Volkswagen Buyers Guide
Click a car name to see the crash test details for that model.
Crash Test Data for 2004 Volkswagen
| Volkswagen Vehicle | Front Star Rating | Side Star Rating | Rollover Resistance Rating | ||
|---|---|---|---|---|---|
| Driver | Passenger | Front Seat | Rear Seat | ||
| 2004 Golf |  | |  | | Not Tested |
| 2004 Golf/GTI | Not Tested | Not Tested | Not Tested | Not Tested | Not Tested |
| 2004 Jetta | | | | | |
| 2004 Jetta | | | Not Tested | Not Tested | |
| 2004 New Beetle | | | Not Tested | Not Tested | |
| 2004 New Beetle | | | |  | |
| 2004 Passat | | | Not Tested | Not Tested | |
| 2004 Phaeton | Not Tested | Not Tested | Not Tested | Not Tested | Not Tested |
| 2004 R32 | Not Tested | Not Tested | Not Tested | Not Tested | Not Tested |
| 2004 Touareg | | | | | Not Tested |
Service Bulletins for 2004 Volkswagen
| 2004 VOLKSWAGEN BEETLE | |
|---|---|
| Bulletin Number: 010702 | |
| DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB | |
| Bulletin Number: 01 08 07 | |
| AIRBAG MONITORING LIGHT ON, PASSENGER OCCUPANT DETECTION SYSTEM, DTC 02511 014 STORED IN MEMORY. *NJ | |
| Bulletin Number: 0405 | |
| HYBRID OIL PAN, INSTALLING. *TT | |
| Bulletin Number: 0406 | |
| HARD STARTING (EXTENDED CRANKING REQUIRED) OR NO START WHEN WET, RUNS ROUGH ON INITIAL START, MAY BE ACCOMPANIED BY LIGHT GRAY SMOKE. *TT | |
| Bulletin Number: 0501 | |
| FUEL GAUGE SENDER, INCORRECT READING. TO INCLUDE VOLKSWAGEN JETTA 2006. *TT | |
| Bulletin Number: 0502 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0511 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P0101 (16485) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0603 | |
| DOOR WINDOWS, MAY SEPERATE FROM WINDOW REGULATOR CLAMPS. *KB | |
| Bulletin Number: 11292005 | |
| ENGINE PRE-HEATER INSTALLATION. CALIX. *TT | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 2010462 | |
| ROUGH ON INITIAL START AT TEMPERATURES BELOW 20 DEGREES F. *KB | |
| Bulletin Number: 2010463 | |
| UPDATE PROGRAMMING, HARD STARTING (EXTENDED CRANKING REQUIRED OR NO START WHEN WET, RUNS ROUGH ON INITIAL START, MAY BE ACCOMPANIED BY LIGHT GRAY SMOKE. *KB | |
| Bulletin Number: 2015831 | |
| VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE | |
| Bulletin Number: 230501 | |
| RUNS ROUGH ON INITIAL START AT TEMPERATURES BELOW -7 DEGREES C (20 DEGREES F). *TT UPDATE. *TT UPDATE. *TT | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: 610501 | |
| HEADLINER, LOOSE AROUND REAR GLASS. *TT | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Control Module R | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: PDI - BEETLE TEC | |
| Beetle Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purc | |
| Bulletin Number: QRUG08212019 | |
| Quick Reference Update Guide. | |
| Bulletin Number: Quick Reference | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: Quick Reference | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Reference Guide | |
| Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. | |
| Bulletin Number: Reference - Refl | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Ref. - Reflash U | |
| Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. | |
| Bulletin Number: SA-28F3 | |
| VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION | |
| Bulletin Number: SA-28F6 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ENGINE SOFTWARE MAY CAUSE THE VEHICLE TO EXCEED EMISSIONS STANDARDS. *RM | |
| Bulletin Number: SA-60A7-S9 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSPECT, CLEAN AND MODIFY SUNROOF DRAINS FOR CERTAIN VOLKSWAGEN VEHICLES AND REVISED MAINTENANCE SCHEDULE; SUNROOF DRAIN INSPECTION AND CLEANING. NO MODELS OR MODEL | |
| Bulletin Number: SAC-28F3/P1-REV | |
| VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A | |
| Bulletin Number: SB-28F3 | |
| VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER | |
| Bulletin Number: SB-69-11-01 | |
| VOLKSWAGEN: AIR BAG LIGHT IS ON WITH AN INTERNAL TROUBLE CODE STORED. THIS COULD BE A WIRING PROBLEM. *RM | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-00-10-06 | |
| VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE | |
| Bulletin Number: TB-01-10-13 | |
| VOLKSWAGEN: UPDATE PROGRAMMING; ENGINE RUNS ROUGH ON INITIAL START AT TEMPERATURES BELOW-7%C (20%F). SOFTWARE UPDATE AND NEW INJECTORS. INSTALLING NEW INJECTORS AND ENGINE CONTROL MODEL UPDATE-PROGRAMMING (FLASHING) USING SOFTWARE VERSION | |
| Bulletin Number: TB-01-12-04 | |
| VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE | |
| Bulletin Number: TB-09-10-02 | |
| VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE FLUCTUATIONS. SOME ELECTRIC CONSUMERS COME ON IN CYCLES OR HAVE NO CONSTANT | |
| Bulletin Number: TB-35-11-01 | |
| VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM | |
| Bulletin Number: TB-94-10-02 | |
| VOLKSWAGEN: HEADLIGHTS MAY INTERMITTENTLY DIM SLIGHTLY AT IDLE. THE HEADLAMPS OR INSIDE LIGHTS INTERMITTENTLY DIM SLIGHTLY AT IDLE SPEED. AT IDLE SPEED THE ALTERNATOR VOLTAGE CAN FLUCTUATE, AS THE ALTERNATOR CANNOT FULLY COMPENSATE THE F | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-13-02 | |
| Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it | |
| Bulletin Number: TT 00-13-04 | |
| Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Spec | |
| Bulletin Number: TT 00-14-03 | |
| Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT001703 | |
| Tip for Scan tool concerns that may occur duing a test plan | |
| Bulletin Number: TT 10 12 01 | |
| Engine replacement tip | |
| Bulletin Number: TT 200901 | |
| Update to existing tip for fuel quality checking. | |
| Bulletin Number: TT 20-09-06 | |
| Tech Tips (TDI Engine - N75 Solenoid Valve Diagnosis): This document informs with graphical aid the testing of the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234. This applies to Mechanical Injection St | |
| Bulletin Number: TT 20-13-01 | |
| Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without co | |
| Bulletin Number: TT 21-13-01 | |
| Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Thi | |
| Bulletin Number: TT 24-08-01 | |
| Tech Tips (Models with 1.8T Engine - Pressure Loss issues): Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then returned to idle. This document informs of what to do should th | |
| Bulletin Number: TT 271002 | |
| Updated to include model year 2014 thru 2018 applicability. | |
| Bulletin Number: TT 32-14-01 | |
| Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installat | |
| Bulletin Number: TT 37-06-06 | |
| Tech Tips (Vehicles with 09G or 09A Transmission -- Replacing Transmission): This document informs If you replace one of these transmissions, check ETKA to see if you must also replace the Transmission Control Module (TCM) at the same ti | |
| Bulletin Number: TT 37-11-05 | |
| Tech Tips (Measure Value Block Request): If a request has been made for several MVBs from a DSG transmission, the test plan "Read measured values for obligation to report" can be selected. This function will retrieve all of the MVBs from t | |
| Bulletin Number: TT 50-14-01 | |
| Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products wil | |
| Bulletin Number: TT 57-13-04 | |
| Tech Tips (Equipped with Immobilizer III - ODIS Key Adaptation Tip): This document informs when adapting keys using ODIS, an error message may be displayed once the test plan directs to cycle the key off. If error is displayed, this does | |
| Bulletin Number: TT57-13-04 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose t | |
| Bulletin Number: TT 87-09-03 | |
| Tech Tips (Coolant fan control module J293 pinout): 1.8L and 2.0L (Except Engine Code BBW), Fan Module J293 Pinout Chart which informs of the terminal types, the inputs, and outputs, the signal purpose, and the signal type | |
| Bulletin Number: TT 87-10-05 | |
| Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may se | |
| Bulletin Number: TT 91-16-03 | |
| Beetle-Coding the Replacement Instrument Cluster | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 961011 | |
| Update to model year applicability. | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02 | |
| TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: Update 02122016 | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: V001404 2010380 | |
| Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. | |
| Bulletin Number: V011407 2014603 | |
| Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). | |
| Bulletin Number: V011408 2014815 | |
| Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of | |
| Bulletin Number: V011503 2014815 | |
| Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers | |
| Bulletin Number: V011602 2014815 | |
| Technical tips on what to do if improper gasoline has been added to the vehicle. | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V011812-2014603 | |
| Update content and include additional models and model year applicability. | |
| Bulletin Number: V011812_2014603 | |
| Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. | |
| Bulletin Number: V171302 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrica | |
| Bulletin Number: V171303 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test | |
| Bulletin Number: V171403 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubricati | |
| Bulletin Number: V171404 2012855 | |
| Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard | |
| Bulletin Number: V171701 2012855 | |
| 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271501 2011894 | |
| Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger | |
| Bulletin Number: V271503 2016076 | |
| Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V501205 2014370 | |
| Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi | |
| Bulletin Number: V501604 2014370 | |
| Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to fi | |
| Bulletin Number: V641504 2016012 | |
| Technical Bulletin (Window, Rear Side, Inoperative): Rear side window inoperative or will not roll up. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of issue. The fault codes for checking warranty | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V851401 2012432 | |
| Technical Bulletin (Temperature Output Control Cannot Be Adjusted): Customer states cannot adjust temperature and/or A/C is not cold. The blend door control lever moves freely, but the blend door does not operate. A bushing that fits on t | |
| Bulletin Number: V871301 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st | |
| Bulletin Number: V871401 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871402 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i | |
| Bulletin Number: V871409 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ | |
| Bulletin Number: V871506 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon | |
| Bulletin Number: V871508 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: V871809-2005566 | |
| To include an additional model year applicability. | |
| Bulletin Number: V871812-2005566 | |
| Update vehicle metadata. | |
| Bulletin Number: V921502 2026253 | |
| Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w | |
| Bulletin Number: V941402 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic | |
| Bulletin Number: V941403 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. | |
| Bulletin Number: V941501 2011521 | |
| Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document | |
| Bulletin Number: VC | |
| INSTALL MERCURY LABEL ON VEHICLES REGISTERED IN THE STATES OF VERMONT, MAINE AND CONNECTICUT - ENVIRONMENTAL COMPLIANCE ACTION CIRCULAR. *TT | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| Bulletin Number: VWP-10-06 | |
| VOLKSWAGEN: WARRANTY INFORMATION FOR TH E TRANSMISSION VALVE BODY. *RM | |
| 2004 VOLKSWAGEN BEETLE CONVERTIBLE | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: Control Module R | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: QRUG08212019 | |
| Quick Reference Update Guide. | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V011812_2014603 | |
| Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. | |
| Bulletin Number: V171303 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V501205 2014370 | |
| Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi | |
| Bulletin Number: V871301 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st | |
| Bulletin Number: V871812-2005566 | |
| Update vehicle metadata. | |
| 2004 VOLKSWAGEN EUROVAN | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: SA-28F3 | |
| VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION | |
| Bulletin Number: SB-28F3 | |
| VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-00-10-06 | |
| VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE | |
| Bulletin Number: TB-35-11-01 | |
| VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-13-02 | |
| Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it | |
| Bulletin Number: TT 00-13-04 | |
| Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Spec | |
| Bulletin Number: TT 00-14-03 | |
| Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT 20-13-01 | |
| Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without co | |
| Bulletin Number: TT 32-14-01 | |
| Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installat | |
| Bulletin Number: TT 450719 | |
| Steering angle adaptation instructions, not included in repair manual | |
| Bulletin Number: TT 50-14-01 | |
| Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products wil | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose t | |
| Bulletin Number: TT 87-10-05 | |
| Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may se | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: V001404 2010380 | |
| Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. | |
| Bulletin Number: V011407 2014603 | |
| Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). | |
| Bulletin Number: V011408 2014815 | |
| Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of | |
| Bulletin Number: V011503 2014815 | |
| Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V171302 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrica | |
| Bulletin Number: V171303 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test | |
| Bulletin Number: V171403 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubricati | |
| Bulletin Number: V171404 2012855 | |
| Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271501 2011894 | |
| Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger | |
| Bulletin Number: V271503 2016076 | |
| Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V501205 2014370 | |
| Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V871301 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st | |
| Bulletin Number: V871401 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871402 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i | |
| Bulletin Number: V871409 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ | |
| Bulletin Number: V871506 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon | |
| Bulletin Number: V871508 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: V921502 2026253 | |
| Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w | |
| Bulletin Number: V941402 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic | |
| Bulletin Number: V941403 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. | |
| Bulletin Number: V941501 2011521 | |
| Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| 2004 VOLKSWAGEN GOLF | |
| Bulletin Number: 004 | |
| ENGINE COOLANT TEMPERATURE (ECT) SENSOR. *TC | |
| Bulletin Number: 010702 | |
| DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB | |
| Bulletin Number: 0401 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P1347/17755 AND P1340/17748 STORED IN MEMORY. INCLUDING VARIOUS MODELS VOLKSWAGEN 2002-2003. *MJ | |
| Bulletin Number: 0401 | |
| NEW STYLE BRAKE LIGHT SWITCH REQUIRES CARE DURING INSTALLATION TO PREVENT DAMAGE TO SWITCH. *TT | |
| Bulletin Number: 0401 | |
| REVERSE GEAR, DIFFICULT TO ENGAGE OR DISENGAGE. *MR | |
| Bulletin Number: 0403 | |
| ENGINE, FLUCTUATING IDLE OR IDLE SPEED TOO LOW. *MJ | |
| Bulletin Number: 0403 | |
| HARD STARTING OR NO START WHEN WET, RUNS ROUGH ON INITIAL START, MAY BE ACCOMPANIED BY LIGHT GRAY SMOKE. *MJ | |
| Bulletin Number: 0405 | |
| HARD STARTING (EXTENDED CRANKING REQUIRED) OR NO START WHEN WET, RUNS ROUGH ON INITIAL START, MAY BE ACCOMPANIED BY LIGHT GRAY SMOKE. *TT | |
| Bulletin Number: 0409 | |
| EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES- HOW TO PERFORM EFFECTIVE DIAGNOSIS RELATED TO FUEL SYSTEM ADAPTATION - SYSTEM TOO RICH/TOO LEAN. VOLKSWAGEN. *MJ | |
| Bulletin Number: 0412 | |
| MALFUNCTION INDICATOR LIGHT (MIL) ON, DIAGNOSTIC TROUBLE CODES (DTCS) STORED IN DIAGNOSTIC TROUBLE CODE (DTC) MEMORY. *MJ | |
| Bulletin Number: 0501 | |
| DOOR WINDOW, SEPARATES FROM WINDOW REGULATOR CLAMPS. *JB | |
| Bulletin Number: 0502 | |
| CUSTOMER STATES HEATER OUTPUT SEEMS INSUFFICIENT. *TT | |
| Bulletin Number: 0502 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0511 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P0101 (16485) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0601 | |
| HEATED SEAT BOTTOM COVER REPLACEMENT. *KB | |
| Bulletin Number: 0603 | |
| DOOR WINDOWS, MAY SEPERATE FROM WINDOW REGULATOR CLAMPS. *KB | |
| Bulletin Number: 060910 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. REVISED EXPIRATION DATES FOR SEAT HEATER CUSTOMER SATISFACTION CAMPAIGNS. AFFECTED VEHICLES MAY HAVE A SEAT HEATER ELEMENT THAN CAN MALFUNCTION WHEN THE IGNITION SW | |
| Bulletin Number: 11292005 | |
| ENGINE PRE-HEATER INSTALLATION. CALIX. *TT | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 2010461 | |
| HARD STARTING (EXTENDED CRANKING REQUIRED) OR NO START WHEN WET, RUNS ROUGH ON INITIAL START, MAY BE ACCOMPANIED BY LIGHT GRAY SMOKE. *KB | |
| Bulletin Number: 2010462 | |
| ROUGH ON INITIAL START AT TEMPERATURES BELOW 20 DEGREES F. *KB | |
| Bulletin Number: 2015831 | |
| VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE | |
| Bulletin Number: 2038887 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: 230501 | |
| RUNS ROUGH ON INITIAL START AT TEMPERATURES BELOW -7 DEGREES C (20 DEGREES F). *TT UPDATE. *TT UPDATE. *TT | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Control Module R | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Elsa Newsletter | |
| Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: M3 | |
| CUSTOMER SATISFACTION CAMPAIGN CIRCULAR - SEAT HEATER ELEMENT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON AND THE SEAT HEATER SWITCH IS ON. THE SEAT HEATER MAT MAY TEMPORARILY OVERHEAT AND BECOME INOPERATIVE. INSTALL NEW PASSENGER SIDE | |
| Bulletin Number: PDI - GOLF GTI T | |
| Golf/GTI Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: | |
| Bulletin Number: PDI - GOLF GTI T | |
| Golf Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purch | |
| Bulletin Number: PDI - GOLF GTI T | |
| Golf Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purcha | |
| Bulletin Number: QRUG08212019 | |
| Quick Reference Update Guide. | |
| Bulletin Number: Quick Reference | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: Quick Reference | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Reference - Refl | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Ref. - Reflash U | |
| Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. | |
| Bulletin Number: SA-28F3 | |
| VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION | |
| Bulletin Number: SA-28F6 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ENGINE SOFTWARE MAY CAUSE THE VEHICLE TO EXCEED EMISSIONS STANDARDS. *RM | |
| Bulletin Number: SA-60A7-S9 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSPECT, CLEAN AND MODIFY SUNROOF DRAINS FOR CERTAIN VOLKSWAGEN VEHICLES AND REVISED MAINTENANCE SCHEDULE; SUNROOF DRAIN INSPECTION AND CLEANING. NO MODELS OR MODEL | |
| Bulletin Number: SAC-28F3/P1-REV | |
| VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A | |
| Bulletin Number: SB-28F3 | |
| VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-00-10-06 | |
| VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE | |
| Bulletin Number: TB-01-10-13 | |
| VOLKSWAGEN: UPDATE PROGRAMMING; ENGINE RUNS ROUGH ON INITIAL START AT TEMPERATURES BELOW-7%C (20%F). SOFTWARE UPDATE AND NEW INJECTORS. INSTALLING NEW INJECTORS AND ENGINE CONTROL MODEL UPDATE-PROGRAMMING (FLASHING) USING SOFTWARE VERSION | |
| Bulletin Number: TB-01-12-04 | |
| VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE | |
| Bulletin Number: TB-35-11-01 | |
| VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-13-02 | |
| Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it | |
| Bulletin Number: TT 00-13-04 | |
| Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Spec | |
| Bulletin Number: TT 00-14-03 | |
| Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT001703 | |
| Tip for Scan tool concerns that may occur duing a test plan | |
| Bulletin Number: TT 10 12 01 | |
| Engine replacement tip | |
| Bulletin Number: TT 200901 | |
| Update to existing tip for fuel quality checking. | |
| Bulletin Number: TT 20-09-06 | |
| Tech Tips (TDI Engine - N75 Solenoid Valve Diagnosis): This document informs with graphical aid the testing of the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234. This applies to Mechanical Injection St | |
| Bulletin Number: TT 20-13-01 | |
| Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without co | |
| Bulletin Number: TT 21-13-01 | |
| Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Thi | |
| Bulletin Number: TT 24-08-01 | |
| Tech Tips (Models with 1.8T Engine - Pressure Loss issues): Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then returned to idle. This document informs of what to do should th | |
| Bulletin Number: TT 271002 | |
| Updated to include model year 2014 thru 2018 applicability. | |
| Bulletin Number: TT 32-14-01 | |
| Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installat | |
| Bulletin Number: TT 37-06-06 | |
| Tech Tips (Vehicles with 09G or 09A Transmission -- Replacing Transmission): This document informs If you replace one of these transmissions, check ETKA to see if you must also replace the Transmission Control Module (TCM) at the same ti | |
| Bulletin Number: TT 50-14-01 | |
| Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products wil | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose t | |
| Bulletin Number: TT 87-09-03 | |
| Tech Tips (Coolant fan control module J293 pinout): 1.8L and 2.0L (Except Engine Code BBW), Fan Module J293 Pinout Chart which informs of the terminal types, the inputs, and outputs, the signal purpose, and the signal type | |
| Bulletin Number: TT 87-10-05 | |
| Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may se | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 961011 | |
| Update to model year applicability. | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02 | |
| TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: Update 02122016 | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: V001404 2010380 | |
| Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. | |
| Bulletin Number: V011407 2014603 | |
| Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). | |
| Bulletin Number: V011408 2014815 | |
| Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of | |
| Bulletin Number: V011503 2014815 | |
| Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers | |
| Bulletin Number: V011602 2014815 | |
| Technical tips on what to do if improper gasoline has been added to the vehicle. | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V011812-2014603 | |
| Update content and include additional models and model year applicability. | |
| Bulletin Number: V011812_2014603 | |
| Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. | |
| Bulletin Number: V171302 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrica | |
| Bulletin Number: V171303 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test | |
| Bulletin Number: V171403 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubricati | |
| Bulletin Number: V171404 2012855 | |
| Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard | |
| Bulletin Number: V171701 2012855 | |
| 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271501 2011894 | |
| Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger | |
| Bulletin Number: V271503 2016076 | |
| Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V501205 2014370 | |
| Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi | |
| Bulletin Number: V501501 2011761 | |
| Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available | |
| Bulletin Number: V501601 2011761 | |
| Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace | |
| Bulletin Number: V501602 2011761 | |
| Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. It gives examples on where to check for repair coverage from warranties, fixing possible issues, and how to docu | |
| Bulletin Number: V501604 2014370 | |
| Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to fi | |
| Bulletin Number: V501606_2011761 | |
| TO UPDATE CLAIM PROCESSING STATEMENT. | |
| Bulletin Number: V551501 2039446 | |
| Technical Bulletin (Corrosion Hood Edge ): Document discusses diagnosis, and potential remedy of issue. The document also has example claim forms for repears. The diagnosis codes for checking warranty coverage for servicing the vehicle are | |
| Bulletin Number: V551603 2039446 | |
| Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. It discusses where to find what appl | |
| Bulletin Number: V551612-2039446 | |
| Corrosion may be found on the folded edge of the hood. Supersedes TB V551603 | |
| Bulletin Number: V551613_2039446 | |
| TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT. | |
| Bulletin Number: V571405 2038887 | |
| Technical Bulletin (Corrosion on the Fold of the Front Inner Door): This document informs of the method to repair Corrosion under the door fold in the area of the extra seal and the Poly Vinyl Chloride (PVC) foil. This document discusses | |
| Bulletin Number: V571503 2038887 | |
| Technical Bulletin (Corrosion on the Fold of the Front Inner Door): Corrosion under the door fold in the area of the extra seal and the Poly Vinyl Chloride (PVC) foil. This document contains information on how to diagnose, and service this | |
| Bulletin Number: V571605-2038887 | |
| To update Claim processing statement. | |
| Bulletin Number: V641501 2039887 | |
| Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move | |
| Bulletin Number: V641502 2039887 | |
| Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. This document contains the fault codes, | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V851401 2012432 | |
| Technical Bulletin (Temperature Output Control Cannot Be Adjusted): Customer states cannot adjust temperature and/or A/C is not cold. The blend door control lever moves freely, but the blend door does not operate. A bushing that fits on t | |
| Bulletin Number: V871301 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st | |
