKE FLUID TO LEAK, DECREASING BRAKING PERFORMANCE AND CAUSING A CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT AND REMOVE EXCESSIVE WELD MATERIAL AND REPAIR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 14, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 856-467-3917.
2007 MITSUBISHI FUSO FM61F
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:01/06/2006 - 04/26/2006
Potential Units Affected:338

Defect Description:

ON CERTAIN TRUCKS, THE VIN LABEL WAS PRINTED WITH AN IMPROPER GROSS VEHICLE WEIGHT RATING (GVWR) AND GROSS AXLE WEIGHT RATING (GAWR) FOR BOTH THE FRONT AND REAR AXLES.

Consequence:

THE MANUFACTURER HAS NOT YET PROVIDED A CONSEQUENCE FOR THIS CAMPAIGN.

Action:

DEALERS WILL REPLACE THE VIN LABELS WITH CORRECTED GVWR AND GAWR VALUES FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 856-467-4500.
2007 MITSUBISHI FUSO FM64F
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:01/11/2006 - 04/21/2006
Potential Units Affected:338

Defect Description:

ON CERTAIN TRUCKS, THE VIN LABEL WAS PRINTED WITH AN IMPROPER GROSS VEHICLE WEIGHT RATING (GVWR) AND GROSS AXLE WEIGHT RATING (GAWR) FOR BOTH THE FRONT AND REAR AXLES.

Consequence:

THE MANUFACTURER HAS NOT YET PROVIDED A CONSEQUENCE FOR THIS CAMPAIGN.

Action:

DEALERS WILL REPLACE THE VIN LABELS WITH CORRECTED GVWR AND GAWR VALUES FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 856-467-4500.
2007 MITSUBISHI FUSO FM64F
NHTSA Campaign ID:SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:03/16/2006 - 03/28/2006
Potential Units Affected:69

Defect Description:

ON CERTAIN TRUCKS, AN EXCESSIVE AMOUNT OF WELD MATERIAL MAY BE PRESENT ON THE REAR AXLE HOUSING AT THE JOINT RETAINER. THE CLEARANCE BETWEEN THE JOINT RETAINER AND BRAKE CONNECTOR MAY BE BEYOND SPECIFICATION AND COULD CAUSE THE ATTACHING BOLT TO LOOSEN ALLOWING THE BRAKE PIPE TO VIBRATE.

Consequence:

THE BRAKE PIPE COULD CRACK, ALLOWING BRAKE FLUID TO LEAK, DECREASING BRAKING PERFORMANCE AND CAUSING A CRASH WITHOUT WARNING.

Action:

DEALERS WILL INSPECT AND REMOVE EXCESSIVE WELD MATERIAL AND REPAIR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 14, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 856-467-3917.
2007 MITSUBISHI FUSO FM657
NHTSA Campaign ID:EQUIPMENT
Manufacturer:Mitsubishi Fuso Truck of America, Inc.
Manufacture Dates:04/03/2003 - 03/03/2017
Potential Units Affected:1153

Defect Description:

Mitsubishi Fuso Truck of America, Inc. (MFTA) is recalling certain 2004-2017 FE84D, FE85D, FEC52, FEC72, FEC92, FGB72, FK61F and FM657 trucks. These trucks are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence:

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Action:

MFTA will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 11, 2018. Owners may contact MFTA customer service at 1-877-711-0707, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. MFTA's number for this recall is MFV00001.
2007 MITSUBISHI FUSO FM65F
NHTSA Campaign ID:EQUIPMENT:OTHER:LABELS
Manufacturer:MITSUBISHI FUSO TRUCK OF AMERICA, INC.
Manufacture Dates:01/12/2006 - 03/02/2006
Potential Units Affected:338

Defect Description:

ON CERTAIN TRUCKS, THE VIN LABEL WAS PRINTED WITH AN IMPROPER GROSS VEHICLE WEIGHT RATING (GVWR) AND GROSS AXLE WEIGHT RATING (GAWR) FOR BOTH THE FRONT AND REAR AXLES.

Consequence:

THE MANUFACTURER HAS NOT YET PROVIDED A CONSEQUENCE FOR THIS CAMPAIGN.

Action:

DEALERS WILL REPLACE THE VIN LABELS WITH CORRECTED GVWR AND GAWR VALUES FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2006. OWNERS MAY CONTACT MITSUBISHI FUSO AT 856-467-4500.