| Bulletin Number: V871401 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871402 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i | |
| Bulletin Number: V871409 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ | |
| Bulletin Number: V871506 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon | |
| Bulletin Number: V871508 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: V871809-2005566 | |
| To include an additional model year applicability. | |
| Bulletin Number: V871812-2005566 | |
| Update vehicle metadata. | |
| Bulletin Number: V921502 2026253 | |
| Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w | |
| Bulletin Number: V941402 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic | |
| Bulletin Number: V941403 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. | |
| Bulletin Number: V941501 2011521 | |
| Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| Bulletin Number: VOS-19-17 | |
| This document outlines updates to the diagnostic software (ODIS). | |
| Bulletin Number: VV | |
| COMFORT SEATS MAY HAVE A SEAT HEATER ELEMENT THAT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON. CUSTOMER SATISFACTION CAMPAIGN VV. *TT | |
| Bulletin Number: VV | |
| CUSTOMER SATISFACTION CAMPAIGN CIRCULAR. INSTALL DRIVER'S SIDE HEATER REPAIR KIT. SEAT HEATER MAY MALFUNCTION WHEN THE IGNITION SWITCH IS ON. THIS COULD CAUSE THE HEATER MAT TO TEMPORARILY OVERHEAT AND BECOME INOPERATIVE. *KB | |
| Bulletin Number: VV-VV00 | |
| CUSTOMER SATISFACTION CAMPAIGN CIRCULAR: CERTAIN VEHICLES EQUIPPED WITH COMFORT SEATS: INSTALL DRIVER'S SIDE SEAT HEATER REPAIR KIT. *PE UPDATED 3/23/09. REVISION TO CUSTOMER SATISFACTION CAMPAIGN. *PE UPDATED 3/17/10. * | |
| Bulletin Number: VZ | |
| COMFORT SEATS MAY HAVE A SEAT HEATER ELEMENT THAT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON. CUSTOMER SATISFACTION CAMPAIGN VZ. *TT | |
| Bulletin Number: VZ-VZ00 | |
| VOLKSWAGEN: CERTAIN VEHICLES EQUIPPED WITH COMFORT SEATS; INSTALL NEW PASSENGER SIDE SEAT HEATER SWITCH. THIS INCLUDE JETTA WAGON. *PE UPDATED 3/23/09. REVISION TO CUSTOMER SATISFACTION CAMPAIGNS FOR SEAT HEATERS. *PE UP | |
| 2004 VOLKSWAGEN GTI | |
| Bulletin Number: 010702 | |
| DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB | |
| Bulletin Number: 0603 | |
| DOOR WINDOWS, MAY SEPERATE FROM WINDOW REGULATOR CLAMPS. *KB | |
| Bulletin Number: 060910 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. REVISED EXPIRATION DATES FOR SEAT HEATER CUSTOMER SATISFACTION CAMPAIGNS. AFFECTED VEHICLES MAY HAVE A SEAT HEATER ELEMENT THAN CAN MALFUNCTION WHEN THE IGNITION SW | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 2015831 | |
| VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: 720702 | |
| SEAT HEATER IS INOPERATIVE. *KB | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Control Module R | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: M3 | |
| CUSTOMER SATISFACTION CAMPAIGN CIRCULAR - SEAT HEATER ELEMENT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON AND THE SEAT HEATER SWITCH IS ON. THE SEAT HEATER MAT MAY TEMPORARILY OVERHEAT AND BECOME INOPERATIVE. INSTALL NEW PASSENGER SIDE | |
| Bulletin Number: PDI - GOLF GTI T | |
| Golf/GTI Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: | |
| Bulletin Number: PDI - GOLF GTI T | |
| Golf Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purch | |
| Bulletin Number: PDI - GOLF GTI T | |
| Golf Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purcha | |
| Bulletin Number: Quick Reference | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: Quick Reference | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Reference Guide | |
| Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. | |
| Bulletin Number: Reference - Refl | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Ref. - Reflash U | |
| Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. | |
| Bulletin Number: SA-28F3 | |
| VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION | |
| Bulletin Number: SAC-28F3/P1-REV | |
| VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A | |
| Bulletin Number: SB-28F3 | |
| VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-00-10-06 | |
| VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE | |
| Bulletin Number: TB-01-12-04 | |
| VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE | |
| Bulletin Number: TB-35-11-01 | |
| VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT001703 | |
| Tip for Scan tool concerns that may occur duing a test plan | |
| Bulletin Number: TT 200901 | |
| Update to existing tip for fuel quality checking. | |
| Bulletin Number: TT 20-09-06 | |
| Tech Tips (TDI Engine - N75 Solenoid Valve Diagnosis): This document informs with graphical aid the testing of the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234. This applies to Mechanical Injection St | |
| Bulletin Number: TT 21-13-01 | |
| Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Thi | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02 | |
| TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: Update 02122016 | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: V011503 2014815 | |
| Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers | |
| Bulletin Number: V011602 2014815 | |
| Technical tips on what to do if improper gasoline has been added to the vehicle. | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V011812_2014603 | |
| Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: V871812-2005566 | |
| Update vehicle metadata. | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| Bulletin Number: VV | |
| COMFORT SEATS MAY HAVE A SEAT HEATER ELEMENT THAT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON. CUSTOMER SATISFACTION CAMPAIGN VV. *TT | |
| Bulletin Number: VV | |
| CUSTOMER SATISFACTION CAMPAIGN CIRCULAR. INSTALL DRIVER'S SIDE HEATER REPAIR KIT. SEAT HEATER MAY MALFUNCTION WHEN THE IGNITION SWITCH IS ON. THIS COULD CAUSE THE HEATER MAT TO TEMPORARILY OVERHEAT AND BECOME INOPERATIVE. *KB | |
| Bulletin Number: VV-VV00 | |
| CUSTOMER SATISFACTION CAMPAIGN CIRCULAR: CERTAIN VEHICLES EQUIPPED WITH COMFORT SEATS: INSTALL DRIVER'S SIDE SEAT HEATER REPAIR KIT. *PE UPDATED 3/23/09. REVISION TO CUSTOMER SATISFACTION CAMPAIGN. *PE UPDATED 3/17/10. * | |
| Bulletin Number: VZ | |
| COMFORT SEATS MAY HAVE A SEAT HEATER ELEMENT THAT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON. CUSTOMER SATISFACTION CAMPAIGN VZ. *TT | |
| Bulletin Number: VZ-VZ00 | |
| VOLKSWAGEN: CERTAIN VEHICLES EQUIPPED WITH COMFORT SEATS; INSTALL NEW PASSENGER SIDE SEAT HEATER SWITCH. THIS INCLUDE JETTA WAGON. *PE UPDATED 3/23/09. REVISION TO CUSTOMER SATISFACTION CAMPAIGNS FOR SEAT HEATERS. *PE UP | |
| 2004 VOLKSWAGEN JETTA | |
| Bulletin Number: 004 | |
| ENGINE COOLANT TEMPERATURE (ECT) SENSOR. *TC | |
| Bulletin Number: 010702 | |
| DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB | |
| Bulletin Number: 01 08 14 | |
| UPDATE PROGRAMMING, MIL ON, DTC'S P0420 AND/OR P0300-P0306 STORED IN ECM FAULT MEMORY. *NJ | |
| Bulletin Number: 0401 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P1347/17755 AND P1340/17748 STORED IN MEMORY. INCLUDING VARIOUS MODELS VOLKSWAGEN 2002-2003. *MJ | |
| Bulletin Number: 0401 | |
| NEW STYLE BRAKE LIGHT SWITCH REQUIRES CARE DURING INSTALLATION TO PREVENT DAMAGE TO SWITCH. *TT | |
| Bulletin Number: 0401 | |
| REVERSE GEAR, DIFFICULT TO ENGAGE OR DISENGAGE. *MR | |
| Bulletin Number: 0403 | |
| ENGINE, FLUCTUATING IDLE OR IDLE SPEED TOO LOW. *MJ | |
| Bulletin Number: 0403 | |
| HARD STARTING OR NO START WHEN WET, RUNS ROUGH ON INITIAL START, MAY BE ACCOMPANIED BY LIGHT GRAY SMOKE. *MJ | |
| Bulletin Number: 0405 | |
| HARD STARTING (EXTENDED CRANKING REQUIRED) OR NO START WHEN WET, RUNS ROUGH ON INITIAL START, MAY BE ACCOMPANIED BY LIGHT GRAY SMOKE. *TT | |
| Bulletin Number: 0405 | |
| HYBRID OIL PAN, INSTALLING. *TT | |
| Bulletin Number: 0409 | |
| EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES- HOW TO PERFORM EFFECTIVE DIAGNOSIS RELATED TO FUEL SYSTEM ADAPTATION - SYSTEM TOO RICH/TOO LEAN. VOLKSWAGEN. *MJ | |
| Bulletin Number: 0412 | |
| MALFUNCTION INDICATOR LIGHT (MIL) ON, DIAGNOSTIC TROUBLE CODES (DTCS) STORED IN DIAGNOSTIC TROUBLE CODE (DTC) MEMORY. *MJ | |
| Bulletin Number: 0501 | |
| DOOR WINDOW, SEPARATES FROM WINDOW REGULATOR CLAMPS. *JB | |
| Bulletin Number: 0501 | |
| FUEL GAUGE SENDER, INCORRECT READING. TO INCLUDE VOLKSWAGEN JETTA 2006. *TT | |
| Bulletin Number: 0502 | |
| CUSTOMER STATES HEATER OUTPUT SEEMS INSUFFICIENT. *TT | |
| Bulletin Number: 0502 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0511 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P0101 (16485) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0601 | |
| HEATED SEAT BOTTOM COVER REPLACEMENT. *KB | |
| Bulletin Number: 0603 | |
| DOOR WINDOWS, MAY SEPERATE FROM WINDOW REGULATOR CLAMPS. *KB | |
| Bulletin Number: 060910 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. REVISED EXPIRATION DATES FOR SEAT HEATER CUSTOMER SATISFACTION CAMPAIGNS. AFFECTED VEHICLES MAY HAVE A SEAT HEATER ELEMENT THAN CAN MALFUNCTION WHEN THE IGNITION SW | |
| Bulletin Number: 11292005 | |
| ENGINE PRE-HEATER INSTALLATION. CALIX. *TT | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 2010461 | |
| HARD STARTING (EXTENDED CRANKING REQUIRED) OR NO START WHEN WET, RUNS ROUGH ON INITIAL START, MAY BE ACCOMPANIED BY LIGHT GRAY SMOKE. *KB | |
| Bulletin Number: 2010462 | |
| ROUGH ON INITIAL START AT TEMPERATURES BELOW 20 DEGREES F. *KB | |
| Bulletin Number: 2015831 | |
| VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE | |
| Bulletin Number: 230501 | |
| RUNS ROUGH ON INITIAL START AT TEMPERATURES BELOW -7 DEGREES C (20 DEGREES F). *TT UPDATE. *TT UPDATE. *TT | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: 720702 | |
| SEAT HEATER IS INOPERATIVE. *KB | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Control Module R | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Elsa Newsletter | |
| Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: M3 | |
| CUSTOMER SATISFACTION CAMPAIGN CIRCULAR - SEAT HEATER ELEMENT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON AND THE SEAT HEATER SWITCH IS ON. THE SEAT HEATER MAT MAY TEMPORARILY OVERHEAT AND BECOME INOPERATIVE. INSTALL NEW PASSENGER SIDE | |
| Bulletin Number: PDI - JETTA JSW | |
| JETTA-JSW Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has p | |
| Bulletin Number: PDI - JETTA TECH | |
| Jetta Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purch | |
| Bulletin Number: PDI - JETTA TECH | |
| JETTA Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purch | |
| Bulletin Number: QRUG08212019 | |
| Quick Reference Update Guide. | |
| Bulletin Number: Quick Reference | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: Quick Reference | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Reference Guide | |
| Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. | |
| Bulletin Number: Reference - Refl | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Ref. - Reflash U | |
| Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. | |
| Bulletin Number: SA-28F3 | |
| VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION | |
| Bulletin Number: SA-28F6 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ENGINE SOFTWARE MAY CAUSE THE VEHICLE TO EXCEED EMISSIONS STANDARDS. *RM | |
| Bulletin Number: SA-60A7-S9 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSPECT, CLEAN AND MODIFY SUNROOF DRAINS FOR CERTAIN VOLKSWAGEN VEHICLES AND REVISED MAINTENANCE SCHEDULE; SUNROOF DRAIN INSPECTION AND CLEANING. NO MODELS OR MODEL | |
| Bulletin Number: SAC-28F3/P1-REV | |
| VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A | |
| Bulletin Number: SB-28F3 | |
| VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-00-10-06 | |
| VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE | |
| Bulletin Number: TB-01-10-13 | |
| VOLKSWAGEN: UPDATE PROGRAMMING; ENGINE RUNS ROUGH ON INITIAL START AT TEMPERATURES BELOW-7%C (20%F). SOFTWARE UPDATE AND NEW INJECTORS. INSTALLING NEW INJECTORS AND ENGINE CONTROL MODEL UPDATE-PROGRAMMING (FLASHING) USING SOFTWARE VERSION | |
| Bulletin Number: TB-01-12-04 | |
| VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE | |
| Bulletin Number: TB-35-11-01 | |
| VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-13-02 | |
| Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it | |
| Bulletin Number: TT 00-13-04 | |
| Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Spec | |
| Bulletin Number: TT 00-14-03 | |
| Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT001703 | |
| Tip for Scan tool concerns that may occur duing a test plan | |
| Bulletin Number: TT 10 12 01 | |
| Engine replacement tip | |
| Bulletin Number: TT 200901 | |
| Update to existing tip for fuel quality checking. | |
| Bulletin Number: TT 20-09-06 | |
| Tech Tips (TDI Engine - N75 Solenoid Valve Diagnosis): This document informs with graphical aid the testing of the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234. This applies to Mechanical Injection St | |
| Bulletin Number: TT 20-13-01 | |
| Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without co | |
| Bulletin Number: TT 21-13-01 | |
| Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Thi | |
| Bulletin Number: TT 24-08-01 | |
| Tech Tips (Models with 1.8T Engine - Pressure Loss issues): Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then returned to idle. This document informs of what to do should th | |
| Bulletin Number: TT 271002 | |
| Updated to include model year 2014 thru 2018 applicability. | |
| Bulletin Number: TT 32-14-01 | |
| Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installat | |
| Bulletin Number: TT 37-06-06 | |
| Tech Tips (Vehicles with 09G or 09A Transmission -- Replacing Transmission): This document informs If you replace one of these transmissions, check ETKA to see if you must also replace the Transmission Control Module (TCM) at the same ti | |
| Bulletin Number: TT 50-14-01 | |
| Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products wil | |
| Bulletin Number: TT 55-13-01 | |
| Tech Tips (Rear Lid Does Not Open After Handle Replacement): If the rear lid handle is replaced with part number 1J0 827 566L, the microswitch from the original handle must be transferred to the new handle. If original microswitch is not a | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose t | |
| Bulletin Number: TT 87-09-03 | |
| Tech Tips (Coolant fan control module J293 pinout): 1.8L and 2.0L (Except Engine Code BBW), Fan Module J293 Pinout Chart which informs of the terminal types, the inputs, and outputs, the signal purpose, and the signal type | |
| Bulletin Number: TT 87-10-05 | |
| Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may se | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 961011 | |
| Update to model year applicability. | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02 | |
| TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: Update 02122016 | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: V001404 2010380 | |
| Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. | |
| Bulletin Number: V011407 2014603 | |
| Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). | |
| Bulletin Number: V011408 2014815 | |
| Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of | |
| Bulletin Number: V011503 2014815 | |
| Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers | |
| Bulletin Number: V011602 2014815 | |
| Technical tips on what to do if improper gasoline has been added to the vehicle. | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V011812-2014603 | |
| Update content and include additional models and model year applicability. | |
| Bulletin Number: V011812_2014603 | |
| Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. | |
| Bulletin Number: V171302 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrica | |
| Bulletin Number: V171303 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test | |
| Bulletin Number: V171403 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubricati | |
| Bulletin Number: V171404 2012855 | |
| Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard | |
| Bulletin Number: V171701 2012855 | |
| 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271501 2011894 | |
| Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger | |
| Bulletin Number: V271503 2016076 | |
| Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V501205 2014370 | |
| Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi | |
| Bulletin Number: V501501 2011761 | |
| Technical Bulletin Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) ): Document discusses diagnosis, and potential remedy of issue. The diagnosis codes for checking warranty coverage for servicing the vehicle are also available | |
| Bulletin Number: V501601 2011761 | |
| Information on areas Surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. Also gives examples of how to calculate cost to repair or replace | |
| Bulletin Number: V501602 2011761 | |
| Document refers to Surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. It gives examples on where to check for repair coverage from warranties, fixing possible issues, and how to docu | |
| Bulletin Number: V501604 2014370 | |
| Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to fi | |
| Bulletin Number: V501606_2011761 | |
| TO UPDATE CLAIM PROCESSING STATEMENT. | |
| Bulletin Number: V531501 2040536 | |
| Technical Bulletin: Rear Quarter Panel Corrosion issues. This document discusses causes, fault codes for servicing, and example claim forms for the servicing of the vehicle | |
| Bulletin Number: V531502 2040536 | |
| Technical Bulletin: Rear Quarter Panel Corrosion issues. This document has the Warranty documentation to inquire about coverage. It also has examples of instances calculating the services performed | |
| Bulletin Number: V531601 2040536 | |
| The document refers to Corrosion being found where the rear bumper cover meets the quarter panel. It discusses how it can happen, and where to find warranty coverage to service the parts | |
| Bulletin Number: V531602-2040536 | |
| To update claim processing statement. | |
| Bulletin Number: V551501 2039446 | |
| Technical Bulletin (Corrosion Hood Edge ): Document discusses diagnosis, and potential remedy of issue. The document also has example claim forms for repears. The diagnosis codes for checking warranty coverage for servicing the vehicle are | |
| Bulletin Number: V551602 2038992 | |
| Document discusses Electrolytic corrosion around the license plate lights (opening/contact surface, inside and outside) because of water ingress via the seal of the license plate lights. Examples of how the issue service can be documented, | |
| Bulletin Number: V551603 2039446 | |
| Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. It discusses where to find what appl | |
| Bulletin Number: V551604-2038992 | |
| To update claim processing statement. | |
| Bulletin Number: V551605-2038994 | |
| To update Claim process statement. | |
| Bulletin Number: V551612-2039446 | |
| Corrosion may be found on the folded edge of the hood. Supersedes TB V551603 | |
| Bulletin Number: V551613_2039446 | |
| TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT. | |
| Bulletin Number: V571405 2038887 | |
| Technical Bulletin (Corrosion on the Fold of the Front Inner Door): This document informs of the method to repair Corrosion under the door fold in the area of the extra seal and the Poly Vinyl Chloride (PVC) foil. This document discusses | |
| Bulletin Number: V571503 2038887 | |
| Technical Bulletin (Corrosion on the Fold of the Front Inner Door): Corrosion under the door fold in the area of the extra seal and the Poly Vinyl Chloride (PVC) foil. This document contains information on how to diagnose, and service this | |
| Bulletin Number: V571605-2038887 | |
| To update Claim processing statement. | |
| Bulletin Number: V641501 2039887 | |
| Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move | |
| Bulletin Number: V641502 2039887 | |
| Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. This document contains the fault codes, | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V851401 2012432 | |
| Technical Bulletin (Temperature Output Control Cannot Be Adjusted): Customer states cannot adjust temperature and/or A/C is not cold. The blend door control lever moves freely, but the blend door does not operate. A bushing that fits on t | |
| Bulletin Number: V871301 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st | |
| Bulletin Number: V871401 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871402 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i | |
| Bulletin Number: V871409 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ | |
| Bulletin Number: V871506 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon | |
| Bulletin Number: V871508 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: V871809-2005566 | |
| To include an additional model year applicability. | |
| Bulletin Number: V871812-2005566 | |
| Update vehicle metadata. | |
| Bulletin Number: V921502 2026253 | |
| Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w | |
| Bulletin Number: V941402 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic | |
| Bulletin Number: V941403 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. | |
| Bulletin Number: V941501 2011521 | |
| Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| Bulletin Number: VT | |
| CHECK/REPOSITION AND SECURE PLASTIC ASSEMBLY AID ON REAR DOOR LOCK RODS. REAR DOOR LOCK MAY NOT OPERATE PROPERLY DUE TO A DAMAGED PLASTIC ASSEMBLY AID. *TT | |
| Bulletin Number: VV | |
| COMFORT SEATS MAY HAVE A SEAT HEATER ELEMENT THAT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON. CUSTOMER SATISFACTION CAMPAIGN VV. *TT | |
| Bulletin Number: VV | |
| CUSTOMER SATISFACTION CAMPAIGN CIRCULAR. INSTALL DRIVER'S SIDE HEATER REPAIR KIT. SEAT HEATER MAY MALFUNCTION WHEN THE IGNITION SWITCH IS ON. THIS COULD CAUSE THE HEATER MAT TO TEMPORARILY OVERHEAT AND BECOME INOPERATIVE. *KB | |
| Bulletin Number: VV-VV00 | |
| CUSTOMER SATISFACTION CAMPAIGN CIRCULAR: CERTAIN VEHICLES EQUIPPED WITH COMFORT SEATS: INSTALL DRIVER'S SIDE SEAT HEATER REPAIR KIT. *PE UPDATED 3/23/09. REVISION TO CUSTOMER SATISFACTION CAMPAIGN. *PE UPDATED 3/17/10. * | |
| Bulletin Number: VZ | |
| COMFORT SEATS MAY HAVE A SEAT HEATER ELEMENT THAT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON. CUSTOMER SATISFACTION CAMPAIGN VZ. *TT | |
| Bulletin Number: VZ-VZ00 | |
| VOLKSWAGEN: CERTAIN VEHICLES EQUIPPED WITH COMFORT SEATS; INSTALL NEW PASSENGER SIDE SEAT HEATER SWITCH. THIS INCLUDE JETTA WAGON. *PE UPDATED 3/23/09. REVISION TO CUSTOMER SATISFACTION CAMPAIGNS FOR SEAT HEATERS. *PE UP | |
| Bulletin Number: WZ | |
| SERVICE ACTION CIRCULAR FOR VEHICLES ASSEMBLED WITH INCORRECT AUTOMATIC TRANSMISSIONS (INCORRECT TRANSMISSION CODE FDG). ALSO INCLUDES LETTER TO VOLKSWAGEN DEALER REGARDING SERVICE ACTION WZ. *TT | |
| 2004 VOLKSWAGEN JETTA WAGON | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| 2004 VOLKSWAGEN NEW BEETLE | |
| Bulletin Number: 0302 | |
| PASSENGER AIR BAG OFF INDICATOR LIGHT IN CENTER DASH COVER MAY STAY ON DEPENDING ON PASSENGER SEAT OCCUPANCY AS REGISTERED BY THE WEIGHT SENSING MAT. *TT | |
| Bulletin Number: 0305 | |
| FRONT TURN SIGNAL BLINKS TOO FAST. FRONT TURN SIGNAL, REPLACING BULB SOCKET. *TT | |
| Bulletin Number: 0401 | |
| AFTER REPLACEMENT OF THE PASSENGER OCCUPANT DETECTION SYSTEM (PODS), THE PASSENGER SEAT BOLSTER OR THE AIRBAG CONTROL MODULE, FAULT CODE 02511 014 - SEAT OCCUPIED RECOGNITION CONTROL MODULE FAULTY - APPEARS. *TT | |
| Bulletin Number: 0401 | |
| NEW STYLE BRAKE LIGHT SWITCH REQUIRES CARE DURING INSTALLATION TO PREVENT DAMAGE TO SWITCH. *TT | |
| Bulletin Number: 0401 | |
| REVERSE GEAR, DIFFICULT TO ENGAGE OR DISENGAGE. *MR | |
| Bulletin Number: 0403 | |
| PASSENGER OCCUPANT DETECTION SYSTEM (PODS) FAULT. *MJ | |
| Bulletin Number: 0404 | |
| HARD STARTING (EXTENDED CRANKING REQUIRED) OR NO START WHEN WET, RUNS ROUGH ON INITIAL START, MAY BE ACCOMPANIED BY LIGHT GRAY SMOKE. *MJ | |
| Bulletin Number: 0409 | |
| EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES- HOW TO PERFORM EFFECTIVE DIAGNOSIS RELATED TO FUEL SYSTEM ADAPTATION - SYSTEM TOO RICH/TOO LEAN. VOLKSWAGEN. *MJ | |
| Bulletin Number: 0412 | |
| MALFUNCTION INDICATOR LIGHT (MIL) ON, DIAGNOSTIC TROUBLE CODES (DTCS) STORED IN DIAGNOSTIC TROUBLE CODE (DTC) MEMORY. *MJ | |
| Bulletin Number: 0417 | |
| AIRBAG MONITORING LIGHT ON, PASSENGER OCCUPANT DETECTION SYSTEM (PODS), DIAGNOSTIC TROUBLE CODE 02511 014 STORED. *TT | |
| Bulletin Number: VE | |
| WINDOW CLAMP BOLTS ON CERTAIN CONVERTIBLE VEHICLES MAY BECOME LOOSE. *TT | |
| Bulletin Number: VK | |
| THE AMPLIFIER MAY NOT COMPLETELY SWITCH OFF WHEN THE IGNITION IS TURNED OFF. SERVICE ACTION CIRCULAR TO CHECK/REPLACE AMPLIFIER ON VEHICLES WITH MONSOON SOUND SYSTEM. *TT | |
| 2004 VOLKSWAGEN PASSAT | |
| Bulletin Number: 004 | |
| ENGINE COOLANT TEMPERATURE (ECT) SENSOR. *TC | |
| Bulletin Number: 010702 | |
| DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB | |
| Bulletin Number: 0401 | |
| ENGINE OIL SPECIFICATIONS, OIL CAPACITY, OIL FILTER. *TT | |
| Bulletin Number: 0402 | |
| LOW ENGINE OIL PRESSURE LIGHT IS ON. *TT | |
| Bulletin Number: 0403 | |
| ENGINE, FLUCTUATING IDLE OR IDLE SPEED TOO LOW. *MJ | |
| Bulletin Number: 0403 | |
| VALVE COVER, DIAGNOSING OIL LEAKAGE FROM GASKETS. *TT | |
| Bulletin Number: 0406 | |
| READINESS CODE, SETTING. *TT | |
| Bulletin Number: 0409 | |
| EVALUATING FUEL MIXTURE DIAGNOSTIC TROUBLE CODES- HOW TO PERFORM EFFECTIVE DIAGNOSIS RELATED TO FUEL SYSTEM ADAPTATION - SYSTEM TOO RICH/TOO LEAN. VOLKSWAGEN. *MJ | |
| Bulletin Number: 0416 | |
| WHEN SLOWING TO A STOP, A HARSH 3RD GEAR TO 2ND GEAR DOWNSHIFT IS FELT AND/OR AFTER SLOWING TO A NEAR STOP THEN ACCELERATING AGAIN, A CLUNK IS FELT. UPDATE PROGRAMMING (FLASHING) TRANSMISSION CONTROL MODULE (TCM) FOR HARSH SHIFTING. * | |
| Bulletin Number: 0419 | |
| UPDATE PROGRAMMING - EVAPORATIVE EMISSIONS (EVAP) SELF-TEST REVISION. *TT | |
| Bulletin Number: 0421 | |
| OIL SLUDGE - WARRANTY EXTENSION FOR 1998-2004 MODEL YEAR VOLKSWAGEN PASSAT WITH 1.8L TURBO ENGINE US AND CANADIAN DEALERS. SERVICE CIRCULAR. *TT | |
| Bulletin Number: 0421 | |
| WARRANTY EXTENSION COVERING CERTAIN OIL SLUDGE RELATED REPAIRS. *TT | |
| Bulletin Number: 0502 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0505 | |
| VEHICLES MAY DISPLAY VIBRATION OF THE HEADLIGHT DUE TO CLEARANCE BETWEEN HEADLIGHT ASSEMBLY AND FRONT FACIA - EXCLUDING NEW PASSAT. *NM | |
| Bulletin Number: 0517 | |
| ANTI-LOCK BRAKE SYSTEM (ABS) CONTROL MODULE WARRANTY REPAIR PROCESS. *TT | |
| Bulletin Number: 092603 | |
| ZF VH RECALL OF THE ZF STEERING PUMP, SUPPLIED TO WD'S FOR REPLACEMENT OF THE AUDI A4 PASSAT P/N 8D0 145 156FX INSTEAD OF THE CORRECT ZF P/N 7691 955 276ZW. 2004 AUDI A4 ALSO INCLUDED. *TT | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 2013233 | |
| ENGINE OIL PRESSURE TOO LOW, LIGHT IS ON, ENGINE FLUSH. *KB | |
| Bulletin Number: 2015831 | |
| VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE | |
| Bulletin Number: 2038981 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: 2038996 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: 561 065 760 A as | |
| Assembly Instructions: Installation of original remote start feature accessory, Volkswagen Passat. | |
| Bulletin Number: 748 | |
| 2003-2004 MODEL YEAR PASSAT WITH HEATED SEATS INSTALL NEW PASSENGER SIDE SEAT HEATER SWITCH. *NJ | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Control Module R | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: CSC-74B8 | |
| VOLKSWAGEN: HEATED SEATS INSTALL NEW PASSENGER SIDE SEAT HEATER SWITCH. AFFECTED VEHICLES MAY HAVE A SEAT HEATER ELEMENT THAT CAN MALFUNCTION WHEN THE IGNITION SWITCH IS ON AND THE SEAT HEATER SWITCH IS ON. *PE | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: P 9-66C8 | |
| VOLKSWAGEN: 2001-2005 MODELS: SERVICE AIR PLENUM AREA TO IMPROVE DRAINAGE AND INSTALL IMPROVED POLLEN FILTER SEAL. WATER COULD LEAK INTO THE PASSENGER COMPARTMENT. 2002 MODELS COULD HAVE LEAKS INTO THE BRAKE BOOSTER. *PE | |
| Bulletin Number: P-9-99C8 | |
| VOLKSWAGEN: SERVICE AIR PLENUM AREA TO IMPROVE DRAINAGE AND INSTALL IMPROVED POLLEN FILTER SEAL. *PE | |
| Bulletin Number: PDI - PASSAT TEC | |
| Passat Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purc | |
| Bulletin Number: QRUG08212019 | |
| Quick Reference Update Guide. | |
| Bulletin Number: Quick Reference | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: Quick Reference | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Reference Guide | |
| Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. | |
| Bulletin Number: Reference Guide | |
| Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. | |
| Bulletin Number: Reference - Refl | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Ref. - Reflash U | |
| Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. | |
| Bulletin Number: SA-28F3 | |
| VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION | |
| Bulletin Number: SA-28F6 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ENGINE SOFTWARE MAY CAUSE THE VEHICLE TO EXCEED EMISSIONS STANDARDS. *RM | |
| Bulletin Number: SAC-28F3/P1-REV | |
| VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A | |
| Bulletin Number: SB-28F3 | |
| VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-00-10-06 | |
| VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE | |
| Bulletin Number: TB-01-12-04 | |
| VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE | |
| Bulletin Number: TB-07-09-06 | |
| VOLKSWAGEN: ENGINE OIL PRESSURE TOO LOW, LIGHT IS ON, ENGINE FLUSH. THE LOW ENGINE OIL PRESSURE CONDITION MAY BE CAUSED BY A RESTRICTION OF THE OIL PUMP SUCTION LINE STRAINER. *PE | |
| Bulletin Number: TB-35-11-01 | |
| VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-13-02 | |
| Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it | |
| Bulletin Number: TT 00-13-04 | |
| Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Spec | |
| Bulletin Number: TT 00-14-03 | |
| Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT001703 | |
| Tip for Scan tool concerns that may occur duing a test plan | |
| Bulletin Number: TT 10 12 01 | |
| Engine replacement tip | |
| Bulletin Number: TT 200901 | |
| Update to existing tip for fuel quality checking. | |
| Bulletin Number: TT 20-09-06 | |
| Tech Tips (TDI Engine - N75 Solenoid Valve Diagnosis): This document informs with graphical aid the testing of the N75 Solenoid Valve in the event of a turbocharger fault code such as P0299 or P0234. This applies to Mechanical Injection St | |
| Bulletin Number: TT 20-13-01 | |
| Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without co | |
| Bulletin Number: TT 21-13-01 | |
| Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Thi | |
| Bulletin Number: TT 23-06-28 | |
| 2.0L TDI Pumpe Duse Engine, with Hard Starting: For long crank/ difficulty starting with the engine hot: Before replacing any components for this complaint, drain the fuel from the vehicle and replace with known good diesel fuel from a rep | |
| Bulletin Number: TT 23-06-28 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: TT 24-08-01 | |
| Tech Tips (Models with 1.8T Engine - Pressure Loss issues): Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then returned to idle. This document informs of what to do should th | |
| Bulletin Number: TT 271002 | |
| Updated to include model year 2014 thru 2018 applicability. | |
| Bulletin Number: TT 32-14-01 | |
| Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installat | |
| Bulletin Number: TT45-13-01 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: TT 50-14-01 | |
| Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products wil | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose t | |
| Bulletin Number: TT 87-10-05 | |
| Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may se | |
| Bulletin Number: TT 90-12-06 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: TT 90-12-06 | |
| Tech Tips (Fuel Gauge Inoperative after Instrument Cluster Replacement with Fault 00771 ?Fuel level sensor -G-?): An inoperative fuel gauge after instrument cluster replacement with fault 00771 ?Fuel level sensor -G-? may be caused by ga | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 961011 | |
| Update to model year applicability. | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02 | |
| TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: Update 02122016 | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: V001404 2010380 | |
| Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. | |
| Bulletin Number: V011407 2014603 | |
| Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). | |
| Bulletin Number: V011408 2014815 | |
| Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of | |
| Bulletin Number: V011503 2014815 | |
| Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers | |
| Bulletin Number: V011602 2014815 | |
| Technical tips on what to do if improper gasoline has been added to the vehicle. | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V011812-2014603 | |
| Update content and include additional models and model year applicability. | |
| Bulletin Number: V011812_2014603 | |
| Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. | |
| Bulletin Number: V171302 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrica | |
| Bulletin Number: V171303 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test | |
| Bulletin Number: V171404 2012855 | |
| Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard | |
| Bulletin Number: V171701 2012855 | |
| 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271501 2011894 | |
| Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger | |
| Bulletin Number: V271503 2016076 | |
| Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V501205 2014370 | |
| Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi | |
| Bulletin Number: V501401 2038981 | |
| Technical Bulletin (Front Fender - Corrosion on Wheel Arch): The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. T | |
| Bulletin Number: V501505_2038981 | |
| TO UPDATE CLAIM PROCESSING STATEMENT. | |
| Bulletin Number: V501603 2038981 | |
| Document discusses issues with The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. It discusses how to service the | |
| Bulletin Number: V501604 2014370 | |
| Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to fi | |
| Bulletin Number: V531601 2040536 | |
| The document refers to Corrosion being found where the rear bumper cover meets the quarter panel. It discusses how it can happen, and where to find warranty coverage to service the parts | |
| Bulletin Number: V531602-2040536 | |
| To update claim processing statement. | |
| Bulletin Number: V551603 2039446 | |
| Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. It discusses where to find what appl | |
| Bulletin Number: V551610-2038996 | |
| To update claiming process statement. | |
| Bulletin Number: V551612-2039446 | |
| Corrosion may be found on the folded edge of the hood. Supersedes TB V551603 | |
| Bulletin Number: V551613_2039446 | |
| TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT. | |
| Bulletin Number: V641501 2039887 | |
| Technical Bulletin (Rear Door Glass Inoperative issue diagnosis): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move | |
| Bulletin Number: V641502 2039887 | |
| Technical Bulletin (Rear Door Glass Inoperative): The rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. This document contains the fault codes, | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V871301 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st | |
| Bulletin Number: V871401 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871402 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i | |
| Bulletin Number: V871409 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ | |
| Bulletin Number: V871506 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon | |
| Bulletin Number: V871508 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: V871809-2005566 | |
| To include an additional model year applicability. | |
| Bulletin Number: V871812-2005566 | |
| Update vehicle metadata. | |
| Bulletin Number: V921502 2026253 | |
| Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w | |
| Bulletin Number: V941402 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic | |
| Bulletin Number: V941403 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. | |
| Bulletin Number: V941501 2011521 | |
| Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document | |
| Bulletin Number: VC | |
| INSTALL MERCURY LABEL ON VEHICLES REGISTERED IN THE STATES OF VERMONT, MAINE AND CONNECTICUT - ENVIRONMENTAL COMPLIANCE ACTION CIRCULAR. *TT | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| Bulletin Number: VP | |
| VEHICLES REMOVE / REPLACE SHOCK ABSORBER SECURING BOLT. *MJ | |
| 2004 VOLKSWAGEN PASSAT WAGON | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 2038981 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: 2038993 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Elsa Newsletter | |
| Summary of Technical Bulletin to include additional model and model year applicability. Corrosion, Front Fenders, at Upper Wheel Opening (U.S. Only) | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: Reference Guide | |
| Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-01-12-04 | |
| VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT 200901 | |
| Update to existing tip for fuel quality checking. | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V011812-2014603 | |
| Update content and include additional models and model year applicability. | |
| Bulletin Number: V171701 2012855 | |
| 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V501401 2038981 | |
| Technical Bulletin (Front Fender - Corrosion on Wheel Arch): The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. T | |
| Bulletin Number: V501505_2038981 | |
| TO UPDATE CLAIM PROCESSING STATEMENT. | |
| Bulletin Number: V501603 2038981 | |
| Document discusses issues with The wheel liner touches the arch area of the fender and rubs off the paint in the contact area. The corrosion is caused by dirt accumulations and movements of the wheel liner. It discusses how to service the | |
| Bulletin Number: V511602-2039000 | |
| 51 16 02 June 7, 2016 2039000 Supersedes Technical Bulletin V511403 dated December 16, 2014 to update Claim Processing statement. Corrosion on the Roof in the Area of the Roof Rails Corrosion on the roof (in the contact area of roof rail/ | |
| Bulletin Number: V531601 2040536 | |
| The document refers to Corrosion being found where the rear bumper cover meets the quarter panel. It discusses how it can happen, and where to find warranty coverage to service the parts | |
| Bulletin Number: V531602-2040536 | |
| To update claim processing statement. | |
| Bulletin Number: V551601 2038993 | |
| Discussion on Corrosion on Rear Lid at Rear Window Area When the rear window heater is switched ON, power is transmitted to the outer sealing lip of the rear window. In some places the window sealer makes contact with the bus bar of the rea | |
| Bulletin Number: V551603 2039446 | |
| Document discusses Corrosion that may be found on the folded edge of the hood. The corrosion may be found on this edge anywhere around the hood. It discusses how to service it, and document that service. It discusses where to find what appl | |
| Bulletin Number: V551611-2038993 | |
| To update claim processing statement. | |
| Bulletin Number: V551611_2038993 | |
| Original version accidently archived 8/9/19. Recreate exact content in new format and republish, as warranty policy still relevant to applicable later model years. | |
| Bulletin Number: V551612-2039446 | |
| Corrosion may be found on the folded edge of the hood. Supersedes TB V551603 | |
| Bulletin Number: V551613_2039446 | |
| TO UPDATE MODEL TABLE TO CLARIFY JETTA WAGON APPLICABILITY TO TB CONTENT. | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: V871812-2005566 | |
| Update vehicle metadata. | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| 2004 VOLKSWAGEN PHAETON | |
| Bulletin Number: 0401 | |
| AFTER REPLACEMENT OF THE PASSENGER OCCUPANT DETECTION SYSTEM (PODS), THE PASSENGER SEAT BOLSTER OR THE AIRBAG CONTROL MODULE, FAULT CODE 02511 014 - SEAT OCCUPIED RECOGNITION CONTROL MODULE FAULTY - APPEARS. *TT | |
| Bulletin Number: 0401 | |
| IGNITION/STARTER SWITCH -E415- DELETION OF EMERGENCY KEY RELEASE FEATURE. *TT | |
| Bulletin Number: 0401 | |
| INSTRUMENT CLUSTER DISPLAY DISTORTION. *TT | |
| Bulletin Number: 0402 | |
| VAS 5051, VAS 5052 GUIDED FAULT FINDING (GFF) DIAGNOSTICS, CONTROL MODULE COMMUNICATION ISSUES. *TT | |
| Bulletin Number: 0403 | |
| DIAGNOSTIC TROUBLE CODE (DTC) 00317 05 IS STORED IN CONVENIENCE CONTROL MODULE DTC MEMORY. *TT | |
| Bulletin Number: 0403 | |
| IGNITION KEY EMERGENCY RELEASE REVISION. *TC | |
| Bulletin Number: 0406 | |
| TIRE PRESSURE MONITORING SYSTEM (TPMS), DIAGNOSING. *TT | |
| Bulletin Number: 0407 | |
| TIRE PRESSURE MONITORING SYSTEM, MODULE CODING. *TT | |
| Bulletin Number: 0407 | |
| TRUNK LID HARNESS, INSTALLING REPAIR HARNESS *SC | |
| Bulletin Number: 0501 | |
| REAR DOOR SUNSHADE REPAIRING BRIKEN HANDLE. *EH | |
| Bulletin Number: 0502 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0502 | |
| FRONT SEAT LUMBAR SUPPORT SQUEAKING. SUPERSEDES 05-01 DATED JAN 28 2005. *EH FRONT AND REAR SEAT, LUMBAR SUPPORT SQUEAKING. *TT | |
| Bulletin Number: 0504 | |
| INTERVENTION LOAD MANAGEMENT. ELECTRICAL CONSUMER MALFUNCTIONS, MESSAGE IN MFI ALERTING DRIVER THAT ELECTRICAL CONSUMERS ARE BEING SHUT DOWN, VEHICLE WILL NOT START. *TT | |
| Bulletin Number: 0506 | |
| INTERVENTION LOAD MANGEMENT. | |
| Bulletin Number: 0602 | |
| NOISE INSULATION COVER (LOWER), RELOCATING FASTENERS AND RE-TORQUE TRANSMISSION OIL PAN BOLTS (BL). *TT | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 2015831 | |
| VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE | |
| Bulletin Number: 2039003 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: 2039211 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Control Module R | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: QRUG08212019 | |
| Quick Reference Update Guide. | |
| Bulletin Number: Quick Reference | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: Quick Reference | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Reference - Refl | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Ref. - Reflash U | |
| Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. | |
| Bulletin Number: SA-28F3 | |
| VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION | |
| Bulletin Number: SAC-28F3/P1-REV | |
| VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A | |
| Bulletin Number: SB-28F3 | |
| VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-00-10-06 | |
| VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE | |
| Bulletin Number: TB-01-12-04 | |
| VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE | |
| Bulletin Number: TB-35-11-01 | |
| VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-13-02 | |
| Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it | |
| Bulletin Number: TT 00-13-04 | |
| Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Spec | |
| Bulletin Number: TT 00-14-03 | |
| Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT001703 | |
| Tip for Scan tool concerns that may occur duing a test plan | |
| Bulletin Number: TT 200901 | |
| Update to existing tip for fuel quality checking. | |
| Bulletin Number: TT 20-13-01 | |
| Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without co | |
| Bulletin Number: TT 32-14-01 | |
| Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installat | |
| Bulletin Number: TT 50-14-01 | |
| Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products wil | |
| Bulletin Number: TT 57-12-02 | |
| Tech Tips (Alarm Goes Off When Unlocking Door With Key Cylinder): This document informs if the vehicle is entered using the door key, the alarm may activate when opening the door. The door lock cylinder does not disarm the alarm. The lock | |
| Bulletin Number: TT 57-12-02 | |
| Tech Tips (Alarm Goes Off When Unlocking Door With Key Cylinder): This odcument informs if the vehicle is entered using the door key, the alarm may activate when opening the door. The door lock cylinder does not disarm the alarm. The lock | |
| Bulletin Number: TT57-12-02 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose t | |
| Bulletin Number: TT 87-10-05 | |
| Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may se | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: Update 02122016 | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: V001404 2010380 | |
| Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. | |
| Bulletin Number: V011407 2014603 | |
| Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). | |
| Bulletin Number: V011408 2014815 | |
| Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of | |
| Bulletin Number: V011503 2014815 | |
| Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers | |
| Bulletin Number: V011602 2014815 | |
| Technical tips on what to do if improper gasoline has been added to the vehicle. | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V011812-2014603 | |
| Update content and include additional models and model year applicability. | |
| Bulletin Number: V011812_2014603 | |
| Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. | |
| Bulletin Number: V171302 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrica | |
| Bulletin Number: V171303 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test | |
| Bulletin Number: V171403 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubricati | |
| Bulletin Number: V171404 2012855 | |
| Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard | |
| Bulletin Number: V171701 2012855 | |
| 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271501 2011894 | |
| Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger | |
| Bulletin Number: V271503 2016076 | |
| Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V501205 2014370 | |
| Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi | |
| Bulletin Number: V571502 2039003 | |
| Technical Bulletin (Corrosion on Front Doors (Multiple Locations)): Alignments in production can lead to hairline cracks in the top coat and paint damage (edges on holes) on the already painted door. Humidity then penetrates paint and cause | |
| Bulletin Number: V571606-2039003 | |
| To update Claim processing statement. | |
| Bulletin Number: V581502 2039211 | |
| Technical Bulletin (Corrosion on Rear Doors (Multiple Locations)): Alignments in production can lead to hairline cracks in the top coat and paint damage (edges on holes) on the already painted door. Humidity then penetrates paint and cause | |
| Bulletin Number: V581602-2039211 | |
| To update claim processing statement. | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V871301 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st | |
| Bulletin Number: V871401 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871402 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i | |
| Bulletin Number: V871409 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ | |
| Bulletin Number: V871506 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon | |
| Bulletin Number: V871508 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: V871812-2005566 | |
| Update vehicle metadata. | |
| Bulletin Number: V921502 2026253 | |
| Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w | |
| Bulletin Number: V941402 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic | |
| Bulletin Number: V941403 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. | |
| Bulletin Number: V941501 2011521 | |
| Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document | |
| Bulletin Number: VC | |
| INSTALL MERCURY LABEL ON VEHICLES REGISTERED IN THE STATES OF VERMONT, MAINE AND CONNECTICUT - ENVIRONMENTAL COMPLIANCE ACTION CIRCULAR. *TT | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| 2004 VOLKSWAGEN R32 | |
| Bulletin Number: 004 | |
| ENGINE COOLANT TEMPERATURE (ECT) SENSOR. *TC | |
| Bulletin Number: 0401 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P1347/17755 AND P1340/17748 STORED IN MEMORY. INCLUDING VARIOUS MODELS VOLKSWAGEN 2002-2003. *MJ | |
| Bulletin Number: 0403 | |
| THE LOWER RADIATOR HOSE COULD CONTACT THE ENGINE COOLING FAN WHICH MAY LEAD TO RADIATOR HOSE WEAR. *TT | |
| Bulletin Number: 0502 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 2015831 | |
| VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE | |
| Bulletin Number: 30DayInvCklst | |
| REMOVED all 12 hour wait period before starting references. ADDED EFB to "Select correct battery type" in bottom box. Also Jetta Wagon 2005 and 2018-2020 Tiguan LWB. | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Control Module R | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: Quick Reference | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Reference Guide | |
| Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. | |
| Bulletin Number: Reference - Refl | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Ref. - Reflash U | |
| Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. | |
| Bulletin Number: SA-28F3 | |
| VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION | |
| Bulletin Number: SA-60A7-S9 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. INSPECT, CLEAN AND MODIFY SUNROOF DRAINS FOR CERTAIN VOLKSWAGEN VEHICLES AND REVISED MAINTENANCE SCHEDULE; SUNROOF DRAIN INSPECTION AND CLEANING. NO MODELS OR MODEL | |
| Bulletin Number: SAC-28F3/P1-REV | |
| VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A | |
| Bulletin Number: SB-28F3 | |
| VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-00-10-06 | |
| VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE | |
| Bulletin Number: TB-01-12-04 | |
| VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE | |
| Bulletin Number: TB-35-11-01 | |
| VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM | |
| Bulletin Number: TSB-28-10-02 | |
| VOLKSWAGEN: MIL ON OR FLASHING, MISFIRE DTCS P0300-0312 STORED IN ECM. THE MISFIRE CONDITION MAY BE CAUSED BY A MALFUNCTIONING IGNITION COIL. VEHICLES ARE OUT OF PRODUCTION. *PE | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: V011602 2014815 | |
| Technical tips on what to do if improper gasoline has been added to the vehicle. | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V011812_2014603 | |
| Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. | |
| Bulletin Number: V171701 2012855 | |
| 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| 2004 VOLKSWAGEN TOUAREG | |
| Bulletin Number: 010504 | |
| CUSTOMER STATES VEHICLE HESITATES. *TT | |
| Bulletin Number: 01 08 11 | |
| UPDATE PROGRAMMING, MIL ON, DTC'S P0420 AND/OR P0430 STORED IN ECM FAULT MEMORY. *NJ | |
| Bulletin Number: 01222007 | |
| UPDATE PROGRAMMING. *KB | |
| Bulletin Number: 0302 | |
| TIRE PRESSURE MONITORING SYSTEM, WARNING LIGHT IS ON. *TT | |
| Bulletin Number: 0303 | |
| TAIL LIGHT ASSEMBLY, REMOVAL PROCEDURE. *TT THIS BULLETIN REPLACES 0303 DATED 09/30/2003. *TT | |
| Bulletin Number: 0401 | |
| IGNITION/STARTER SWITCH -E415- DELETION OF EMERGENCY KEY RELEASE FEATURE. *TT | |
| Bulletin Number: 0401 | |
| INSTRUMENT CLUSTER MULTI-FUNCTION DISPLAY SHOWS AN AIR SUSPENSION ERROR MESSAGE. DIAGNOSTIC TROUBLE CODES (DTCS) 00774, 00775, 00776, 01769 MAY ALSO BE STORED IN MEMORY. *TT | |
| Bulletin Number: 0401 | |
| MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODES (DTC) P1347/17755 AND P1340/17748 STORED IN MEMORY. INCLUDING VARIOUS MODELS VOLKSWAGEN 2002-2003. *MJ | |
| Bulletin Number: 0401 | |
| RADIO FREQUENCY REMOTE CONTROL TRANSMITTER FUNCTIONS ONLY AT CLOSE RANGE. *TT | |
| Bulletin Number: 0401 | |
| REAR HATCH GLASS, OPEN WARNING DISPLAYED IN MULTI-FUNCTION DISPLAY. *MJ | |
| Bulletin Number: 0402 | |
| AIRBAG LIGHT IN INSTRUMENT CLUSTER IS ON AND ONE OR BOTH OF THE FOLLOWING DIAGNOSTIC TROUBLE CODES ARE STORED IN DIAGNOSTIC TROUBLE CODES (DTC) MEMORY. *MJ | |
| Bulletin Number: 0402 | |
| BATTERY CUT-OFF SWITCH, DISCONNECTING AND REMOVING DURING THE PRE-DELIVERY INSPECTION (PDI). THIS BULLETIN SUPERSEDES GROUP 00 NUMBER 04-02 DATED APR 6, 2004 AND GROUP 00 NUMBER 04-03 DATED APR 28, 2004. *TT | |
| Bulletin Number: 0402 | |
| DURING LOW SPEED TURNS/MANEUVERING VEHICLE FEELS AS IF IT IS BINDING/TIRES SCRUBBING. *MJ | |
| Bulletin Number: 0402 | |
| STARTER, DOES NOT CRANK, ENGINE DOES NOT START; KEY CANNOT BE REMOVED FROM IGNITION SWITCH. SUPERSEDES BULLETIN 04-02 DATED NOV 19, 2004. *TT | |
| Bulletin Number: 0402 | |
| STARTER DOES NOT CRANK, ENGINE DOES NOT START. *TC | |
| Bulletin Number: 0402 | |
| TIRE PRESSURE MONITORING SYSTEM, ANTENNA UPDATE. *TT | |
| Bulletin Number: 0402 | |
| TIRE PRESSURE MONITORING SYSTEM DISPLAYS ERROR IN INSTRUMENT CLUSTER. *TT | |
| Bulletin Number: 0402 | |
| TRANSFER CASE, CHECKING/REPLACEMENT. *MJ | |
| Bulletin Number: 0402 | |
| WINDSHIELD, CONDENSATION ON EXTERIOR LOWER CENTER DURING WARM/HUMID WEATHER CONDITIONS. *MJ | |
| Bulletin Number: 0403 | |
| IGNITION KEY EMERGENCY RELEASE REVISION. *TC | |
| Bulletin Number: 0403 | |
| PASSENGER OCCUPANT DETECTION SYSTEM (PODS) FAULT. *MJ | |
| Bulletin Number: 0403 | |
| TIRE PRESSURE SYSTEM, WARNING LIGHT IS ON. *AK | |
| Bulletin Number: 0404 | |
| TIRE PRESSURE MONITORING SYSTEM, MODULE CODING. *MJ | |
| Bulletin Number: 0405 | |
| AUTOMATIC BATTERY CUTOFF SWITCH (BCS), MALFUNCTIONING RESULTING IN BATTERY DISCHARGE. *MJ | |
| Bulletin Number: 0405 | |
| TIRE PRESSURE MONITORING SYSTEM (TPMS), DIAGNOSING. *TT | |
| Bulletin Number: 0407 | |
| UPDATE PROGRAMMING (FLASHING) TRAILER CONTROL MODULE. *TT | |
| Bulletin Number: 0413 | |
| UPDATE PROGRAMMING (FLASHING) TRANSMISSION CONTROL MODULE (TCM) FOR HARSH SHIFTING. *MJ | |
| Bulletin Number: 0415 | |
| CUSTOMER STATES VEHICLE HESITATES. *MJ | |
| Bulletin Number: 0417 | |
| AIRBAG MONITORING LIGHT ON, PASSENGER OCCUPANT DETECTION SYSTEM (PODS), DIAGNOSTIC TROUBLE CODE 02511 014 STORED. *TT | |
| Bulletin Number: 0501 | |
| AIR SUSPENSION, (DTC) DIAGNOSTIC TROUBLE CODE 01772 008 STORED IN DTC MEMORY. SUPERSEDES 0402 DATED DECEMBER 20, 2004. *TT | |
| Bulletin Number: 0501 | |
| DISSATISFACTION WITH LENGTH OF TREAD LIFE / WARE RATE OF OE TIRE APPLICATION. *TT | |
| Bulletin Number: 0501 | |
| REQUIRED REAR FINAL DRIVE DIFFERENTIAL GEAR OIL CHANGE. *TT | |
| Bulletin Number: 0502 | |
| DIAGNOSTIC TROUBLE CODE (DTC) P1603 (18011) STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0502 | |
| EXTERIOR DOOR HANDLE STICKS IN THE OPENED POSITION AFTER DOOR IS OPENED. *TT | |
| Bulletin Number: 0502 | |
| REPLACE FLEXIBLE FUEL SENSOR -G133- AND RE-PRIME FUEL SYSTEM. *TT | |
| Bulletin Number: 0502 | |
| STARTER DOES NOT CRANK, ENGINE DOES NOT START; KEY CANNOT BE REMOVED FROM IGNITION SWITCH. *EH UPDATE. *TT | |
| Bulletin Number: 0503 | |
| MODULE, VEHICLE POSITION RECOGNITION CONTROL -J603-, DIAGNOSIS. *TT | |
| Bulletin Number: 0509 | |
| MALFUNCTION INDICATOR LAMP (MIL) IS ON, DIAGNOSTIC TROUBLE CODES (DTCS) P1411, P1423, SECONDARY AIR INJECTION SYSTEM BANK 1, BANK 2, FLOW TOO LOW ARE STORED IN DTC MEMORY. *TT | |
| Bulletin Number: 0512 | |
| TRAILER LIGHTS INOPERATIVE, UPDATE PROGRAMMING (FLASHING) TRAILER CONTROL MODULE. *SC | |
| Bulletin Number: 0515 | |
| UPDATE PROGRAMMING TO ELIMINATE POSSIBLE ENGINE STUMBLE OR ROUGH RUNNING CONDITION (OD). *TT | |
| Bulletin Number: 0601 | |
| SELF LEVELING SUSPENSION, ERROR MESSAGE DISPLAYED IN MULTI-FUNCTION DISPLAY. INSTRUMENT PANEL MALFUNCTION. *KB | |
| Bulletin Number: 1-2017 Update | |
| This communication is to update our ProFi dealers of the current status of the latest inbound and outbound ProFi requests. | |
| Bulletin Number: 171901_2012855 | |
| Remote Key Battery Replacement | |
| Bulletin Number: 2010617 | |
| TIRE PRESSURE MONITORING SYSTEM (TPMS). *KB | |
| Bulletin Number: 2014628 | |
| DOOR, FRONT OR REAR INNER RELEASE HANDLE REMAINS IN OPEN POSITION WHEN EXITING THE VEHICLE. *KB | |
| Bulletin Number: 2014708 | |
| TRANSMISSION, INDICATOR ILLUMINATED IN INSTRUMENT CLUSTER. *KB | |
| Bulletin Number: 2015831 | |
| VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE | |
| Bulletin Number: 2031104 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: 2039001 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: 270701 | |
| GENERATOR, INSUFFICIENT OUPUT EQUIPPED WITH HID/BI-XENON HEADLAMPS AND/OR AIR SUSPENSION. *KB | |
| Bulletin Number: 44 08 01 | |
| TIRE PRESSURE MONITORING SYSTEM (TPMS), DIAGNOSING. *NJ | |
| Bulletin Number: 5 | |
| PRODUCT UPDATE CIRCULAR. INSTALL IMPROVED AIR FILTER HOUSING AND INSPECT/REPLACE BATTERY CABLE, IF NECESSARY. *KB | |
| Bulletin Number: 690402 | |
| SIDE AIRBAG IGNITER, DIAGNOSTIC TROUBLE CODE(S) (DTCS) STORED IN DTC MEMORY. ORIGINAL NOT RECEIVED. *TT | |
| Bulletin Number: 90D7 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. 2004-2005 MY TOUAREG - INSPECT DRIVER'S AND PASSENGER'S SIDE IMPACT AIRBAG CONNECTORS AND INSTALL WIRING HARNESS KIT(S), IF NECESSARY. CSC WAS RECEIVED. *NJ | |
| Bulletin Number: 940501 | |
| TAIL LIGHT ASSEMBLY, DIFFICULT TO REMOVE OR LENS CRACKS DURING REMOVAL. *TT | |
| Bulletin Number: A971861 2013504- | |
| This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts. | |
| Bulletin Number: Control Module R | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Elsa 6-22-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech | |
| Bulletin Number: Elsa 6-29-15 | |
| This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions. | |
| Bulletin Number: Gasoline Engine | |
| Gasoline Engine Misfire Diagnosis document | |
| Bulletin Number: On-car analysis | |
| On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) | |
| Bulletin Number: On-car analysis | |
| On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex) | |
| Bulletin Number: PDI - TOUAREG TE | |
| "Touareg Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has pu | |
| Bulletin Number: PDI - TOUAREG TE | |
| TOUAREG Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has pur | |
| Bulletin Number: QRUG08212019 | |
| Quick Reference Update Guide. | |
| Bulletin Number: Quick Reference | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: Quick Reference | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Quicktip 1.2_TB | |
| Trailer braking information. | |
| Bulletin Number: Quick Tip - Trai | |
| Trailer braking information | |
| Bulletin Number: Quick Tip - Trai | |
| Trailer towing information | |
| Bulletin Number: Reference Guide | |
| Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins. | |
| Bulletin Number: Reference Guide | |
| Engine Control Module Updates: This document informs of complaints, and the software updates / Tech Bulletins associated with servicing engine control module issues: | |
| Bulletin Number: Reference Guide | |
| Engine Control Module Updates: This document informs of complaints, and the software updates/Tech Bulletins associated with servicing engine control module issues: | |
| Bulletin Number: Reference Guide | |
| Transmission Control Module Updates: This document informs of the software, and technical bulletins that service corresponding cars and their Transmission Control Module complaint issues. | |
| Bulletin Number: Reference - Refl | |
| Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle | |
| Bulletin Number: Ref. - Reflash U | |
| Quick Reference Update Guide of the vehicles expected upgraded software level. The latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles. | |
| Bulletin Number: SA-28F3 | |
| VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION | |
| Bulletin Number: SA-28F6 | |
| VOLKSWAGEN SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ENGINE SOFTWARE MAY CAUSE THE VEHICLE TO EXCEED EMISSIONS STANDARDS. *RM | |
| Bulletin Number: SAC-28F3/P1-REV | |
| VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA A | |
| Bulletin Number: SB-28F3 | |
| VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PER | |
| Bulletin Number: SM 33-2019 | |
| The part number listed in the document is to be returned if it meets the criteria provided. | |
| Bulletin Number: SM 44-2017 EN | |
| This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward. | |
| Bulletin Number: TB-00-10-06 | |
| VOLKSWAGEN: CHILD RESTRAINT LATCH GUIDANCE FIXTURE; COMPLIANCE WITH FMVSS 225 (USA ONLY). UPDATE TO EXISTING TECHNICAL BULLETIN. NO PRODUCTION CHANGE REQUIRED. ALL MODELS. *PE | |
| Bulletin Number: TB-01-09-16 | |
| VOLKSWAGEN: DRIVETRAIN BINDING/TIRES SCRUBBING DURING LOW SPEED MANEUVERING, ESP LIGHT IN INSTRUMENT CLUSTER ON OR FLASHING. TENSION IN DRIVETRAIN; VIBRATION AND LOAD SENSITIVE KNOCKING FROM THE DRIVETRAIN; CRACKING NOISE UPON ACCELERATION | |
| Bulletin Number: TB-01-11-29 | |
| VOLKSWAGEN: CERTAIN MODEL YEAR VEHICLES EXPERIENCE TIRE RUBBING OR BINDING OF DRIVETRAIN AT LOW SPEED AND THE INSTRUMENT CLUSTER LIGHT WOULD BE ON OR FLASHING. *PE | |
| Bulletin Number: TB-01-12-04 | |
| VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE | |
| Bulletin Number: TB-35-11-01 | |
| VOLKSWAGEN: THE GEAR BOX HAS A MOMENTARILY DELAY WHILE ACCELERATING. *RM | |
| Bulletin Number: TB-87-08-02 | |
| VOLKSWAGEN: A/C INOPERATIVE, EVAPORATOR TEMPERATURE SENSOR-G308-DAMAGED OR DISLODGED. SYMPTOMS CAN BE POOR HEAT, NO COOLING, OR INSUFFICIENT COOLING. *PE | |
| Bulletin Number: TB-97-09-02 | |
| VOLKSWAGEN: THE WIRING HARNESS LOCATED ON THE DRIVER'S SIDE FLOOR PAN NEAR THE A PILLAR MAY HAVE A CORRODED SPLICE(S) CONNECTION. LOCATE SPLICE TO DETERMINE POSSIBLE CORROSION. REPAIR WIRING AS PER REPAIR MANUAL. *PE | |
| Bulletin Number: Touareg Module S | |
| VOLKSWAGEN DEALERSHIP COMMUNICATION: Based on dealer feedback of ODIS Service module scan lockups on early Touareg. VOLKSWAGEN created a method for a temporary workaround. The document is its procedure | |
| Bulletin Number: TSB-28-10-02 | |
| VOLKSWAGEN: MIL ON OR FLASHING, MISFIRE DTCS P0300-0312 STORED IN ECM. THE MISFIRE CONDITION MAY BE CAUSED BY A MALFUNCTIONING IGNITION COIL. VEHICLES ARE OUT OF PRODUCTION. *PE | |
| Bulletin Number: TT 001202 | |
| TT 001202........Also includes 2005 Jetta wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: TT 00-13-02 | |
| Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it | |
| Bulletin Number: TT 00-13-04 | |
| Tech Tips (All Models 2000-2014 - Part ordering): If a needed service part is on back order, upgrade the daily order to a red order and check the ?Car Down? box to escalate the order. This document informs how to contact VWGoA Parts Spec | |
| Bulletin Number: TT 00-14-03 | |
| Tech Tips (SVM Update Instructions): This document informs when performing SVM updates, the scan tool should be hardwired to the vehicle and the Bluetooth physically turned off. A hard wired internet connection is also recommended. | |
| Bulletin Number: TT 00-16-02 | |
| Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used | |
| Bulletin Number: TT001703 | |
| Tip for Scan tool concerns that may occur duing a test plan | |
| Bulletin Number: TT 01-15-02 | |
| Tech Tips (Scan tool lock up/Scan stops at 33%): While performing a GFF scan (with the newer version of ODIS software), the scan tool can lock up at 33%. The document informs how to service this issue | |
| Bulletin Number: TT 200901 | |
| Update to existing tip for fuel quality checking. | |
| Bulletin Number: TT 20-13-01 | |
| Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without co | |
| Bulletin Number: TT 21-13-01 | |
| Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. Thi | |
| Bulletin Number: TT 32-14-01 | |
| Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installat | |
| Bulletin Number: TT 42-08-01 | |
| Tech Tips (Clicking Noise from Rear End): This document informs For a complaint of ?clicking noise when backing up and then braking?, be sure to check the lower outboard control arm in the rear suspension for any play in the bushing. Th | |
| Bulletin Number: TT42-08-01 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: TT 50-14-01 | |
| Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products wil | |
| Bulletin Number: TT 55-13-01 | |
| Tech Tips (Rear Lid Does Not Open After Handle Replacement): If the rear lid handle is replaced with part number 1J0 827 566L, the microswitch from the original handle must be transferred to the new handle. If original microswitch is not a | |
| Bulletin Number: TT 57-12-02 | |
| Tech Tips (Alarm Goes Off When Unlocking Door With Key Cylinder): This document informs if the vehicle is entered using the door key, the alarm may activate when opening the door. The door lock cylinder does not disarm the alarm. The lock | |
| Bulletin Number: TT 57-12-02 | |
| Tech Tips (Alarm Goes Off When Unlocking Door With Key Cylinder): This odcument informs if the vehicle is entered using the door key, the alarm may activate when opening the door. The door lock cylinder does not disarm the alarm. The lock | |
| Bulletin Number: TT57-12-02 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engin | |
| Bulletin Number: TT 64-14-02 | |
| Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose t | |
| Bulletin Number: TT 87-10-05 | |
| Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may se | |
| Bulletin Number: TT 91 19 01 | |
| Alternative method for radio code retrieval. | |
| Bulletin Number: TT 96-12-08 | |
| SUMMARY TO BE PROVIDED ON A FUTURE DATE. | |
| Bulletin Number: TT 96-12-08 | |
| Tech Tips (Access/Start Module Fault 00183 ?Interior Access/Start Authorization Antenna 1-R138? Diagnosis Tip): When diagnosing Access/start fault 00183, be aware that the fault can indicate a concern with either the R138 Interior Access/S | |
| Bulletin Number: TT 96-12-08 | |
| Tech Tips (Access/Start Module Fault 00183 ?Interior Access/Start Authorization Antenna 1-R138? Diagnosis Tip): When diagnosing Access/start fault 00183, be aware that the fault can indicate a concern with either the R138 Interior Access/St | |
| Bulletin Number: TT 97-12-02 | |
| Data Link connector pin assignment chart that is applicable to all models. Update model year applicability. | |
| Bulletin Number: TT 97-14-02 | |
| TECH TIP DENOTING POTENTIAL FOR DAMAGE OF THE DATA LINK CONNECTOR WHEN USING AFTER MARKET PLUG IN DEVICES OR SCAN TOOLS AND SUBSEQUENT DIAGNOSTIC DIRECTION. | |
| Bulletin Number: TT 97-14-02ss1 | |
| Tech Tips Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System) | |
| Bulletin Number: Update 02122016 | |
| Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated | |
| Bulletin Number: V001404 2010380 | |
| Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions. | |
| Bulletin Number: V011407 2014603 | |
| Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU). | |
| Bulletin Number: V011408 2014815 | |
| Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of | |
| Bulletin Number: V011503 2014815 | |
| Discusses the issues associated with using contaiminated gasoline. There are recommendations to use top tier gasoline retailers | |
| Bulletin Number: V011602 2014815 | |
| Technical tips on what to do if improper gasoline has been added to the vehicle. | |
| Bulletin Number: V011615 2014815 | |
| Update to include additional model year applicability. | |
| Bulletin Number: V011812_2014603 | |
| Update vehicle metadata to include pull ahead models. Also includes R32 2002-2007 and 2002-2006 Jetta Wagon. | |
| Bulletin Number: V1.0 | |
| Trailer braking information | |
| Bulletin Number: V1.0 | |
| Trailer towing information | |
| Bulletin Number: V171302 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrica | |
| Bulletin Number: V171303 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customers have stated oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. This document informs how to test | |
| Bulletin Number: V171403 2017813 | |
| Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubricati | |
| Bulletin Number: V171404 2012855 | |
| Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard | |
| Bulletin Number: V171701 2012855 | |
| 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901-2012855 | |
| Engine Oils Which Meet Volkswagen Oil Quality Standards | |
| Bulletin Number: V171901_2012855 | |
| Engine oil quality standards. Also includes all models for 1997-2003. Also Rabbit from 2006-2009. | |
| Bulletin Number: V171901_2012855 | |
| Update to Volkswagen engine oil standards. Also includes 2004 and 2005 Jetta Wagon and 2018-2020 Tiguan LWB | |
| Bulletin Number: V271501 2011894 | |
| Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger | |
| Bulletin Number: V271503 2016076 | |
| Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw | |
| Bulletin Number: V271901-2011894 | |
| Battery Testing and Charging instruction. Updated to include model year 2019 applicability. | |
| Bulletin Number: V501205 2014370 | |
| Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be signifi | |
| Bulletin Number: V501604 2014370 | |
| Technical Bulletin about Paint Finish, Reducing Swirl Marks and Fine Scratches New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. The document also have infromation about where to fi | |
| Bulletin Number: V581501 2039001 | |
| Technical Bulletin (Corrosion, Rear Inner Doors in Door Fold Area): Corrosion in the fold of the rear door issue. This document contains information on how to diagnose, and service this issue. This document also gives examples on filling o | |
| Bulletin Number: V581601-2039001 | |
| To update Claim processing statement. | |
| Bulletin Number: V691601 2010479 | |
| Update model year applicability to include 2017. | |
| Bulletin Number: V871301 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): An unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first st | |
| Bulletin Number: V871401 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871402 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i | |
| Bulletin Number: V871409 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ | |
| Bulletin Number: V871506 2019947 | |
| Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon | |
| Bulletin Number: V871508 2005566 | |
| Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start | |
| Bulletin Number: V871620 2005566 | |
| Update model and model year applicability. | |
| Bulletin Number: V871622 2019947 | |
| Update to model year applicability. | |
| Bulletin Number: V871812-2005566 | |
| Update vehicle metadata. | |
| Bulletin Number: V921502 2026253 | |
| Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w | |
| Bulletin Number: V941402 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic | |
| Bulletin Number: V941403 2011521 | |
| Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue. | |
| Bulletin Number: V941501 2011521 | |
| Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document | |
| Bulletin Number: V971201 2031104 | |
| Technical Bulletin (Diagnostic Connector - No ECM Communication): Some model year 2003 ? 2004 V6 Touareg?s may exhibit a loss of communication through the OBD diagnostic connector. The signal ground wire may be missing from pin 5 of the di | |
| Bulletin Number: V971201 2031104 | |
| Technical Bulletin (Diagnostic Connector - No ECM Communication): Some model year 2003-2004 V6 Touareg's may exhibit a loss of communication through the OBD diagnostic connector. The signal ground wire may be missing from pin 5 of the diag | |
| Bulletin Number: VC | |
| INSTALL MERCURY LABEL ON VEHICLES REGISTERED IN THE STATES OF VERMONT, MAINE AND CONNECTICUT - ENVIRONMENTAL COMPLIANCE ACTION CIRCULAR. *TT | |
| Bulletin Number: VHW-17-11 | |
| VAS 6154 Replacement Part Setup Guide | |
| Bulletin Number: VQ | |
| A RUBBER PART CAN RUB AGAINST THE POWER STEERING AND/OR TRANSMISSION FLUID LINES LOCATED BEHIND THE RADIATOR GRILLE. THIS RUBBING CAN LEAD TO CORROSION OF THE LINES AND POSSIBLY EVEN A FLUID LEAK. *TT | |
| Bulletin Number: VWP-13-17 | |
| VOLKSWAGEN: INFORMATION PROVIDED REGARDING WARRANTY INFORMATION, ON SOME VEHICLES, FOR FACTORY INSTALLED HID HEADLIGHT BULB(S) LIMITED EXTENSION WARRANTY. MODELS 2004-2007 TOUAREG. *PE | |
| 2004 VOLKSWAGEN TOUAREG 2 | |
| Bulletin Number: PDI - TOUAREG TE | |
| "Touareg Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has pu | |
Recalls for 2004 Volkswagen
| 2004 VOLKSWAGEN BEETLE | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 06/01/2002 - 11/30/2006 |
| Potential Units Affected: | 1002000 |
Defect Description:ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY. Consequence:THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING. Action:DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN BEETLE | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, DIESEL |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 03/01/2004 - 08/29/2004 |
| Potential Units Affected: | 19284 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP. Consequence:FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE. Action:DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN BEETLE | |
|---|---|
| NHTSA Campaign ID: | AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 07/30/2002 - 10/31/2004 |
| Potential Units Affected: | 76900 |
Defect Description:VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAIN HIGH TEMPERATURE CONDITIONS. IF THIS OCCURS, THE AIR BAG INDICATOR LIGHT WILL ILLUMINATE AND THE FALLBACK ALGORITHM WILL ENSURE THAT THE FRONT AIR BAGS ALWAYS DEPLOY IN A FRONTAL CRASH IN WHICH THE VEHICLE'S DECELERATION IS HIGH ENOUGH TO ACTIVATE THE FRONTAL AIR BAGS. Consequence:IN LOW-SEVERITY FRONTAL IMPACTS, THE FRONT AIR BAGS MAY DEPLOY MORE FORCEFULLY THAN DESIGNED, INCREASING THE POSSIBILITY OF INJURY TO OUT-OF-POSITION FRONT SEAT OCCUPANTS. Action:DEALERS WILL INSPECT EACH VEHICLE TO DETERMINE THAT THE SPECIFIC DEFECT CRASH SENSOR IS PRESENT ON ONE OR BOTH SIDES OF THE VEHICLE. ALL OF THE DEFECT CRASH SENSORS WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 31, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN GOLF | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, DIESEL |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 03/01/2004 - 08/29/2004 |
| Potential Units Affected: | 19284 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP. Consequence:FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE. Action:DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN GOLF | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 02/01/2000 - 07/31/2005 |
| Potential Units Affected: | 1002000 |
Defect Description:ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY. Consequence:THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING. Action:DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN GTI | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 02/01/2000 - 07/31/2005 |
| Potential Units Affected: | 1002000 |
Defect Description:ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY. Consequence:THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING. Action:DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN JETTA | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, DIESEL |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 03/01/2004 - 08/29/2004 |
| Potential Units Affected: | 19284 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP. Consequence:FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE. Action:DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN JETTA | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 10/01/2000 - 11/30/2004 |
| Potential Units Affected: | 1002000 |
Defect Description:ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY. Consequence:THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING. Action:DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN NEW BEETLE | |
|---|---|
| NHTSA Campaign ID: | AIR BAGS |
| Manufacturer: | VOLKSWAGEN OF AMERICA,INC |
| Manufacture Dates: | 07/01/2003 - 08/31/2003 |
| Potential Units Affected: | 333 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THE PASSENGER DETECTION FUNCTION OF THE PASSIVE OCCUPANT DETECTION SYSTEM (PODS) MAY BECOME DISABLED. Consequence:SHOULD THE PODS CONTROL UNIT MALFUNCTION, THE AIR BAG SYSTEM IN THE VEHICLE WILL NOT WORK AS DESIGNED AND MAY NOT BE ABLE TO PROPERLY PROTECT OCCUPANTS IN A CRASH. Action:DEALERS WILL REPROGRAM THE PODS. OWNER NOTIFICATION ORIGINALLY BEGAN OCTOBER 3, 2003. VW HAS DETERMINED THAT ADDITIONAL VEHICLES NEED TO BE REPAIRED. THE RECALL FOR THE ADDITIONAL VEHICLES IS EXPECTED TO BEGIN ON DECEMBER 17, 2004. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN NEW BEETLE | |
|---|---|
| NHTSA Campaign ID: | EQUIPMENT:OTHER:LABELS |
| Manufacturer: | VOLKSWAGEN OF AMERICA,INC |
| Manufacture Dates: | 06/01/2003 - 09/30/2003 |
| Potential Units Affected: | 15115 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THE TIRE INFORMATION LABEL IS INCORRECT IDENTIFYING THE VEHICLE AS A FIVE-PASSENGER VEHICLE, INSTEAD OF A FOUR-PASSENGER VEHICLE. Consequence:EXCEEDING THE CORRECT SEATING CAPACITY IN A VEHICLE PUTS OCCUPANTS AT RISK FOR INJURY IN A CRASH, AND CAN RESULT IN VEHICLE OVERLOADING, WHICH CAN AFFECT VEHICLE HANDLING AND PUT YOU AT RISK FOR A CRASH. Action:OWNERS WILL BE SENT A NEW LABEL AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN ON FEBRUARY 9, 2004. OWNERS SHOULD CONTACT VWOA AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN PASSAT | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, DIESEL |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 03/01/2004 - 08/29/2004 |
| Potential Units Affected: | 19284 |
Defect Description:ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP. Consequence:FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE. Action:DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN PASSAT | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 04/01/2002 - 04/30/2005 |
| Potential Units Affected: | 1002000 |
Defect Description:ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY. Consequence:THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING. Action:DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN PASSAT | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:DELIVERY |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 06/01/1999 - 05/31/2005 |
| Potential Units Affected: | 412000 |
Defect Description:VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE. Consequence:A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE. Action:DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN R32 | |
|---|---|
| NHTSA Campaign ID: | EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 10/01/2003 - 05/30/2004 |
| Potential Units Affected: | 1002000 |
Defect Description:ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY. Consequence:THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING. Action:DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN TOUAREG | |
|---|---|
| NHTSA Campaign ID: | FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
| Manufacturer: | Volkswagen Group of America, Inc. |
| Manufacture Dates: | 02/18/2003 - 11/30/2006 |
| Potential Units Affected: | 73941 |
Defect Description:Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak. Consequence:A fuel leak in the presence of an ignition source increases the risk of a fire. Action:Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai. | |
| 2004 VOLKSWAGEN TOUAREG | |
|---|---|
| NHTSA Campaign ID: | SEAT BELTS:REAR |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 04/01/2003 - 12/31/2003 |
| Potential Units Affected: | 24269 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES, THE REAR SEAT BELT LATCH ATTACHMENT BOLT MAY HAVE BEEN INSUFFICIENTLY RIVETED. Consequence:IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY. Action:DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE BELT BUCKLE. OWNER NOTIFICATION BEGAN ON JUNE 21, 2004. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987. | |
| 2004 VOLKSWAGEN TOUAREG | |
|---|---|
| NHTSA Campaign ID: | ELECTRICAL SYSTEM:WIRING |
| Manufacturer: | VOLKSWAGEN OF AMERICA,INC |
| Manufacture Dates: | 04/01/2003 - 07/25/2003 |
| Potential Units Affected: | 670 |
Defect Description:ON CERTAIN SPORT UTILITY VEHICLES, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) WIRING HARNESS MAY HAVE BEEN IMPROPERLY ROUTED DURING ASSEMBLY. AN IMPROPERLY ROUTED TPMS WIRING HARNESS MAY CONTACT THE PARKING BRAKE CABLE SPRING. Consequence:IF THIS HAPPENS, THE TPMS WIRING CIRCUIT COULD BE INTERRUPTED, RESULTING IN AN INOPERATIVE TPMS, AND CAUSING A SHORT-TO-GROUND CONDITION THAT COULD POTENTIALLY RESULT IN A FIRE. Action:DEALERS WILL INSPECT THE TPMS WIRING HARNESS ROUTING AND, IF NECESSARY, CORRECT THE WIRING HARNESS ROUTING. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT VWOA AT 1-800-893-5298. | |
| 2004 VOLKSWAGEN TOUAREG | |
|---|---|
| NHTSA Campaign ID: | SEAT BELTS |
| Manufacturer: | VOLKSWAGEN OF AMERICA, INC |
| Manufacture Dates: | 03/26/2003 - 09/20/2004 |
| Potential Units Affected: | 50483 |
Defect Description:CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS. Consequence:WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH. Action:DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987. | |
